2023 HYUNDAI IONIQ 6

POWER TRAIN:DRIVELINE:DRIVESHAFT

Hyundai Motor America (Hyundai) is recalling certain 2023 IONIQ 5, IONIQ 6, and Genesis GV60 vehicles. The rear inner driveshaft may have been improperly heat-treated, allowing it to break under load and resulting in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:CHARGING:MODULE:SOFTWARE

Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

ELECTRICAL SYSTEM

The car horn malfunctioned. I was not able to warn other drivers I was approaching and they were about to hit me. The component was inspected and replaced over a year ago in May 2024 under the vehicle warranty. No warning lights appeared when it happened.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

I was crossing the Mackinac Bridge, northbound, this afternoon, at the time traveling over the bridge deck's grates in the left lane. Traffic was backed up and I was traveling in the single-digit MPH. There was more that a car's length between myself and the next car ahead, and as I accelerated a little bit to close the distance my emergency braking activated. Fortunately, the car behind me was trailing by a little bit and was also traveling slowly.

ELECTRICAL SYSTEM

ICCU failure. EV car flashed battery issues and could not drive. ICCU and 12 volt battery replaced after 10 days in dealership shop. Manufacturer inspected. Prior to issue electric hatchback closed half way then stalled. I drove to the dealership and asked them to check if there was something wrong. They closed the hatch manually and said the 12 volt battery was fine and the computer said something blocked the closure, I left the dealership and made it less than a mile before battery light went off (within 5 minutes of leaving dealership). Made it back to dealership in turtle mode and this time computer said the ICCU failed.

FUEL/PROPULSION SYSTEM

When driving the instrument panel displayed a warning message of electrical problem and stop the vehicle. BlueLink displayed failure code P1A9096 indicating ICCVU failure. Drove vehicle to local dealer where the ICCU/fuse was replaced.

ELECTRICAL SYSTEM

Left the house, made it a few miles from the house. Loud pop from the rear seat, warning lights came up on the dash limited power and check electrical system. Was limited to 25mph to drive home. All recalls were done prior to failure. Last recall was done approx 2 weeks prior to failure. ICCU was diagnosed as the failure and was replaced.

FUEL/PROPULSION SYSTEM

Left the house, made it a few miles from the house. Loud pop from the rear seat, warning lights came up on the dash limited power and check electrical system. Was limited to 25mph to drive home. All recalls were done prior to failure. Last recall was done approx 2 weeks prior to failure. ICCU was diagnosed as the failure and was replaced.

ELECTRICAL SYSTEM

The Integrated Charging Control Unit (ICCU) failed in November 2024. Instrument panel warning indicated an electrical failure and that the vehicle should be stopped immediately. The Hyundai dealer identified Diagnostic Trouble Code (DTC) P1A9096 and per Service Campaign 997 Technical Service Bulletin 23-01-060H replaced the Integrated Charging Control Unit (ICCU). In December 2024 Recall 272 TSB 24-01-086H software upgrade installed to further address Integrated Charging Control Unit (ICCU) failure.

UNKNOWN OR OTHER

March 21st at around 7:30 PM, I was driving on the highway when my panoramic sunroof suddenly exploded—or shattered—completely out of nowhere. It was a clear night, no rain or debris, and there were no cars directly in front of me. Nothing hit it—no rocks, no objects—just a loud bang, and the glass was gone. I’ve got photos of the damage (attached), and it’s clear this wasn’t caused by an external impact. The glass blew outward, which makes me think it’s a manufacturing defect or stress in the material. Thankfully, no one was hurt, but this is a major safety issue.

ELECTRICAL SYSTEM

There are 2 horns; a high tone and a low tone. The low tone horn failed, making the horn sound difficult to hear. This same issue has been reported by many Ioniq 6 owners. I scheduled an appt w/ a Hyundai dealer and the defective horn was replaced. This happened when the vehicle had less than 3,000 miles.

UNKNOWN OR OTHER

The horn on my vehicle is defective after 16000 miles. I am available to take it in for an inspection. I was almost backed into and I had no way of alerting the other driver. This problem has not been reproduced by my local dealership but it has been at other national and international dealerships per forums. I am unsure if this component has been inspected by the manufacturer, police, insurance company, etc. This problem was random without warning which makes this even more of a safety concern since I had no clue this was defective until I actually had to use it.

ELECTRICAL SYSTEM

The horn on my vehicle is defective after 16000 miles. I am available to take it in for an inspection. I was almost backed into and I had no way of alerting the other driver. This problem has not been reproduced by my local dealership but it has been at other national and international dealerships per forums. I am unsure if this component has been inspected by the manufacturer, police, insurance company, etc. This problem was random without warning which makes this even more of a safety concern since I had no clue this was defective until I actually had to use it.

ELECTRICAL SYSTEM

Shortly after the ICCU recall was repaired I received numerous electrical system warnings on my Hyundai Ioniq 6 (2023, SE model). The dealership identified the problem to be the Battery Management System needed a complete replacement would you take 1-2 weeks. When you factor in three different ICCU service appointments (two SW updates and full replacement) the BMS issue was the fourth electrical / battery issue in the 16 months I've owned the vehicle. Purchased Sept 20, 2023 and have 40k miles.

UNKNOWN OR OTHER

The ioniq 6 horn is a two (2) tone horn. First, one (1) of the tones went out (lower tone). Now, the horn completely doesn't work. Reading online, this is a common issue with the 2023 & 2024 ioniq 6. This is the same horn (car is the same platform) as the ioniq 5, and lots of forums online also have people posting about their horns going out and not working at all.

ELECTRICAL SYSTEM

4 days after having recall 272 performed by the dealer the ICCU on the vehicle failed. Warning lights indicated failure and to stop the vehicle. Luckily, only 1 mile from home and drove it home under reduced power . Called the dealer (70 miles away) and was told to tow the car to them. Car was diagnosed with ICC failure. Replacement had to be ordered but might take at least 4 weeks.