FORD F-450

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Ford Motor Company (Ford) is recalling certain 2015 F-250, F-350, F-450, Expedition, Lincoln Navigator, and MKC vehicles. The rearview camera printed circuit board terminal header connector may be loose or damaged, which can result in a blank or distorted image.

Risk: A blank or distorted rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

EXTERIOR LIGHTING

Life Line Emergency Vehicles (Life Line) is recalling one 2020 Ford F450 vehicle and one 2017 Navistar Durastar vehicle, equipped with 7x9 combination LED Stop-Tail-Turn reverse lights. The lights may be too bright, exceeding the maximum light output allowed which may adversely affect the vision of drivers. As such, these lamps fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: The excessive brightness may affect the vision of other drivers, increasing the risk of a crash.

EQUIPMENT

LGE Coachworks, Inc. (LGE Coachworks) is recalling certain 2018-2019 Ford E-450, F-550, and Freightliner M2-based vehicles equipped with ASA Electronics Voyager back-up camera displays. The displays may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.

Risk: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.

EQUIPMENT

VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.

Risk: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.

EXTERIOR LIGHTING:BRAKE LIGHTS

Taylor Made Ambulances is recalling certain 2017-2018 Ford E-350, F-450, E-450, F-550, and GMC G3500-based ambulances equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.

Risk: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Risk: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Risk: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

STRUCTURE:BODY:DOOR

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."

Risk: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.

EQUIPMENT

PJ's Truck Bodies & Equipment Co., (PJ's) is recalling certain 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis modified by PJ's and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.

Risk: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

ENGINE

The contact owns a 2016 Ford F-450. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of automotive power. An unknown engine-related message was displayed on the instrument panel. The vehicle was towed to a local dealer where it was diagnosed and determined that there were metal shavings inside the engine. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 66,000.

FUEL SYSTEM, DIESEL

The contact owns a 2020 Ford F-450 The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

FUEL/PROPULSION SYSTEM

Vehicle caught fire. Fire in the engine compartment after heavy fuel smell/odor.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford F-450. The contact stated that while driving at 40 MPH, the engine overheated. The contact pulled over safely and noticed there was smoke from the hood and fire. The contact used a fire extinguisher to extinguish the fire. The engine's hot light was illuminated. There were no reported injuries. The vehicle was towed to an RV park. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 97,000.

FUEL SYSTEM, DIESEL

The contact owns a 2020 Ford F-450. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The contact stated that while hauling an RV at 65 MPH, with the cruise control feature activated, the message that the "Engine has Stopped - Pull Over Immediately" was displayed, and the vehicle stalled. The vehicle was steered to the side of the road, and the contact attempted to restart the vehicle. The contact stated that the engine was turning over however, the vehicle failed to start. The vehicle was towed to a dealer to be diagnosed, and the dealer retrieved DTC: P0087. Additionally, there were metal shavings found in the fuel system. The contact was informed that the fuel pump and the entire fuel system needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 104,717.

UNKNOWN OR OTHER

tailgate opens while driving could cause jackknife of trailer and truck has recall, recall has been performed 3 times and still having issues midway ford inspected and said the tailgate is functioning as intended no warning or indicators this is 2nd time this has happened and recalls have been performed also have surveillance video of me leaving a customer's house with tailgate up and closed and when i pull to end of driveway and make a left u can see the tailgate come down while in motion driving .ford motor company and the dealer refuse to help with damages and have no concern this could happen to me on a off ramp or at higher speeds and this could end up in a life threating situation, they cannot offer me a fix or repairs to my vehicle or trailer even though i have a letter from them that says they will, customer satisfaction program 21mo5 it states coverage for this issue for 10yrs or 150,000miles i currently have 117000 miles and year coverage until 2027

FUEL SYSTEM, DIESEL

The contact owns a 2019 Ford F450. The contact stated that when the vehicle was started, the check engine warning light illuminated. The contact stated that while driving at an undisclosed speed, the vehicle went into LIMP Mode. The vehicle was taken to the dealer where it was diagnosed and determined that the diesel particle filter (DPF) had failed. The sensor was replaced. The contact stated that the failure persisted. The vehicle was taken back to the dealer. The sensor had been replaced four times. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 19,000.

FUEL/PROPULSION SYSTEM

My truck is outfitted with the CP4 fuel pump. These pumps are failing on a regular basis and destroying entire fuel systems costing the vehicle owner as much as $20,000 to replace. If this pump goes out while driving, it could be a major safety issue. I tow a 44 foot trailer with my truck and this can cause a deadly accident. I called Ford and there is no recall as of now. There are attorneys out there using the Lemon Law act to go after the ones that have failed so far. These pumps are not designed to be used with American Diesel. They are made in Europe and designed for their fuel. I am just trying to prevent an accident. I’d like Ford to just recall this pump and replace it.

FUEL SYSTEM, DIESEL

The contact owns a 2020 Ford F-450. The contact stated that after starting the vehicle, the engine ran for several minutes before the vehicle independently shut off. No warning lights were illuminated. The contact attempted to restart the vehicle however, the vehicle failed to start. The vehicle was towed to the residence. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact referenced NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL) as probable cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 184,000.