2020 GILLIG LOW FLOOR
View all complaints and recalls for this specific model year.
2020 GILLIG LOW FLOOR Summary
2020
Model Year
0
Total Complaints
13
Total Recalls
22865
Vehicles Affected
Recalls
2020 GILLIG LOW FLOOR
91 vehicles affected
EQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS
Gillig, LLC (Gillig) is recalling certain 2019-2024 Low Floor transit buses. The rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to detach and fall.
Risk: A monitor that detaches and falls from the ceiling increases the risk of injury.
2020 GILLIG LOW FLOOR
4286 vehicles affected
POWER TRAIN:DRIVELINE:DRIVESHAFT
Gillig, LLC (Gillig) is recalling certain 2019-2023 Low Floor transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.
Risk: A sudden loss of drive power can increase the risk of a crash. Additionally, a disabled bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.
2020 GILLIG LOW FLOOR
169 vehicles affected
ELECTRICAL SYSTEM:PROPULSION SYSTEM: CABLES:FASTENER/CONNECTOR
Gillig, LLC (Gillig) is recalling certain 2019-2022 Low Floor electric transit buses. The EV resolver cable connector may experience a loss of electrical connectivity, unexpectedly switching from Drive to Neutral with no warning.
Risk: An unexpected switch to neutral can cause a loss of vehicle propulsion and increase the risk of a crash.
2020 GILLIG LOW FLOOR
592 vehicles affected
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Gillig, LLC (Gillig) is recalling certain 2014-2021 Low Floor transit buses. The rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "OFF" position.
Risk: The engine may be started unexpectedly, increasing the risk of injury to anyone nearby the engine compartment during maintenance operations.
2020 GILLIG LOW FLOOR
86 vehicles affected
SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Gillig, LLC (Gillig) is recalling certain 2020-2021 Low Floor Diesel, CNG, and Battery Electric buses. The rear axle may come out of alignment during operation.
Risk: An improperly aligned rear axle may cause a loss of vehicle control, increasing the risk of a crash.
2020 GILLIG LOW FLOOR
4428 vehicles affected
FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL
Gillig, LLC. (Gillig) is recalling certain 2017-2020 Low Floor vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
2020 GILLIG LOW FLOOR
78 vehicles affected
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Gillig, LLC (Gillig) is recalling certain 2020-2021 Low Floor vehicles equipped with Cummins L9 Diesel Engines. The engine calibration software's management of the injection of Diesel Exhaust Fluid can allow excessive ammonia into the tailpipe exhaust.
Risk: Exposure to high levels of ammonia can increase the risk of injury.
2020 GILLIG LOW FLOOR
148 vehicles affected
FUEL SYSTEM, DIESEL:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Gillig, LLC (Gillig) is recalling certain 2020-2021 Low Floor vehicles equipped with Cummins L9 Diesel Engines that have remote Stage 2 fuel filters and pressurized hoses. A fuel leak may occur from the fuel hose between the fuel pump and the remote fuel filter head.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
2020 GILLIG LOW FLOOR
229 vehicles affected
STRUCTURE:BODY:DOOR
Gillig, LLC (Gillig) is recalling certain 2020-2021 29, 35, 40-foot Low Floor and BRT buses powered by Compressed Natural Gas (CNG). The overlap between the curb side and street side roof doors is insufficient and may allow the street side door to accidentally open.
Risk: An open door may strike another vehicle or structure, increasing the risk of a crash.
2020 GILLIG LOW FLOOR
3728 vehicles affected
SUSPENSION:REAR
Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor buses. The rear suspension lower control rods may experience fatigue failure due to stiffened end bushings.
Risk: If the rear suspension lower control rod fails, the bus may have reduced handling and stability, increasing the risk of a crash.
2020 GILLIG LOW FLOOR
531 vehicles affected
STEERING:HYDRAULIC POWER ASSIST:PUMP
Gillig, LLC. (Gillig) is recalling certain 2013-2020 hybrid and all-electric Low Floor buses equipped with a steering system that uses a high-voltage electric motor and hydraulic pump assembly to provide power steering assist. The shaft coupling between the motor and pump may fail and cause a loss of hydraulic power steering assist.
Risk: A loss of power steering assist may increase the risk of crash.
2020 GILLIG LOW FLOOR
275 vehicles affected
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor transit buses powered by compressed natural gas (CNG). The thermally activated pressure relief device (PRD) installed on the CNG fuel system may not vent the system when exposed to heat, potentially resulting in the system rupturing.
Risk: If the fuel system ruptures from exposure to heat, there may be an increased risk of injury.
2020 GILLIG LOW FLOOR
8224 vehicles affected
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector.
Risk: With the improper circuit breaker rating, an electrical short in either of these circuits may increase the risk of a fire.
Complaints
No complaints found.