2020 GMC SIERRA 2500

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE

General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.

Risk: Rear wheel lock-up can increase the risk of a crash.

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

TIRES:TEMPORARY/EMERGENCY SPARE TIRE

General Motors, LLC. (GM) is recalling certain 2020-2021 Chevrolet Silverado 2500 and GMC Sierra 2500 vehicles equipped with a 17" spare tire (RPO ZHQ or ZXT) and either the 20" accessory road tire (RPO REM) or the 18" accessory road tire (RPO Q2V). Operating the spare tire with other 20" or 18" tires can prevent the Anti-Lock Braking System (ABS) from engaging.

Risk: An ABS system that cannot control the rear wheels independently increases the risk of a crash.

STRUCTURE:BODY:HOOD

General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles previously recalled under 20V-142. Some of the vehicles in 20V-324 were not part of Recall 20V-142 but received defect parts during another service (typically during collision repair). The hood-latch striker wires on replacement hoods installed for Safety Recall 20V-142 may not have been heat-treated properly, possibly causing them to fracture.

Risk: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles. The diffuser component of the Roof-Rail Air Bag (RRAB) inflator may not have been properly crimped to the inflator and could separate from the inflator during air bag deployment.

Risk: If the diffuser separates from the inflator during deployment, RRAB performance may be degraded, increasing the risk of injury in a crash.

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The hood-latch striker wires may not have been heat-treated properly, possibly causing them to fracture.

Risk: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.

SEAT BELTS

General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.

Risk: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact stated that while driving approximately 70-80 MPH, the transmission downshifted, and the rear wheels locked up. The contact was able to coast to the side of the road. The contact was unsure if a warning light had illuminated. The vehicle was towed to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. There were metal shavings found mixed in with the transmission fluid; however, the vehicle remained with the dealer unrepaired. The contact was informed by the dealer that the warranty had expired, and the vehicle could not be repaired. The manufacturer was notified of the failure but declined to assist in covering the cost of the repair. The failure mileage was approximately 166,000.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact stated that while her husband was driving 30 MPH, the rear wheels locked up and the vehicle skidded to a complete stop. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission had imploded and needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V797000 (Power Train); the VIN was included but the vehicle had not been repaired. The manufacturer was not notified of the failure. The failure mileage was 125,000.

POWER TRAIN

What component or system failed or malfunctioned, and is it available for inspection upon request? - Transmission Valve Body resulting in a P0700 & P0747 code. Yes currently installed in vehicle. How was your safety or the safety of others put at risk? - When the vehicle goes into a limp mode to protect the transmission and rear-wheel lock up, the truck shuttered and hard downshifted. Speed limit is restricted to 5th gear only. I've been instructed by GM to continue driving and using the vehicle until the problem happens again, knowingly putting myself and others at risk on a second failure that could happen at any time. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes this is a common problem with a recall #N242454440, NHTSA 24V-797. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Mine has been rejected by GM. Although I documented and photographed the failure codes, I cleared them from the vehicle in order to attempt to safely get to the dealer and prevent further damages. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? At the time of failure yes, check engine light and codes from an engine monitor coinciding with the known problems. Engine speed / power was reduced to allow only 5th gear.

POWER TRAIN

After the transmission recall was completed, I’m now having erratic shifting. Having the recall adding software monitoring for a hardware issue is inadequate. Now that I am out of warrentee, gm has not resolved the issue and now I am having shifting problems.

UNKNOWN OR OTHER

Cracks in the rear sliding window plastic upper rail glass guide causing Rear window leaking water and causing mold from water leaking. GMC has a service bulletin number 18-NA-383 knowing of this issue and not telling customers purchasing the GMC vehicle. The service bulletin was released in 2019 before purchasing the truck and they still didn't inform the customers. My child rides in the back in a car seat and now has been breathing in this mold and mildew for how long. I have had my vehicle in with Titus will Gmc in olympia multiple times for service and inspection of various recalls and still didn't inform me of this issue.

UNKNOWN OR OTHER

Tailgate unlatches unexpectedly. Has happened while parked and while driving. Almost caused accident to others.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact stated that the vehicle was under NHTSA Campaign Number: 24V797000 (Power Train) and the vehicle was repaired. The contact stated that after the recall repair, the transmission started shifting hard. The vehicle was taken to the dealer, and the contact was informed that the transmission module would reprogram and adjust independently. The contact stated that a week later, while driving approximately 45 MPH, the vehicle started to run rough, and the message engine power reduced was displayed. The transmission fault, parking brake system alert, service parking brake, and the check engine warning light illuminated. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the fuel injector was open, causing high resistance in the connector for cylinder #4. The transmission could not be diagnosed until the injector was repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was 125,000.

FUEL SYSTEM, DIESEL

The contact owns a 2020 GMC Sierra 2500. The contact stated that the vehicle was under NHTSA Campaign Number: 24V797000 (Power Train) and the vehicle was repaired. The contact stated that after the recall repair, the transmission started shifting hard. The vehicle was taken to the dealer, and the contact was informed that the transmission module would reprogram and adjust independently. The contact stated that a week later, while driving approximately 45 MPH, the vehicle started to run rough, and the message engine power reduced was displayed. The transmission fault, parking brake system alert, service parking brake, and the check engine warning light illuminated. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the fuel injector was open, causing high resistance in the connector for cylinder #4. The transmission could not be diagnosed until the injector was repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was 125,000.

ENGINE AND ENGINE COOLING

The contact owns a 2020 GMC Sierra 2500. The contact stated that the vehicle was under NHTSA Campaign Number: 24V797000 (Power Train) and the vehicle was repaired. The contact stated that after the recall repair, the transmission started shifting hard. The vehicle was taken to the dealer, and the contact was informed that the transmission module would reprogram and adjust independently. The contact stated that a week later, while driving approximately 45 MPH, the vehicle started to run rough, and the message engine power reduced was displayed. The transmission fault, parking brake system alert, service parking brake, and the check engine warning light illuminated. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the fuel injector was open, causing high resistance in the connector for cylinder #4. The transmission could not be diagnosed until the injector was repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was 125,000.

UNKNOWN OR OTHER

I have a notice of a recall for the transmission control module and I took it to a GMC dealership and they are refusing to fix it. The transmission will not shift so I am unable to drive it

STEERING

The contact owns a 2020 GMC Sierra 2500. The contact stated that while driving at various speeds, the steering wheel was pulling to the left unintentionally. Additionally, the contact stated that there was significant play in the steering wheel. The contact stated that while driving 35-40 MPH and driving through a puddle of water, the vehicle veered violently at a 60-degree angle into the left lane while the contact was firmly grabbing the steering wheel, nearly causing a crash. The vehicle was taken to the dealer and was diagnosed with upper steering shaft failure. The contact was informed that the upper steering shaft needed to be replaced. The part was replaced. Additionally, the vehicle was taken to a Tire Shop, where the tires were replaced and alignment was performed. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 31,800.

POWER TRAIN

ODI # 11646185 My truck on [XXX] leaked transmission coolant from the jumper line leak( which this part is recalled but not for my VIN #) $400.61 dollars and left me stranded in the middle of the highway and had to be towed. After the repair and checking the transmission was discovered it was ruined because of the leak. So now I have to have a new transmission installed at Jennings in Beardstown IL to the cost of $7363.39. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

ODI # 11646185 My truck on [XXX] leaked transmission coolant from the jumper line leak( which this part is recalled but not for my VIN #) $400.61 dollars and left me stranded in the middle of the highway and had to be towed. After the repair and checking the transmission was discovered it was ruined because of the leak. So now I have to have a new transmission installed at Jennings in Beardstown IL to the cost of $7363.39. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

Transmission not shifting correctly. Have had the recall software update. Two new valve bodies and still not shifting correctly. Transmission is known to lock up.

UNKNOWN OR OTHER

My truck had been sitting idling for about 20 minutes on a job site on flat level ground. I turn around for whatever reason and my truck is driving forward with on one in it but my dog. The truck ran into an out rigger on my crane. I had 3 of my employees there that witnessed this happen. I got into my truck and the shifter was in drive. Somehow my dog was able to shift my truck into drive from park while it was sitting idle. I have 3 eye witnesses as well as pictures of the incident. I have pictures but was no able to upload them to they portal.

POWER TRAIN

My truck had been sitting idling for about 20 minutes on a job site on flat level ground. I turn around for whatever reason and my truck is driving forward with on one in it but my dog. The truck ran into an out rigger on my crane. I had 3 of my employees there that witnessed this happen. I got into my truck and the shifter was in drive. Somehow my dog was able to shift my truck into drive from park while it was sitting idle. I have 3 eye witnesses as well as pictures of the incident. I have pictures but was no able to upload them to they portal.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact stated while driving 30 MPH, the engine revved while the vehicle lost motive power in the middle of the road. The contact was unable to pull over to the side of the road. The vehicle was restarted but was undrivable. An unknown warning light was illuminated. The contact stated that while the vehicle was being towed, there was a significant amount of fluid leaking onto the ground. The vehicle was towed to Ryan's Repair, where it was diagnosed with a fractured transmission cooler line. The vehicle was not repaired. The mechanic related the failure to an unknown recall. The dealer was not notified of the failure. The manufacturer was notified of the failure, but no assistance was provided because the VIN was not included in the TSB. The failure mileage was approximately 112,000.

STRUCTURE:BODY

Vehicle was parked in a school parking lot. Rear Trailer Harness and modules in back short circuited causing an electrical fire that expanded to the driver’s taillight rear bumper, and bed of truck.

BACK OVER PREVENTION: WARNINGS

Vehicle was parked in a school parking lot. Rear Trailer Harness and modules in back short circuited causing an electrical fire that expanded to the driver’s taillight rear bumper, and bed of truck.

ELECTRICAL SYSTEM

Vehicle was parked in a school parking lot. Rear Trailer Harness and modules in back short circuited causing an electrical fire that expanded to the driver’s taillight rear bumper, and bed of truck.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

STRUCTURE:BODY

While towing my dump trailer early in the morning for about 20 minutes I noticed sudden hard up shifting and down shifting in some gears on flat surface roads. I then proceeded to approach an incline hill about a 5% grade and then, what I've recently learned, my transmission locked up and released for a split second. The roads were slick so it didn't seem too harsh, I continued with no incident for another 40 miles and then it happened again while pulling up a 7% grade in a left hand sharp turn at 40 mph. The truck fish tailed and jack knifed my trailer on the left rear side of my truck and the front left side of the trailer. I was on a one lane road and had to continue until I reached my detitanation, I slowed and maintained a speed of 45 in order to prevent it from happening again but it did it 5 more times before reaching my destination. I'm currently scheduled to have the transmission checked on 02/27/2025 at Peterson's Chevrolet Nampa Idaho. In the meantime, I have no means of using any of my trailers.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacture was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train). After reading the context of the recall, the contact stated that the proposed remedy of a software update was not an adequate repair for the rear wheel lock-up failure. The contact stated that the safety of the vehicle could not be trusted and believed that the vehicle was unsafe to operate. The local dealer was made aware of the issue and confirmed the recall remedy. The contact was referred to the manufacturer for further assistance. The manufacturer was made aware of the issue and the contact proposed a buyback offer for the vehicle which the manufacturer denied. The contact was provided a case number. The contact had not experienced a failure. Parts distribution disconnect.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact stated while driving 63 MPH, and towing a 15,000 lb. 5th Wheel RV, the contact heard the rear wheels make an abnormal squealing or chirping sound. The contact stated that the front end of the vehicle was pulling to the right. The contact adjusted the steering wheel to the left to compensate. The contact stated that the vehicle was losing motive power. The contact stated that the drive(D) symbol was flashing on the instrument cluster. The contact depressed the accelerator pedal; however, the vehicle failed to respond as intended. The contact exited the highway and stopped the vehicle. The contact had the vehicle towed to an independent mechanic. The mechanic scanned the vehicle but did not retrieve any fault codes. The mechanic researched online and informed the contact that the VIN was included in NHTSA Campaign Number: 24V797000 (Power Train) for a defective transmission control valve. The contact was referred to a dealer by the mechanic. The vehicle was not repaired. The contact had the vehicle towed to a local dealer who diagnosed the vehicle and determined that the transmission needed to be replaced. The contact was informed that the transmission was not covered for repairs if damaged while performing the recall repair. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 112,000.

POWER TRAIN

The contact owns a 2020 GMC Sierra 2500. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, and the transmission jerked. The contact stated that the transmission was skipping gear while shifting. The check engine warning light turned on and off. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 114,000. VIN tool confirms parts not available.

ENGINE

The contact owns a 2020 GMC Sierra 2500. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, and the transmission jerked. The contact stated that the transmission was skipping gear while shifting. The check engine warning light turned on and off. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 114,000. VIN tool confirms parts not available.