2015 FORD FIESTA

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2015 Fiesta, 2016 Fusion, and 2016 Lincoln MKZ vehicles sold, or ever registered in Alabama, Arkansas, Arizona, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, New Mexico, Nevada, Oklahoma, Oregon, South Carolina, Texas, Utah, Washington, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. A component inside the door latches may break, which can make it difficult to latch or possibly allow the doors to open while driving.

Risk: Vehicle doors opening unexpectedly while driving can increase the risk of a crash or injury.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2014-2015 Fiesta, 2014-2016 Fusion and Lincoln MKZ vehicles sold, or ever registered in Alabama, Arkansas, Arizona, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, New Mexico, Nevada, Oklahoma, Oregon, South Carolina, Texas, Utah, Washington, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.

Risk: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.

ENGINE AND ENGINE COOLING:ENGINE

Ford Motor Company (Ford) is recalling certain 2014 Escape, 2014-2015 Fiesta ST, 2013-2014 Fusion and 2013-2015 Transit Connect vehicles equipped with 1.6L GTDI engines. If the vehicle is started and driven with an insufficient level of coolant within the engine cooling system, the engine cylinder head may overheat, crack and leak oil.

Risk: If the cylinder head cracks and leaks oil, the oil may contact a hot engine or exhaust component, increasing the risk of a fire.

POWER TRAIN

The contact owns a 2015 Ford Fiesta. The contact stated that while attempting to start the vehicle, the vehicle failed to start as expected. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the Transmission Control Module. The contact was informed that the TCM needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 140,000.

POWER TRAIN

The contact owns a 2015 Ford Fiesta. The contact stated that after the battery was replaced, the message "Transmission Malfunction Service Now" message was displayed on the instrument panel. The contact stated that while driving at various speeds, the RPMs fluctuated, and the engine revved abnormally. Whenever the contact attempted to depress the brake pedal, the engine jerked, and the transmission failed to shift as intended. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. Upon investigation, the contact related the failure to the Customer Satisfaction Program: 14M02 (Transmission Control Module); however, the VIN was not included. The failure persisted, and the vehicle remained at the residence unrepaired. The contact had parked the vehicle out of safety concerns. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 199,000.

POWER TRAIN

MALFUNCTION OF AUTOMATIC TRANSMISSION MODULE.REVERSE NOT ENGAGING.SLIPPING OF GEARS WHILE OPERATING.DIAGONISIS CONFIRMED AT PEORIA FORD PEORIA AZ ON 8/25.4 WEEKS AFTER WARRANTY EXPIRED!!!!!!!!!! CHECK ENGINE LIGHT AT TIME OF MALFUNCTION.VERY DANGEROUS SITUATION NOT ABLE TO CONTROL AUTO !!!!!!!!!!!!!!!!!!!!

POWER TRAIN

The contact owns a 2015 Ford Fiesta. The contact stated that the vehicle failed to start, and upon jumpstarting the vehicle, the message "Transmission Failure - Service Now" was displayed. The vehicle was taken to an independent mechanic, who informed the contact that the VIN was included in an unknown recall, and the contact was referred to the dealer for assistance. The vehicle was taken to the dealer, where the contact was informed that the recall had expired. The dealer replaced the TCM at the contact's expense. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 125,000. The VIN was not available.

POWER TRAIN

The contact owns a 2015 Ford Fiesta. The contact stated that while driving at various speeds, the engine jerked while depressing the accelerator pedal. The contact stated that the "Engine Malfunction Service Now" message was displayed on the instrument panel at start up. The vehicle was taken to dealer where the contact was provided an estimate for the repair. Upon investigation, the contact discovered that the vehicle was included in Customer Satisfaction Program: 14M02 (Transmission control module extended warranty coverage); however, the dealer refused to honor the warranty. The manufacturer was notified of the failure but provided the same information as the dealer. The vehicle was not repaired. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 45,000.

POWER TRAIN

The contact owns a 2015 Ford Fiesta. The contact stated while driving 65 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the check engine warning light was illuminated. The contact drove the vehicle to the shoulder of the road and turned off the vehicle. The contact stated that the vehicle was restarted, and after several attempts, the vehicle started. The vehicle was driven to the residence. The dealer was made aware of the failure but provided no assistance. The vehicle was taken to an independent mechanic, where it was diagnosed with TCM failure. The manufacturer was made aware of the failure but provided no assistance. The contact was informed of an unknown recall for the TCM however, the recall had expired. The contact had not received a recall notification. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 120,000.

ENGINE

In May, my 2015 Ford Fiesta SE went into "limp mode" before reaching the speed limit of 25mph. Immediately afterwards it was taken into a local shop, Mobile Mechanic, where no codes were active and coolant level was between min and max level. Next day, car experienced misfiring check engine light and overheating before being looked at by a mechanic. Mechanic replaced spark plugs due to code reading misfiring in cylinder 3. Car still continued to misfire and due to slight lower level of coolant, Engine overheated and cracked a cylinder block in the 1.0-liter three-cylinder EcoBoost engine. This car is used to travel with two children under [XXX] and [XXX]. The beginning of June the car overheated on a hot day traveling home with the two kids and myself. We had to sit in the heat for close to an hour before temperature gauge returned to normal, I checked the coolant and it was still between min and max levels. On the same trip, it was on the verge of overheating again due to climbing the hill before our house. After finding out the cylinder block was cracked by my mechanic we discovered there has been a recall issue with the same engine, Recall 17S09, that began in January 2018, a month before I purchased my car from Redwood Ford in Ukiah California ([XXX]). I called W. C. Sanderson Ford in Healdsburg, California on July, 15th, 2025 to see if it would be possible to see if this recall was actually fixed on my vehicle, which they responded that the recall has nothing to do with my car and they can't do anything about my car. The representative specifically said that due to my car being 10 years old it has been disqualified of the recall and is no longer attached to my VIN. I have taken this car to the same local mechanic 4 times since the ending of May, 2025 for the same issues before we discovered the cracked cylinder block, mechanic took pictures of fluid and water inside cylinder 3. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

In 2020, Documents were subpoened proving that Ford falsified doors and used a dangerous faulty transmission in Ford Fiesta and Focus Moodels from 2011-2015. There were so many lawsuits, they settled through arbitration. The judicial system only required an extended waranty- no recall or redesign. These vehicles are dangerous, and when transmission overheats, the cars stop in the middle of the road. Many will not go in Reverse. Ford is recouping their arbitration settlement money by continuing to sell these cars on the Used Car Market with the same DPS6 Transmissions which they knew were faulty and dangerous, and falsified documents about, with Clean Car Faxes, often low mileage- because heat starts transmission failure, and that is not fair. The pledge does not say...."WitH liberty and justice for ALL WHO CAN AFFORD IT!" I HAVE AMOST BEEN REAR-ENDED TWICE, because car stops when Trans gets hot. One driver of a 4'4 truck, speeding around a blind spot, swerved into oncoming lane, rolled down his window, pointed a pistol at me, cursing because I ALMOST made HIM WRECK! although my safety flashers were on. There are no shoulders on these rural roads. This car is DANGEROUS! WHY WAS FORD ALLOWED TO GET AWAY WITH THIS? Falsification of documents about a cars safety is fraud. There are tens of thousands with Clean Car Faxes still being sold unfairly to unknowing victims with modest incomes who TRUST CAR FAX DOCUMENTATION.

POWER TRAIN

The transmission control module (TCM) on my 2015 Ford Fiesta was failing at 81,000 miles. It was difficult to accelerate the car even at low speeds (25-30 mph) and my check engine light was on. I took my vehicle to the nearest Ford Dealership (Big Star Ford in Manvel, TX) who assessed my vehicle and determined the TCM needed to be replaced. They replaced the part but told me it was not under the 14M02 warranty. My check engine light did come on once back in May and the car was struggling to speed up but when I took it to a car shop the check engine light was not on and the mechanic said it was fine.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

The contact owns a 2015 Ford Fiesta. The contact stated that while operating the vehicle, the check engine warning light illuminated, and the vehicle failed to properly accelerate while depressing the accelerator pedal. The vehicle was taken to the local O'Reilly's and was diagnosed with transmission failure. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not eligible for Customer Satisfaction Program: 14M02 (Extended Warranty Coverage for TCM) related to the failure. The failure mileage was 79,000.

ENGINE

There is a recall (Recall no. 17V209000) that my VIN should have been included in but is not. My vehicle was not equipped with a coolant level sensor from the factory and does not alert to low coolant levels in the vehicle, which can lead to overheating, engine damage, and potential engine fire. The recall fix is a new updated coolant tank design, the inclusion of a coolant level sensor, and a software update for the function of said sensor.

UNKNOWN OR OTHER

the manufacture have fixed the car the recall yesterday.

ELECTRICAL SYSTEM

The contact's wife owns a 2015 Ford Fiesta. The contact stated that while the vehicle was idling or driving below 20 MPH, the vehicle sputtered and then shut off with the battery and check engine warning lights flashing on the instrument panel. The vehicle was taken to an unknown dealer, where the contact was informed that there were no recalls on the VIN. The contact asked for an estimate for a diagnostic test but was denied service. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer then referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 112,000.

ENGINE

The contact's wife owns a 2015 Ford Fiesta. The contact stated that while the vehicle was idling or driving below 20 MPH, the vehicle sputtered and then shut off with the battery and check engine warning lights flashing on the instrument panel. The vehicle was taken to an unknown dealer, where the contact was informed that there were no recalls on the VIN. The contact asked for an estimate for a diagnostic test but was denied service. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer then referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 112,000.

ENGINE

On 3/10/2025, when driving my 2015 Ford Fiesta SE, I experienced a sudden failure consisting of a "lurch", lost all drive power to the vehicle, and had to use inertia to steer myself out of traffic to the shoulder of the road. After exiting the vehicle, I inspected all tires (no issues) and popped the hood (no visible issues like smoke). I requested emergency roadside assistance to tow my vehicle to the nearest mechanic shop. After troubleshooting the vehicle, the shop confirmed that all fluid levels were okay and the timing belt had failed, specifically noting that the manufacture-recommended PMI is at 150,000 miles and my vehicle only had 118,579 miles. What component failed = Timing belt. Is it available for inspection = It can be. How was safety at risk = Losing all mechanical power while going up a grade in heavy traffic. Has the problem been confirmed = Yes, by an independent service center. Has the vehicle been inspected by the manufacturer, police, or insurance = No, but I did call Ford's service line to notify them; no action taken on their part. Any warnings = No sounds, no transient loss of power, no warning lights; just a sudden "bang" and "lurch".

ENGINE AND ENGINE COOLING

The contact owns a 2015 Ford Fiesta. The contact stated that during cold weather conditions, the check engine and the low oil pressure warning lights illuminated intermittently. The failure had become constant over time. The contact who is a certified mechanic, diagnosed the vehicle and determined that the camshaft had failed due to a camshaft position timing performance bank code. The contact replaced the spark plugs and, while doing so, noticed oil in the thread of cylinder #3 spark plug. The contact became aware of NHTSA Campaign Number: 17V209000 (engine and engine cooling). The dealer was contacted and confirmed that the VIN was not included in NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling). The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 85,000.