2022 FORD F-250

SERVICE BRAKES

The truck has 66,500 miles. One of our employees was driving and had the harmonic balancer bolt back out and harmonic balancer fell off. Truck has been sent to Midway Ford in Roseville, MN for repair.

STEERING

The truck has 66,500 miles. One of our employees was driving and had the harmonic balancer bolt back out and harmonic balancer fell off. Truck has been sent to Midway Ford in Roseville, MN for repair.

ENGINE

The truck has 66,500 miles. One of our employees was driving and had the harmonic balancer bolt back out and harmonic balancer fell off. Truck has been sent to Midway Ford in Roseville, MN for repair.

FUEL SYSTEM, GASOLINE

The contact owns a 2022 Ford F-250. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 55-60 MPH and hauling a Fifth Wheel Trailer, the low-pressure fuel pump suddenly failed and the vehicle lost power, causing the vehicle to stall. The contact activated the hazard lights and waited for a tow truck that was in the far-left lane on the freeway. The check engine warning light illuminated immediately when the vehicle lost power. The vehicle was towed to the dealer, who determined that the vehicle had experienced the failure listed in NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) but could not yet be repaired because parts to do the recall repair were not yet available. The dealer referred the contact to the NHTSA Hotline to report the failure. The manufacturer was informed of the failure and opened a case. The failure mileage was 21,646.

FUEL SYSTEM, GASOLINE

I just picked up my Ford F-250 (2022) from Allstar Ford in Prairieville, La. It will have been 3 weeks since I had my truck towed to this dealer! On Tuesday [XXX] my truck stalled in heavy traffic and was able to glide off [XXX] in Baton Rouge and same to a dead stop at the end intersection. I blocked traffic for 30 minutes until truck started and was able to get out of traffic! My Ford pass App text a message to me that my fuel pump module had failed. Dealer could not diagnose a failure and after 3 weeks I finally went and picked it up. They did offer to replace the fuel pump for $1700.00 as my 100,000 warranty could not be applied because dealer diagnostics could not recognize the fault??? Truck has 72,000 mile on it!! So now I am driving around in a vehicle that could stall at any time, without any notice. Now what do I do?? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.

STEERING

Bumps in the road caused steering wheel to shake violently (Death Wobble) until truck was stopped in the middle of a 4-lane expressway. Truck is now at the dealer for inspection of frontend steering components. If there was heavier traffic, there would have been an accident. no warning signs present, only bumps in the road which the truck was not able to dampen or control.

SUSPENSION

Bumps in the road caused steering wheel to shake violently (Death Wobble) until truck was stopped in the middle of a 4-lane expressway. Truck is now at the dealer for inspection of frontend steering components. If there was heavier traffic, there would have been an accident. no warning signs present, only bumps in the road which the truck was not able to dampen or control.

STEERING

Death Wobble. Steering wheel shook violently twice in one 25 mile trip. Once at 73 MPH and once at 65 MPH. Almost caused a crash due to being on a curve in the road when it occurred.

FUEL SYSTEM, DIESEL

The contact owns a 2022 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

UNKNOWN OR OTHER

Rear view camera does not always display, either black screen with distorted view lines or complete blue screen. Vehicle is not on current camera recall list

POWER TRAIN

The contact owns a 2022 Ford F-250. The contact stated that while driving 60 MPH, the vehicle skipped gears, decelerated unintendedly and lost motive power. The check engine warning light was illuminated. The contact stated that the failure had progressively increased. The vehicle was taken to the local dealer, where the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 30,000. The VIN was not available.

ENGINE

The contact owns a 2022 Ford F-250. The contact stated that while driving 60 MPH, the vehicle skipped gears, decelerated unintendedly and lost motive power. The check engine warning light was illuminated. The contact stated that the failure had progressively increased. The vehicle was taken to the local dealer, where the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 30,000. The VIN was not available.

FUEL/PROPULSION SYSTEM

Fuel pumps failure causing the truck to loose power while in traffic. I have spent 8 thousand dollars in repairs and I am still all of a sudden low Fuel pressure pops up on the screen and it looses power. Has left me stranded 200 miles from my house. Ford has told me that they can't get it to happen for their tech and told me to drive it. Same thing happened again 200 miles away from my house. I feel like Ford knows what it does and doesn't want to correct the problem. These trucks are very expensive to buy and to operate with all the service that has to be done to keep it on the road. I have been driving Ford trucks for over 35 years and this has got to be the worst one ever also the most expensive.

ENGINE AND ENGINE COOLING

The contact owns a 2022 Ford F-250. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, who performed a service update on the vehicle, which required a software update. The check engine warning light remained illuminated. The vehicle was returned to the dealer, who diagnosed that the catalytic converter had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer offered to cover part of the cost of the repair. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 62,454.

UNKNOWN OR OTHER

Power fold mirrors do not fold in or out as designed. Mirrors do not completely fold out causing safety issue when a need to change lanes. Issue appears to occur when ambient outdoor temperature is above 85 degrees and/or when the sun heats mirrors. I have reported the issue to the Ford dealer several times when the problem was intermittent and was told they could not diagnose the issue due to it being intermittent. The service writers I have spoken with also stated they have never heard of the issue. This problem started at approximately 6,000 miles (intermittent) and has escalated to very close to 100% of the time now. Vehicle mileage is currently 46,000 miles. There are several complaints on various forums on the internet regarding this issue. Vehicle is available for inspection.

ENGINE

The contact owns a 2022 Ford F-250. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that there was a misfire in cylinder #2. The contact was informed that the vehicle needed to be taken to a Ford dealer for assistance. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 24B25. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 80,000.

ELECTRICAL SYSTEM

While my truck was under warranty, I reported intermittent failure of the front passenger door lock not functioning. Because it was intermittent, the dealership said since they couldn't replicate the issue they would not try to fix the issue. Now that I am out of warranty, the lock has failed completely and the front passenger door does not automatically lock when I am driving. The safety issue is that it will not lock or unlock automatically when it should. All other door locks work properly. Ford has refused to fix this as if it were still under warranty.

FORWARD COLLISION AVOIDANCE: WARNINGS

Engine making noise and has misfire

LANE DEPARTURE: BLIND SPOT DETECTION

Engine making noise and has misfire

ENGINE

Engine making noise and has misfire

ENGINE

The contact owns a 2022 Ford F-250. The contact stated that upon starting the vehicle, there was an abnormal tapping sound coming from the engine and the vehicle was idling rough. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was advised that further diagnostic testing was required to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 76,000.

UNKNOWN OR OTHER

I brought my 2022 F-250 in to Tasca Ford in Seekonk, MA in July 2024 because the camera system was malfunctioning. It would sometimes freeze, or certain cameras would work and others wouldn't, or sometimes choosing a different camera would do nothing and the current camera would stay on the screen and never leave. Sometimes the camera would be a little distorted. Obviously unreliable cameras are annoying, but this can also be dangerous. And sometimes the cameras all worked fine! Tasca replaced a wiring harness and it was covered under warranty. In April 2025, I took the truck back in to Tasca as the camera problems were happening again. Same symptoms as before. They said the fix is to replace the APIM(?) image processing module, and that it would cost $3000 and that I was 6 months out of warranty. They submitted a request to Ford to cover this as a pre-existing condition and it was denied. I contacted Ford today because of the recall "25S49" which covers similar trucks, but not 2022 F-250's. I explained to Ford that my truck is having the exact same symptoms described in the recall. I asked them to extend the recall to my truck. They said they can't do that, and that I should contact NHTSA.

ELECTRICAL SYSTEM

The contact owns a 2022 Ford F-250. The contact received notification of NHTSA Campaign Number: 25V132000 (Electrical System); however, the part to do the recall repair was unavailable. The dealer informed the contact that the next available recall repair appointment would be in six months. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

POWER TRAIN

While driving between 65-75 mph the truck starts to vibrate in the rear. When I first bought it they said it was a heat shield but noice is getting worse and vibration is felt in floor. It has been to dealer twice now and on 4/24 will be the third time.

STRUCTURE:BODY

The drivers door power door lock fails to operate either to unlock the vehicle or to lock it. This is a safety risk as the power door lock should automatically lock the door once the vehicle reaches a certain speed to help doors remain shut in roll over accidents. Automatically locking the door also provides some security to occupants for carjacking. This problem first started when the door lock actuator failed to work in freezing weather at approximately 19,000 miles. The dealer was unwilling to repair it under warranty do to not being able to duplicate the condition despite video evidence. The problem has progressed to where it now no longer functions at all. This is not an uncommon issue as I have spoke with others who have had the same failure. Previous model year trucks have has customer gotten extended warranty from Ford to cover the lock malfunctions. Customer Satisfaction Program 20M04. Links to others reporting the same/similar issue: [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL SYSTEM, DIESEL

The contact's husband owns a 2022 Ford F-250. The contact stated while her husband was driving 30 MPH and pulling into the dealer's driveway for an oil change, the vehicle stalled. An unknown warning light was illuminated. The vehicle failed to restart and was pulled into the service bay. The dealer was able to diagnose the vehicle with the assistance of a manufacturer field technician. The dealer diagnosed that there were metal shavings in the oil and in the fuel system. The dealer repaired or replaced the internal high-pressure fuel pump components. The contact later received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated while the dealer was performing an oil change on the vehicle recently, and the dealer informed the contact that there were metal shavings in the oil and there was oil leaking into the engine compartment. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact they could not verify the recall remedy status information. The failure mileage was approximately 50,000. VIN tool confirms parts not available.

ENGINE AND ENGINE COOLING

The contact's husband owns a 2022 Ford F-250. The contact stated while her husband was driving 30 MPH and pulling into the dealer's driveway for an oil change, the vehicle stalled. An unknown warning light was illuminated. The vehicle failed to restart and was pulled into the service bay. The dealer was able to diagnose the vehicle with the assistance of a manufacturer field technician. The dealer diagnosed that there were metal shavings in the oil and in the fuel system. The dealer repaired or replaced the internal high-pressure fuel pump components. The contact later received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated while the dealer was performing an oil change on the vehicle recently, and the dealer informed the contact that there were metal shavings in the oil and there was oil leaking into the engine compartment. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact they could not verify the recall remedy status information. The failure mileage was approximately 50,000. VIN tool confirms parts not available.

FUEL SYSTEM, DIESEL

The contact owns a 2022 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact's husband stated that while driving 70 MPH, the accelerator pedal was depressed, and the vehicle failed to respond. The check engine warning light was illuminated. The contact's husband stated that the check engine warning light was illuminated, and the vehicle lost motive power. The contact stated that after turning off and restarting the vehicle, the vehicle functioned as needed for several days. The vehicle was then taken to a dealer and the contact's husband was informed that there was no technician available to repair the vehicle. The vehicle was diagnosed with turbo failure. The vehicle was not repaired. The failure mileage was approximately 82,000. VIN tool confirms parts not available.

POWER TRAIN

The contact owns a 2022 Ford F-250. The contact stated that while his son was driving at 3 MPH, the vehicle jerked abnormally. There were no warning lights illuminated. The contact stated that the vehicle should have been included in NHTSA Campaign Number: 22V087000 (Structure, Power Train). The vehicle was then taken to a dealer where it was diagnosed, and the contact was informed that the transmission output shaft shield and heat shield needed to be replaced. The vehicle was not yet repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,900.

STRUCTURE

The contact owns a 2022 Ford F-250. The contact stated that while his son was driving at 3 MPH, the vehicle jerked abnormally. There were no warning lights illuminated. The contact stated that the vehicle should have been included in NHTSA Campaign Number: 22V087000 (Structure, Power Train). The vehicle was then taken to a dealer where it was diagnosed, and the contact was informed that the transmission output shaft shield and heat shield needed to be replaced. The vehicle was not yet repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,900.

UNKNOWN OR OTHER

The component of issue is the rear drivers side FOX shock added by Tuscany Motor Co, majority owned by Fox Factory. This component collides with the rear brake fluid line causing excessive wear. Eventual failure of this line could potentially cause brake failure leading to a major road hazard. This component is available for inspection upon request. According to my local dealership, other Shelby Super Bajas have the same design flaw with the shock absorber. This component/issue has not been inspected by the manufacturer, police, insurance, or others besides my dealership. There were no warning lamps or other forms of warning besides visual excessive wear of the brake line.

POWER TRAIN

Injector learning offset limits keeps triggering a code. Fuel consumption goes way up. Ford just clears the code but it always comes back.

POWER TRAIN

Injector offset learning limits keeps triggering a engine light. Fuel consumption goes way up. Ford doesnt fix the problem they just keep clearing the code, but it always comes back

POWER TRAIN

Check engine light comes on with injector codes. Ford clears the code and the problem continues to come back. Truck uses a lot more fuel when this is active. No help from Ford on getting this resolved. Issue: Some 2020-2022 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with cylinder injection pulse offset diagnostic trouble codes (DTC) P2B11, P2B13, P2B15, P2B17, P2B19, P2B1B, P2B1D, and/or P2B1F stored in the powertrain control module (PCM) after various fuel system repairs. This may be due to incorrect learned values in the PCM. To correct the condition, follow the Service Procedure to reprogram the PCM, reprogram the transmission control module (TCM), and perform the Reset Minimum Fuel Mass Adaptions All Cylinders.

POWER TRAIN

Check engine light comes on with injector codes. Ford clears the code and the problem continues to come back. Truck uses a lot more fuel when this is active. No help from Ford on getting this resolved. Issue: Some 2020-2022 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with cylinder injection pulse offset diagnostic trouble codes (DTC) P2B11, P2B13, P2B15, P2B17, P2B19, P2B1B, P2B1D, and/or P2B1F stored in the powertrain control module (PCM) after various fuel system repairs. This may be due to incorrect learned values in the PCM. To correct the condition, follow the Service Procedure to reprogram the PCM, reprogram the transmission control module (TCM), and perform the Reset Minimum Fuel Mass Adaptions All Cylinders.

ENGINE

I was driving at a highway speed of 65 mph when suddenly the check engine light came on and the speed quickly dropped to 25 mph. The alert that appeared on the truck computer was low fuel pump pressure. This put myself and my family at risk of a severe accident. The dealership found corrosion in the fuel line and a problem with fuel pump. They felt it was possibly from contaminated fuel. They were working on 3 other vehicles with the same problem. This had not happened before and this is a vehicle driven daily. The term the came up with was a " Catastrophic fuel system Failure"

FUEL/PROPULSION SYSTEM

I was driving at a highway speed of 65 mph when suddenly the check engine light came on and the speed quickly dropped to 25 mph. The alert that appeared on the truck computer was low fuel pump pressure. This put myself and my family at risk of a severe accident. The dealership found corrosion in the fuel line and a problem with fuel pump. They felt it was possibly from contaminated fuel. They were working on 3 other vehicles with the same problem. This had not happened before and this is a vehicle driven daily. The term the came up with was a " Catastrophic fuel system Failure"

TIRES

All 4 tires have this oily/greasy substance that is leaking from where the letters are at on “MICHELIN”. The oily/greasy substance it eating at the tires specifically around the letters. I believe these tires are faulty. Notice the oily/greasy substance a year ago maybe longer. Then recently found that where this oily/greasy substance is at is eating away at the tires. All 4 have some signs 2 of them have major signs. I have more pictures but they won’t upload.

VISIBILITY

The contact owns a 2022 Ford F-250. The contact received notifications of NHTSA Campaign Numbers: 22V250000 (VISIBILITY) and 24V957000 (FUEL SYSTEM, DIESEL); however, the parts to do the recall repairs were not yet available. The contact stated that while driving 65 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal and the vehicle stalled. There was no warning light illuminated. The contact coasted the vehicle over to the side of the road. The contact exited the vehicle and noticed diesel fuel was on the ground. The vehicle was towed to the dealer where it was diagnosed, and it was determined that the fuel pump had failed. The vehicle was repaired. The manufacturer was not notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The failure mileage was approximately 73,000. VIN tool confirms parts not available for NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL). Parts distribution disconnect for NHTSA Campaign Number: 22V250000 (VISIBILITY).

FUEL SYSTEM, DIESEL

The contact owns a 2022 Ford F-250. The contact received notifications of NHTSA Campaign Numbers: 22V250000 (VISIBILITY) and 24V957000 (FUEL SYSTEM, DIESEL); however, the parts to do the recall repairs were not yet available. The contact stated that while driving 65 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal and the vehicle stalled. There was no warning light illuminated. The contact coasted the vehicle over to the side of the road. The contact exited the vehicle and noticed diesel fuel was on the ground. The vehicle was towed to the dealer where it was diagnosed, and it was determined that the fuel pump had failed. The vehicle was repaired. The manufacturer was not notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The failure mileage was approximately 73,000. VIN tool confirms parts not available for NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL). Parts distribution disconnect for NHTSA Campaign Number: 22V250000 (VISIBILITY).

FUEL/PROPULSION SYSTEM

While driving on freeway, engine started to miss/hesitate. No check engine light. Miss/hesitation started to get more frequency and started smelling gas. No check engine light. Took offramp and truck died at stop sign. Pushed truck to gas station. Once out of truck, the smell of gas was prominent. Checked under hood and saw nothing unusual. Looked under truck on driver side and saw gas dripping from the transmission to the bumper under the truck. Looked under passenger side and saw more gas. Walked around to driver side, opened the driver door (which turns the fuel pump on) and saw gas spraying from under the truck. Got under the truck and determined that the supply connector on front side of fuel tank was disconnected. I reconnected the connector, clipped it locked, checked for leaks and restarted engine. There have been no further problems. Determined that approximately 10 plus gallons of gas sprayed under the truck. Approximate milage at time of incident was 6500 miles, current mileage is 6900 miles. I have purchased and plan to replace the following Ford part numbers per the Ford workshop manual which contains the connector and downstream fuel line: PC3Z 9J280, LC3Z 9S278.

FUEL/PROPULSION SYSTEM

Engine started to tick and loss of power, had it hauled to ford dealership in Tulia tx to later find out that it had faulty rocker arms which is a known problem after calling around asking other dealerships if they have seen other pickups come in with the same issue! After digging further into the motor they found that the fuel system was going bad and also would have to be replaced which is also a well known issue after ford recalled 300,000 of these pickups with the same issue

ENGINE

Engine started to tick and loss of power, had it hauled to ford dealership in Tulia tx to later find out that it had faulty rocker arms which is a known problem after calling around asking other dealerships if they have seen other pickups come in with the same issue! After digging further into the motor they found that the fuel system was going bad and also would have to be replaced which is also a well known issue after ford recalled 300,000 of these pickups with the same issue