2011 FORD F-250

ELECTRICAL SYSTEM:SOFTWARE

FORD IS RECALLING CERTAIN MODEL YEAR 2011 FORD F-150, F-250, F-350, F-450, F-550, EDGE, AND LINCOLN MKX TRUCKS MANUFACTURED FROM OCTOBER 25, 2010, THROUGH NOVEMBER 20, 2010. THESE VEHICLES WERE INSPECTED USING INTEGRATED DIAGNOSTIC SYSTEM (IDS) THAT HAD A CUSTOM SOFTWARE ROUTINE TO READ THE SUSPECT BODY CONTROL MODULE (BCM) SERIAL NUMBER. BASED ON THE SERIAL NUMBER THE BCM WAS EITHER NOT AFFECTED OR REPLACED. THE CUSTOM SOFTWARE ROUTINE WAS NOT READING THE CORRECT SET OF CHARACTERS, AND WAS NOT ABLE TO IDENTIFY A BCM THAT REQUIRED REPLACEMENT AFFECTED BCMS MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.

Risk: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH COULD RESULT IN A VEHICLE FIRE.

STEERING

The contact owns a 2011 Ford F-250. The contact stated that while driving over a bump at a high rate of speed, the contact experienced the death wobble and the contact temporarily lost control of the vehicle. The contact slowed down and the violent shaking ceased. The contact stated that the tie rods, ball joints, and other front-end parts were replaced to reduce the risk of the failure recurring. The contact stated that while driving 70 MPH and towing a trailer, the contact experienced the death wobble. The vehicle drifted from the far-left lane over to the far-right lane and the contact lost control of the vehicle. The contact called a local dealer and was informed that there were no recalls on the vehicle. The contact was then referred to the manufacturer and was provided a case number. The manufacturer advised the contact to report the failure to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 263,000.

SUSPENSION

The contact owns a 2011 Ford F-250. The contact stated that while driving over a bump at a high rate of speed, the contact experienced the death wobble and the contact temporarily lost control of the vehicle. The contact slowed down and the violent shaking ceased. The contact stated that the tie rods, ball joints, and other front-end parts were replaced to reduce the risk of the failure recurring. The contact stated that while driving 70 MPH and towing a trailer, the contact experienced the death wobble. The vehicle drifted from the far-left lane over to the far-right lane and the contact lost control of the vehicle. The contact called a local dealer and was informed that there were no recalls on the vehicle. The contact was then referred to the manufacturer and was provided a case number. The manufacturer advised the contact to report the failure to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 263,000.

ENGINE

The contact owns a 2011 Ford F-250. The contact stated that while driving 60 MPH, the vehicle vigorously shuddered. In addition, the contact allowed the vehicle to decelerate independently to come to a stop. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed; however, no cause for the failure was found. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 200,000.

STRUCTURE:BODY

The contact owns a 2011 Ford F-250. The contact stated that while making a turn in either direction, there was an abnormal crunching sound coming from the vehicle. There was no warning light illuminated. Upon investigation, the contact discovered that the sound was caused by a misalignment between the cab and the bed of the truck. Due to the failure the cab mount bushings became worn and needed to be replaced or repaired. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN. The contact was provided a case number and was then referred to the NHTSA Hotline to report the failure. The vehicle was not yet repaired. The failure mileage was approximately 7,000.

AIR BAGS

I was recently hit in the drivers door causing the door, the cab, and the running board to be damaged. The side impact air bag did not deploy. the entire drivers door is damaged and the cab of the truck behind the door is damaged. the running board was completely under the cab of the truck.

FUEL/PROPULSION SYSTEM

Truck started leaking fuel and then the engine shut down the next day it was drove, while driving! I’ve received 2 quotes and need the whole fuel system replaced due to CP4 pump failing which will cost about $13,000! This is the same issue as the 24S78 Ford recall but my truck doesn’t fall in the correct year! I still owe 10k on this vehicle so it’s basically totaled now.

STEERING

When driving over 55mph and hitting a bump, pothole, etc....the death wobble starts taking excessive force to keep the truck on the road with the steering wheel nowhere aligned to where the tires are aimed. Dealership stated they wouldn't take the vehicle on trade due to the steering box needing to be addressed first. no warning lamps illuminate. Happens every time while driving from mileage 170K - 189K.