2012 FORD F-250

ELECTRICAL SYSTEM

I just had to replace the ECM because it fired. after replacing that it still won't start. I've talked to multiple people who have had the same problem.

POWER TRAIN

I just had to replace the ECM because it fired. after replacing that it still won't start. I've talked to multiple people who have had the same problem.

ENGINE

I just had to replace the ECM because it fired. after replacing that it still won't start. I've talked to multiple people who have had the same problem.

ENGINE AND ENGINE COOLING

The contact owns a 2012 Ford F-250. The contact stated that the vehicle was previously taken to an unknown dealer, where it was diagnosed with engine seizure due to coolant intrusion in the engine. The contact stated that while the dealer was in the process of replacing the engine, the dealer informed the contact that the transmission also needed to be replaced. The dealer replaced the engine and the transmission. The contact stated that while driving at various speeds, the vehicle was bucking and jerking. The gear shift indicator light displayed that the transmission was slipping from drive(D) to neutral(N) and reverse(R). The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission needed to be replaced; however, the part was on back order. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 27,500.

POWER TRAIN

The contact owns a 2012 Ford F-250. The contact stated that the vehicle was previously taken to an unknown dealer, where it was diagnosed with engine seizure due to coolant intrusion in the engine. The contact stated that while the dealer was in the process of replacing the engine, the dealer informed the contact that the transmission also needed to be replaced. The dealer replaced the engine and the transmission. The contact stated that while driving at various speeds, the vehicle was bucking and jerking. The gear shift indicator light displayed that the transmission was slipping from drive(D) to neutral(N) and reverse(R). The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission needed to be replaced; however, the part was on back order. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 27,500.

STRUCTURE:BODY

I purchased this truck new in 2013 and it has only been serviced by Ford, except for an Air Lift Suspension Kit install to allow load leveling when towing. Low miles: 54484 actual. No collision damage, original paint. Date of repair:06/25/2025. Jenkins Ford RO#[XXX]. My truck has a Supercab (Extended Cab) with short rear doors that open to the rear. Both of these rear doors failed within 5 minutes of each other. Specifically, the inside door handles and opening levers on the forward facing side of the doors failed. This is absolutely a safety hazard because a Child, Senior, Handicapped person, pet, etc., would be trapped from making an emergency exit in case of accident or fire. A more athletic person may be able to pull themselves over the from bench seat to exit, but still delaying the exit and dangerous. There were no warnings to alert anyone of the failures. Jenkins Ford (Crystal River, FL) diagnosed the problem and made the costly repair. Both door cables were replaced, no warranty. Cost: $1558.80 I called Ford USA Customer Relations (800) 392-3673 at 1:16PM EDT on 06/24/2025. C/S Rep "Kisha" said Ford would not assist in any goodwill for repair of this safety item. I researched this problem online an apparently, this is a common failure due to plastic parts holding the cables. I acknowledge that this vehicle is over 10 years old, but feel that this is a safety item Ford should stand behind. People keep vehicles longer these days and mine has been garaged, meticulously maintained by Ford, and has extremely low miles. Jenkins Ford did a very professional repair and I'm very happy with this dealer. The Ford Motor Company should be required to recall and repair this problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

it keeps throwing a check engine light for miss fire but ive replaced all of the ignition and fuel parts and it keeps happening now its loosing power and getting hot for no reason.

ENGINE

it keeps throwing a check engine light for miss fire but ive replaced all of the ignition and fuel parts and it keeps happening now its loosing power and getting hot for no reason.

ELECTRICAL SYSTEM

it keeps throwing a check engine light for miss fire but ive replaced all of the ignition and fuel parts and it keeps happening now its loosing power and getting hot for no reason.

STRUCTURE

The contact owns a 2012 Ford F-250. The contact stated that while driving at slow speeds, the rear end of the vehicle seemed to be falling apart. The contact stated that the failure was due to the cab mount bushing. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The approximate failure mileage was 100,000.

ENGINE AND ENGINE COOLING

The contact owns a 2012 Ford F-250. The contact stated while he was stopped at a traffic signal, he smelled a burning plastic smell. The contact observed that smoke was being emitted from under the vehicle's front end. The contact pulled off the road and parked. As he exited the vehicle, he observed that flames were shooting from under the vehicle. The contact stated that in a few minutes, the flames had engulfed the engine compartment. The fire department was called, and the police had also arrived. The fire was extinguished using water. The police did not filed a report. The contact stated that the vehicle was towed to an impound lot. The manufacturer was not informed of the failure. The failure mileage was approximately 161,000.

SUSPENSION

Driving on Pa turnpike twice this year and at 70 mph my 2012 ford f 250 with 79000 miles on it started shaking uncontrollably , had my wife and granddaughter with me and they cried and screamed till it stopped. Going to the dealer to see what Ford is going to fix for me before someone is killed ! Hopefully a recall or free fix! I have been educated that this has been an on going issue in many F250 Fords.

STEERING

Driving on Pa turnpike twice this year and at 70 mph my 2012 ford f 250 with 79000 miles on it started shaking uncontrollably , had my wife and granddaughter with me and they cried and screamed till it stopped. Going to the dealer to see what Ford is going to fix for me before someone is killed ! Hopefully a recall or free fix! I have been educated that this has been an on going issue in many F250 Fords.

FUEL SYSTEM, DIESEL

The contact owns a 2012 Ford F-250. The contact stated that the engine power was significantly reduced and there was a whining sound coming from the engine compartment. While starting the vehicle, there was a high-pitched whining sound heard. The check engine warning light was illuminated. The contact inspected the vehicle and determined there was a failure with the fuel pump. The fuel pumps were replaced 4 times, and the front and rear fuel pressure regulators were replaced several times since 2012. The contact was adding coolant to the vehicle every 2 months. The contact stated that the failure persisted. The dealer was contacted and informed of the failure. The dealer confirmed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was informed of the failure and confirmed that the VIN was not under recall. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 120,000.

ENGINE AND ENGINE COOLING

The contact owns a 2012 Ford F-250. The contact stated that the engine power was significantly reduced and there was a whining sound coming from the engine compartment. While starting the vehicle, there was a high-pitched whining sound heard. The check engine warning light was illuminated. The contact inspected the vehicle and determined there was a failure with the fuel pump. The fuel pumps were replaced 4 times, and the front and rear fuel pressure regulators were replaced several times since 2012. The contact was adding coolant to the vehicle every 2 months. The contact stated that the failure persisted. The dealer was contacted and informed of the failure. The dealer confirmed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was informed of the failure and confirmed that the VIN was not under recall. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 120,000.