GOSHEN PACER LS

EQUIPMENT ADAPTIVE/MOBILITY

Goshen Coach (Goshen) is recalling certain modle year 2006-2015 Pacer, Pacer LS, Pacer LTD, GCII, Impulse, Connection, Commander, G-Force, G-Force Access, G-Force LTD, Sentinel, Sentinel UC, and Mainstream Low Floor buses manufactured January 1, 2006, to October 19, 2015, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Risk: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

SEATS

Goshen Coach (Goshen) is recalling certain model year 2014-2015 Pacer, Pacer LS, PacerLTD, GCII, Impulse, Connection, Commander, G-Force, G-Force Access, G-FforceLTD, Sentinel, Sentinel UC, Mainstream Low Floor vehicles manufactured July 1, 2014, to July 27, 2015. The driver and passenger seat mounting space not have been properly tightened. The bolts can come loose and cause the seat to move if involved in a crash. Thus, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) No. 207, "Seating Systems."

Risk: The failure of the seat to stay in place in the event of a crash increases the risk of injury to the occupant in that seat.

SEAT BELTS:FRONT:WEBBING

Goshen Coach (Goshen) is recalling certain model year 2013-2015 Pacer, Pacer LS, Pacer LTD, GCII, Impulse, Connection, Commander, G-Force, G-Force Access, G-Force LTD, Sentinel, Sentinel UC, and Mainstream Low Floor buses manufactured August 26, 2013, to June 18, 2015. In the affected vehicles, the passenger seat belts may rub against the metal seat frame and fray. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

Risk: A frayed seat belt fray may fail to properly restrain the seat occupant in the event of a crash, increasing the risk of injury.

EQUIPMENT

Goshen Coach is recalling certain buses as follows: GC II, model years 2006-2012; GCII-550, model years 2007-2009; G-Force, model years 2011-2012; Pacer, model years 2006-2012; Pacer LS, model years 2008, 2010, and 2013; Pacer LTD, model year 2012; and Sentinel, model year 2011. The buses are equipped with a Ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover.

Risk: The cable may contact the power lug at the base of the wheel chair lift causing a short circuit that could result in a fire.

EQUIPMENT ADAPTIVE/MOBILITY

GOSHEN IS RECALLING CERTAIN MODEL YEAR 2007-2011 TRANSIT BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

Risk: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR’S OCCUPANT COULD FALL AND SUSTAIN INJURY.

EQUIPMENT ADAPTIVE/MOBILITY

GOSHEN COACH HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2008-2010 BUSES MANUFACTURED BETWEEN SEPTEMBER 2007 AND FEBRUARY 2010, EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS, DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

Risk: WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.