2023 FORD MAVERICK

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles previously repaired incorrectly under recall number 24V-140. The instrument panel cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays," and 102, "Transmission shift position sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 105, 108, and 208.

Risk: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.

EXTERIOR LIGHTING:TURN SIGNAL

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal has failed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: A nonfunctioning exterior turn signal cannot notify other drivers that the vehicle is turning, increasing the risk of a crash.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.

Risk: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.

ENGINE

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire increases the risk of injury.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

EXTERIOR LIGHTING:TAIL LIGHTS

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293. The body control module (BCM) may inadvertently deactivate one or both rear tail lights.

Risk: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.

ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Ford Motor Company (Ford) is recalling certain 2023-2024 Maverick, Ford Bronco Sport, and Mustang Mach-E vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.

Risk: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2022-2024 Ford Maverick vehicles equipped with Connected Touch Radios (CTR). The rearview camera image may freeze when the vehicle is in reverse.

Risk: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

EXTERIOR LIGHTING:TAIL LIGHTS

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. The Body Control Module (BCM) may inadvertently deactivate one or both rear tail lights.

Risk: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles. The Instrument Panel Cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays," and 102, "Transmission shift position sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 105, 108, and 208.

Risk: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.

TIRES

Ford Motor Company (Ford) is recalling certain 2023 Maverick and Bronco Sport vehicles. The tires may have been manufactured incorrectly, which may result in a loss of vehicle handling and control.

Risk: A loss of vehicle handling and control increases the risk of a crash.

ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: A nonfunctioning exterior turn signal will not notify other drivers that the vehicle is turning, increasing the risk of a crash.

EXTERIOR LIGHTING:TAIL LIGHTS

Ford Motor Company (Ford) is recalling certain 2023 Maverick vehicles. A missing electrical circuit may cause the trailer taillights to not illuminate as intended when utilizing the vehicle trailer tow electrical connector. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: Trailer taillights that do not illuminate as intended can increase the risk of a crash.

POWER TRAIN

CV axles failed at 30,000 miles, repaired under warranty. Replaced axles have failed again at 60,000 miles, no warranty. No hard driving, simply highway miles. This seems to be common in these vehicles and need to be recalled for defective parts. This has caused me poor fuel mileage, damage to new tires, instability while driving, and possible unknown damage to transaxle.

ELECTRICAL SYSTEM

The 12-volt battery loses charge and issues a warning that remote features have been disabled. This issue has been going on since January 2025. To date, I have recharged the battery 15 times, plus taken it to 2-different Ford dealerships for warranty service. Both were unable to resolve the problem. Beginning with the 2025 model year, Ford commenced installing AGM 12-volt batteries which resolved the problem. The vehicle is still under warranty but the dealerships simply recharge the battery and return the vehicle. My vehicle is not part of the Ford recall for this problem. The root cause appears to be poor quality Chinese batteries used in the early model years.

POWER TRAIN

At approximately 37,000 miles, the CV axles on my 2023 Ford Maverick Hybrid required replacement due to premature wear. Now, at around 62,200 miles, the vehicle is experiencing excessive vibration and shaking during acceleration, particularly noticeable at moderate to high speeds. This issue appears to be related to the powertrain or suspension system and may indicate a recurring or unresolved problem with the CV axles or associated components. The vibrations are severe enough to affect vehicle control, especially during lane changes or merging onto highways. When accelerating to merge into highway traffic, the vehicle shakes and vibrates so profusely that it feels like the car is going to shake apart. This makes it difficult to accelerate normally and safely, putting both the driver and surrounding vehicles at risk. The shaking could lead to loss of traction or steering instability, increasing the likelihood of an accident. This issue has been widely reported by other Ford Maverick owners and has been a frequently discussed problem in forums and owner communities for over a year. Despite its prevalence, there appears to be no long-term fix other than replacing the CV axle assembly with the same OEM part, which may be the root cause of the problem. That is why I feel it is important to bring this to your attention — it is a known issue with no real correction, and it continues to affect vehicle safety. No warning lights or messages appeared prior to the onset of the problem. The component is available for inspection upon request.

SUSPENSION

At approximately 37,000 miles, the CV axles on my 2023 Ford Maverick Hybrid required replacement due to premature wear. Now, at around 62,200 miles, the vehicle is experiencing excessive vibration and shaking during acceleration, particularly noticeable at moderate to high speeds. This issue appears to be related to the powertrain or suspension system and may indicate a recurring or unresolved problem with the CV axles or associated components. The vibrations are severe enough to affect vehicle control, especially during lane changes or merging onto highways. When accelerating to merge into highway traffic, the vehicle shakes and vibrates so profusely that it feels like the car is going to shake apart. This makes it difficult to accelerate normally and safely, putting both the driver and surrounding vehicles at risk. The shaking could lead to loss of traction or steering instability, increasing the likelihood of an accident. This issue has been widely reported by other Ford Maverick owners and has been a frequently discussed problem in forums and owner communities for over a year. Despite its prevalence, there appears to be no long-term fix other than replacing the CV axle assembly with the same OEM part, which may be the root cause of the problem. That is why I feel it is important to bring this to your attention — it is a known issue with no real correction, and it continues to affect vehicle safety. No warning lights or messages appeared prior to the onset of the problem. The component is available for inspection upon request.

UNKNOWN OR OTHER

At approximately 37,000 miles, the CV axles on my 2023 Ford Maverick Hybrid required replacement due to premature wear. Now, at around 62,200 miles, the vehicle is experiencing excessive vibration and shaking during acceleration, particularly noticeable at moderate to high speeds. This issue appears to be related to the powertrain or suspension system and may indicate a recurring or unresolved problem with the CV axles or associated components. The vibrations are severe enough to affect vehicle control, especially during lane changes or merging onto highways. When accelerating to merge into highway traffic, the vehicle shakes and vibrates so profusely that it feels like the car is going to shake apart. This makes it difficult to accelerate normally and safely, putting both the driver and surrounding vehicles at risk. The shaking could lead to loss of traction or steering instability, increasing the likelihood of an accident. This issue has been widely reported by other Ford Maverick owners and has been a frequently discussed problem in forums and owner communities for over a year. Despite its prevalence, there appears to be no long-term fix other than replacing the CV axle assembly with the same OEM part, which may be the root cause of the problem. That is why I feel it is important to bring this to your attention — it is a known issue with no real correction, and it continues to affect vehicle safety. No warning lights or messages appeared prior to the onset of the problem. The component is available for inspection upon request.

UNKNOWN OR OTHER

I have previously had the backup camera recall repaired/updated the software and it worked fine for awhile. This week I had it freeze up on me and almost cause me to back end to another vehicle

UNKNOWN OR OTHER

violent shaking on accelerating

ELECTRICAL SYSTEM

Battery in truck continually dead Malfunctioning equipment had left me stranded Vehicle has been inspected numerous times and ford will Not fix

ELECTRICAL SYSTEM

The contact owns a 2023 Ford Maverick. The contact stated that on three occasions, while the vehicle was parked, the vehicle failed to start. The contact attempted to jumpstart the vehicle however, the vehicle failed to start. The vehicle was taken to a dealer to be diagnosed, and it was determined that the battery needed to be replaced. The vehicle was repaired but the failure reoccurred three months later. The contact stated that the dealer replaced the battery, and the vehicle was taken to the dealer, where it was determined that the battery was defective and needed to be replaced. The battery was replaced however, the failure reoccurred approximately four months later. The vehicle was taken to a different dealer, where it was diagnosed that the battery needed to be replaced. The manufacturer was notified of the failure. The contact believed that the failure was related to Manufacturer Recall Number: 53801. The failure mileage was approximately 22,000.

POWER TRAIN

Both front axles had to be replaced at 62000 miles. Just about of fords power train warranty. Have read multiple issues of these trucks having the same problem.

STEERING

2023 Maverik Hybrid at around 30,000 miles Vehicle would start shaking while accelerating. I took it to the dealership and they had to replace all the components in the front end of the truck. I know have about 60,000 miles on the vehicle and I'm having the same shaking problem while accelerating. It looks like this is a common occurrence with this vehicle. It is no longer under warranty and is going to cost a lot to get fixed. Not excited about having a major repair every 30,000 miles.

POWER TRAIN

2023 Maverik Hybrid at around 30,000 miles Vehicle would start shaking while accelerating. I took it to the dealership and they had to replace all the components in the front end of the truck. I know have about 60,000 miles on the vehicle and I'm having the same shaking problem while accelerating. It looks like this is a common occurrence with this vehicle. It is no longer under warranty and is going to cost a lot to get fixed. Not excited about having a major repair every 30,000 miles.

STEERING

Cv axles went out at 55k causing shaking at highway speeds while accelerating. Frequently when starting the car the steering wont activate right away even after the car begins to move for 5-10 feet. Dealer cant replicate because it doesnt happen every time. But it is still doing it and may cause a crash in the future....

POWER TRAIN

Cv axles went out at 55k causing shaking at highway speeds while accelerating. Frequently when starting the car the steering wont activate right away even after the car begins to move for 5-10 feet. Dealer cant replicate because it doesnt happen every time. But it is still doing it and may cause a crash in the future....

STEERING

The contact owns a 2023 Ford Maverick. The contact stated while driving at an undisclosed speed and upon attempting to make a left turn, the steering wheel seized with the “Power Steering Assist Fault” message displayed. The contact was able to pull over on the side of the road. There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the steering column was faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The contact stated that the failure had also occurred while driving 20 MPH and making a left turn. The vehicle was taken back to the same dealer where it was diagnosed again, and the contact was informed that the steering column was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 13,600.

STEERING

I purchased the 2023 ford maverick xlt with about 12,000 miles in may, right from the start I started having problems with the steering freezing up, almost hit a wall exiting the freeway, a few times it happened close to my house, it happens without warning, the warning "steering assist fault service required"comes up on dashboard , I have gone to the dealer a few times, the first time they said they had taken care of it, but I drove the truck after and later the steering froze up again, I took it in again and they said it was the steering column, it had a internal fault, so I left the vehicle there and next day they called me that the vehicle was ready, so I drove it home which is about eight miles from the dealer, no sooner had I was about to turn in the driveway that the steering froze on me, I borrowed my wife's car and went to the dealer told them what happened and the manager said to take it in again so they could check it , but I told the manager that I couldn't because iam afraid to drive the truck for my safety and other innocent people, so my truck sits in my driveway unable to drive it.

ELECTRICAL SYSTEM

The vehicle has less than 12,000 miles. Vehicle repeatedly entered "deep sleep" mode, disabling vehicle remote features and lights inside of vehicle. Took to dealership multiple times. Battery test showed sulfation and can no longer function as designed. Factory 12v battery replaced and software update completed yet still experiencing the same “deep sleep” mode.

ENGINE

While driving on the highway at normal speed in normal conditions, I suddenly lost ABS, traction control, downhill assist, hold assist, AdvanceTrac, Cruise control, and a severe reduction of power. The engine went into limp mode and would not rev past 3k RPM. This made driving on the highway very dangerous as I could not keep up speed and risked getting rear-ended. The wrench icon came on, as well as ABS and traction control. Cruise control would not work. Messages appeared stating "Service engine soon", "Service AdvanceTrac", "Downhill assist issue", "Hold assist issue", and a few more I can't recall. Sometimes they go away on its own and the vehicle works fine, sometimes restarting the vehicle clears the issue. The issues will appear randomly, sometimes very soon after starting the car and driving, sometimes 100 miles later.

VEHICLE SPEED CONTROL

While driving on the highway at normal speed in normal conditions, I suddenly lost ABS, traction control, downhill assist, hold assist, AdvanceTrac, Cruise control, and a severe reduction of power. The engine went into limp mode and would not rev past 3k RPM. This made driving on the highway very dangerous as I could not keep up speed and risked getting rear-ended. The wrench icon came on, as well as ABS and traction control. Cruise control would not work. Messages appeared stating "Service engine soon", "Service AdvanceTrac", "Downhill assist issue", "Hold assist issue", and a few more I can't recall. Sometimes they go away on its own and the vehicle works fine, sometimes restarting the vehicle clears the issue. The issues will appear randomly, sometimes very soon after starting the car and driving, sometimes 100 miles later.

POWER TRAIN

While driving on the highway at normal speed in normal conditions, I suddenly lost ABS, traction control, downhill assist, hold assist, AdvanceTrac, Cruise control, and a severe reduction of power. The engine went into limp mode and would not rev past 3k RPM. This made driving on the highway very dangerous as I could not keep up speed and risked getting rear-ended. The wrench icon came on, as well as ABS and traction control. Cruise control would not work. Messages appeared stating "Service engine soon", "Service AdvanceTrac", "Downhill assist issue", "Hold assist issue", and a few more I can't recall. Sometimes they go away on its own and the vehicle works fine, sometimes restarting the vehicle clears the issue. The issues will appear randomly, sometimes very soon after starting the car and driving, sometimes 100 miles later.

BACK OVER PREVENTION: WARNINGS

I Was backing into my designated parking spot in front of our store and a estranged driver cut me off and parked in two parking spots including the designated parking spot in front of the store and a handicapped parking spot next to the designated parking spot causing me to back into another car illegally parked in a third handicap in front of the store. The passenger side view mirror was clipped and the glass cracked on the passenger side door.

ELECTRICAL SYSTEM

I Was backing into my designated parking spot in front of our store and a estranged driver cut me off and parked in two parking spots including the designated parking spot in front of the store and a handicapped parking spot next to the designated parking spot causing me to back into another car illegally parked in a third handicap in front of the store. The passenger side view mirror was clipped and the glass cracked on the passenger side door.

ELECTRICAL SYSTEM

While traveling at speed there was a severe malfunction of the vehicle's stereo system. While driving the stereo was initially silent but later began to produce extremely loud noise/static. The volume of the noise was so extreme I had to take my hands off the steering wheel to cover my ears. The stereo did not respond to any power or volume input to stop the sound and I was forced to quickly pull over to the side of the road to turn off and exit the vehicle. The sound only stopped after exiting the vehicle and locking with the key fob. There were no warning signals prior to this failure. I have experienced this problem several times in the past while the vehicle was parked, when first starting the vehicle. This was the first instance of experiencing the problem while driving, within the first 1 minute after starting the vehicle. The stereo was initially on and set to a reasonable volume level, but was malfunctioning and completely silent. After driving for ~45 seconds the stereo began producing this extremely loud noise. I have found several reports of similar stereo issues with the Ford Maverick and also F150 trucks that are equipped with a similar B&O sound system.   This malfunction could potentially lead to an extremely dangerous situation, inability to safely operate the vehicle, and loss of situational awareness. I have dash cam footage of the incident, which I can provide upon request.

UNKNOWN OR OTHER

While traveling at speed there was a severe malfunction of the vehicle's stereo system. While driving the stereo was initially silent but later began to produce extremely loud noise/static. The volume of the noise was so extreme I had to take my hands off the steering wheel to cover my ears. The stereo did not respond to any power or volume input to stop the sound and I was forced to quickly pull over to the side of the road to turn off and exit the vehicle. The sound only stopped after exiting the vehicle and locking with the key fob. There were no warning signals prior to this failure. I have experienced this problem several times in the past while the vehicle was parked, when first starting the vehicle. This was the first instance of experiencing the problem while driving, within the first 1 minute after starting the vehicle. The stereo was initially on and set to a reasonable volume level, but was malfunctioning and completely silent. After driving for ~45 seconds the stereo began producing this extremely loud noise. I have found several reports of similar stereo issues with the Ford Maverick and also F150 trucks that are equipped with a similar B&O sound system.   This malfunction could potentially lead to an extremely dangerous situation, inability to safely operate the vehicle, and loss of situational awareness. I have dash cam footage of the incident, which I can provide upon request.

POWER TRAIN

The front of the vehicle started shaking with acceleration. This shaking became worse and vehicle was unsafe to drive. The vehicle was brought to ford dealership and they will be replacing the front half shafts and brackets.

POWER TRAIN:AXLE ASSEMBLY

The contact owns a 2023 Ford Maverick. The contact stated while driving at various speeds and attempting to depress the brake pedal, the brakes made a loud screeching sound and the vehicle surged forward before coming to a complete stop. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was advised that the passenger’s side axle was faulty and needed to be replaced. The vehicle was repaired, however the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 50,000.

ELECTRICAL SYSTEM

Total 12v battery drain/failure which is a known problem with the Ford Maverick Hybrid, could not even put hazards on to avoid getting hit on the side of the road. Ford tests battery and says battery is good, but the problem is the Maverick Hybrid is not adequately charging the battery when it is driven.

EXTERIOR LIGHTING

Total 12v battery drain/failure which is a known problem with the Ford Maverick Hybrid, could not even put hazards on to avoid getting hit on the side of the road. Ford tests battery and says battery is good, but the problem is the Maverick Hybrid is not adequately charging the battery when it is driven.

POWER TRAIN

I bought a pre-owned "Gold Certified" 2023 Ford Maverick from a Ford dealer. The vehicle had around 32,000 or so miles at purchase. Soon after purchase, discovered that while accelerating from around 50-60 mph, the front end of the vehicle started heavily shaking without warning. The vehicle was taken to the Ford dealer who informed us that both front axles needed to be replaced. They informed us that they have seen this issue with other Ford Mavericks. The repairs were covered under warranty, and nobody was injured. This is an unsettling, since I have seen on this website numerous complaints about this same issue. Yet there has not been a TSB or recall to my knowledge.

ELECTRICAL SYSTEM

I own a 2023 Ford Maverick XLT Hybrid. I am having issues with the 12v battery. The battery drains unexpectedly making the truck go into Battery Saver Mode. I already took it to the Ford de leadership where it received a new 12v battery. Couple of months go by and now the replacement battery is having the same issue.

POWER TRAIN

On acceleration from a stand still or in motion, the vehicle will start to shake/wobble pretty violently. It will go away when letting go of the gas. Seems to be coming from the front end wheels. Going under the car and checking all connecting points, the CV axle has a lot of play. You can move it around.

SUSPENSION

On acceleration from a stand still or in motion, the vehicle will start to shake/wobble pretty violently. It will go away when letting go of the gas. Seems to be coming from the front end wheels. Going under the car and checking all connecting points, the CV axle has a lot of play. You can move it around.

WHEELS

On acceleration from a stand still or in motion, the vehicle will start to shake/wobble pretty violently. It will go away when letting go of the gas. Seems to be coming from the front end wheels. Going under the car and checking all connecting points, the CV axle has a lot of play. You can move it around.

FORWARD COLLISION AVOIDANCE: WARNINGS

While traveling 80 MPH using cruise control, the vehicle speed suddenly reduced and several warning lights illuminated. The three warnings were Pre-Collision Assist Not Available, Service Engine Soon Warning, and Powertrain Malfunction / Reduced Power. The accelerator pedal did not work but I was able to coast to the nearest exit. I stopped, turned the vehicle off and back on a few times but the warning lights would come back on. When I shifted the transmission into Drive the vehicle would take off on its own. I drove the remaining 30 miles just letting the vehicle accelerate on its own because the pedal did not work. It wouldn't accelerate over 35 MPH. The vehicle would still pull when I applied the brakes. Once home, I turned the vehicle off for an hour. When I turned it on the warning lights no longer illuminated and the vehicle drove normal.

ENGINE

While traveling 80 MPH using cruise control, the vehicle speed suddenly reduced and several warning lights illuminated. The three warnings were Pre-Collision Assist Not Available, Service Engine Soon Warning, and Powertrain Malfunction / Reduced Power. The accelerator pedal did not work but I was able to coast to the nearest exit. I stopped, turned the vehicle off and back on a few times but the warning lights would come back on. When I shifted the transmission into Drive the vehicle would take off on its own. I drove the remaining 30 miles just letting the vehicle accelerate on its own because the pedal did not work. It wouldn't accelerate over 35 MPH. The vehicle would still pull when I applied the brakes. Once home, I turned the vehicle off for an hour. When I turned it on the warning lights no longer illuminated and the vehicle drove normal.

POWER TRAIN

While traveling 80 MPH using cruise control, the vehicle speed suddenly reduced and several warning lights illuminated. The three warnings were Pre-Collision Assist Not Available, Service Engine Soon Warning, and Powertrain Malfunction / Reduced Power. The accelerator pedal did not work but I was able to coast to the nearest exit. I stopped, turned the vehicle off and back on a few times but the warning lights would come back on. When I shifted the transmission into Drive the vehicle would take off on its own. I drove the remaining 30 miles just letting the vehicle accelerate on its own because the pedal did not work. It wouldn't accelerate over 35 MPH. The vehicle would still pull when I applied the brakes. Once home, I turned the vehicle off for an hour. When I turned it on the warning lights no longer illuminated and the vehicle drove normal.

UNKNOWN OR OTHER

I was feeling a shaking throughout while driving. I took it into the dealership to have it looked at as it is a fairly new vehicle with less than 25k miles on it. They informed me that both of the CV Axles had gone out and were replaced. I was so shocked as those are supposed to last a fairly long time on a vehicle. I researched and it appears several Maverick owners have experienced the same thing, with some stating they be gone out twice before 34k miles and some as early as 10k miles. When I asked if it was a good thing I brought it in, the advisor told me absolutely it was as it is a huge safety issue if left unfixed. There were no warning lights for it nor any recall for it. I most certainly believe there needs to be something done about this.

SUSPENSION

I was feeling a shaking throughout while driving. I took it into the dealership to have it looked at as it is a fairly new vehicle with less than 25k miles on it. They informed me that both of the CV Axles had gone out and were replaced. I was so shocked as those are supposed to last a fairly long time on a vehicle. I researched and it appears several Maverick owners have experienced the same thing, with some stating they be gone out twice before 34k miles and some as early as 10k miles. When I asked if it was a good thing I brought it in, the advisor told me absolutely it was as it is a huge safety issue if left unfixed. There were no warning lights for it nor any recall for it. I most certainly believe there needs to be something done about this.

ELECTRICAL SYSTEM

2023 Ford Maverick Hybrid XLT lost all engine power at highway speed in the left lane of [XXX] . Red Warning Triangle with notice to pull over and Check Engine light with codes P0811, P0E71 and P1920. Truck then went completely dead, no electrical indication on the instrument panel and would not start. I towed it to the dealer and they said they reset and reloaded software on the PCM and BCM, but no explanation of what caused the issue to occur. Very unsafe for everyone if these hybrid vehicles can just go dead like this with no warning and no prior issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

2023 Ford Maverick Hybrid XLT lost all engine power at highway speed in the left lane of [XXX] . Red Warning Triangle with notice to pull over and Check Engine light with codes P0811, P0E71 and P1920. Truck then went completely dead, no electrical indication on the instrument panel and would not start. I towed it to the dealer and they said they reset and reloaded software on the PCM and BCM, but no explanation of what caused the issue to occur. Very unsafe for everyone if these hybrid vehicles can just go dead like this with no warning and no prior issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

2023 Ford Maverick Hybrid XLT lost all engine power at highway speed in the left lane of [XXX] . Red Warning Triangle with notice to pull over and Check Engine light with codes P0811, P0E71 and P1920. Truck then went completely dead, no electrical indication on the instrument panel and would not start. I towed it to the dealer and they said they reset and reloaded software on the PCM and BCM, but no explanation of what caused the issue to occur. Very unsafe for everyone if these hybrid vehicles can just go dead like this with no warning and no prior issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SERVICE BRAKES

Brakes are very "grabby" and lurchy at low speeds. sometimes it starts to shudder

VISIBILITY

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V594000 (VISIBILITY); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that the part was on backorder. The contact had not experienced the failure. Parts distribution disconnect.

FUEL/PROPULSION SYSTEM

Dealer states that they found a crack at the seam where filler neck connects to fuel tank. Fuel leak traces coming from where the hose assembly attaches to the gas tank. Visible fuel seaping and strong gasoline smell in garage.

STRUCTURE

The contact owns a 2023 Ford Maverick. The contact stated that the interior passenger’s side floorboard was wet. The vehicle was taken to a local dealer, where it was diagnosed; however, the cause of the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 40,000.

VISIBILITY/WIPER

I had the recall work done for the back up camera that freezes while I am reversing. After the recall has been completed, it still freezes/glitches while I'm backing up. Nothing changed after they performed the recall work. I do believe that the technician performed the work he was told to, but it hasn't accomplished anything. The rear view camera still takes a few seconds to engage once I put the car in reverse, and while I am in reverse, actively backing up the car, the camera feed freezes repeatedly on-screen.

ELECTRICAL SYSTEM

I had the recall work done for the back up camera that freezes while I am reversing. After the recall has been completed, it still freezes/glitches while I'm backing up. Nothing changed after they performed the recall work. I do believe that the technician performed the work he was told to, but it hasn't accomplished anything. The rear view camera still takes a few seconds to engage once I put the car in reverse, and while I am in reverse, actively backing up the car, the camera feed freezes repeatedly on-screen.

BACK OVER PREVENTION: WARNINGS

I had the recall work done for the back up camera that freezes while I am reversing. After the recall has been completed, it still freezes/glitches while I'm backing up. Nothing changed after they performed the recall work. I do believe that the technician performed the work he was told to, but it hasn't accomplished anything. The rear view camera still takes a few seconds to engage once I put the car in reverse, and while I am in reverse, actively backing up the car, the camera feed freezes repeatedly on-screen.

SUSPENSION

Bad CV axles causing vibration while accelerating.

POWER TRAIN

Bad CV axles causing vibration while accelerating.

SERVICE BRAKES

The contact owns a 2023 Ford Maverick. The contact stated that while driving approximately 40 MPH, the brake warning light illuminated. The contact attempted to depress the brake pedal; however, the brakes failed to stop the vehicle. The contact shifted into neutral and coasted to a patch of grass where the vehicle came to a stop. The vehicle was turned off and after a while and shifted into park and restarted. The contact stated that several unknown warning lights were illuminated. The contact turned off and restarted the vehicle and became aware that the lights were no longer illuminated and continued driving. The dealer was contacted, and it was confirmed there were no recalls on the VIN. The contact stated that approximately 3 months after the first failure, the failure reoccurred while driving approximately 45 MPH, causing the contact to coast onto the off-ramp and a curb while in neutral to stop the vehicle. Several unknown warning lights were illuminated. The contact was able to restart and drive the vehicle to the dealer with the hazard lights activated. The dealer was unable to diagnose the failure. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was approximately 18,000.

BACK OVER PREVENTION

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available. VIN tool confirms parts not available.

SUSPENSION

I recently reported my Ford maverick for the failure of the front right CV joint/axle at 22k miles. Well when I picked it up from Ford. They notified me that the front left is also bad. And I'm at 23k miles. These are clearly an issue that's happening everywhere.

POWER TRAIN

I recently reported my Ford maverick for the failure of the front right CV joint/axle at 22k miles. Well when I picked it up from Ford. They notified me that the front left is also bad. And I'm at 23k miles. These are clearly an issue that's happening everywhere.

BACK OVER PREVENTION

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while reversing out of the driveway, the back-over prevention camera failed to display an image behind the vehicle. The passenger had to verbally inform the driver of what was behind the vehicle. The dealer was not contacted. The manufacturer was made aware of the issue. The failure mileage was 12,377. VIN tool confirms parts not available.

UNKNOWN OR OTHER

The manufacturer has not corrected the recall in a timely manner. The recall 24V684 was started in September 2024. It is six month later March 2025 and no fix has been identified.

SUSPENSION

Front Left CV Axle replaced at 5000 miles. Same CV axle needs to replaced now at 10287 miles.

BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING

My backup camera freezes while in reverse, which makes it difficult to gauge my surroundings accurately and has almost caused an accident a number of times now.

SUSPENSION

The cv joint axles are failing. No axles on a new car or truck should EVER fail under 100k miles. Ford maverick axles are failing at under 50k miles. And mine failed at 22k miles. And Ford will only replace 1 at a time. Not only is this a manufacturer defect that can cause accidents or injury but Ford needs to yet again be held accountable. No one pays good money for a factory faulty vehicle.

POWER TRAIN

The cv joint axles are failing. No axles on a new car or truck should EVER fail under 100k miles. Ford maverick axles are failing at under 50k miles. And mine failed at 22k miles. And Ford will only replace 1 at a time. Not only is this a manufacturer defect that can cause accidents or injury but Ford needs to yet again be held accountable. No one pays good money for a factory faulty vehicle.

UNKNOWN OR OTHER

Camera freezes when I'm in reverse. Backed up in to a telephone pole last year and had several thousand dollars in damage. Paid the deductible, my rates went up and my cars value went down. Was backing out of parking space yesterday and almost hit a small child when it froze again. Ford needs to fix this issue that they have known about for ahwile.

BACK OVER PREVENTION

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue; however, the contact was informed that parts were not yet available for the recall repair. The manufacturer was not made aware of the issue. The contact stated that there had been several issues with the rearview camera since the vehicle was purchased. There were no warning lights illuminated. The failure mileage was approximately 100. VIN tool confirms parts not available.

BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING

Both the Blind Spot and Cross Traffic warning systems work erratically or not at all. Even after software update and reset. Cross traffic will sense a small car then ignore the bus next? Same with Blind Spot very inconsistent or not functional! Dealer is less than helpful. Any trip to the dealer means leaving your vehicle with them all day so they can put off working on it until the last minute.

LANE DEPARTURE: BLIND SPOT DETECTION

Both the Blind Spot and Cross Traffic warning systems work erratically or not at all. Even after software update and reset. Cross traffic will sense a small car then ignore the bus next? Same with Blind Spot very inconsistent or not functional! Dealer is less than helpful. Any trip to the dealer means leaving your vehicle with them all day so they can put off working on it until the last minute.

SUSPENSION

First time i noticed an issue was [XXX] felt vibration and took to Freeport Ford, Freeport, IL 61030. They took for a test drive and noticed nothing. I returned to Freeport Ford on 01/30/25 for the same issue, violent shaking when accelerating worse on an incline..They told me it was tires and that the 2 fronts had to be replaced 4/32 tread at this point they placed the 2 good rear tires on the front which didn't change a thing, I ordered 2 new tires, and on 01/31/25 took to a Chevrolet dealer in Freeport (friend of mine), they diagnosed that i had 2 faulty CV axles, i let Freeport Ford know of this diagnosis. New tires were installed 02/04/25 on the rear, still didn't change a thing, i told them I had checked the Maverick Forums and found out several complaints about faulty CV axles prematurely failing, at this point they stated they have ordered me a new set of axles, and let me drive out of the dealership on those faulty axles..Now playing the waiting game to see if axles come in first or if a catastrophic axles failure occurs first. Definitely not happy with Ford at this point and believe this needs to be a recall at this time due to all the complaints. Thank you, [XXX] 02/04/25 4:35p.m. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

Two problems 1. Auto Start/Stop feature 2. Pre-Collision Assist (1) Auto Start/Stop feature- unpredictable.. 1. My engine turns off at busy intersection for red light with a vehicle coming in fast from behind, I hit gas to move forward . My truck revs hard from starting with foot on gas and darts forward. Almost went into cross traffic. 2. There is a current recall on Maverick batteries. Numerous complaints on the Facebook Ford Maverick of vehicle shutting off for auto-stop, but not starting in traffic conditions due to the battery. Fact - any electrical or computer problem and your vehicle is now stranded in an intersection. The Maverick has several electrical recalls. 3. I have timed my Vehicle Restart response on camera. It takes approx 1 more second for my vehicle engine to re-start and advance forward. For many accidents 1 second is the difference of life and death. 4. When I stop to put the vehicle in reverse, it will auto-stop while I am shifting. My vehicle is now sitting in the road, until I hit reverse and no brake, then "jumps" backwards in reverse. 5. The feature cannot be turned off permanently- it must be turned off manually for every trip. Summary - I have sent these concerns to Ford. They will not provide a way to turn off this feature. Only option is to pay a mechanic to disable it with an aftermarket product, which could of course, damage something else. (2) Front Collision Warning System - Has gone off three times for no valid reason. One time simply passing an oncoming vehicle 2 times passing police vehicles on the side of the road with flashing lights. I have lowered it's alert level to low and seems to help. But clearly, Emergency lights setting off a system that takes some control of stirring and braking is a concern.

ENGINE

Two problems 1. Auto Start/Stop feature 2. Pre-Collision Assist (1) Auto Start/Stop feature- unpredictable.. 1. My engine turns off at busy intersection for red light with a vehicle coming in fast from behind, I hit gas to move forward . My truck revs hard from starting with foot on gas and darts forward. Almost went into cross traffic. 2. There is a current recall on Maverick batteries. Numerous complaints on the Facebook Ford Maverick of vehicle shutting off for auto-stop, but not starting in traffic conditions due to the battery. Fact - any electrical or computer problem and your vehicle is now stranded in an intersection. The Maverick has several electrical recalls. 3. I have timed my Vehicle Restart response on camera. It takes approx 1 more second for my vehicle engine to re-start and advance forward. For many accidents 1 second is the difference of life and death. 4. When I stop to put the vehicle in reverse, it will auto-stop while I am shifting. My vehicle is now sitting in the road, until I hit reverse and no brake, then "jumps" backwards in reverse. 5. The feature cannot be turned off permanently- it must be turned off manually for every trip. Summary - I have sent these concerns to Ford. They will not provide a way to turn off this feature. Only option is to pay a mechanic to disable it with an aftermarket product, which could of course, damage something else. (2) Front Collision Warning System - Has gone off three times for no valid reason. One time simply passing an oncoming vehicle 2 times passing police vehicles on the side of the road with flashing lights. I have lowered it's alert level to low and seems to help. But clearly, Emergency lights setting off a system that takes some control of stirring and braking is a concern.

ELECTRICAL SYSTEM

Two problems 1. Auto Start/Stop feature 2. Pre-Collision Assist (1) Auto Start/Stop feature- unpredictable.. 1. My engine turns off at busy intersection for red light with a vehicle coming in fast from behind, I hit gas to move forward . My truck revs hard from starting with foot on gas and darts forward. Almost went into cross traffic. 2. There is a current recall on Maverick batteries. Numerous complaints on the Facebook Ford Maverick of vehicle shutting off for auto-stop, but not starting in traffic conditions due to the battery. Fact - any electrical or computer problem and your vehicle is now stranded in an intersection. The Maverick has several electrical recalls. 3. I have timed my Vehicle Restart response on camera. It takes approx 1 more second for my vehicle engine to re-start and advance forward. For many accidents 1 second is the difference of life and death. 4. When I stop to put the vehicle in reverse, it will auto-stop while I am shifting. My vehicle is now sitting in the road, until I hit reverse and no brake, then "jumps" backwards in reverse. 5. The feature cannot be turned off permanently- it must be turned off manually for every trip. Summary - I have sent these concerns to Ford. They will not provide a way to turn off this feature. Only option is to pay a mechanic to disable it with an aftermarket product, which could of course, damage something else. (2) Front Collision Warning System - Has gone off three times for no valid reason. One time simply passing an oncoming vehicle 2 times passing police vehicles on the side of the road with flashing lights. I have lowered it's alert level to low and seems to help. But clearly, Emergency lights setting off a system that takes some control of stirring and braking is a concern.

BACK OVER PREVENTION

The contact owns a 2023 Ford Maverick. The contact stated that while reversing, the back over prevention camera display failed to function as intended. The contact stated that the back over prevention camera display screen had frozen. The dealer was made aware of the failure; however, the contact was advised that a diagnostic test fee was required. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 14,939. VIN tool confirms parts not available.