2024 HYUNDAI KONA

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Hyundai Motor America (Hyundai) is recalling certain 2024 Elantra, Venue, and Kona vehicles. An electrical short circuit may occur in the exhaust gas recirculation (EGR) valve assembly, which can result in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Hyundai Motor America (Hyundai) is recalling certain 2024 Kona vehicles. The 12-Volt battery cables may chafe against the engine control module bracket and short circuit during a crash.

Risk: A short circuit increases the risk of an engine compartment fire.

ELECTRICAL SYSTEM

The contact owns a 2024 Hyundai Kona. The contact stated that the vehicle was equipped with alarms set to sound off and send a text notification when the vehicle was accessed without the key, key fob, or remote access being activated. Later, the vehicle began displaying additional electrical issues. The contact stated that the instrument panel would illuminate intermittently and display different warnings and systems being activated; however, the contact was unable to recall what the lights that were displayed. While driving on a forked road, the Lane Assist feature prevented the vehicle from being able to veer left, keeping the vehicle driving straight. The contact used excessive force to steer the vehicle to veer towards the left. The vehicle was taken to the dealer, who was unable to diagnose the cause of the failure. The vehicle was not repaired for any electrical failures. The contact received notice of a recall for the software regarding the Theft Prevention system, needing a software update. The vehicle was returned to the dealer, and the remedy was completed. While attempting to accelerate after being idle at a red light, the vehicle failed to accelerate as intended. The contact turned off the vehicle, waited for a while, and then restarted the vehicle, at which time the contact was able to continue driving. Several unknown warning lights were illuminated. The vehicle was returned to the dealer, who diagnosed that the software update caused the battery to drain quickly. The battery was replaced. The manufacturer was made aware of the failure. The manufacturer opened two cases for the failures. The failure mileage was approximately 9,500.

SERVICE BRAKES

While at a light, the auto stop/start kicked on but when it was time to start driving again and I pressed the gas pedal, the car would not move. There was a long beep and then the check battery icon and an alert came on my dash board stating “Auto Stop is Off. Shift to P or N and start engine manually.” When I turned off the ignition and restarted the car, the alert went off but two additional icons showed up on my dash board- check engine and check oil. Then my steering wheel locked up and I could not press on the breaks or gas pedal. I could not operate my car for more than 30 minutes.

ELECTRICAL SYSTEM

While at a light, the auto stop/start kicked on but when it was time to start driving again and I pressed the gas pedal, the car would not move. There was a long beep and then the check battery icon and an alert came on my dash board stating “Auto Stop is Off. Shift to P or N and start engine manually.” When I turned off the ignition and restarted the car, the alert went off but two additional icons showed up on my dash board- check engine and check oil. Then my steering wheel locked up and I could not press on the breaks or gas pedal. I could not operate my car for more than 30 minutes.

STEERING

While at a light, the auto stop/start kicked on but when it was time to start driving again and I pressed the gas pedal, the car would not move. There was a long beep and then the check battery icon and an alert came on my dash board stating “Auto Stop is Off. Shift to P or N and start engine manually.” When I turned off the ignition and restarted the car, the alert went off but two additional icons showed up on my dash board- check engine and check oil. Then my steering wheel locked up and I could not press on the breaks or gas pedal. I could not operate my car for more than 30 minutes.

EXTERIOR LIGHTING

While driving the instrument panel, headlights and infotainment screen all went black. Has happened multiple times but difficult to replicate. Vehicles head lights turned off while driving in the early morning (dark) but turned back on within a second or two. No warnings, no lights, no errors.

ELECTRICAL SYSTEM

While driving the instrument panel, headlights and infotainment screen all went black. Has happened multiple times but difficult to replicate. Vehicles head lights turned off while driving in the early morning (dark) but turned back on within a second or two. No warnings, no lights, no errors.

SERVICE BRAKES

the car loss power and shut completely off and ran into the wall with my sister and my child in there on the interstate can I please get help about this matter it could've been worse where i could've lost them forever. I don't want this to happen to nobody else they cars know about these malfunctions and still but these cars on the market for accidents to happen. Please something needs to be done about this.

ELECTRICAL SYSTEM

the car loss power and shut completely off and ran into the wall with my sister and my child in there on the interstate can I please get help about this matter it could've been worse where i could've lost them forever. I don't want this to happen to nobody else they cars know about these malfunctions and still but these cars on the market for accidents to happen. Please something needs to be done about this.

STEERING

the car loss power and shut completely off and ran into the wall with my sister and my child in there on the interstate can I please get help about this matter it could've been worse where i could've lost them forever. I don't want this to happen to nobody else they cars know about these malfunctions and still but these cars on the market for accidents to happen. Please something needs to be done about this.

SERVICE BRAKES

My family got in a accident on this recall of loss of power on the high way making the car crash into a wall... 8/16/25 3:06 pm in Duval county Jacksonville,FL Something needs to be done about this my kids have gotten hurt

STEERING

My family got in a accident on this recall of loss of power on the high way making the car crash into a wall... 8/16/25 3:06 pm in Duval county Jacksonville,FL Something needs to be done about this my kids have gotten hurt

ELECTRICAL SYSTEM

My family got in a accident on this recall of loss of power on the high way making the car crash into a wall... 8/16/25 3:06 pm in Duval county Jacksonville,FL Something needs to be done about this my kids have gotten hurt

POWER TRAIN

Hyundai engages emergency parking brake EPB) automatically when in parked on an incline. The EPB will disengage under normal operation if all doors are closed. If doors are open, EPB will not disengage. If going from park to drive, this is not a problem. However, if in drive, traveling with trunk open for oversized cargo, the vehicle will drive normally until a stop on an incline, when the EPB will engage automatically, and then when the driver tries to proceed from the stop, their vehicle is disabled. The driver can provide power to drive train and burn the EPB. The driver must manually intervene after every stop on an incline to disengage the EPB to avoid being disabled at an intersection.

ELECTRICAL SYSTEM

Hyundai engages emergency parking brake EPB) automatically when in parked on an incline. The EPB will disengage under normal operation if all doors are closed. If doors are open, EPB will not disengage. If going from park to drive, this is not a problem. However, if in drive, traveling with trunk open for oversized cargo, the vehicle will drive normally until a stop on an incline, when the EPB will engage automatically, and then when the driver tries to proceed from the stop, their vehicle is disabled. The driver can provide power to drive train and burn the EPB. The driver must manually intervene after every stop on an incline to disengage the EPB to avoid being disabled at an intersection.

ELECTRICAL SYSTEM

Woke up and battery was dead. Car about one year old, no warnings about battery level through Bluelink or any onboard monitoring system. Dealer says dead battery is normal. Tons of issues online relating to dead batteries in new Konas

SEATS

On June 5, 2025 I picked up a passenger who couldn't sit in the passenger seat because the headrest is canted at an unsafe angle so the passenger looks down and cannot look straight through the windshield. There is a page in the manual that shows the headrest is adjustable; this is wrong because the headrest is not adjustable. On July 2, 2025 I took it the vehicle in for recalls and asked about this; the service worker said there is no solution because replacement headrests are the same.

ENGINE

A few different days over the past few months. Driving heated seats stopped working. Check engine warning light on intermittently. Key fob not working. Multiple error codes stored in system cleared by dealer. shut down the car screen has stayed on. AC light has stayed on when car is off. Screen has turned off “check you back seat” upon leaving the car heard the engine still on 3x. At the gas station turned off the car, miles to zero reading 5, P park stays on, odometer reading on. As tank filling miles to zero rapidly increased from 5 to 300. I have a video of this. Been in for service multiple times. Presently at the dealer. They r unable to replicate this. They do not seem concerned about this. I feel it is a safety and operational concern. Prefer by car not be communicating even with itself while I’m pumping gas. They want me to pick up the car. I do not wish to. I have asked if miles to zero reading is supposed to increase real time I would like to see this is the manual or other documentation. Otherwise I feel it is a huge safety risk to have my car not shut down when I ask it to. What’s to say it won’t shut down while I’m driving 75mph on the freeway? Thank you

ELECTRICAL SYSTEM

A few different days over the past few months. Driving heated seats stopped working. Check engine warning light on intermittently. Key fob not working. Multiple error codes stored in system cleared by dealer. shut down the car screen has stayed on. AC light has stayed on when car is off. Screen has turned off “check you back seat” upon leaving the car heard the engine still on 3x. At the gas station turned off the car, miles to zero reading 5, P park stays on, odometer reading on. As tank filling miles to zero rapidly increased from 5 to 300. I have a video of this. Been in for service multiple times. Presently at the dealer. They r unable to replicate this. They do not seem concerned about this. I feel it is a safety and operational concern. Prefer by car not be communicating even with itself while I’m pumping gas. They want me to pick up the car. I do not wish to. I have asked if miles to zero reading is supposed to increase real time I would like to see this is the manual or other documentation. Otherwise I feel it is a huge safety risk to have my car not shut down when I ask it to. What’s to say it won’t shut down while I’m driving 75mph on the freeway? Thank you

SEAT BELTS

5 minutes into my drive my the whole dashboard (speedometer and music screen) all went black, & my headlights went out. this lasted for about 3 seconds. not sure what happened or why but not something that should happen with such a new car.

EXTERIOR LIGHTING

5 minutes into my drive my the whole dashboard (speedometer and music screen) all went black, & my headlights went out. this lasted for about 3 seconds. not sure what happened or why but not something that should happen with such a new car.

ELECTRICAL SYSTEM

5 minutes into my drive my the whole dashboard (speedometer and music screen) all went black, & my headlights went out. this lasted for about 3 seconds. not sure what happened or why but not something that should happen with such a new car.

POWER TRAIN

Multiple people I know with 2024 Hyundai Kona AWD cars are having the same problem around 10k or so miles. The AWD is locking up. Car feels like rear wheels are slipping when turning and accelerating out of a full or partial stop. This is a widespread problem on this model and I am very surprised it is not a recall yet. Many drivers are having coupler or entire rear differential replaced on their cars-some less than 1 year old, or about 1 year old.

UNKNOWN OR OTHER

The window on the drivers, passenger side. Yes it could be inspected. Fingers caught in the area where the window goes into the door at the bottom, 2 and a half year old child in car seat next to window. This is the first time it happened. she does not ride in the car often. I have not contacted the dealership Yet. No others have been contacted yet. The window went down and the child was screaming with her fingers caught. UNKNOWN.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

On Monday [XXX] I was driving home from work going 45 mph when my forward collision warning came on and the car stopped. However, there was no one in front of me. This was extremely dangerous and if there was a car behind me I could have been hit. I am extremely scared to drive this car. I had it towed to Lynne’s Hyundai in Bloomfield NJ. They said their computer could not find an issue so had nothing to fix and asked me to pick up the car. However, after what I experienced I refused and called corporate Hyundai. They told me my safety was their number one priority and they would resolve this for me. However, after they spoke to the dealership they said they could not duplicate the problem so nothing could be done. I gave numerous solutions that would make me happy but none were taken. I now have a car I am literally scared to death to drive and had another malfunction with the front sensor yesterday where it told me the car in front of me was pulling away but it was stopped. The vehicle is available for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VISIBILITY/WIPER

While driving the vehicle the digital dashboard for the RPM's and Speedometer, infotainment center, accent lighting and all exterior lighting including tail lamps, head lights, turn signals and marker lights all powered off for approximately 2-3 seconds. During this time, the engine continued to run as if nothing had occurred. After the 2-3 seconds all affected systems that shut down turned back on and continued as if nothing had occurred. Even Apple carplay had no signal reconnection time, almost like it was never disconnected in the first place. This issue appears to just shut down all outward lighting/indicator lamps and then power back up. This issue has repeated itself on 5 separate occasions over the course of the last 3 days. Took it to a dealer on the 4th day (today, March 6th), and they could not get the issue to replicate despite driving for 30 miles and having it for 3 or so hours under their care. No codes were logged, no indicator lamps showed an issue and no erratic driving or lasting effects of the power blip. Outside of the dealership this issue has not been inspected further. A contact was made with Hyundai USA in attempt to address this safety issue. No reply has been received since submitting yesterday afternoon. This issue has happened during the day as well but given the lighting conditions is not as dangerous as losing all head lamps or tail lamps at night where the driver or other drivers may be affected as they travel about the roadways in the case of merging on and off of a highway or being able to see any animals that run into the roadway.

EXTERIOR LIGHTING

While driving the vehicle the digital dashboard for the RPM's and Speedometer, infotainment center, accent lighting and all exterior lighting including tail lamps, head lights, turn signals and marker lights all powered off for approximately 2-3 seconds. During this time, the engine continued to run as if nothing had occurred. After the 2-3 seconds all affected systems that shut down turned back on and continued as if nothing had occurred. Even Apple carplay had no signal reconnection time, almost like it was never disconnected in the first place. This issue appears to just shut down all outward lighting/indicator lamps and then power back up. This issue has repeated itself on 5 separate occasions over the course of the last 3 days. Took it to a dealer on the 4th day (today, March 6th), and they could not get the issue to replicate despite driving for 30 miles and having it for 3 or so hours under their care. No codes were logged, no indicator lamps showed an issue and no erratic driving or lasting effects of the power blip. Outside of the dealership this issue has not been inspected further. A contact was made with Hyundai USA in attempt to address this safety issue. No reply has been received since submitting yesterday afternoon. This issue has happened during the day as well but given the lighting conditions is not as dangerous as losing all head lamps or tail lamps at night where the driver or other drivers may be affected as they travel about the roadways in the case of merging on and off of a highway or being able to see any animals that run into the roadway.

ELECTRICAL SYSTEM

While driving the vehicle the digital dashboard for the RPM's and Speedometer, infotainment center, accent lighting and all exterior lighting including tail lamps, head lights, turn signals and marker lights all powered off for approximately 2-3 seconds. During this time, the engine continued to run as if nothing had occurred. After the 2-3 seconds all affected systems that shut down turned back on and continued as if nothing had occurred. Even Apple carplay had no signal reconnection time, almost like it was never disconnected in the first place. This issue appears to just shut down all outward lighting/indicator lamps and then power back up. This issue has repeated itself on 5 separate occasions over the course of the last 3 days. Took it to a dealer on the 4th day (today, March 6th), and they could not get the issue to replicate despite driving for 30 miles and having it for 3 or so hours under their care. No codes were logged, no indicator lamps showed an issue and no erratic driving or lasting effects of the power blip. Outside of the dealership this issue has not been inspected further. A contact was made with Hyundai USA in attempt to address this safety issue. No reply has been received since submitting yesterday afternoon. This issue has happened during the day as well but given the lighting conditions is not as dangerous as losing all head lamps or tail lamps at night where the driver or other drivers may be affected as they travel about the roadways in the case of merging on and off of a highway or being able to see any animals that run into the roadway.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

The contact owns a 2024 Hyundai Kona. The contact was away from the residence for several weeks, and after returning, while attempting to start the vehicle, the vehicle failed to start. The contact called for Roadside Service who was also unable to start the vehicle. The contact had the vehicle towed to a local dealer. The dealer determined that the battery had failed and needed to be replaced, along with the battery terminals and electrical wiring harnesses. The vehicle was repaired. The contact stated that the vehicle had started to exhibit electrical failures. The contact stated that while starting the vehicle, the instrument cluster failed to boot up properly. Additionally, the contact became aware that the fan was blowing air independently. The contact had taken the vehicle to another dealer. The contact was advised by the dealer that the vehicle needed to remain at the dealer for a week for further testing. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The failure mileage was approximately 941.

ELECTRICAL SYSTEM

The contact owns a 2024 Hyundai Kona. The contact was away from the residence for several weeks, and after returning, while attempting to start the vehicle, the vehicle failed to start. The contact called for Roadside Service who was also unable to start the vehicle. The contact had the vehicle towed to a local dealer. The dealer determined that the battery had failed and needed to be replaced, along with the battery terminals and electrical wiring harnesses. The vehicle was repaired. The contact stated that the vehicle had started to exhibit electrical failures. The contact stated that while starting the vehicle, the instrument cluster failed to boot up properly. Additionally, the contact became aware that the fan was blowing air independently. The contact had taken the vehicle to another dealer. The contact was advised by the dealer that the vehicle needed to remain at the dealer for a week for further testing. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The failure mileage was approximately 941.