2010 GLAVAL BUS CONCORDE II

STRUCTURE:EMERGENCY:ESCAPE/EGRESS/EXIT

Forest River, Inc. (Forest River) is recalling certain 2008-2016 Glaval Bus Apollo, Concorde II, Entourage, Legacy, Primetime, Sport, Titan, Titan II, and Titan II Low Floor transit buses manufactured from August 1, 2008, through March 6, 2016. The labels on the rear emergency exit window are not located within 16 centimeters of the release mechanisms as required. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Risk: If the label is not located the correct distance from the mechanism, it may hinder an occupant's ability to open the emergency window and escape from the vehicle quickly in the event of an emergency.

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Glaval Bus is recalling certain model year 2010-2013 Universal, Entourage, Concorde II, Titan, Titan II and Legacy transit buses manufactured June 1, 2010, through June 30, 2013, and equipped with a Ford 5.4L or 6.8L engine and a Trans/Air-brand air conditioner. In the affected vehicles, depending on the routing of the alternator harness, and the orientation of the heater hose spring clamp at the front of the intake manifold, the alternator harness may be pinched between the spring clamp and the air conditioner compressor mounting bracket.

Risk: The charging system may fail which could lead to the vehicle stalling while driving, increasing the risk of a crash. Additionally, the spring clamp could pierce both the positive and negative wires of the alternator harness creating a short circuit which could result in a fire.

EQUIPMENT

Glaval Bus is recalling certain model year 2010-2013 Universal, Concorde II, Entourage, Primetime, Titan II, Apollo, and Sport buses, certain model year 2011-2013 Titan II lf and Legacy buses and certain model year 2010 Synergy buses. The affected buses are equipped with a rear interior air conditioner evaporator which may come loose from its ceiling mounting over time.

Risk: The evaporator unit may detach from the ceiling and fall increasing the risk of injury.

ELECTRICAL SYSTEM

Glaval Bus is recalling certain model year 2009-2010 Entourage, Sport, Universal, Titan, Titan II, Apollo, Primetime, Concorde, and Concorde II transit buses manufactured August 4, 2009, through June 7, 2010 and equipped with A&M Systems-brand electric door actuators. Voltage spikes may damage electrical components and electrical circuits within the actuator, causing the circuit board to develop high resistance.

Risk: High resistance may cause the circuit board to overheat, increasing the risk of a fire.

EQUIPMENT ADAPTIVE/MOBILITY

GLAVAL IS RECALLING CERTAIN BUSES EQUIPPED WITH BRAUN CENTURY-2 AND/OR VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

Risk: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR’S OCCUPANT COULD FALL AND SUSTAIN INJURY.

EQUIPMENT:APPLIANCE:AIR CONDITIONER

GLAVAL IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2007 TRANSIT BUSES BUILT ON FORD, GMC, CHEVROLET, AND FREIGHTLINER CHASSIS AND EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Risk: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.