2021 GMC SIERRA 2500

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE

General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.

Risk: Rear wheel lock-up can increase the risk of a crash.

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC:CONTROL MODULE

General Motors, LLC (GM) is recalling certain 2021-2022 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 vehicles with electronic brake control modules (EBCM) replaced during vehicle assembly. The bolts that attach the brake pressure modulator valve (BPMV) assembly may not be properly tightened, which could fail to seal the two sub-assemblies and allow water intrusion.

Risk: Water in the BPMV may cause an electrical short circuit and increase the risk of fire.

TIRES:TEMPORARY/EMERGENCY SPARE TIRE

General Motors, LLC. (GM) is recalling certain 2020-2021 Chevrolet Silverado 2500 and GMC Sierra 2500 vehicles equipped with a 17" spare tire (RPO ZHQ or ZXT) and either the 20" accessory road tire (RPO REM) or the 18" accessory road tire (RPO Q2V). Operating the spare tire with other 20" or 18" tires can prevent the Anti-Lock Braking System (ABS) from engaging.

Risk: An ABS system that cannot control the rear wheels independently increases the risk of a crash.

SEAT BELTS

General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used at one or more fastening locations to secure the seat belts to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached to the vehicle.

Risk: If a seat belt assembly is not properly attached to the vehicle, the seat belt may not properly restrain an occupant in the event of a crash, increasing the risk of injury.

ELECTRICAL SYSTEM

When I’m in reverse the up the cameras turn off. On one incident I was backing up and the camera turned off causing me to back up into the wall of my house

LATCHES/LOCKS/LINKAGES

The contact owns a 2021 GMC Sierra 2500. The contact received Manufacturer's Recall Number: N232426400, for water intrusion into the electronic gate-release switch. The vehicle was repaired. The contact stated that six months after the vehicle was repaired, the tailgate failed to operate as intended. While at the residence, the taillights and headlights were flashing. The contact also became aware that the tailgate had unlatched independently while the vehicle was parked. The message "Integrated Tailgate Open or Integrated Tailgate not Latched" was displayed. The contact stated that there was an abnormal clicking sound coming from the actuator when the tailgate opened independently. The vehicle was taken to the dealer, where it was diagnosed that there was water in the switch. The dealer informed the contact that the repairs were already made and, due to the water intrusion into the switch, the dealer refused to redo the repair under the previous recall. The vehicle was repaired. The manufacturer was notified of the failure, and denied assistance since the recall repair was already performed. The failure mileage was approximately 53,000.

SERVICE BRAKES

Parking brake locking up. There is recall on the brake module for my year make and model but my vehicle isn't on the list and I feel it should be. I'm having the same issues as they are. I can't drive it until it is fixed. Very dangerous.

LATCHES/LOCKS/LINKAGES

The contact owns a 2021 GMC Sierra 2500. The contact stated that the VIN was included in NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages) and the main exterior touchpad switch assembly was replaced. The contact stated that after the recall repair the second exterior touchpad switch assembly suddenly short circuited and caused the trunk to open unintendedly. The vehicle was returned to the dealer who stated that that only one exterior touchpad switch assembly was replaced, despite the remedy stating that the exterior touchpad switch assemblies would be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 55,700.

POWER TRAIN

Radiator hose connection broke and loose fluid and transmission got broken

POWER TRAIN

While driving down the highway pulling a trailer the truck started to slow down rapidly. We were able to pull to the side of the road before the truck came to a complete stop on its own. From that point forward, we could not get the truck to move forward even in 4WD. Ended up towing the truck back and a repair shop determined the transmission needed replaced. About 4 months later, we received notice of a recall describing a similar scenario. I submitted the invoice and documentation to GM, but my claim was denied because the codes and symptoms did not match the criteria for the recall.

POWER TRAIN

Hard shifting. Back wheels locking up

LANE DEPARTURE: WARNING

Known issue and has been attributed to a manufacturing defct, but no recall- Leaking headlight caused damage to headlight- now turn signal and headlight do not work. Entire assembly needs to be replaced, GM / Extended Warranty Company will not cover, this safety part. Head light and turn signal were working on the way to the dealer, 1 month later when we picked it up - Right turn signal malfuction reading appeared on dash, headlight blinking and will not work. Picked up on Friday 1/30/25, and made an appointment for the following Wednesday to take it back in. Was told by dealer today that the replacement will not be covered and will cost $2100.00 to replace. This is a safety part and the truck can not be driven legally or safely without both headlights working.

EXTERIOR LIGHTING

Known issue and has been attributed to a manufacturing defct, but no recall- Leaking headlight caused damage to headlight- now turn signal and headlight do not work. Entire assembly needs to be replaced, GM / Extended Warranty Company will not cover, this safety part. Head light and turn signal were working on the way to the dealer, 1 month later when we picked it up - Right turn signal malfuction reading appeared on dash, headlight blinking and will not work. Picked up on Friday 1/30/25, and made an appointment for the following Wednesday to take it back in. Was told by dealer today that the replacement will not be covered and will cost $2100.00 to replace. This is a safety part and the truck can not be driven legally or safely without both headlights working.

EXTERIOR LIGHTING

Headlight vent failed. Hid control board filled up with moisture. Headlight is flashing like emergency vehicle if it turns on at all.

EXTERIOR LIGHTING

The front left headlamp assembly low beam light unexpectedly began to flicker repetitively until the vehicle was turned off. In addition, the left front turn signal was failed, but an indication of the failed turn signal was not always present. The headlamp assembly was taken in for replacement at a local GMC dealership promptly due to safety concerns of operating the vehicle on public roadways with this condition. The safety of others was at risk due to the strobing effect of the flickering lights and not being able to drive the vehicle during conditions where headlights are necessary. The flickering/strobing condition of the headlamp was highly distractive and puts other drivers are risk. In addition, due to the natural height of the vehicle the cast of the beam is closer to the rear view mirror height of the majority of vehicles. The problem was confirmed by a local GMC dealership and was identified as a faulty headlamp assembly. The vehicle was not inspected by any other party besides the dealer who performed the diagnosis and repair. There were no symptoms of warning messages prior to the failure.

ELECTRICAL SYSTEM

Headlights and turn signals failed. Flickering of various lights (Daytime running lamp, low beam, high beam, turn signals) followed by total failure. 3700 dollar repair at dealer to replace both headlamp assemblies. Barely over miles of warranty, but still in the 3 year warranty time period. Not having forward lighting is of course a major safety issue. Vehicle should be recalled. Many others are having the issue.