FORD F-250

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Ford Motor Company (Ford) is recalling certain 2015 F-250, F-350, F-450, Expedition, Lincoln Navigator, and MKC vehicles. The rearview camera printed circuit board terminal header connector may be loose or damaged, which can result in a blank or distorted image.

Risk: A blank or distorted rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

POWER TRAIN:AXLE ASSEMBLY

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350, single rear wheel and dual rear wheel, 4X4 vehicles. The front axles may contain a wheel end yoke that was not properly welded to the axle tube end.

Risk: An improperly welded axle may affect vehicle control, increasing the risk of a crash.

EQUIPMENT

VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.

Risk: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Risk: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350 vehicles equipped with electronically locking rear differentials. The passenger side rear axle shaft may fail prematurely due to a material issue.

Risk: A broken passenger side rear axle could result in a loss of drive power and the inability to hold the vehicle still when in Park. If the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of a crash.

SEATS

Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.

Risk: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Risk: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

STRUCTURE:BODY:DOOR

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."

Risk: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.

EXTERIOR LIGHTING:TAIL LIGHTS

FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

Risk: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

SERVICE BRAKES

The truck has 66,500 miles. One of our employees was driving and had the harmonic balancer bolt back out and harmonic balancer fell off. Truck has been sent to Midway Ford in Roseville, MN for repair.

STEERING

The truck has 66,500 miles. One of our employees was driving and had the harmonic balancer bolt back out and harmonic balancer fell off. Truck has been sent to Midway Ford in Roseville, MN for repair.

ENGINE

The truck has 66,500 miles. One of our employees was driving and had the harmonic balancer bolt back out and harmonic balancer fell off. Truck has been sent to Midway Ford in Roseville, MN for repair.

BACK OVER PREVENTION

The contact owns a 2015 Ford F-250. The contact stated that while attempting to reverse, the rearview camera became inoperable. The contact stated that the rearview camera image appeared blank and occasionally distorted. The contact received notification of NHTSA Campaign Number: 25V270000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The dealer was contacted. The dealer confirmed that parts were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 104,327.

FUEL SYSTEM, GASOLINE

The contact owns a 2022 Ford F-250. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 55-60 MPH and hauling a Fifth Wheel Trailer, the low-pressure fuel pump suddenly failed and the vehicle lost power, causing the vehicle to stall. The contact activated the hazard lights and waited for a tow truck that was in the far-left lane on the freeway. The check engine warning light illuminated immediately when the vehicle lost power. The vehicle was towed to the dealer, who determined that the vehicle had experienced the failure listed in NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) but could not yet be repaired because parts to do the recall repair were not yet available. The dealer referred the contact to the NHTSA Hotline to report the failure. The manufacturer was informed of the failure and opened a case. The failure mileage was 21,646.

BACK OVER PREVENTION

The contact owns a 2014 Ford F-250. The contact stated that while reversing, the rearview camera displayed a mirrored image, compromising the back over prevention system. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V442000 (Back Over Prevention), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 80,000.

FUEL SYSTEM, DIESEL

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

FUEL/PROPULSION SYSTEM

The fuel pump blew up in our F250 while driving a main road on Thursday [XXX]. The vehicle was towed to the nearby facility to investigate the situation. It was discovered today 9/8/2025 that the fuel pump had sent metal shavings through the whole fuel systems which all needs to be replaced now. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL SYSTEM, GASOLINE

I just picked up my Ford F-250 (2022) from Allstar Ford in Prairieville, La. It will have been 3 weeks since I had my truck towed to this dealer! On Tuesday [XXX] my truck stalled in heavy traffic and was able to glide off [XXX] in Baton Rouge and same to a dead stop at the end intersection. I blocked traffic for 30 minutes until truck started and was able to get out of traffic! My Ford pass App text a message to me that my fuel pump module had failed. Dealer could not diagnose a failure and after 3 weeks I finally went and picked it up. They did offer to replace the fuel pump for $1700.00 as my 100,000 warranty could not be applied because dealer diagnostics could not recognize the fault??? Truck has 72,000 mile on it!! So now I am driving around in a vehicle that could stall at any time, without any notice. Now what do I do?? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.