2012 FORD FOCUS

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.

Risk: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.

FUEL SYSTEM, GASOLINE:STORAGE

Ford Motor Company (Ford) is recalling certain 2012 and 2017 Focus vehicles equipped with 2.0L GDI gasoline engines and 2013-2014 Focus ST vehicles equipped with 2.0L GTDI engines, previously recalled under 18V-735. The affected vehicles did not have the Powertrain Control Module (PCM) updated as intended. Therefore, the Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in the fuel vapor management system.

Risk: The excessive vacuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.

FUEL SYSTEM, GASOLINE:STORAGE

Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.

Risk: The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain model year 2012-2015 Ford Focus, 2013-2015 Ford Escape and Ford C-MAX, 2015 Lincoln MKC and Ford Mustang, and 2014-2016 Ford Transit Connect vehicles. A component within the door latches may break, preventing the doors from latching and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.

Risk: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.

EXTERIOR LIGHTING

Ford is recalling certain model year 2012-2013 Focus BEV vehicles equipped with High Intensity Discharge (HID) headlights, manufactured September 15, 2011, through May 6, 2013; and model year 2013 Focus ST vehicles equipped with High Intensity Discharge (HID) headlights, manufactured February 16, 2012, through May 7, 2013. Due to a wiring incompatability, the front side marker lamps may not function. Thus, these vehicles fail to comply to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Without the proper illumination of the side maker lamps, the vehicle may be less visible in night time conditions, increasing the risk of a crash.

EQUIPMENT

This recall involves aftermarket parts sold by Yakima Products, Inc. for use on model year 2012 and 2013 Ford Focus vehicles. This recall is being conducted by Yakima, not by Ford. Certain combined Q-Tower and Q128 Clip rooftop rack systems, part numbers 8000124 and 8000728, do not fully contact the door frame.

Risk: Without proper contact of the rooftop rack clip to the door frame, there is insufficient clamping pressure and friction. The system may slide off the vehicle when loaded with accessories, possibly becoming a road hazard to other vehicles or causing injury to pedestrians.

ENGINE

The car started shutting down while I am driving and also hard to start after

ELECTRICAL SYSTEM

The car started shutting down while I am driving and also hard to start after

POWER TRAIN

I purchased this car as a certified pre owned car from the Mazda dealership In mechanicsburg PA about two and a half years ago. The transmission failed and the car was unsafe to drive after 3 months from the purchase date. The Mazda dealership didn’t know how to fix the transmission as it’s a complicated process. They tried to send it to a ford dealership but they would not work on it. It took Mazda awhile to finish my transmission because they didn’t know how to fix it. Now the same exact problem is occurring two years later. I haven’t even put 40,000 miles on my car after the replacement of the new transmission. As I stated before the car is unsafe to drive and I need it for work. This brand new transmission should not be failing after only 2 years and 35,000 miles. Included files are from November 2022 when I purchased the car and from February and march 2023 when the transmission was fixed.

POWER TRAIN

On Friday [XXX], I was at a stop sign waiting to turn right, when it was my turn to go my car would not move at all, forward or back, the regular lights on the dash board were still on. I put my blinkers on and had all cars go around me. I turned my car off and then back on, that's when the check engine light came on. After 8 minutes of turning the car off and on, I was able to move backwards and forwards I was able to drive. I stopped at AutoZone on the way to get my car scanned. I received a report with a bunch of p-codes. I made it home, I called Ford, they didn't have any immediate appointments. The closet Ford dealership to me says they don't work on cars over 10 years old. I made an appointment at Firestone for saturday morning, they got the same P-codes and said they were all transmission problems and recommended I go to a Ford dealership or a transmission specialists. on my way home from Firestone, first my car speed felt like it was speeding up on it's on and then my car slowed down tremendously and I has to pull over, again I put my blinkers on. After 5 minutes I was able to move again, I was close to home. My car moved so slow feeling like it would stop any time, i drove with my blinkers on and made it home. On Monday my car wouldn't start up at all. A Ford that would take my car didn't have an appointment for 2 weeks. So I made an appointment with AAMCO for Tuesday and I had my car towed there because it wouldn't turn on. My safety was put at risk because I could have been driving at normal speed and could've slowed down out of know where and a car could have slammed into the back or side of me. AMMCO says it my dual input clutch assembly, actuators, forks and TCM This is my first time ever seeing the check engine light on [XXX] Ford's TCM extended warranty expired [XXX]. I called Ford's corporate customer service for help with diagnosis and repair but they said there was nothing they could do. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated that while driving between first and second gear, the vehicle shuddered and lost motive power temporarily. The vehicle was taken to two independent mechanics, where the contact was informed that the TCM or the shift interlock actuator needed to be replaced. The contact stated that after the mechanic replaced the shift interlock actuator, the vehicle operated as needed temporarily, and the failure recurred. The vehicle was taken to the dealer to be repaired under a Class Action Lawsuit settlement; however, the dealer informed the contact that the vehicle was not covered. The dealer diagnosed that the transmission clutch was slipping, and the dealer determined that the transmission needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle had failed to respond upon shifting to reverse(R) and failed to exceed first gear or 10 MPH. The check engine warning light was illuminated. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that the VIN was not under recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 67,000.

POWER TRAIN

I own a 2012 Ford Focus with approximately 51,000 miles. The transmission warning light came on, and I was informed by a repair shop that the transmission control module (TCM) and gears need repair. This vehicle uses the PowerShift dual-clutch transmission (DPS6), which has been the subject of a class-action lawsuit and multiple extended warranties due to widespread failures. The car exhibits jerking, delayed acceleration, and loss of power, which create dangerous driving conditions, particularly when merging into traffic or crossing intersections. Ford informed me I am outside the warranty period and refused to assist, despite this being a well-documented, recurring safety issue for which they have admitted fault in other cases. I am reporting this issue because it poses a serious safety hazard, and I believe the TCM defect should be subject to a mandatory recall. Ford is shifting the burden of a known manufacturing defect onto consumers, and this needs to be addressed before someone is injured.

ELECTRICAL SYSTEM

I own a 2012 Ford Focus with approximately 51,000 miles. The transmission warning light came on, and I was informed by a repair shop that the transmission control module (TCM) and gears need repair. This vehicle uses the PowerShift dual-clutch transmission (DPS6), which has been the subject of a class-action lawsuit and multiple extended warranties due to widespread failures. The car exhibits jerking, delayed acceleration, and loss of power, which create dangerous driving conditions, particularly when merging into traffic or crossing intersections. Ford informed me I am outside the warranty period and refused to assist, despite this being a well-documented, recurring safety issue for which they have admitted fault in other cases. I am reporting this issue because it poses a serious safety hazard, and I believe the TCM defect should be subject to a mandatory recall. Ford is shifting the burden of a known manufacturing defect onto consumers, and this needs to be addressed before someone is injured.

ENGINE AND ENGINE COOLING

The contact owns a 2012 Ford Focus. The contact stated that while attempting to start the vehicle, the engine shuddered while idling, with the check engine warning light illuminated. The local independent mechanic was contacted; however, the vehicle was not diagnosed. The contact was advised that the failure might be attributed to coolant intrusion into the engine. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,058.

POWER TRAIN

The contact's mother owns a 2012 Ford Focus. The contact stated that while his mother was driving at an undisclosed speed, the transmission was slipping, and the vehicle stalled. The check engine warning light was illuminated. The contact's mother pulled over and had the vehicle towed to an independent mechanic and the dealer, who determined that the Transmission Control Module (TCM) had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 14M02 (Transmission Control Module Extended Warranty Coverage); however, the vehicle was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 100,000.

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated that while driving 35 MPH, the vehicle jerked and the transmission unexpectedly downshifted. The contact was able to pull over to the side of the road. The message "Transmission Overheating" was displayed, and the check engine warning light illuminated. The contact turned off the vehicle and waited until the transmission had cooled down. The contact was able to restart the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 195,000.

POWER TRAIN

I am reporting a recurring safety issue with the DPS6 dual-clutch automatic transmission in my 2012 Ford Focus (VIN: [XXX] ). The vehicle intermittently fails to shift beyond 3rd gear while in motion, resulting in loss of acceleration and inability to maintain safe highway speeds. The most recent incident occurred in July 2025 while my son was driving. The car would not upshift past 3rd gear, forcing him to pull off the road. We took the vehicle to a Ford dealership, which ran diagnostics and ultimately identified diagnostic trouble code P2832: “Shift Fork B Position Sensor Circuit Low.” This error points to failure of the clutch actuator assembly, a key component of the DPS6 system. The dealership linked the issue to internal transmission component failure but stated the original warranty repair had already been used and no coverage was currently open. Ford Customer Relationship Center advised us to have the dealer submit through the Specialty Recall Program and to file a safety complaint with NHTSA. This failure is consistent with the issues outlined in Technical Service Bulletin (TSB) 16-0109, which addresses shuddering, hesitation, and shifting failure in Ford’s DPS6 transmission due to actuator and clutch contamination. The vehicle previously underwent warranty repair for transmission issues, and this is a repeat failure tied to the same known defect. This defect affects drivability and safety, especially for younger or less experienced drivers. Ford has acknowledged the defect in class action settlements and internal bulletins, but is denying coverage in this case. I am requesting NHTSA investigate this ongoing pattern of failure and pressure Ford to address these safety risks before they result in serious injury. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the TCM, purge valve, and clutch assembly had failed and needed to be replaced. The TCM and purge valve were repaired under warranty. The clutch assembly was not repaired or replaced. The manufacturer was made aware of the failure and referred the contact to the NHTSA hotline for further assistance. The approximate failure mileage was 128,000.

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the TCM, purge valve, and clutch assembly had failed and needed to be replaced. The TCM and purge valve were repaired under warranty. The clutch assembly was not repaired or replaced. The manufacturer was made aware of the failure and referred the contact to the NHTSA hotline for further assistance. The approximate failure mileage was 128,000.

UNKNOWN OR OTHER

The Power Steering shut down suddenly while I was driving it. I am [XXX], and certainly did NOT have the power to turn the wheel like it needed. If there had been fast moving traffic at that time, I could have been hit and severely injured, Why hasn't this been recalled yet? The problem has been confirmed by an independent service center. I had to go there when my power steering intermittently came back on because it was only 6 blocks away from my house and I didn't dare try to drive it to a ford dealer which was 12 miles away. I'm not positive about the light coming on, but I believe I saw a circle with an "i" inside of it I was too stressed to notice completely, when I was trying to control my car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING

The Power Steering shut down suddenly while I was driving it. I am [XXX], and certainly did NOT have the power to turn the wheel like it needed. If there had been fast moving traffic at that time, I could have been hit and severely injured, Why hasn't this been recalled yet? The problem has been confirmed by an independent service center. I had to go there when my power steering intermittently came back on because it was only 6 blocks away from my house and I didn't dare try to drive it to a ford dealer which was 12 miles away. I'm not positive about the light coming on, but I believe I saw a circle with an "i" inside of it I was too stressed to notice completely, when I was trying to control my car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated while at a stop light, the accelerator pedal was depressed; however, the vehicle failed to move forward. The contact stated that the failure had occurred while driving on a major highway. The contact stated that after the vehicle sat for approximately ten minutes, the vehicle was restarted, and the vehicle independently reset. The vehicle was driven to the residence. In addition, the contact stated that several days prior to the failure, the vehicle was started; however, the gear shifter failed to shift into drive(D). The contact stated the gear shifter only shifted into reverse(R), and the transmission fault warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 37,000.

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated while driving 45 MPH, the message "Transmission Hot," was displayed. In addition, the transmission was slipping. The vehicle was taken to the dealer; however, the vehicle was not inspected or diagnosed. The contact was informed that the failure was a known failure, there was no fix available. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 225,000.

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle jerked and failed to accelerate as intended while depressing the accelerator pedal. In addition, the contact stated the transmission unexpectedly downshifted before slamming into gear. The vehicle intermittently returned to normal functionality, or the RPM would fluctuate, and the transmission would shift rough. No warning light was illuminated. The vehicle was taken to the dealer, who retrieved DTC: P07A3 (Failure with the clutch A stuck causing transmission friction). The contact was informed that the clutch actuator needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 150,000.

POWER TRAIN

Unknown

UNKNOWN OR OTHER

Unknown

SERVICE BRAKES

I was starting to pull away from a traffic light but the car would not go to second gear and was shaking violently this has happened more times then I can count and I take care of my [XXX] we travel 50 miles a day in this car on one of the most dangerous roads in the nation [XXX] ) there are places on this road with no emergency lanes in case my car stalls again or just won't go into gear and I have drivers bearing down on me at 70 miles an hour. I know for a fact these issues have come up with countless others that have bought this vehicle and I just don't understand why this isn't a big enough safety concern is it going to take the death of me and my grandson for a recall to be made on this piece of garbage ford calls a transmission? I don't have $ for another vehicle and if this one doesn't keep getting me to work I'll be out of a job and we will be homeless a friend helped me buy this car and I assumed he checked it out first and he only looked at the accident report but not the overall report on these vehicles which shouldn't even be on car lots for sale they are unsafe death traps and when people start dying in them which im sure has already happened those deaths are on ford and on this so called national highway safety because your not doing your job this recall should have happened years ago INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

I was starting to pull away from a traffic light but the car would not go to second gear and was shaking violently this has happened more times then I can count and I take care of my [XXX] we travel 50 miles a day in this car on one of the most dangerous roads in the nation [XXX] ) there are places on this road with no emergency lanes in case my car stalls again or just won't go into gear and I have drivers bearing down on me at 70 miles an hour. I know for a fact these issues have come up with countless others that have bought this vehicle and I just don't understand why this isn't a big enough safety concern is it going to take the death of me and my grandson for a recall to be made on this piece of garbage ford calls a transmission? I don't have $ for another vehicle and if this one doesn't keep getting me to work I'll be out of a job and we will be homeless a friend helped me buy this car and I assumed he checked it out first and he only looked at the accident report but not the overall report on these vehicles which shouldn't even be on car lots for sale they are unsafe death traps and when people start dying in them which im sure has already happened those deaths are on ford and on this so called national highway safety because your not doing your job this recall should have happened years ago INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

I was starting to pull away from a traffic light but the car would not go to second gear and was shaking violently this has happened more times then I can count and I take care of my [XXX] we travel 50 miles a day in this car on one of the most dangerous roads in the nation [XXX] ) there are places on this road with no emergency lanes in case my car stalls again or just won't go into gear and I have drivers bearing down on me at 70 miles an hour. I know for a fact these issues have come up with countless others that have bought this vehicle and I just don't understand why this isn't a big enough safety concern is it going to take the death of me and my grandson for a recall to be made on this piece of garbage ford calls a transmission? I don't have $ for another vehicle and if this one doesn't keep getting me to work I'll be out of a job and we will be homeless a friend helped me buy this car and I assumed he checked it out first and he only looked at the accident report but not the overall report on these vehicles which shouldn't even be on car lots for sale they are unsafe death traps and when people start dying in them which im sure has already happened those deaths are on ford and on this so called national highway safety because your not doing your job this recall should have happened years ago INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the failure persisted for approximately an hour. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 14M02. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 171,000.

FUEL SYSTEM, GASOLINE

The contact owns a 2012 Ford Focus. The contact stated that while attempting to refuel, the fuel nozzle continuously clicked off. Additionally, while operating the vehicle, the fuel gauge malfunctioned and displayed inaccurate fuel information. The contact stated that the fuel gauge incorrectly displayed a full fuel tank; however, the contact stated that the vehicle stalled. The tow service was called to the scene and discovered that there was no fuel in the fuel tank. The tow service added fuel and the vehicle restarted and operated normally. The vehicle was taken to the local dealer who diagnosed that the fuel tank, fuel gasket, and canister purge valve were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 127,255.

UNKNOWN OR OTHER

Transmission problem

ENGINE

I went to emissions and I received an “Important Vehicle Safety Recall Information” notice that states Transmission Control Module Extendes Warranty Coverage”.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

The contact owns a 2012 Ford Focus. The contact stated that the front driver's side door failed to latch securely while closed. The contact stated that the door occasionally unintendedly opened while driving. The contact stated that the failure required him to drive with an arm out the window holding the door closed. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 16V643000 (Latches/Locks/Linkages); however, the part to do the recall repair was not yet available. The dealer diagnosed the vehicle and informed the contact that the part to repair the vehicle was on backorder. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 178,000. Parts distribution disconnect.

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated that the message “Transmission Overheating – Pullover and Wait 5 Minutes Before Continuing to Drive” was displayed. The contact stated that the vehicle jerked while driving at various speeds, the transmission failed to shift properly. The contact stated that while attempting to accelerate from idling, the vehicle jerked abnormally before accelerating. The contact stated that occasionally the RPM became elevated; however, the vehicle failed to accelerate as intended. The vehicle was taken to the dealer who diagnosed that the Transmission Control Module (TCM) had failed and the dual-clutch system, A and B, was faulty and needed to be replaced. Additionally, the seals on the transmission had failed, causing transmission fluid to leak from the transmission. The contact was informed that the TCM, dual-clutch system, and seals need to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and provided the contact with a reference number for the call. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

UNKNOWN OR OTHER

TCM needs replaced. Car does not have reverse, stalls and overheating.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The contact owns a 2012 Ford Focus. The contact stated that the window motor in the passenger’s side window was no longer functioning while attempting to roll down the window. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. The contact was informed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 99,085.

STEERING

Power steering light intermittently comes on and vehicles looses power steering. Upon turning vehicle off then back on power steering will come back on. Can't get it to act up long enough for mechanic to diagnose. Only a matter of time before an accident happens. There are hundreds of complaints online about this same issue. Ford has issued some recalls but not on my particular VIN...

FUEL SYSTEM, GASOLINE

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed that the purge valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 143,500.

ENGINE

Ford manufactured faulty clutches in Ford Focus cars years 2012-2015. The clutches were put in automatic transmissions and after short periods of time the clutch slips requiring full replacements. In 2023 my daughter was driving on a 55 mile per hour highway when the car shut down and would no longer drive. She had to immediately pull over and have the car towed to the dealership. We spent $4,600 reporting the clutch. Just barely after 2 years the clutch is completely out again. A clutch in an automatic car should not go out within 2 years and 13,000 miles. When the clutch slips it puts the driver and other drivers at increased risk of an accident. Ford is aware of these issues and refuse to do any sort of recalls.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The TCM on the transmission needs fixed they said i could get a rental car.

ENGINE

The TCM on the transmission needs fixed they said i could get a rental car.

UNKNOWN OR OTHER

The TCM on the transmission needs fixed they said i could get a rental car.

POWER TRAIN

We have had constant problems with the car just randomly not starting. Some days it’ll work fine and then the next it won’t start even if you try to jump it

ELECTRICAL SYSTEM

We have had constant problems with the car just randomly not starting. Some days it’ll work fine and then the next it won’t start even if you try to jump it

FUEL/PROPULSION SYSTEM

Since I have had this vehicle, the message " steering assist fault" for my electronic steering has been popping up in the dash screen since as far back as 2016 when there were recalls on the Ford fusion. However, a simple fix would be to turn off the engine and restart the vehicle, and it was go away, only to return a few weeks, or a month later. I repeated the same steps. Now, it has gone out completely, a few months ago. Back then, they told me it would cost about $800, now they are saying $2500. It has occurred various times going back to 2016 until currently, which it is out. Keep in mind, this message has appeared since 2016 and I believe I have contacted you all, who told me that only the Ford Fusion, which has the same exact electrical steering system, went out and that the recall only covered the Ford Fusions models.

STEERING

Since I have had this vehicle, the message " steering assist fault" for my electronic steering has been popping up in the dash screen since as far back as 2016 when there were recalls on the Ford fusion. However, a simple fix would be to turn off the engine and restart the vehicle, and it was go away, only to return a few weeks, or a month later. I repeated the same steps. Now, it has gone out completely, a few months ago. Back then, they told me it would cost about $800, now they are saying $2500. It has occurred various times going back to 2016 until currently, which it is out. Keep in mind, this message has appeared since 2016 and I believe I have contacted you all, who told me that only the Ford Fusion, which has the same exact electrical steering system, went out and that the recall only covered the Ford Fusions models.

SUSPENSION

Since I have had this vehicle, the message " steering assist fault" for my electronic steering has been popping up in the dash screen since as far back as 2016 when there were recalls on the Ford fusion. However, a simple fix would be to turn off the engine and restart the vehicle, and it was go away, only to return a few weeks, or a month later. I repeated the same steps. Now, it has gone out completely, a few months ago. Back then, they told me it would cost about $800, now they are saying $2500. It has occurred various times going back to 2016 until currently, which it is out. Keep in mind, this message has appeared since 2016 and I believe I have contacted you all, who told me that only the Ford Fusion, which has the same exact electrical steering system, went out and that the recall only covered the Ford Fusions models.

ENGINE AND ENGINE COOLING

The contact owns a 2012 Ford Focus. The contact stated that while the vehicle was parked in the driveway, there was a puddle of liquid with an abnormal odor underneath the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer for an unknown recall repair, and a message was displayed. The message “Stop vehicle immediately to prevent engine damage” was displayed. The contact pulled over to the side of the road, waited for the tow truck, and the vehicle was towed to the dealer. The dealer diagnosed the vehicle with a timing cover assembly failure. The vehicle was repaired under recall. The local dealer was contacted; however, the vehicle was not repaired because it was not under recall after the recent failure. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 138,000.

FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER

The contact owns a 2012 Ford Focus. The contact stated the vehicle failed to start. No warning light was illuminated. The contact called AAA, who jump-started the vehicle. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the purge valve had failed. The contact stated that the vehicle was repaired. The contact stated that on a separate occasion, while driving 10 MPH up a hill and attempting to accelerate, the vehicle briefly lost motive power and jerked before slamming into first gear. Several unknown warning lights were illuminated. The contact stated that the vehicle was taken to an independent mechanic who diagnosed that the transmission control module had failed. The vehicle was not repaired. The contact stated that the failure reoccurred. The contact received a postcard from the manufacturer for a manufacturer's recall for the canister purge valve (24N07). The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated the vehicle failed to start. No warning light was illuminated. The contact called AAA, who jump-started the vehicle. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the purge valve had failed. The contact stated that the vehicle was repaired. The contact stated that on a separate occasion, while driving 10 MPH up a hill and attempting to accelerate, the vehicle briefly lost motive power and jerked before slamming into first gear. Several unknown warning lights were illuminated. The contact stated that the vehicle was taken to an independent mechanic who diagnosed that the transmission control module had failed. The vehicle was not repaired. The contact stated that the failure reoccurred. The contact received a postcard from the manufacturer for a manufacturer's recall for the canister purge valve (24N07). The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated while driving at approximately 35 MPH, the accelerator pedal was depressed; however, the vehicle hesitated before responding as intended. The contact stated that several unknown warning lights were illuminated. The contact had taken the vehicle to a local dealer; however, the vehicle was not diagnosed or repaired. The contact stated that the hesitation occurred at various speeds, with an abnormal whirring sound coming from underneath the vehicle. The manufacturer was not informed of the failure. The failure mileage was approximately 107,000.

POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

The contact owns a 2012 Ford Focus. The contact stated that upon starting the vehicle, the engine started to shake violently; occasionally, causing the vehicle to shut off unexpectedly. The contact was able to restart the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and the contact was informed that the torque converter was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 81,000.

POWER TRAIN:AUTOMATIC TRANSMISSION:INTERNAL:CLUTCHES/BANDS

The contact owns a 2012 Ford Focus. The contact stated while the vehicle was parked and attempting to start the vehicle, the vehicle failed to respond. The vehicle was under warranty and was taken to the dealer. The vehicle was diagnosed with clutch failure. The vehicle was repaired, and the clutch was replaced. On another occasion, the vehicle started to lose motive power and failed to reverse. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the clutch had left residue, which caused the transmission to fail. The vehicle was then taken to a dealer where it was diagnosed with clutch failure; however, the contact was informed that the clutch was not under warranty. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 93,000.

LATCHES/LOCKS/LINKAGES

The contact owns a 2012 Ford Focus. The contact stated that while driving at various speeds, the trunk latch disengaged, causing the trunk to open unexpectedly. The contact stated that the failure had occurred 3 times within a month. The dealer was contacted and informed of the failure. The dealer confirmed that the VIN was not under recall. The vehicle was not diagnosed or repaired. The dealer referred the contact to the NHTSA Hotline to report the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 132,000.

POWER TRAIN

Transmission shudders and struggles to shift gears due to sticking clutch. This causes a dangerous delay in transmission engagement. (Numerous occasions without specific dates.) I have previously had the TCM reprogrammed multiple times.( 8 or 9 times) The car still does not drive properly. I have brought it in to 2 Ford dealerships to have the Ford customer satisfaction program completed. Both dealerships refused to honor the Ford CSP. (Five Star Ford of North Richland Texas and Southwest Ford of Weatherford Texas)

ENGINE

The contact owns a 2012 Ford Focus. The contact stated while driving at approximately 65 MPH, the check engine warning light illuminated, and the vehicle was losing motive power. The contact was able to exit the highway and stop the vehicle. The contact turned off and restarted the vehicle and was able to regain vehicle functionality. The contact stated that the vehicle was taken to a local dealer who diagnosed the vehicle. The contact stated that the vehicle was repaired; however, the contact was not notified of the cause of the failure. The contact stated that the failure reoccurred. The contact stated that the vehicle was taken back to the same dealer several times and the contact was advised that the vehicle was repaired; however, the failure reoccurred. The contact received a postcard from the manufacturer for two manufacturer recalls for the TCM: (14M02) and Canister purge valve (24N07); however, after calling the dealer, the contact was informed that the vehicle was no longer covered under warranty for the manufacturer recalls. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 91,000.

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated while driving at approximately 65 MPH, the check engine warning light illuminated, and the vehicle was losing motive power. The contact was able to exit the highway and stop the vehicle. The contact turned off and restarted the vehicle and was able to regain vehicle functionality. The contact stated that the vehicle was taken to a local dealer who diagnosed the vehicle. The contact stated that the vehicle was repaired; however, the contact was not notified of the cause of the failure. The contact stated that the failure reoccurred. The contact stated that the vehicle was taken back to the same dealer several times and the contact was advised that the vehicle was repaired; however, the failure reoccurred. The contact received a postcard from the manufacturer for two manufacturer recalls for the TCM: (14M02) and Canister purge valve (24N07); however, after calling the dealer, the contact was informed that the vehicle was no longer covered under warranty for the manufacturer recalls. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 91,000.

POWER TRAIN

The contact owns a 2012 Ford Focus. The contact stated that upon the depression of the accelerator pedal, the vehicle hesitated and jerked with several unknown warning lights illuminated. The vehicle was towed to a dealer and was diagnosed with a defective motor mount. The vehicle was then taken to an independent mechanic and was diagnosed with a defective transmission. The contact was informed by the independent mechanic that they did not have the tools to repair the vehicle. The vehicle was taken back to the dealer and the contact was informed that the TCM (Transmission Control Module) was defective and needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 94,000.

FUEL/PROPULSION SYSTEM

Vehicle has difficulty starting after refuel. Vehicle stalls randomly to the point that is too much of a danger to drive. All of the symptoms correlate to recall (18S32) yet this particular vehicles vin was not listed in the list of recalled vehicles. The DTC's are as follows,P0420, P0456, P1450. Upon being serviced for the ford customer satisfaction program 24N07 it was noted by a service advisor that the replacement of a fuel tank and fuel pump was necessary which would be a reference to recall (18S32). However due to this vin not falling under recall (18S32) the service for a replacement fuel tank and fuel pump is not covered by warranty. Vehicle has erratic and innacurate fuel gauge indication. Vehicle stalled in the middle of traffic shortly after service was completed. Dealership has no clearance from Ford to address problem because 24N07 makes no mention of components that could be affected by faulty canister purge valve, unlike (18S32) and as such leaves this vehicle to be a hazard on the road.

ENGINE

Vehicle has difficulty starting after refuel. Vehicle stalls randomly to the point that is too much of a danger to drive. All of the symptoms correlate to recall (18S32) yet this particular vehicles vin was not listed in the list of recalled vehicles. The DTC's are as follows,P0420, P0456, P1450. Upon being serviced for the ford customer satisfaction program 24N07 it was noted by a service advisor that the replacement of a fuel tank and fuel pump was necessary which would be a reference to recall (18S32). However due to this vin not falling under recall (18S32) the service for a replacement fuel tank and fuel pump is not covered by warranty. Vehicle has erratic and innacurate fuel gauge indication. Vehicle stalled in the middle of traffic shortly after service was completed. Dealership has no clearance from Ford to address problem because 24N07 makes no mention of components that could be affected by faulty canister purge valve, unlike (18S32) and as such leaves this vehicle to be a hazard on the road.

ENGINE

I’ve been to several Fords for the Transmission control module TCM, the engine lagging or stalling all lights on my car going on now my whole right side of my car doesn’t work after telling Ford about these problems. They denied to fix my car even though there was a customer care warranty through Ford

ELECTRICAL SYSTEM

I’ve been to several Fords for the Transmission control module TCM, the engine lagging or stalling all lights on my car going on now my whole right side of my car doesn’t work after telling Ford about these problems. They denied to fix my car even though there was a customer care warranty through Ford

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

The contact owns a 2012 Ford Focus. The contact stated while attempting to close the doors of the vehicle, the doors failed to latch securely. The vehicle was taken to a dealer, and the contact was provided an estimate for the repair, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to report the failure. The contact related the failure to NHTSA Campaign Number: 16V643000 (LATCHES/LOCKS/LINKAGES); however, the VIN was not included. The failure mileage was 300,000.

STRUCTURE:BODY

Back passenger door fails to latch when closed.

STEERING

Received Steering Assist Fault message. Vehicle has lost power steering ability without warning causing a safety issue

STEERING

During some Christmas shopping within the past few weeks, my cars power steering went out completely with no warning or sounds to repair or seek assistance. Not only was my life in danger, but the safety of others in the vehicles surrounding me. I couldn't even turn my wheel if I tried. There have been other instances in other cars where I could strong arm the wheel and be ok, but there was absolutely nothing I could do about turning the wheel whatsoever! When my dad came with power steering fluid, we discovered that these cars don't even have a reservoir for power steering fluid and that this was more than likely a battery or module issue or worse the power steering pump. This is ridiculous that there is no service light or warning that the power steering is going out or losing power. Ford should fix this because it seems like this is an ongoing issue with Fords in general