2022 FORD MUSTANG MACH E

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)

Ford Motor Company (Ford) is recalling certain 2022 Mustang Mach E vehicles equipped with an extended range battery. The high voltage battery main contactors may overheat.

Risk: An overheated high voltage battery contactor can result in a loss of drive power, increasing the risk of a crash.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2021-2025 Mustang Mach E vehicles. In the event of a low battery charge, the electronic door latches may remain locked once the driver or front passenger exits and shuts the door, possibly trapping someone who is unable to use the inside door release handles, such as a child in the back seat.

Risk: The inability to enter or exit the vehicle in an emergency increases the risk of injury.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM):SOFTWARE

Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E vehicles previously repaired incorrectly under recall number 22V-412. The high voltage battery main contactors may overheat.

Risk: An overheated high voltage battery contactor may cause the vehicle to lose drive power, increasing the risk of a crash.

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)

Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E vehicles equipped with an extended range battery. The high voltage battery main contactors may overheat.

Risk: An overheated high voltage battery contactor can result in a loss of drive power, increasing the risk of a crash.

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

Ford Motor Company (Ford) is recalling certain 2022 Mustang Mach-E vehicles. The right-rear axle half shafts may have been manufactured improperly, allowing the half shaft stem to break under load.

Risk: A broken half shaft can cause a loss of drive power, or a rollaway could occur while parked if the electronic parking brake is not engaged. Either of these scenarios can increase the risk of a crash.

ELECTRICAL SYSTEM

My wife was driving on the parkway when her Mustang Mach-E started flashing multiple warning messages on the HUD. The vehicle suddenly died with no power. She was in a center lane of traffic in a 6-lane section. The vehicle did not let her put the car into neutral to push it out of the way. When they tried to get back into the car they found that it would not open and after she and the police officer who stopped searched Google and YouTube, they learned that there is no way to manually open the vehicle with no power. This was confirmed by the dealership.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The front camera has failed. The automatic emergency breaking, the adaptive cruise control, and normal cruise control do not work, at all. The camera began to fail within the first year of ownership but it would start to work shortly after. After about 1.5 years of ownership, there was a permanent sign of malfunction on the screen, making the above features inoperable.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

The front camera has failed. The automatic emergency breaking, the adaptive cruise control, and normal cruise control do not work, at all. The camera began to fail within the first year of ownership but it would start to work shortly after. After about 1.5 years of ownership, there was a permanent sign of malfunction on the screen, making the above features inoperable.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The Adaptive Cruise Control indicated speed lags when user changes speed. The lag will fluctuate from non-existent to 4-5sec at times. It occurs at different speeds and for different changes (e.g., speeding up to 45mph or speeding down to 25mph.) It also occurs when changing speeds in different increments (e.g., one click up for 1mph increase or hold down for 5mph decrease.) The lag is only in the display and not the actual drivetrain, meaning that the selected speed in the Adaptive Control indicator is not relaying the selected speed even though the car itself is changing speed. This is a safety issue as you don't know whether the car has registered a speed increase or decrease for several seconds (which at higher speeds is certainly not safe.) There was an OTA related to the Instrument Control Panel sent earlier this summer that was successfully installed, IPC-25.7.46, however this may be a coincidence. After calling multiple times to Ford, including their OTA update team, their EV Technology Team, and a generic Customer Experience team, I was told to bring it into a dealership AND submit a complaint to NHTSA. The dealership identified modules that required updating but that did not fix the issue. Ford has NOT been helpful and their Customer Experience reps have been dismissive of the seriousness of this issue.

UNKNOWN OR OTHER

I was waiting in a drive thru behind a line of cars at a full stop for some time, so I was using One Pedal assist/Auto Hold. My car suddenly accelerated and slammed into the car in front of me.

VEHICLE SPEED CONTROL

I was waiting in a drive thru behind a line of cars at a full stop for some time, so I was using One Pedal assist/Auto Hold. My car suddenly accelerated and slammed into the car in front of me.

SERVICE BRAKES

I was waiting in a drive thru behind a line of cars at a full stop for some time, so I was using One Pedal assist/Auto Hold. My car suddenly accelerated and slammed into the car in front of me.

FORWARD COLLISION AVOIDANCE: WARNINGS

Shortly after purchasing my vehicle on [XXX], specifically on [XXX] a significant malfunction was encountered, indicated by the 'Front Camera Fault Service Required' and 'Pre-Collision Assist Not Available' warnings. Returning to the dealership on May 5th, the manager misinformed, stating the issue was a recall and required service at a Ford dealership. However, upon contacting Ford Lincoln with the VIN, it was discovered these codes are not associated with any recall. I returned to the dealership, provided them the printout from Ford Lincoln explaining the codes and how it's not a recall. They then told me that they will not honor the repairs due to me exceeding my 30-day extension. I proceeded to leave and said I'll deal with it when it poses a problem. After a resent software update, a new code popped up saying "Door Fault Service Required". July 2025 Koons Ford picked my car up and they confirmed that the issues documented in the attached photos are not covered by any recalls. However, this experience is further corroborated by attached photos and testimony from others reporting identical recurring problems since 2022. You can reference to the [XXX] " for the other vehicle owner's testimony. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Shortly after purchasing my vehicle on [XXX], specifically on [XXX] a significant malfunction was encountered, indicated by the 'Front Camera Fault Service Required' and 'Pre-Collision Assist Not Available' warnings. Returning to the dealership on May 5th, the manager misinformed, stating the issue was a recall and required service at a Ford dealership. However, upon contacting Ford Lincoln with the VIN, it was discovered these codes are not associated with any recall. I returned to the dealership, provided them the printout from Ford Lincoln explaining the codes and how it's not a recall. They then told me that they will not honor the repairs due to me exceeding my 30-day extension. I proceeded to leave and said I'll deal with it when it poses a problem. After a resent software update, a new code popped up saying "Door Fault Service Required". July 2025 Koons Ford picked my car up and they confirmed that the issues documented in the attached photos are not covered by any recalls. However, this experience is further corroborated by attached photos and testimony from others reporting identical recurring problems since 2022. You can reference to the [XXX] " for the other vehicle owner's testimony. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VEHICLE SPEED CONTROL

Shortly after purchasing my vehicle on [XXX], specifically on [XXX] a significant malfunction was encountered, indicated by the 'Front Camera Fault Service Required' and 'Pre-Collision Assist Not Available' warnings. Returning to the dealership on May 5th, the manager misinformed, stating the issue was a recall and required service at a Ford dealership. However, upon contacting Ford Lincoln with the VIN, it was discovered these codes are not associated with any recall. I returned to the dealership, provided them the printout from Ford Lincoln explaining the codes and how it's not a recall. They then told me that they will not honor the repairs due to me exceeding my 30-day extension. I proceeded to leave and said I'll deal with it when it poses a problem. After a resent software update, a new code popped up saying "Door Fault Service Required". July 2025 Koons Ford picked my car up and they confirmed that the issues documented in the attached photos are not covered by any recalls. However, this experience is further corroborated by attached photos and testimony from others reporting identical recurring problems since 2022. You can reference to the [XXX] " for the other vehicle owner's testimony. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

The recall has no estimated repair date: the initial notification was June 16th. This has passed a reasonable amount of time, with no repair but a "we think we might fix it around the 3rd quarter of 2025" - definitely not satisfying the law. Tesla already had one death from entrapment post accident: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

LATCHES/LOCKS/LINKAGES

The contact owns a 2022 Ford Mustang Mach-E. The contact received notification of NHTSA Campaign Number: 25V404000 (Electrical System, Latches/Locks/Linkages); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while attempting to exit the vehicle, the doors automatically locked independently. The contact called AAA o assist with unlocking the vehicle to be able to exit the vehicle. The dealer was contacted and confirmed that there was no fix yet available. The manufacturer was made aware of the failure and sent AAA to assist the contact. The failure mileage was unknown. VIN tool confirms parts not available.

ELECTRICAL SYSTEM

The contact owns a 2022 Ford Mustang Mach-E. The contact received notification of NHTSA Campaign Number: 25V404000 (Electrical System, Latches/Locks/Linkages); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while attempting to exit the vehicle, the doors automatically locked independently. The contact called AAA o assist with unlocking the vehicle to be able to exit the vehicle. The dealer was contacted and confirmed that there was no fix yet available. The manufacturer was made aware of the failure and sent AAA to assist the contact. The failure mileage was unknown. VIN tool confirms parts not available.

FUEL/PROPULSION SYSTEM

I was driving my car when all of a sudden it lost all acceleration and power, I was lucky that I wasn't on the highway anymore and was able to pull over safely on a side street while car was rolling still. Dealer said 12V battery fused, and I have been reading forums where this is a common issue.. In a normal ICE car when 12V battery dies while driving, car can still drive, in this case, it just stops and pops up a dozen errors about everything being broken.

POWER TRAIN

I was driving my car when all of a sudden it lost all acceleration and power, I was lucky that I wasn't on the highway anymore and was able to pull over safely on a side street while car was rolling still. Dealer said 12V battery fused, and I have been reading forums where this is a common issue.. In a normal ICE car when 12V battery dies while driving, car can still drive, in this case, it just stops and pops up a dozen errors about everything being broken.

SERVICE BRAKES

Vehicle Information: •Make: Ford •Model: Mach-E •Model Year: 2022 •Vehicle Type: Electric SUV •VIN: [XXX] •Mileage at time of incident: 31114 •Purchased in: California Incident Date: [XXX] Location: Laguna Niguel, CA Injury: Yes Crash: Yes Fire: No Airbags Deployed: No Police Report Filed: Yes Description of Complaint: On or around [XXX], I was driving my 2022 Ford Mach-E when the steering wheel suddenly locked and the braking system failed completely. I lost all control of the vehicle and was unable to slow or steer the car, leading to a crash. Despite the severity of the incident, the airbags did not deploy. At the time, I did not have obvious injuries, but shortly afterward, I began to experience severe pain and physical impairment, including an inability to stand or walk without difficulty. These symptoms have worsened and are now impacting my daily life. The vehicle is now completely inoperable and appears to have suffered a critical system malfunction, possibly involving its electric or software control systems. There were no warning lights or indicators before the failure. I believe this is a serious safety defect in the Ford Mach-E and could pose a danger to other drivers. I am requesting that the NHTSA investigate whether this is part of a broader pattern of defects affecting Ford’s EV line and take action to prevent further injuries or fatalities. Contact Information: •Name: [XXX] •Phone: [XXX] •Email: [XXX] •Preferred contact method: email INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

Vehicle Information: •Make: Ford •Model: Mach-E •Model Year: 2022 •Vehicle Type: Electric SUV •VIN: [XXX] •Mileage at time of incident: 31114 •Purchased in: California Incident Date: [XXX] Location: Laguna Niguel, CA Injury: Yes Crash: Yes Fire: No Airbags Deployed: No Police Report Filed: Yes Description of Complaint: On or around [XXX], I was driving my 2022 Ford Mach-E when the steering wheel suddenly locked and the braking system failed completely. I lost all control of the vehicle and was unable to slow or steer the car, leading to a crash. Despite the severity of the incident, the airbags did not deploy. At the time, I did not have obvious injuries, but shortly afterward, I began to experience severe pain and physical impairment, including an inability to stand or walk without difficulty. These symptoms have worsened and are now impacting my daily life. The vehicle is now completely inoperable and appears to have suffered a critical system malfunction, possibly involving its electric or software control systems. There were no warning lights or indicators before the failure. I believe this is a serious safety defect in the Ford Mach-E and could pose a danger to other drivers. I am requesting that the NHTSA investigate whether this is part of a broader pattern of defects affecting Ford’s EV line and take action to prevent further injuries or fatalities. Contact Information: •Name: [XXX] •Phone: [XXX] •Email: [XXX] •Preferred contact method: email INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AIR BAGS

Vehicle Information: •Make: Ford •Model: Mach-E •Model Year: 2022 •Vehicle Type: Electric SUV •VIN: [XXX] •Mileage at time of incident: 31114 •Purchased in: California Incident Date: [XXX] Location: Laguna Niguel, CA Injury: Yes Crash: Yes Fire: No Airbags Deployed: No Police Report Filed: Yes Description of Complaint: On or around [XXX], I was driving my 2022 Ford Mach-E when the steering wheel suddenly locked and the braking system failed completely. I lost all control of the vehicle and was unable to slow or steer the car, leading to a crash. Despite the severity of the incident, the airbags did not deploy. At the time, I did not have obvious injuries, but shortly afterward, I began to experience severe pain and physical impairment, including an inability to stand or walk without difficulty. These symptoms have worsened and are now impacting my daily life. The vehicle is now completely inoperable and appears to have suffered a critical system malfunction, possibly involving its electric or software control systems. There were no warning lights or indicators before the failure. I believe this is a serious safety defect in the Ford Mach-E and could pose a danger to other drivers. I am requesting that the NHTSA investigate whether this is part of a broader pattern of defects affecting Ford’s EV line and take action to prevent further injuries or fatalities. Contact Information: •Name: [XXX] •Phone: [XXX] •Email: [XXX] •Preferred contact method: email INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

The contact owns a 2022 Ford Mustang Mach-E. The contact stated that the rear driver's side door and passenger's side doors failed to open intermittently. The vehicle was taken to an unknown dealer, where the failure could not be duplicated. The contact later became aware that the VIN was included in NHTSA Campaign Number: 25V404000 (Electrical System, Latches/Locks/Linkages), which the contact related to the failure; however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and advised the contact that the VIN was not included in the recall; however, the VIN tool confirmed that the VIN was included in the recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 25,000. VIN tool confirms parts not available.

LATCHES/LOCKS/LINKAGES

The contact owns a 2022 Ford Mustang Mach-E. The contact stated that the rear driver's side door and passenger's side doors failed to open intermittently. The vehicle was taken to an unknown dealer, where the failure could not be duplicated. The contact later became aware that the VIN was included in NHTSA Campaign Number: 25V404000 (Electrical System, Latches/Locks/Linkages), which the contact related to the failure; however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and advised the contact that the VIN was not included in the recall; however, the VIN tool confirmed that the VIN was included in the recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 25,000. VIN tool confirms parts not available.

ELECTRICAL SYSTEM

The contact owns a 2022 Ford Mustang Mach E. The contact received notification of NHTSA Campaign Number: 25V404000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted and advised the contact that the part to do the recall might be available by the end of 2025. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

ELECTRICAL SYSTEM

My 2022 Ford Mustang Mach-E has experienced a complete failure of the front passenger door latch. The electronic latch (e-latch) button does not light up or respond, and the door remains fully open and cannot be latched or secured. This occurred without any damage or external cause. I’ve been informed that this issue requires full latch replacement at my expense, totaling over $760. I’m also aware of a pending recall (25S65) related to 12V discharge and door latch functionality, but I’ve been told my vehicle is not currently covered — even though the symptoms appear directly related. This is a safety-critical failure because the door cannot be secured while driving, creating a serious risk of passenger ejection in motion. This issue appears to be common among early Mach-E models and should be formally investigated.

ELECTRICAL SYSTEM

I was driving my car like normal when a handful of warning signs popped up on the front screen and the brakes went out. I could only stop by pushing on the pedal with all my force, and it eventually slowed the car to a stop, but took an incredibly long distance to do so. A handful of warning lights popped on the screen when this happened: -Power train malfunction/reduced power - antilock brake fault - pre collision assist not available - hill start assist warning

SERVICE BRAKES

I was driving my car like normal when a handful of warning signs popped up on the front screen and the brakes went out. I could only stop by pushing on the pedal with all my force, and it eventually slowed the car to a stop, but took an incredibly long distance to do so. A handful of warning lights popped on the screen when this happened: -Power train malfunction/reduced power - antilock brake fault - pre collision assist not available - hill start assist warning

AIR BAGS

The contact owns a 2022 Ford Mustang Mach E. The contact stated that while driving approximately 20 MPH and pressing the brake pedal to stop, the vehicle suddenly accelerated forward and crashed into the rear of a second vehicle. Before the crash, the pre-collision warning had activated, but the vehicle did not stop. The front end of the had sustained severe damage but no bags deployed. No injuries were reported. A police report was taken at the scene, and the vehicle was later towed to a nearby collision facility. The cause of the failures has not yet been determined. The manufacturer and local dealer have not yet been contacted. The failure mileage was 19,100.

SERVICE BRAKES

The contact owns a 2022 Ford Mustang Mach E. The contact stated that while driving approximately 20 MPH and pressing the brake pedal to stop, the vehicle suddenly accelerated forward and crashed into the rear of a second vehicle. Before the crash, the pre-collision warning had activated, but the vehicle did not stop. The front end of the had sustained severe damage but no bags deployed. No injuries were reported. A police report was taken at the scene, and the vehicle was later towed to a nearby collision facility. The cause of the failures has not yet been determined. The manufacturer and local dealer have not yet been contacted. The failure mileage was 19,100.

VEHICLE SPEED CONTROL

The contact owns a 2022 Ford Mustang Mach E. The contact stated that while driving approximately 20 MPH and pressing the brake pedal to stop, the vehicle suddenly accelerated forward and crashed into the rear of a second vehicle. Before the crash, the pre-collision warning had activated, but the vehicle did not stop. The front end of the had sustained severe damage but no bags deployed. No injuries were reported. A police report was taken at the scene, and the vehicle was later towed to a nearby collision facility. The cause of the failures has not yet been determined. The manufacturer and local dealer have not yet been contacted. The failure mileage was 19,100.

STRUCTURE:BODY

Glass roof was cracked in December by what looked like a shell dropped on the top. Had it repaired by insurance on January 16, 2025. Less than two months later, there is another crack that appeared out of no where. Was not at work that week and the car was parked in my garage. I never felt any impact of any kind. Sent pics to insurance (sunroof express) and they are refusing to cover it under warranty.

POWER TRAIN

- What component or system failed or malfunctioned, and is it available for inspection upon request? According to the technician, there was a 12-volt battery in the beginning, but after staying in the shop for three days, they found that it was HVBJB, also known as the bussed electrical center (BEC). The car was recalled last July and was in the shop for about a month for HVBJB, also known as the bussed electrical center (BEC). The shop had already replaced the part last year. - How was your safety or the safety of others put at risk? The car suddenly stopped and lost battery power when I was driving on [XXX] going to [XXX]. Las Vegas, Nevada. The car turned off, and there was an error message on the screen. I could not move the car anymore. "When the car suddenly stopped, my wife and I felt like we had hit a wall at 45 miles per hour". - Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

- What component or system failed or malfunctioned, and is it available for inspection upon request? According to the technician, there was a 12-volt battery in the beginning, but after staying in the shop for three days, they found that it was HVBJB, also known as the bussed electrical center (BEC). The car was recalled last July and was in the shop for about a month for HVBJB, also known as the bussed electrical center (BEC). The shop had already replaced the part last year. - How was your safety or the safety of others put at risk? The car suddenly stopped and lost battery power when I was driving on [XXX] going to [XXX]. Las Vegas, Nevada. The car turned off, and there was an error message on the screen. I could not move the car anymore. "When the car suddenly stopped, my wife and I felt like we had hit a wall at 45 miles per hour". - Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

- What component or system failed or malfunctioned, and is it available for inspection upon request? According to the technician, there was a 12-volt battery in the beginning, but after staying in the shop for three days, they found that it was HVBJB, also known as the bussed electrical center (BEC). The car was recalled last July and was in the shop for about a month for HVBJB, also known as the bussed electrical center (BEC). The shop had already replaced the part last year. - How was your safety or the safety of others put at risk? The car suddenly stopped and lost battery power when I was driving on [XXX] going to [XXX]. Las Vegas, Nevada. The car turned off, and there was an error message on the screen. I could not move the car anymore. "When the car suddenly stopped, my wife and I felt like we had hit a wall at 45 miles per hour". - Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)