2023 GENESIS GV60

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Hyundai Motor America (Hyundai) is recalling certain Genesis 2023-2025 G90 and GV60 vehicles. Due to a software error, the instrument panel display may fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."

Risk: An instrument panel display that fails to show critical safety information, such as the speedometer or warning lights, increases the risk of a crash.

POWER TRAIN:DRIVELINE:DRIVESHAFT

Hyundai Motor America (Hyundai) is recalling certain 2023 IONIQ 5, IONIQ 6, and Genesis GV60 vehicles. The rear inner driveshaft may have been improperly heat-treated, allowing it to break under load and resulting in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:CHARGING:MODULE:SOFTWARE

Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

POWER TRAIN:DRIVELINE:DRIVESHAFT

Hyundai Motor America (Hyundai) is recalling certain 2023 Genesis GV60 vehicles equipped with an all-wheel drive powertrain system.  The rear driveshafts may fracture, which can result in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

SEAT BELTS:PRETENSIONER

Hyundai Motor America (Hyundai) is recalling certain 2020-2023 Genesis GV80, 2021-2023 Genesis G80, 2022-2023 Genesis GV70, and 2023 Genesis GV60 vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioners may explode upon deployment.

Risk: An exploding seat belt pretensioner can project metal fragments into the vehicle, strike vehicle occupants, and result in injury.

EXTERIOR LIGHTING

The headlights have excessive moisture on the inside. Genesis replaced them once a year ago but now they have moisture on the inside lens so bad that you can't see the LED bulbs. This is a known issue with the GV60 and even though the car is under warranty Genesis will not cover this under warranty, they say it's normal! The moisture is changing the way the headlights light up the road and this moisture issue is a major safety concern. This needs to be fixed, no headlight beam should ever be obstructed by material inside the headlight assembly. Thank You [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SEAT BELTS

I leased a 2023 Genesis GV60, which was misrepresented as new but had multiple safety recalls, including ICCU battery failure, AWD/powertrain malfunction, and seatbelt defects. From the start, the seatbelts didn’t secure properly, and the car failed NY state inspection, causing me to lose a job that required a safe vehicle. Despite six visits to different service centers in 3 months, no actual repairs were completed. Mechanics admitted they didn’t understand the battery defect. The recalls later disappeared from the system without resolution. This is highly unsafe and deceptive. Genesis refused accountability, claiming they don’t control dealership practices—yet they allowed a dealer to fraudulently lease a car with open recalls. They also filed a false insurance claim under my name, inflating my premium and causing me over $33,000 in damages. I visited five other luxury dealers and confirmed that other brands do not allow demo or recall vehicles to be sold this way. Genesis’ refusal to fix or buy back the car and their attempt to cover up recall issues reveals a systemic failure in recall enforcement and corporate responsibility. I urge NHTSA to investigate.

POWER TRAIN

I leased a 2023 Genesis GV60, which was misrepresented as new but had multiple safety recalls, including ICCU battery failure, AWD/powertrain malfunction, and seatbelt defects. From the start, the seatbelts didn’t secure properly, and the car failed NY state inspection, causing me to lose a job that required a safe vehicle. Despite six visits to different service centers in 3 months, no actual repairs were completed. Mechanics admitted they didn’t understand the battery defect. The recalls later disappeared from the system without resolution. This is highly unsafe and deceptive. Genesis refused accountability, claiming they don’t control dealership practices—yet they allowed a dealer to fraudulently lease a car with open recalls. They also filed a false insurance claim under my name, inflating my premium and causing me over $33,000 in damages. I visited five other luxury dealers and confirmed that other brands do not allow demo or recall vehicles to be sold this way. Genesis’ refusal to fix or buy back the car and their attempt to cover up recall issues reveals a systemic failure in recall enforcement and corporate responsibility. I urge NHTSA to investigate.

ELECTRICAL SYSTEM

I leased a 2023 Genesis GV60, which was misrepresented as new but had multiple safety recalls, including ICCU battery failure, AWD/powertrain malfunction, and seatbelt defects. From the start, the seatbelts didn’t secure properly, and the car failed NY state inspection, causing me to lose a job that required a safe vehicle. Despite six visits to different service centers in 3 months, no actual repairs were completed. Mechanics admitted they didn’t understand the battery defect. The recalls later disappeared from the system without resolution. This is highly unsafe and deceptive. Genesis refused accountability, claiming they don’t control dealership practices—yet they allowed a dealer to fraudulently lease a car with open recalls. They also filed a false insurance claim under my name, inflating my premium and causing me over $33,000 in damages. I visited five other luxury dealers and confirmed that other brands do not allow demo or recall vehicles to be sold this way. Genesis’ refusal to fix or buy back the car and their attempt to cover up recall issues reveals a systemic failure in recall enforcement and corporate responsibility. I urge NHTSA to investigate.

POWER TRAIN

I leased a Genesis GV60 in July 2023. The car was under a stop sale order and had to be repaired before it was leased to me because of a known issue with the rear axle. The dealership performed the fix to the vehicle and then proceeded to lease me the vehicle. In January 2025 while driving approximately 40 MPH on a paved flat road, I experienced a sudden thud and loss of power. When I applied pressure to the accelerator a loud angry noise came from the back of the vehicle. Smoke and a burning smell came from the back of the vehicle. There were electrical issues with the car being initial unresponsive to attempts to put the car in park, unlock doors and turn off the vehicle. We left the vehicle on the side of the road. We were in a remote location in a very cold climate with no cell phone signal at dusk. We flagged down a passing-by driver for transport to a safe location where we could call Genesis Emergency Roadside assistance. The car was towed to an authorized Genesis dealership and the rear axle was replaced at no cost to me. Repair staff at the dealership confirmed that based on their inspection there was no indication that the car had experienced any type of impact / injury that could explain the fractured rear axle. In March 2025, again I was driving on a paved flat road going approximately 30 MPH. As I was approaching a stop sign, I again experienced what felt like a sudden thud, and heard a high pitched whine. When I tried to accelerate off the stop sign and cross traffic I again experienced a lack of power with an angry noise and the smell of smoke. The car was towed to the original dealership where the vehicle was purchased and it was confirmed that the rear axle had broken again just two months after having been replaced. I am unwilling to drive the vehicle again our of concern for my safety and that of others.

ELECTRICAL SYSTEM

The vehicle's instrument panel, behind steering wheel displaying things like speed and warning signs, periodically goes blank at start up for between 30 seconds and 15 minutes. There are lots of reports of this problem on sites like Redit and Genesis Forum, however, Genesis has not issued a recall for even a service bulletin. This apparently common problem is a safety hazard as the driver does not have access to critical safety information, including the vehicle's speed, for a period of time. Because this problem is periodic, it is often difficult to verify at the dealership as it does not produce fault codes. This leaves consumers in a bind as the problem persists since the dealership and manufacturer will not always address.

ELECTRICAL SYSTEM

On 3/5/2025 I was driving my car and accelerating to 45 miles per hour when the Stop vehicle and check power supply warning on my car showed on the dash followed by a loud and starting audible tone. I pulled over to check the car and it still worked well. I then went home and tried to charge the vehicle off of our level 2 charger and the vehicle would not start to charge. I brought the car to the dealer the next day after charging the 12 volt battery overnight. I charged the 12 volt battery because the car was no longer charging it as the charging system was not working. The dealer then diagnosed that the ICCU and main fuse were broken and needed replacement. These were the problem parts that previous NHTSA recalls were issued and completed on this vehicle to address this failure. My car still failed with around 6,750 miles driven. I want to let the NHTSA know that the failures of this critical part are still happening despite the manufacturer's recalls being completed in a timely manner.

POWER TRAIN

On 3/5/2025 I was driving my car and accelerating to 45 miles per hour when the Stop vehicle and check power supply warning on my car showed on the dash followed by a loud and starting audible tone. I pulled over to check the car and it still worked well. I then went home and tried to charge the vehicle off of our level 2 charger and the vehicle would not start to charge. I brought the car to the dealer the next day after charging the 12 volt battery overnight. I charged the 12 volt battery because the car was no longer charging it as the charging system was not working. The dealer then diagnosed that the ICCU and main fuse were broken and needed replacement. These were the problem parts that previous NHTSA recalls were issued and completed on this vehicle to address this failure. My car still failed with around 6,750 miles driven. I want to let the NHTSA know that the failures of this critical part are still happening despite the manufacturer's recalls being completed in a timely manner.

POWER TRAIN:AUTOMATIC TRANSMISSION

The contact owns a 2023 Genesis GV60. The contact stated while driving 30 MPH, the front driver’s and passenger's side seat belts failed to lock securely. There were no warning lights illuminated. The dealer was contacted to schedule an appointment. The contact then received a recall letter for an unknown recall repair for the seat belts and the all-wheel drive power train. The vehicle was repaired; however, the failure persisted. The contact then started to hear an abnormal sound coming from the vehicle. The dealer was contacted and scheduled a second appointment. The dealer repaired the driver's side seat belt; however, the failure persisted with the front passenger's seat belt, and the all-wheel drive. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100.

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

The contact owns a 2023 Genesis GV60. The contact stated while driving 30 MPH, the front driver’s and passenger's side seat belts failed to lock securely. There were no warning lights illuminated. The dealer was contacted to schedule an appointment. The contact then received a recall letter for an unknown recall repair for the seat belts and the all-wheel drive power train. The vehicle was repaired; however, the failure persisted. The contact then started to hear an abnormal sound coming from the vehicle. The dealer was contacted and scheduled a second appointment. The dealer repaired the driver's side seat belt; however, the failure persisted with the front passenger's seat belt, and the all-wheel drive. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100.

UNKNOWN OR OTHER

Upon startup, the dashboard cluster that displays safety information and the speedometer did not power on until several minutes had passed. This happens randomly. This console includes the safety warning information and the speedometer and is not the infotainment screen (which worked as it should). This has not been reported to the dealership yet, though the issue is known and discussed on several owner forums.

ELECTRICAL SYSTEM

This car is fully electric. Upon start up in cold weather and for up to about 5 miles thereafter, the instrument panel remains black. This eliminates any displayed driving information including warnings, speedometer, driving mode and other items such as brake regeneration, etc. The distance traveled before the panel eventually energizes appears to be increasing. All other vehicle functions continue to operate. A saving grace for my car is that it displays the speed in the heads-up-display but all other information is unavailable. The dealer has determined that the instrument panel will be replaced under warranty. They state that the book price for the panel is in excess of $9,000! The car has approximately 23K mi at this time (1/13/2025)

VEHICLE SPEED CONTROL

Completed NHTSA recall 24V-868 at my dealer December 13th 2024. ICCU failed on 1/1/2025 and I am awaiting on the 3rd ICCU for my vehicle in less than 2 years. Similar issue happened December 2023, completed the ICCU recall and had the ICCU fail in a similar fashion.

POWER TRAIN

Completed NHTSA recall 24V-868 at my dealer December 13th 2024. ICCU failed on 1/1/2025 and I am awaiting on the 3rd ICCU for my vehicle in less than 2 years. Similar issue happened December 2023, completed the ICCU recall and had the ICCU fail in a similar fashion.

ELECTRICAL SYSTEM

Completed NHTSA recall 24V-868 at my dealer December 13th 2024. ICCU failed on 1/1/2025 and I am awaiting on the 3rd ICCU for my vehicle in less than 2 years. Similar issue happened December 2023, completed the ICCU recall and had the ICCU fail in a similar fashion.