2019 FORD FUSION

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

UNKNOWN OR OTHER

The rear backup camera when in reverse shows a blank screen. When switched to park or drive, a message appears on the screen that says camera unavailable with a warning sign. This began early June 2025. It does not happen every time but it is more often than not. I have had this looked at by a Ford authorized dealer however the problem would not arise for them to see it in action. Yes I can use my mirrors but it is useless to have a safety tool on a vehicle that is defective.

ENGINE

Coolant is intruding into the engine, with no sign of a leak. There was a TSB 22-2229 issued that my car falls under, but ford claims they are not at fault to pay for it. This was a manufacturing error, and was at no fault of my own. My car has less than 60k miles on it. A check engine light came on for cylinder 3 misfire. There was no warning signs that an engine failure was occurring. The car is not driveable as it could overheat at any moment.

ENGINE

The vehicle is having issues with not starting, white smoke coming from exhaust, multiple misfire issues, can not accelerate as car lags out in power. I had a mechanic do some diagnostic testing on it and he confirmed coolant is leaking down into the motor and the engine block is cracked. It currently is not drivable. Engine light started to come on and said it was the coil packs misfiring we changed them and it did not fix the issue. Put a brand new battery in as well and still won't start often. I have reported this to a law firm handling the case against Ford for this known issue. I have kids and do not feel safe putting them in this car as it is unreliable that could cause us serious injury.

ELECTRICAL SYSTEM

I have a 2019 ford fusion turbo engine and everytime I accelerate the turbo is wicking into the pcm the control module which is causing hazards sucking as at random times whenever I turn left the steering wheel with get stuck and the brakes will lock for a couple seconds and then go back to normal. I had Meineke do a diagnostic on the car and they showed oil in the pcm aswell as the loss of connection between the pcm and its sensors. They drove the car and while driving the car going 20mph the car is reading as going 100

VEHICLE SPEED CONTROL

I have a 2019 ford fusion turbo engine and everytime I accelerate the turbo is wicking into the pcm the control module which is causing hazards sucking as at random times whenever I turn left the steering wheel with get stuck and the brakes will lock for a couple seconds and then go back to normal. I had Meineke do a diagnostic on the car and they showed oil in the pcm aswell as the loss of connection between the pcm and its sensors. They drove the car and while driving the car going 20mph the car is reading as going 100

STEERING

I have a 2019 ford fusion turbo engine and everytime I accelerate the turbo is wicking into the pcm the control module which is causing hazards sucking as at random times whenever I turn left the steering wheel with get stuck and the brakes will lock for a couple seconds and then go back to normal. I had Meineke do a diagnostic on the car and they showed oil in the pcm aswell as the loss of connection between the pcm and its sensors. They drove the car and while driving the car going 20mph the car is reading as going 100

ELECTRICAL SYSTEM

Going approximately 55 Miles an hour on the freeway and my car starts profusely shaking. I pulled to the side of the highway tow truck comes up behind me. Ann, my cylinder 4 was noted to be misfiring. I had it towed to Midas and that is where it was determined that engine coolant leaked into my cylinders and now being told that my car requires a new engine!! Mind you i have already paid 5K to replace the timing chain because apparently my car skipped timing due to oil pan leak. Both of these issues are posted on TSB BULLETINS ON THE FORD WEBSITE. I am NOT GOING TO PAY 11K for a new engine not to mention the 5K I already paid and all my other maintenance that I have paid for. Ford was deceptive knowing selling these vehicles with a QA ISSUE! AND THEY REFUSE TO ASSIST THE CONSUMER. THEY NEED TO BE HELD ACCOUNTABLE FOR THEIR NEGLIGENCE!!

ENGINE

Going approximately 55 Miles an hour on the freeway and my car starts profusely shaking. I pulled to the side of the highway tow truck comes up behind me. Ann, my cylinder 4 was noted to be misfiring. I had it towed to Midas and that is where it was determined that engine coolant leaked into my cylinders and now being told that my car requires a new engine!! Mind you i have already paid 5K to replace the timing chain because apparently my car skipped timing due to oil pan leak. Both of these issues are posted on TSB BULLETINS ON THE FORD WEBSITE. I am NOT GOING TO PAY 11K for a new engine not to mention the 5K I already paid and all my other maintenance that I have paid for. Ford was deceptive knowing selling these vehicles with a QA ISSUE! AND THEY REFUSE TO ASSIST THE CONSUMER. THEY NEED TO BE HELD ACCOUNTABLE FOR THEIR NEGLIGENCE!!

POWER TRAIN

I purchased my car at 36, 380 miles and at 51,380 my torque converter has failed.Shift solenoid b stuck on. My warranty has expired in February. My car was well taken care of and should not have been damaged. Ford needs to fix this issue immediately. This is unacceptable.

UNKNOWN OR OTHER

Sunroof is leaking and maybe other areas. But it’s getting the ceiling wet around front are of the sunroof and starting to effect the radio playing and eventually probably the buttons on the ceiling

STEERING

First, we will start with every time I turn my car to the left the steering wheel box and the brakes skid then the ABS sensor comes on Then we will start with the car every time I put it into a gear. It automatically goes back to park, and I cannot move the car in any direction. When the issue first started, I could reverse then when I put the car and drive in the middle of the street it would automatically go back to park which could cause a crash I only have video proof of this.

UNKNOWN OR OTHER

First, we will start with every time I turn my car to the left the steering wheel box and the brakes skid then the ABS sensor comes on Then we will start with the car every time I put it into a gear. It automatically goes back to park, and I cannot move the car in any direction. When the issue first started, I could reverse then when I put the car and drive in the middle of the street it would automatically go back to park which could cause a crash I only have video proof of this.

ELECTRICAL SYSTEM

First, we will start with every time I turn my car to the left the steering wheel box and the brakes skid then the ABS sensor comes on Then we will start with the car every time I put it into a gear. It automatically goes back to park, and I cannot move the car in any direction. When the issue first started, I could reverse then when I put the car and drive in the middle of the street it would automatically go back to park which could cause a crash I only have video proof of this.

ENGINE

Internal coolant leak into cylinder heads causing overheating and engine failure. dealer confirmed diagnosis in writing. this matches ford TSB 19-2346, but ford refuses coverage since over 100k miles. This creates a safety hazard; vehicle overheats suddenly and can stall while driving.

ENGINE

The vehicle had 115,000 miles and was diagnosed with an engine coolant leak which caused the need for the 1.5L Turbo EcoBoost engine to need to be replaced. However, my VIN for some reason unknown to me, was not included in the Engine Coolant Leak recall (21N12). I contacted Ford and was told I would be put in the Customer Satisfaction Program but only to find out the the representative I had spoken with gave me incorrect information and I was not able to be included in that Program. I’ve had to pay for about 2 years now a car payment on a car that has not ran and have been unable to get the car fixed. This needs to be addressed by Ford and taken care of and paid for by Ford in my opinion. I don’t know why my vehicle wasn’t included in this recall but clearly there were many more vehicles with this problem and a lot of customers are probably suffering as I am, still stuck paying for a vehicle that I cannot afford to get the engine replaced in. Shame on FORD!

UNKNOWN OR OTHER

My car is at 119,000 miles and 2019 ford fusion. I was driving on a local street when my cars warning popped up with a notice that my cars coolant was overheated. I immediately pulled over and turned off the car. My cars coolant tank was completely depleted. The problem was determined to be a coolant leak into cylinder 2. The check engine code of P0302 MISFIRE ON #2 CYLINDER. This issue had the potential to result in an engine fire and severe injury.

ENGINE

My car is at 119,000 miles and 2019 ford fusion. I was driving on a local street when my cars warning popped up with a notice that my cars coolant was overheated. I immediately pulled over and turned off the car. My cars coolant tank was completely depleted. The problem was determined to be a coolant leak into cylinder 2. The check engine code of P0302 MISFIRE ON #2 CYLINDER. This issue had the potential to result in an engine fire and severe injury.

ELECTRICAL SYSTEM

See attached document for complaint. Text from attached document: Despite completing the interim repair, the vehicle still cannot charge, and my repeated inquiries, including under case number CXH-05041947-L 1V3X6, have been met with vague promises of replacement batteries being available "next quarter" with no resolution in sight. Furthermore, I learned on July 23, 2025, that Ford offered a buy-back program for affected vehicles that ended on July 1, 2025, which I was never informed about.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated that while driving approximately 45-65 MPH and depressing the brake pedal, the vehicle made an abnormal waterflow sound. The check engine warning light was intermittently illuminated. The contact stated that upon scanning the vehicle with a code scanner, the contact retrieved a diagnostic trouble code related to a cylinder #2 misfire. The contact stated that upon replacing the spark plug in cylinder #2, the check engine warning light turned off; however, the failure persisted. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion in the engine block. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the repair could not be covered under Ford Campaign Number: 21N12; because the vehicle had exceeded the mileage limitation. The failure mileage was unknown.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated that while driving approximately 60 MPH, the vehicle was shaking abnormally with the check engine warning light illuminated before starting to blink afterwards. The vehicle was steered over to the side of the road and restarted; however, the failure persisted. The vehicle was taken to an Auto Zone, where a handheld diagnostic machine retrieved DTC: P0304, C2008-13, C2007-13, and B1111-53. The vehicle was taken to the dealer to be diagnosed, and it was determined that there was coolant intrusion in cylinder #4, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 86,996.

ENGINE

Purchased vehicle unknowingly part of program 19B37 that had not been completed. Coolant has leaked into the engine and now need s new engine. Does not qualify for service action 21N12 since original satisfaction program 19B37 was not completed and now past mileage. Now the vehicle needs an entire engine! Still owe on the car, warranties have all expired. Engine must ne replaced due to the reported coant defect that I was not made aware of at purchase. Good should fix this!

ENGINE

Yesterday, [XXX], I was driving my vehicle on [XXX] in rural Kansas, to drop my mother off at the airport, and my [XXX] daughter was in the vehicle. My vehicle's temperature went directly to warning status, and I was no longer able to accelerate. I immediately put my hazards on and tried to make my way to the nearest exit to ensure we were in a safe position. Ford knows that coolant intrusion is possible in the engine block. While discussing with Ford today on the phone from 11:07 AM until 11:34 AM, and being escalated to a supervisor, they said that nothing could be done on their end, and advised to contact NHTSA. The safety of myself and others was at risk because of the faulty manufacturing of the engine and coolant system, which they report is part of a customer satisfaction program, but this is a major safety concern because, in the event it was not midday and there were more vehicles on the road, there could have been an accident. Ford Customer Satisfaction Program 21N12 One-time repair for vehicles included in 19B37 This is a known issue Ford recognizes through their customer satisfaction program. They are unwilling to assist, although in 2022, I was under the mileage specifications included in the customer satisfaction program. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SUSPENSION

The vehicle wheels and steering wheel bounce and shake when brakes are applied, regardless of the speed level; this felt like I am losing control of the vehicle and as if the wheels, and components of suspension or brake system will collapse all of the sudden. No warning lights came up in the dashboard. The vehicle was inspected by the dealership (Kearny Mesa Ford Service, 7303 Clairemont Mesa Blvd, San Diego, CA 92111) and they confirmed the problem, the problem still persisted after they performed checks and repairs, their response was "we are not sure what's causing the problem and we need more time to diagnose.".

STEERING

The vehicle wheels and steering wheel bounce and shake when brakes are applied, regardless of the speed level; this felt like I am losing control of the vehicle and as if the wheels, and components of suspension or brake system will collapse all of the sudden. No warning lights came up in the dashboard. The vehicle was inspected by the dealership (Kearny Mesa Ford Service, 7303 Clairemont Mesa Blvd, San Diego, CA 92111) and they confirmed the problem, the problem still persisted after they performed checks and repairs, their response was "we are not sure what's causing the problem and we need more time to diagnose.".

SERVICE BRAKES

The vehicle wheels and steering wheel bounce and shake when brakes are applied, regardless of the speed level; this felt like I am losing control of the vehicle and as if the wheels, and components of suspension or brake system will collapse all of the sudden. No warning lights came up in the dashboard. The vehicle was inspected by the dealership (Kearny Mesa Ford Service, 7303 Clairemont Mesa Blvd, San Diego, CA 92111) and they confirmed the problem, the problem still persisted after they performed checks and repairs, their response was "we are not sure what's causing the problem and we need more time to diagnose.".

ENGINE

The contact owns a 2019 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to Auto Zone where it was connected to a diagnostic machine and failure codes retrieved indicated that the failure was cylinder failure and a coil pack. The contact was informed that the cylinders and coil pack needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to an independent mechanic where it was diagnosed with cylinder and head gasket failure. The vehicle was not repaired. The vehicle was then taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to take the vehicle to the dealer for diagnostic testing. The failure mileage was approximately 143,000.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated that upon start the vehicle, the engine was misfiring. There was no warning light illuminated. The vehicle was taken to a local dealer to be diagnosed, and the contact was informed that the head gasket was faulty and needed to be replaced. Additionally, the engine needed to be replaced due to coolant intrusion. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 108,000.

ENGINE

The contact owns a 2019 Ford Fusion. The contact stated while driving approximately 60 MPH, there was an abnormal rattling sound coming from the engine compartment. While the vehicle was stopped, the vehicle started shaking abnormally. On one occasion, while driving 10 MPH, the vehicle stalled. The vehicle was not able to be restarted and remained at the location for almost a week. The vehicle was then towed to the residence. The vehicle was taken to a dealer but was not diagnosed or repaired. The vehicle was then taken to an independent mechanic where it was diagnosed and determined that the flex plate was cracked and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 101,000.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated that while operating the vehicle, the engine overheated with the check engine warning light illuminated. The vehicle was taken to the local mechanic who replaced the water pump however, the failure persisted. The cause of the failure was not yet determined, and the vehicle was not repaired. The manufacturer and local dealer were not notified of the failure. The failure mileage was 75,000.

ENGINE

My car is part of a recall with Ford Motor Company - customer satisfaction recall 21N12 - I HAVE A COOLANT LEAK WHICH CAN CAUSE FIRE, and dealership refuses to help because my VIN number doesn"t show up as being affected. However in a letter mailed out by Ford Motor Company it states my vehicle is in fact covered under the saftey recall.. original recall letter was for 2013-2028 ford fusion ecoboost engines. Ford mailed out another letter saying that some 2019 models will experience same issue due to having the same engine. Ford did not mail out letters to 2019 owners for this recall. according to the recall , my car was built at the same plant and same time. I need my VIN number somehow attached to this recall so my dealership can do what is right. Fryer Ford in Ahoskie, NC refuses to help and I do not want to risk driving something that can catch fire. Please tell me what I need to do or verify that my car is in fact part of this recall. Thank you for any assistance in this matter

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated that the vehicle was shaking abnormally at start-up. The vehicle was taken to the dealer however, a cause for the issue was not found. The failure persisted, and the check engine warning light illuminated. The contact's husband replaced the spark plugs and ignition coils; however, several days later, the failure reoccurred, and the spark plugs, and ignition coils were replaced an additional three separate times due to the persistent failure. The vehicle was then taken to an independent mechanic where a diagnostic test indicated that there was coolant intrusion into cylinder #3. The manufacturer was notified of the failure and informed the contact that there were no recalls on the vehicle. The contact was then referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 94,000.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated that upon start of the vehicle, an "Engine Coolant Overtemperature" message appeared on the instrument panel and the Ford Mobile App. The contact attempted to drive the vehicle to an independent mechanic; however, the vehicle hesitated upon depression of the accelerator pedal. The contact drove the vehicle back to the residence and used a code reader to retrieve the "Cylinder Head Over Temperature" message. The contact's stepfather called the dealer and was informed hm that there was an undisclosed recall; however, the VIN was not included in the recall. The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was unknown.

ENGINE AND ENGINE COOLING

The contact’s daughter owns a 2019 Ford Fusion. The contact stated that when the vehicle was started, the check engine warning light illuminated. Additionally, the messages "Engine Overheated" and "Service Now” were displayed. The contact’s daughter attempted to drive the vehicle, but the vehicle had shifted into "LIMP Mode". The vehicle was pulled over into a parking lot and restarted, but the failure persisted. The vehicle was taken to the residence where a handheld diagnostic machine retrieved information that the cylinder head was over temperature. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.

ELECTRICAL SYSTEM

The electrical system constantly discharges the battery. If the car is not started at least every three days, the battery discharges and must be taken to Ford to have the battery replaced. Ford customer service and the dealer know about this and have taken the position that as a customer I must go start the car because Ford cannot fix the problem, Unknown why they cannot fix it. To start the car every three days is very difficult for me because I am disabled and must climb stairs and walk to the street to manually start the car. Ford suggested using the remote start feature of furnished with the car by Ford. The remote start works but it is limited to remote starting the car two times and then you must go to the car and manually start the car. If I am unable to get to the car in time to start it, the battery goes dead and I cannot use my car in case of an emergency. Ford has been made aware of this, Ford says they agree it is a problem but that Ford Engineers won't remove the two start limit. Ford will not say why there is a two start limit. This could be fixed (limit removed) by just updating the software. Ford does not respond anymore when I ask them about it.

ENGINE

The car would periodically have white smoke coming out the exhaust I assumed it was bad gas and then all of a sudden it just had a ton of white smoke ended up being the the head gasket to the small block was bad and defective and Ford knew about it and did nothing about it. There was a safety performance alert, which I did not receive.The car is only six years old and I just paid it off.

ENGINE

The contact owns a 2019 Ford Fusion. The contact stated that while having a routine oil change, the mechanic observed a leak in the oil pan. The vehicle was taken to three dealers and one independent mechanic where it was diagnosed that there was an oil pan gasket leak and the oil pan gasket needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 60,000.

ENGINE

A check engine light came on and our mechanic ran diagnostics to find that there was antifreeze leaking. He said it could be the head gasket but we needed to take it to Ford dealership. We took it in and were told that it is indeed leaking coolant into cylinder due to a crack in the cylinder wall. I am the original owner and have kept up with all maintenance in the 6years I have owned the car. I was told that Fors is “aware” of these issues.

ENGINE

Coolant leakage (no warning light/alert for driver) cause significant damage to engine block. Damage lead to cylinder misfiring and oil leakage. Oil leakage/check engine light occurred same day, prompting scheduling service at Ford dealership. Ford service center states short block needs replaced and car is not safe to drive. Upon research, this is a known issue for this make/model/year and has an open customer satisfaction program that covers the cost of repairs. However, both service center and Ford Customer Service state this vehicle's VIN number is not included in the repair program, despite acknowledging this is the same problem addressed in the repair program. Ford Customer Service recommended submitting this problem and the car's VIN to NHTSA for possible inclusion in the outstanding recall.

POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

The contact owns a 2019 Ford Fusion. The contact stated that while coming to a stop, the contact heard a loud sound coming from the engine compartment. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the flex plate, torque converter, and front pump had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 75,000.

ENGINE

The contact owns a 2019 Ford Fusion. The contact stated that while coming to a stop, the contact heard a loud sound coming from the engine compartment. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the flex plate, torque converter, and front pump had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 75,000.

POWER TRAIN

The 6F35 transmission in BOTH of our Ford vehicles that we drive daily for work and school. The Ford Fusion is currently in the shop, but the Ford Escape is available for inspection. My safety was put at risk as my Fusion suddenly, without warning, stopped accelerating in the middle of a 2 lane highway, very unsafe. My daughter's Escape is putting her safety at risk because she has the same 6F35 transmission, the car is still "drivable" at the moment but not safely drivable, with the rough shifting between 2nd-3rd gear, the slow acceleration and sometimes won't go into gear, her safety is at risk. Like MANY other Ford owners with this transmission, the car will end up breaking down and needing $5000 in repairs. Yes the issue has been reproduced by the service center. No, Ford has not reached out to me, I have left 7 messages without any return calls, I have sent multiple emails that were returned to sender. There were no warning lights, messages or problems on the Fusion prior to this happening. I own two Ford cars that are both undrivable, I cannot get to work, my daughter cannot get to work/school. Ford is VERY aware of this transmission issue but will not issue a recall. Also at times when I put my Fusion into drive, from reverse, the backup camera would stay on for a few minutes which makes driving very hard/confusing and very unsafe. Ford needs to take accountability and issue a recall for vehicles with this defective transmission instead of ignoring the issues and telling buyers their vehicles are reliable.

FORWARD COLLISION AVOIDANCE: WARNINGS

My front camera is often unavailable. I took it in multiple times and they couldn’t find an issue. Recently my back up camera has been acting up. It is unavailable most of the time, other times the screen is black, sometimes it’ll work and then cut out. There is a recall on other ford vehicles for this issue. I looked up if it needs a software update and it doesn’t. We’ve checked the camera and wiring harness and they’re both intact and in good condition.

BACK OVER PREVENTION: WARNINGS

My front camera is often unavailable. I took it in multiple times and they couldn’t find an issue. Recently my back up camera has been acting up. It is unavailable most of the time, other times the screen is black, sometimes it’ll work and then cut out. There is a recall on other ford vehicles for this issue. I looked up if it needs a software update and it doesn’t. We’ve checked the camera and wiring harness and they’re both intact and in good condition.

ELECTRICAL SYSTEM

My front camera is often unavailable. I took it in multiple times and they couldn’t find an issue. Recently my back up camera has been acting up. It is unavailable most of the time, other times the screen is black, sometimes it’ll work and then cut out. There is a recall on other ford vehicles for this issue. I looked up if it needs a software update and it doesn’t. We’ve checked the camera and wiring harness and they’re both intact and in good condition.

POWER TRAIN

Occasionally, the vehicle will drive in reverse when started and the shifter knob is turned to Drive (forward). This has occurred at least 5 times and the dealership has not been able to replicate the issue. So in their minds, it is not an issue. On one of those instances we noted that that shifter did not have any mode highlighted even though it was put into Drive. There were no warning lamps illuminated, no system messages. The car simply started to reverse when taking the foot off of the brake. The car had to be turned off and restarted multiple times to get it to go forward. This can be dangerous as one could inadvertently strike an object or person that is behind the vehicle.

ENGINE

In 2020, I received a notice from Ford that my 2019 Ford Fusion had a Customer Satisfaction Program repair. I took the vehicle to an authorized Ford Dealer in April of 2020 to have the repair completed, which to my knowledge was completed by the service technicians at Ford. Today, my car broke down while I was traveling to work. I was able to get it to an authorized Ford service dealer and they informed me that my engine was going to need to be replaced due to coolant leaking into the engine. According to Ford, they are not willing to help with the cost of fixing the engine, since my mileage is past what is stated on the CSP notice, even though this was supposedly fixed 5 years ago, way before the mileage that was required and the car was still under warranty. Now, I'm stuck trying to figure out how to pay for a new engine, when Ford knew about this issue and is unwilling to help their customers even when they do the right thing.

ENGINE

coolant intrusion in engine with less than 7 years of life and under 84k miles. wont replace engine with the program because it didnt get the pcm update beforehand. Never got a letter for it and my vin doesnt say im apart of the program even though my car was build in the time frame and plant that they had this coolant intrusion issue.

ENGINE

Coolant intrusion that Ford knows happens with these cars even with maintenance now they want me to pay 10k to get a new Engine with an updated part.

ENGINE

Ford 2.0L EcoBoost engine. 2017-2019 Fusion. Also, in 2 other Ford and Lincoln models. I bought 2019 Fusion used and car has just under 69000 miles. Due to a known engine defect there can be coolant intrusion into a cylinder. In my case #2 cylinder. See TSB # 22-2229 from Ford. Check engine light came on. took to dealer and replaced 1 ign coil and 4 spark plugs. Thought issue resolved until check engine light came back on. Returned to dealer and advise that engine needed replacement. If continued to operate engine could lock-up while driving thus creating a safety for myself and others on the highway. Ford knows of this defect caused by their design of the block.

POWER TRAIN

The contact owns a 2019 Ford Fusion. The contact stated that while the vehicle was parked, the vehicle stalled. There were no warning lights illuminated. The contact took the vehicle to an independent mechanic, where it was diagnosed that the flex plate was loose. The vehicle was then towed to a dealer, where it was diagnosed with a cracked flex plate. The vehicle was repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 56,660.

ENGINE

The contact owns a 2019 Ford Fusion. The contact stated that while the vehicle was parked, the vehicle stalled. There were no warning lights illuminated. The contact took the vehicle to an independent mechanic, where it was diagnosed that the flex plate was loose. The vehicle was then towed to a dealer, where it was diagnosed with a cracked flex plate. The vehicle was repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 56,660.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle was able to be restarted. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined there was coolant intrusion into cylinder #3, causing damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 82,000.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was an engine misfire, with the check engine warning light illuminated. The vehicle was able to restart. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into the engine, which caused engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 108,831.

ENGINE

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was an engine misfire, with the check engine warning light illuminated. The vehicle was able to restart. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into the engine, which caused engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 108,831.

POWER TRAIN

The contact owns a 2019 Ford Fusion. The contact stated that while starting the vehicle, there was a loud clanking noise coming from the engine compartment, with the check engine and transmission warning lights illuminated. The vehicle was able to restart. The vehicle was towed to the dealer, where it was diagnosed and determined that the flex plate had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 126,000.

ENGINE

The contact owns a 2019 Ford Fusion. The contact stated that while starting the vehicle, there was a loud clanking noise coming from the engine compartment, with the check engine and transmission warning lights illuminated. The vehicle was able to restart. The vehicle was towed to the dealer, where it was diagnosed and determined that the flex plate had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 126,000.

ENGINE

The failure occurred in the engine block or head gasket of the 2.0L EcoBoost engine, leading to coolant intrusion into the cylinders. Yes, the affected engine components were inspected by local dealer and confirmed long block issue. The safety of the driver and others was put at risk due to the potential for: Sudden engine misfire or stalling, which could lead to a loss of power while driving. White smoke from the exhaust reducing visibility for other drivers. Engine overheating, which could cause a breakdown in traffic or on highways. Yes, the problem has been reproduced and confirmed by a Ford dealer and/or independent service center through diagnostic tests, which identified coolant intrusion into the cylinders. The vehicle has been inspected by the manufacturer’s authorized dealer during diagnostic testing to confirm the issue. It has not been inspected by police or insurance representatives. Yes, warning lamps and other symptoms appeared prior to the failure, including: MIL (Check Engine Light) with DTCs such as P0300-P0304 White exhaust smoke, indicating coolant burning in the engine. Engine running rough, especially during cold starts. Low coolant level, requiring frequent refills, with no visible external leaks. These symptoms first appeared [insert time frame or mileage if known].

FORWARD COLLISION AVOIDANCE: WARNINGS

1.5 liter Engine built in 2019 has Antifreeze Leaking inside cylinder 1 needs Complete Engine. Also a recall on Electrical System propulsion System and Traction Battery Management System ENERGY Control Module Part Number: 23533.

ELECTRICAL SYSTEM

1.5 liter Engine built in 2019 has Antifreeze Leaking inside cylinder 1 needs Complete Engine. Also a recall on Electrical System propulsion System and Traction Battery Management System ENERGY Control Module Part Number: 23533.

ENGINE

1.5 liter Engine built in 2019 has Antifreeze Leaking inside cylinder 1 needs Complete Engine. Also a recall on Electrical System propulsion System and Traction Battery Management System ENERGY Control Module Part Number: 23533.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated that while driving approximately 30-35 MPH, the "Engine Coolant Overtemperature" message was displayed on the instrument panel. The accelerator was depressed and failed to respond as intended. The vehicle started losing motive power. The contact was able to coast to the side of the road. The contact inspected the vehicle and noticed that there was no coolant inside the reservoir. The contact added coolant to the vehicle. The vehicle was restarted, and the contact drove to the residence; however, the failure recurred, and the coolant reservoir was empty. The vehicle was taken to the dealer, and it was diagnosed and determined that the radiator had failed. The vehicle was repaired. The dealer diagnosed the vehicle again and confirmed coolant intrusion into the cylinders, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was approximately 38,500.

ENGINE

In 2023 I was experiencing engine issues. There was a check engine light that continued to come on signaling a cylinder misfire. I replaced the sparkplugs and coils however the issue persisted so I made an appointment to bring it to a Ford Dealership. The Ford dealership contacted me to advise that the issue I was experiencing is a known issue with the Ford Ecoboost motor where coolant ends up leaking into the cylinders causing a failure. This is a huge detriment to safety because I could have had a vehicle fire, or my car could have seized up on the highway while I was driving had I not gotten this to a dealership. I contacted Ford regarding the issue and their response was alarming. Since I was slightly over my warranty my vehicle was not covered for any repairs and they would not address the issue despite it being a known problem with these motors. I was stuck with a 7,000 dollar repair bill and "save your receipts and hope for the best" from Ford. Their negligence was alarming and after doing much research I have found that there still was not a recall issued and many people have experienced this issue.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle shuddered and loss automotive power. No warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the spark plugs needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was towed back to the independent mechanic where it was diagnosed that the coolant reservoir tank needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was taken to a different independent mechanic where it was diagnosed that the engine needed to be replaced. The contact researched and was made aware of an unknown recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 56,000.

ENGINE AND ENGINE COOLING

The contact's daughter owns a 2019 Ford Fusion. The contact stated that the vehicle failed to start on the first attempt. The contact stated that once the vehicle was started, there was a white-colored smoke coming from the exhaust pipe. The contact stated that while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal, with the check engine warning light illuminated. The vehicle was initially taken to an independent mechanic and was diagnosed with cylinder #2 misfire. The spark plugs were replaced; however, the failure persisted. The vehicle was then taken to a dealer where a diagnostic test was performed, and the result was coolant intrusion into cylinder #2. The contact was informed that the engine short block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 74,000.

ENGINE AND ENGINE COOLING

See attached document for complaint.

POWER TRAIN

Coolant leak in engine

FUEL/PROPULSION SYSTEM

Coolant leak in engine

ENGINE

Coolant leak in engine

ELECTRICAL SYSTEM

During the month of dec 2024 my car didnt start. I called Triple A to jump start my car to get home. During Christmas break of 2024 i purchased a brand new battery and now a month and two weeks later the battery is completely dead again. Sometimes is hard to get the car up to speed and feels like it struggles to maintain it as well. The electrical system also kicks my radio connection off and on while driving. The first incident happened dec. 21,2023 and the second incident happened Jan. 27,2025.

ENGINE

The contact owns a 2019 Ford Fusion. The contact stated while driving at an undisclosed speed, the engine was overheating with the temperature warning light illuminated. The vehicle was restarted, and the contact added coolant to the coolant reservoir; however, the failure persisted. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 86,300.

ENGINE

The contact owns a 2019 Ford Fusion. While the contact's son was driving at an undisclosed speed, the cruise control failed to function as intended. The contact stated that the vehicle was shaking erratically, and the brakes independently activated. Additionally, the check engine warning light was illuminated. The contact stated that the failure had occurred while her son was driving on a busy highway. The vehicle was pulled over to the shoulder of the roadway. The vehicle was towed to the dealer where it was diagnosed with a failed electric actuator. The contact was informed that the electric actuator, gaskets, and spark plugs needed to be replaced. The vehicle was being repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 82,000.