2020 HONDA PASSPORT

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER

Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.

Risk: An air bag that deploys unintentionally during a crash can increase the risk of injury.

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.

BACK OVER PREVENTION:DISPLAY FUNCTION

Honda (American Honda Motor Co.) is recalling certain 2018-2023 Odyssey, 2019-2022 Pilot, and 2019-2023 Passport vehicles. Due to a faulty Media Oriented Systems Transport (MOST) communication coaxial cable connector, the rearview camera image may not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.

Risk: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.

TIRES

Honda (American Honda Motor Co.) is recalling certain 2019-2020 Passport and Pilot vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.

Risk: Overcured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation, which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash or injury.

ELECTRICAL SYSTEM:SOFTWARE

Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."

Risk: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.

EQUIPMENT:OTHER:LABELS

Honda (American Honda Motor Co.) is recalling certain 2020 Passport and Pilot vehicles. The certification label may have been printed with ink that can be wiped away with a solvent, removing the Gross Axle Weight Rating (GAWR) and Gross Vehicle Weight Rating (GVWR) information.

Risk: If the operator is unable to refer to the label information, the vehicle may be overloaded, increasing the risk of a crash.

ELECTRICAL SYSTEM

On 4-5 occasions, the auto shutoff system will shut the vehicle down at a stop light when the brake is depressed. The vehicle did not restart as normal. In order to get the vehicle to restart, the vehicle has to be turned completely off and allowed to sit for 1 minute. The battery was fully charged and less than 1 yr old. The dealer was asked and did not find any problems and could not determine a cause. As a retired couple, this is quite concerning especially when in a major city, fully stopped and unable to get the car moving. The other drivers get upset and angry, which is scary these days. I am concerned that the auto shutoff might engage in heavy interstate stop and go traffic, which could lead to a major highway crash. Interestingly, I just received a note from a law firm filing a class action suit against Honda, if repairs were made. So, clearly there is a defect in the auto shut off system which need to be addressed.

ELECTRICAL SYSTEM

Component Affected: Engine / Auto Idle Stop (AIS) system Crash: No Fire: No Injuries: No Deaths: No Incident 1 •Date: January 30, 2025 •Time: ~9:45 AM •Location: Dysart Rd & E Van Buren St, Avondale, AZ •Witness: Taylor (passenger) •Speed: 0 mph (stopped at red light) •Weather: 49°F ambient temperature Description: While stopped at a red light, the Auto Idle Stop (AIS) system engaged. When I attempted to accelerate as the light turned green, the engine failed to restart. The car was immobilized in the left-hand lane, hazards on, and shifted itself into Park. Multiple attempts to restart failed. After several minutes and repeated actions (cycling ignition, exiting and re-entering the vehicle), the car finally restarted. Safety Concern: The vehicle was disabled in active traffic, creating a hazardous situation for myself, my passenger, and surrounding drivers. Incident 2 •Date: August 13, 2025 •Time: ~6:37 AM •Location: Off-ramp of N Verrado Way & Papago Fwy, Buckeye, AZ •Speed: 0 mph (stopped at ramp light) •Witness: None •Weather: 86°F ambient temperature Description: While stopped on the freeway off-ramp, the AIS engaged. When I attempted to proceed, the engine failed to restart. The vehicle was stuck on the ramp with hazards on and remained inoperative for several minutes until it finally restarted. Safety Concern: The car was disabled on a freeway off-ramp during morning traffic, creating a serious risk of collision. Incident 3 •Date: August 19, 2025 •Time: ~3:04 PM •Location: 1520 N Verrado Way, Buckeye, AZ (Shell gas station parking lot) •Speed: 0 mph (shifting from Park to Reverse) •Weather: 110°F ambient temperature •Witness: None Description: After completing a quick errand, I entered the vehicle, started it normally, and attempted to back out of a parking space. When I shifted into reverse, the engine stalled due to AIS. This time, the car placd itself into Neutral rather than Park. The restart delay was shorter

ENGINE

Component Affected: Engine / Auto Idle Stop (AIS) system Crash: No Fire: No Injuries: No Deaths: No Incident 1 •Date: January 30, 2025 •Time: ~9:45 AM •Location: Dysart Rd & E Van Buren St, Avondale, AZ •Witness: Taylor (passenger) •Speed: 0 mph (stopped at red light) •Weather: 49°F ambient temperature Description: While stopped at a red light, the Auto Idle Stop (AIS) system engaged. When I attempted to accelerate as the light turned green, the engine failed to restart. The car was immobilized in the left-hand lane, hazards on, and shifted itself into Park. Multiple attempts to restart failed. After several minutes and repeated actions (cycling ignition, exiting and re-entering the vehicle), the car finally restarted. Safety Concern: The vehicle was disabled in active traffic, creating a hazardous situation for myself, my passenger, and surrounding drivers. Incident 2 •Date: August 13, 2025 •Time: ~6:37 AM •Location: Off-ramp of N Verrado Way & Papago Fwy, Buckeye, AZ •Speed: 0 mph (stopped at ramp light) •Witness: None •Weather: 86°F ambient temperature Description: While stopped on the freeway off-ramp, the AIS engaged. When I attempted to proceed, the engine failed to restart. The vehicle was stuck on the ramp with hazards on and remained inoperative for several minutes until it finally restarted. Safety Concern: The car was disabled on a freeway off-ramp during morning traffic, creating a serious risk of collision. Incident 3 •Date: August 19, 2025 •Time: ~3:04 PM •Location: 1520 N Verrado Way, Buckeye, AZ (Shell gas station parking lot) •Speed: 0 mph (shifting from Park to Reverse) •Weather: 110°F ambient temperature •Witness: None Description: After completing a quick errand, I entered the vehicle, started it normally, and attempted to back out of a parking space. When I shifted into reverse, the engine stalled due to AIS. This time, the car placd itself into Neutral rather than Park. The restart delay was shorter

ENGINE

The first major issue I just started running into at about 90,000 miles is the engine auto start stop feature. I usually disable it when I drive due to the inability for the car to provide adequate start from a stop, but when I don’t, I’ve had the vehicle completely stall on me at a stoplight and won’t let me restart the vehicle for several minutes leaving me stranded and vulnerable sitting in a lane on a highway. I’ve had about a dozen instances of this issue now over the last several months. The second issue is with the adaptive, cruise control or the emergency, stopping on the vehicle where it will jam on the brakes, even though there are no cars in front of me it inaccurately picks up vehicles in the oncoming lane. There are more than 8 feet separated from my vehicle. I have had the system recalibrated and have complained about it at the dealer, but I’ve been told that there’s nothing wrong with it. Just thought I’d report that as well because it’s almost got me into several accidents by jamming on my brakes for no reason and almost being rear-ended.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The first major issue I just started running into at about 90,000 miles is the engine auto start stop feature. I usually disable it when I drive due to the inability for the car to provide adequate start from a stop, but when I don’t, I’ve had the vehicle completely stall on me at a stoplight and won’t let me restart the vehicle for several minutes leaving me stranded and vulnerable sitting in a lane on a highway. I’ve had about a dozen instances of this issue now over the last several months. The second issue is with the adaptive, cruise control or the emergency, stopping on the vehicle where it will jam on the brakes, even though there are no cars in front of me it inaccurately picks up vehicles in the oncoming lane. There are more than 8 feet separated from my vehicle. I have had the system recalibrated and have complained about it at the dealer, but I’ve been told that there’s nothing wrong with it. Just thought I’d report that as well because it’s almost got me into several accidents by jamming on my brakes for no reason and almost being rear-ended.

STEERING

Compliance bushing cracked and coming apart which is a known common issue with Honda Passports from the 2020 timeframe. Thank you for your time!

POWER TRAIN

The auto idle stop failed to restart at a traffic light. This happened at a busy intersection in heavy traffic. The date given below is the most recent incident; it has happened twice now. Usually I try to remember to disable the idle stop feature, but this time I forgot, and it failed. The first time it happened was November 2024.

ELECTRICAL SYSTEM

The auto idle stop failed to restart at a traffic light. This happened at a busy intersection in heavy traffic. The date given below is the most recent incident; it has happened twice now. Usually I try to remember to disable the idle stop feature, but this time I forgot, and it failed. The first time it happened was November 2024.

FORWARD COLLISION AVOIDANCE: WARNINGS

Numerous times over the past year, the Passports forward collision warning system and automatic braking system have incorrectly alerted and automatically braked the vehicle when it was not warranted in the situation. This occurs most frequently when on a two lane undivided road (with one lane traveling in each direction). While driving on these roads, the vehicle is frequently incorrectly judging a head on collision will occur with oncoming traffic, and start the audible and visual warning system and sometimes also automatic braking. In these instances both vehicles are well within their side of the roadway and no collision is remotely close to occurring. However the automatic hard braking could cause a rear end collision with the vehicle behind me. Seems to be most common on curvy sections of roadway.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Numerous times over the past year, the Passports forward collision warning system and automatic braking system have incorrectly alerted and automatically braked the vehicle when it was not warranted in the situation. This occurs most frequently when on a two lane undivided road (with one lane traveling in each direction). While driving on these roads, the vehicle is frequently incorrectly judging a head on collision will occur with oncoming traffic, and start the audible and visual warning system and sometimes also automatic braking. In these instances both vehicles are well within their side of the roadway and no collision is remotely close to occurring. However the automatic hard braking could cause a rear end collision with the vehicle behind me. Seems to be most common on curvy sections of roadway.

ENGINE

The Passport is equipped with an auto stop/start engine feature. In the last week, while stopped in traffic in the roadway the engine shut off, but did not turn back on causing the car to stall in traffic for several minutes before I was able to restart it. The vehicle shifted to neutral and wouldn't restart until the power was fully off and the door was opened and closed. Both times I was stuck in a travel lanes for approximately 3-5 minutes.

ELECTRICAL SYSTEM

The Passport is equipped with an auto stop/start engine feature. In the last week, while stopped in traffic in the roadway the engine shut off, but did not turn back on causing the car to stall in traffic for several minutes before I was able to restart it. The vehicle shifted to neutral and wouldn't restart until the power was fully off and the door was opened and closed. Both times I was stuck in a travel lanes for approximately 3-5 minutes.

ENGINE

Auto Idle Stop feature fails and I can not get the engine to start for a few minutes. I get stuck in traffic with horns honking behind me and people mad and passing me in an unsafe manner. I have replaced the battery and have had the battery and starter retested; they are OK. I brought it to Easy Honda, in Houston, and they say they can't find anything wrong, since it only happens intermittently. My problem has existed since I bought the vehicle new. I have 55,000 miles on the vehicle. Also, intermittently, the engine will not crank over when it is a hot engine. I live in Houston, so it is hot a lot. I read that this is a problem with millions of Honda and Acura vehicles. When can we get some help on a fix? [XXX] cell [XXX] or [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

TODAY, I WAS MERGING OFF [XXX] TO [XXX] WITH NO CARS OR OBSTACLES AROUND AND THE AUTOMATIC BRAKING SYSTEM DEPLOYED AND THE CAR BRIEFLY SLAMMED ON THE BRAKES AND WHEN I PRESSED DOWN ON THE GAS IT RELEASED ITSELF. LUCKY NO CARS WERE BEHIND ME AT THE TIME BUT IT DID SCARE MY WIFE AND I AT THE TIME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

While stopped at a busy intersection under a red light our 2020 Honda Passport's 'Auto Idle Stop Function' had automatically stopped the engine with the brakes applied, upon releasing the brakes the engine did not restart as it was supposed to. I reapplied the brakes which were no longer 'powered brakes' and tried ot restart the vehicle but it would not start. A message came up on the dash to put the vehicle in park which I did. At that point when starting the vehicle it did start, put it in 'D' and drove past the interection to the relief of all those behind me. Had this been my wife I doubt she would have been able to do this as quickly as I did. This is a safety hazard and Honda needs to have a recall to fix this issue. Currently we are trying to remember to keep the 'Auto Idle Stop Function' in the 'OFF' position. We bought this vehicle new and have kept it in great condition.

UNKNOWN OR OTHER

On a cold winter day the vehicle would not start. With dangerous windchills this could have been very bad had the vehicle been further away from home. The battery and all systems in the vehicle were good. The Honda dealership diagnosed it as having a frozen starter (see attached doccument). Upon warming up the vehicle inside the dealership garage, it started without issues. The dealership said the starter had froze due to condensation inside the starter and that a new version of the starter is available that prevents this from happening. The new starter cost $1600. As shown in the photos the starters are exactly the same but the new version is better sealed to prevent condensation. I feel this should be a recall due to the original part being defective and not sealed properly which caused failure. I have contacted Honda and they refuse to pay for any portion of this defect.

FORWARD COLLISION AVOIDANCE: WARNINGS

Every time I am on a two lane road and am navigating a right hand curve at any speed and a white car or truck is in oncoming traffic, in their lane, the vehicle alerts me to brake. The system beeps and flashes BRAKE! on the instrument panel. This happens each time as if the cameras are not calibrated correctly. It's incredibly annoying and happens every time even with the system turned down as low as Honda will allow. This could be very distracting to many drivers. I have chosen to just ignore the system which is not a good situation.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Every time I am on a two lane road and am navigating a right hand curve at any speed and a white car or truck is in oncoming traffic, in their lane, the vehicle alerts me to brake. The system beeps and flashes BRAKE! on the instrument panel. This happens each time as if the cameras are not calibrated correctly. It's incredibly annoying and happens every time even with the system turned down as low as Honda will allow. This could be very distracting to many drivers. I have chosen to just ignore the system which is not a good situation.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

On Nov 9, 2024 I was pulling into a parking spot in a public parking garage, after turning 2 tight corners to approach the parking spot. About half way into the parking spot, the car suddenly lurched and accelerated and I crashed into a 90 degree concrete corner wall! It happened SO fast, without any warning sounds or ABS brakes deploying. The entire front passenger corner of my car was badly damaged. Luckily I was not injured, nor were there any other vehicles or persons involved. It is just not possible that I could have personally pulled into a parking spot at such a high speed as to cause such extreme damage to the vehicle! I drove the vehicle to a body shop on 11/11/24, which was one recommended by my insurance company. The vehicle was inspected by the body shop, which was directly in contact with my insurance company. I did ask the shop to make sure the mechanic checked for any safety issues during repair, as I was concerned as to the cause of the accident. I have an impeccable driving record and I cannot explain how such an accident could happen! I had no issues with the car previously. Upon further inspection into the damage, on 1/3/25 it was finally evaluated as a total loss, as there was damage to the frame and other issues! I did receive a statement on 1/3/25 from the body shop that there was a "fault in the system, causing gas pedal lock, which might be cause of accident". I felt I had to report this possible issue that resulted in a total loss and obviously could have injured myself, others or other vehicles!

SERVICE BRAKES

On Nov 9, 2024 I was pulling into a parking spot in a public parking garage, after turning 2 tight corners to approach the parking spot. About half way into the parking spot, the car suddenly lurched and accelerated and I crashed into a 90 degree concrete corner wall! It happened SO fast, without any warning sounds or ABS brakes deploying. The entire front passenger corner of my car was badly damaged. Luckily I was not injured, nor were there any other vehicles or persons involved. It is just not possible that I could have personally pulled into a parking spot at such a high speed as to cause such extreme damage to the vehicle! I drove the vehicle to a body shop on 11/11/24, which was one recommended by my insurance company. The vehicle was inspected by the body shop, which was directly in contact with my insurance company. I did ask the shop to make sure the mechanic checked for any safety issues during repair, as I was concerned as to the cause of the accident. I have an impeccable driving record and I cannot explain how such an accident could happen! I had no issues with the car previously. Upon further inspection into the damage, on 1/3/25 it was finally evaluated as a total loss, as there was damage to the frame and other issues! I did receive a statement on 1/3/25 from the body shop that there was a "fault in the system, causing gas pedal lock, which might be cause of accident". I felt I had to report this possible issue that resulted in a total loss and obviously could have injured myself, others or other vehicles!

VEHICLE SPEED CONTROL

On Nov 9, 2024 I was pulling into a parking spot in a public parking garage, after turning 2 tight corners to approach the parking spot. About half way into the parking spot, the car suddenly lurched and accelerated and I crashed into a 90 degree concrete corner wall! It happened SO fast, without any warning sounds or ABS brakes deploying. The entire front passenger corner of my car was badly damaged. Luckily I was not injured, nor were there any other vehicles or persons involved. It is just not possible that I could have personally pulled into a parking spot at such a high speed as to cause such extreme damage to the vehicle! I drove the vehicle to a body shop on 11/11/24, which was one recommended by my insurance company. The vehicle was inspected by the body shop, which was directly in contact with my insurance company. I did ask the shop to make sure the mechanic checked for any safety issues during repair, as I was concerned as to the cause of the accident. I have an impeccable driving record and I cannot explain how such an accident could happen! I had no issues with the car previously. Upon further inspection into the damage, on 1/3/25 it was finally evaluated as a total loss, as there was damage to the frame and other issues! I did receive a statement on 1/3/25 from the body shop that there was a "fault in the system, causing gas pedal lock, which might be cause of accident". I felt I had to report this possible issue that resulted in a total loss and obviously could have injured myself, others or other vehicles!

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

The contact owns a 2020 Honda Passport. The contact stated that while driving at an undisclosed speed, the Forward Collision Avoidance system activated and briefly applied the Automatic Emergency Braking system before returning to normal functionality. The vehicle returned to normal functionality, but the failure became a regular occurrence. The Forward Collision Avoidance warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 35,000.

FORWARD COLLISION AVOIDANCE: WARNINGS

We are currently experiencing very cold weather in my area. I have a Honda Passport that uses a camera for its braking, LKAS, ACC, and other features. During extreme cold, the camera shorts out causing safety systems to fail. Others report the same issue on Honda cars: [XXX] No accident or injury resulted - merely trying to avoid a future safety issue INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

We are currently experiencing very cold weather in my area. I have a Honda Passport that uses a camera for its braking, LKAS, ACC, and other features. During extreme cold, the camera shorts out causing safety systems to fail. Others report the same issue on Honda cars: [XXX] No accident or injury resulted - merely trying to avoid a future safety issue INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)