2021 Ford F-150 Recalls, Problems & Complaints

2021 FORD F-150

ID: 2129025

ELECTRICAL SYSTEM

The alternator failed at 60,000 ish miles. Specific mileage can be provided upon request. It appears this is a common problem as alternators and alternator parts are unavailable. I have had to order a custom alternator.

2021 FORD F-150

ID: 2128282

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated that there was an abnormal squeaking sound coming from the vehicle while driving at various speeds. The failure persisted, and the ABS, Hill Start Assist Not Available, Pre-Collision Assist Not Available, and several other messages appeared on the instrument panel. The vehicle was taken to a dealer where the contact was informed that the wheel hub bolt in the rear axle was fractured and caused the failure. The contact was informed that the VIN was included in NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was on backorder. The manufacturer was notified of the failure and requested a status update on the part. The contact was then informed that the dealer would call the manufacturer and request the part to repair the vehicle. The vehicle was not repaired. The failure mileage was approximately 45,000.

2021 FORD F-150

ID: 2128214

EXTERIOR LIGHTING

The passenger side daytime running lamp has burned out in one section. Ford says in order to replace this the whole headlight must be replaced at a cost of $1,400. Daytime running lamps are a requirement for safety and the inability to repair the running lamp without replacing the entire headlight poses a safety risk to both the driver and other vehicles on the road.

2021 FORD F-150

ID: 2127525

UNKNOWN OR OTHER

Truck has been at Ford dealership since July 9th for this recall. After updating the computer as mentioned in the recall, a ‚Äútrailer brake fault‚Äù was displayed and we were left with no trailer brakes while towing our camper. It has beyond a ‚Äúreasonable amount of time‚Äù to get this safety issue fixed. Compaign recall number: 25S15/25V132

2021 FORD F-150

ID: 2127524

SERVICE BRAKES

Truck has been at Ford dealership since July 9th for this recall. After updating the computer as mentioned in the recall, a ‚Äútrailer brake fault‚Äù was displayed and we were left with no trailer brakes while towing our camper. It has beyond a ‚Äúreasonable amount of time‚Äù to get this safety issue fixed. Compaign recall number: 25S15/25V132

2021 FORD F-150

ID: 2126627

POWER TRAIN

Fords 10r80 transmission is a known failure point. Why are they not recalling it?????? I bought my vehicle used from a ford dealership with 36k miles. Quickly realized it was a lemon but nothing I could do. The biggest issue is the transmission. The transmission does not shift properly, it slips, it has major clunking and hard downshifts sometimes pushing through brake pressure, etc. I fought with two separate dealerships to take a look and after months of them trying to convince me it was fine, they tore it apart and it was damaged. Now the "rebuilt" trans is doing the same thing even leaving me in limp mode just now until I turned the vehicle off and back on. You guys need to do something about this please. Ford is not doing anything and its hurting consumers and going to cause an accident if it hasn't already.

2021 FORD F-150

ID: 2126439

SERVICE BRAKES

See attached document for complaint.

2021 FORD F-150

ID: 2126438

ENGINE AND ENGINE COOLING

See attached document for complaint.

2021 FORD F-150

ID: 2126372

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part required for the recall repair was not yet available. The vehicle was taken to the local dealer, where it was determined that the left and right rear axle shaft assemblies had failed and needed to be replaced. The dealer informed the contact that the parts were not yet available for the recall repair and needed to be ordered. The manufacturer was not made aware of the failure. The failure mileage was unknown.

2021 FORD F-150

ID: 2126118

ENGINE

I have a safety recall notice 24S55 / NHTSA recall 24V635 on my F-150. Ford requires 2-3 days to diagnose the problem due to current workload. During this diagnostic period, Ford refuses to provide a rental or loaner, leaving me without transportation. I use the truck for work, so I do not have a way to take the truck in for the recall without coming out of pocket for a replacement vehicle. My understanding is that this is a gray area, as Ford has not issued instructions to stop driving, so are not legally required to provide a rental vehicle during the diagnostic period. The fact remains I would have to take a financial loss to bring my vehicle in for this recall due to the diagnostic time. A simple solution would be for Ford to provide a replacement vehicle during this time. I discussed this with the dealership and the corporate number, to no avail.

2021 FORD F-150

ID: 2125866

EXTERIOR LIGHTING

On my 2021 Ford F-150, the passenger-side LED daytime running light (DRL) has become noticeably dim compared to the driver‚Äôs side. This issue is widely reported by other owners of 2021-23 F-150 trucks. The problem is not electrical. Owners who have disassembled the headlight assemblies have found that the fiber-optic style light tube that distributes the LED‚Äôs light becomes heat-damaged over time. This burned spot blocks light from passing through the DRL, leaving one side of the vehicle significantly dimmer or out. Safety Concern: DRLs are a safety-critical feature designed to increase vehicle visibility during daytime driving. When one DRL is dim or inoperative, it reduces the truck‚Äôs visibility to oncoming drivers and creates an inconsistent lighting pattern that can cause confusion for other road users. This increases the risk of daytime collisions. This is not a cosmetic issue ‚Äî it directly affects vehicle safety. The failure is common across this model year, but Ford only sells the DRL as part of the entire headlight assembly. The cost of replacement ($800‚Äì$1,200 per side) places a heavy burden on owners, especially since the defect appears prematurely and outside warranty coverage. Request: I urge NHTSA to investigate this widespread defect in Ford F-150 headlights. The DRL failure clearly reduces vehicle visibility and poses a safety risk, making it a safety-related defect that warrants further action, including the possibility of a recall or extended coverage. [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 FORD F-150

ID: 2125562

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that, upon routine maintenance, it was noticed by the local dealer that the axle shaft bolt had fractured. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 33,000.

2021 FORD F-150

ID: 2125519

FUEL/PROPULSION SYSTEM

The truck hesitated at a section in the highway where it almost stalled out and I needed to cross over and almost got hit by on coming traffic. Also it has happened multiple times going down the highway the vehicle will start to stop and go it feels like the vehicle is going to stall out. This is very dangerous and I feel like this needs immediate attention

2021 FORD F-150

ID: 2125447

ELECTRICAL SYSTEM

I had driven the car about 15 residential miles to Home Depot and back. As I was driving into my driveway I smelled smoke and looked forward to see a puff of smoke coming out from the front, driver's side wheel well. I put the car in park and pulled the hook release control under the steering wheel. Suddenly flames were coming out the sides of the hood, about 12" high. I pulled the car quickly away from the house and trees. Put the car in park, as the flames were now engulfing the entire hood. I quickly got away from the car and called 911. The Fire Department is close to my house, yet by the time they arrived the car, including interior cabin, was fully engulfed in flames.

2021 FORD F-150

ID: 2125446

ENGINE

I had driven the car about 15 residential miles to Home Depot and back. As I was driving into my driveway I smelled smoke and looked forward to see a puff of smoke coming out from the front, driver's side wheel well. I put the car in park and pulled the hook release control under the steering wheel. Suddenly flames were coming out the sides of the hood, about 12" high. I pulled the car quickly away from the house and trees. Put the car in park, as the flames were now engulfing the entire hood. I quickly got away from the car and called 911. The Fire Department is close to my house, yet by the time they arrived the car, including interior cabin, was fully engulfed in flames.

2021 FORD F-150

ID: 2125253

EXTERIOR LIGHTING

Left Side Day Time Driving Light went out on top half on my 2021 F150 Ford Truck. Ford has many complaints of this happening to the Day Time Driving Lights from 2021 to 2024. The light is a complete replacement of the entire head light assembly for $ 2000 at the dealer. Day Time Driving Lights are a Safety Feature of Automobiles and should be part of warranties. This is a major problem with the Ford lighting system and it shouldn't cost $2000 to replace a daytime driving light. Being a Safety Item it should be recalled and Ford should be made to replace these head light assemblies to ensure the safety of all drivers.

2021 FORD F-150

ID: 2125136

VISIBILITY/WIPER

I was driving in a torrential rain storm in Florida. My wipers were on as I have the Platinum edition which has numerous sensors. I heard a strange sound then nothing the wipers stopped and I could not see a thing. I was in traffic so i put my hazard lights on and I indicated to the right and pulled over. I could not drive the vehicle so I had to wait the storm out before I could drive. When I got home I noted that this was a common problem with the 2021 F150 and in Particular the Platinum edition. I called Greenway Ford who told me it was covered under warranty but when I got there they advised me that my vehicle was not part of the recall. They advised that a technician could take a look at $179 to assess the damage. I said its clearly wiper motor as there is no sound at all when you try to turn on the wipers its completely dead. I wondered if any other owners had suffered the same fate. Unfortunately I cant drive the vehicle right now as we have regular storms in Orlando. I have only had the vehicle a few months and I was pretty disappointed in their response as it was really dangerous when this happened. I am not a mechanic but it appears by the VIN my vehicle was not part of the recall. I am reporting this in case there are other owners who suffered the same issue and it may warrant a recall. I thank you in advance for any help you can provide and thank you for keeping us safe.

2021 FORD F-150

ID: 2124941

ELECTRICAL SYSTEM

The contact owns a 2021 Ford F-150. The contact stated that while opening the front driver‚Äôs side door, there was an abnormal grinding coming from the motor for the retractable running board on the front passenger‚Äôs side, and the running board failed to deploy as designed. The vehicle was taken to the dealer where it was diagnosed and determined that the motor in the retractable running board had failed and needed to be replaced. The vehicle was not repaired. The contact attempted to replace the motor for the retractable running board himself and failed. The manufacturer was not notified of the failure. The failure mileage was 81,000.

2021 FORD F-150

ID: 2124886

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 21V090000 (VISIBILITY), 23V896000 (POWER TRAIN), and 25V315000 (BACK OVER PREVENTION); however, the parts to do the recall repairs were not yet available. The contact stated that while driving 70 MPH, the vehicle jerked abnormally. On another occasion, the tailgate failed to function as intended. The vehicle was taken to the dealer, but was not diagnosed. The vehicle was repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.

2021 FORD F-150

ID: 2124885

VISIBILITY

The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 21V090000 (VISIBILITY), 23V896000 (POWER TRAIN), and 25V315000 (BACK OVER PREVENTION); however, the parts to do the recall repairs were not yet available. The contact stated that while driving 70 MPH, the vehicle jerked abnormally. On another occasion, the tailgate failed to function as intended. The vehicle was taken to the dealer, but was not diagnosed. The vehicle was repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.

2021 FORD F-150

ID: 2124884

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 21V090000 (VISIBILITY), 23V896000 (POWER TRAIN), and 25V315000 (BACK OVER PREVENTION); however, the parts to do the recall repairs were not yet available. The contact stated that while driving 70 MPH, the vehicle jerked abnormally. On another occasion, the tailgate failed to function as intended. The vehicle was taken to the dealer, but was not diagnosed. The vehicle was repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.

2021 FORD F-150

ID: 2124120

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

2021 FORD F-150

ID: 2123978

EXTERIOR LIGHTING

The LEDs in the daytime running lights have failed. They are partially burned out. Based on research, I‚Äôve done online this is apparently a common problem.

2021 FORD F-150

ID: 2123935

STEERING

Random times my clockspring makes clicking sounds and the car iant able to be driven. Getting many messages about issues with the vehicle

2021 FORD F-150

ID: 2123934

ELECTRICAL SYSTEM

Random times my clockspring makes clicking sounds and the car iant able to be driven. Getting many messages about issues with the vehicle

2021 FORD F-150

ID: 2123798

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train). The contact stated that the dealer was contacted several times regarding parts availability; however, the contact was informed that parts were on a national back order. The contact stated that the most recent letter stated that parts were available; however, when the contact called the dealer, the dealer stated that parts were still not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

2021 FORD F-150

ID: 2123785

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention). The contact stated that the camera was flashing, the image was blocked, and the camera became inoperable. The driver had to use the mirrors while reversing. There were no warning lights illuminated. The vehicle was taken to the local dealer, where the software update was completed, but the failure persisted. The contact was informed that further inspection of the vehicle was needed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 35,000.

2021 FORD F-150

ID: 2123524

AIR BAGS

The contact owns a 2021 Ford F-150. The contact stated that while her husband was stopped, a 2023 Dodge Ram 1500 reversed at approximately 55 MPH, causing the rear to crash into the front of her husband's front of vehicle. No air bags¬†deployed. The contact's husband and grandfather, who was a passenger in the vehicle, were injured. The grandfather sustained neck and facial injuries, primarily around the neck and chin area. The husband suffered injuries to his hands. Medical attention was required for both occupants. A police report was filed, and the vehicle was towed. The insurance company was pending an inspection to determine if the vehicle was destroyed or not. The contact informed the dealer of the incident, and referred¬†the contact to the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to¬†the NHTSA Hotline. The¬†failure mileage was approximately 59,000.

Crash 2 Injured

2021 FORD F-150

ID: 2123196

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

2021 FORD F-150

ID: 2123146

POWER TRAIN

My 2021 Ford F-150 5.0L V8 with the 10-speed automatic transmission has ongoing and severe transmission issues that create a dangerous safety hazard. The vehicle intermittently loses power and feels like it slips completely out of gear while driving, including at highway speeds. This sudden loss of acceleration is unsafe and could easily lead to an accident. The most severe issues occur between 2nd and 4th gear. The truck slams in and out of gear, hesitates, and lurches violently. Shifting often feels like the transmission is ‚Äúhunting‚Äù for the right gear, and hesitation occurs throughout other gear ranges as well. At times, it feels like a new driver learning to operate a manual transmission‚Äîjerky, unpredictable, and unsafe. This is not an isolated problem. After researching on multiple owner forums, I found many other 2021 F-150 owners reporting the exact same issues: slipping out of gear, hard shifts between 2nd‚Äì4th, hesitation, loss of power, and violent shifting. These widespread complaints strongly suggest a defect in the design or function of this 10-speed transmission. This is not just a drivability issue‚Äîit is a critical safety concern. I have lost power while merging and while traveling at highway speeds, leaving me unable to accelerate when needed. In city driving, the hesitation and gear slamming create dangerous situations when crossing intersections or pulling into traffic. Given the number of owners reporting similar problems, I believe this is a systemic defect that requires immediate investigation and action. Ford needs to address this transmission failure before it leads to crashes, injuries, or fatalities.

2021 FORD F-150

ID: 2122421

EXTERIOR LIGHTING

Right side headlight had partial failure resulting in insuffient lighting. had it replaced because Ford said its not a covered item. Three months later the left side headlight went partially out. ive spoke to a few Ford owners who has had the same problem and Ford is not recognizing this issue as a defective part. I think this problem needs to be addressed.

2021 FORD F-150

ID: 2122209

ELECTRICAL SYSTEM

Fords Sync system fails to connect to internet and won‚Äôt update resulting in transmission failing to relearn as you drive

2021 FORD F-150

ID: 2121342

STEERING

Power steering rack failure, while driving though a puddle less than 6 inches deep. Cost over $1900 to replace. My wife's 2014 volkswagen passat is able to drive though deeper water.. on 8/13 I was unable to move over on a road that had some puddles due to oncoming traffic. After driving though the small puddle my power steering went out. Took to the mechanic and he said its a known issue due to how Ford did not seal their wiring well under the trucks and it hangs lower allowing the water to seep into the cables and cause the powering steering rack to fail.. this is unacceptable its a truck a puddle should not cause a truck to loose power steering.

2021 FORD F-150

ID: 2121341

POWER TRAIN

Power steering rack failure, while driving though a puddle less than 6 inches deep. Cost over $1900 to replace. My wife's 2014 volkswagen passat is able to drive though deeper water.. on 8/13 I was unable to move over on a road that had some puddles due to oncoming traffic. After driving though the small puddle my power steering went out. Took to the mechanic and he said its a known issue due to how Ford did not seal their wiring well under the trucks and it hangs lower allowing the water to seep into the cables and cause the powering steering rack to fail.. this is unacceptable its a truck a puddle should not cause a truck to loose power steering.

2021 FORD F-150

ID: 2121340

ENGINE

Power steering rack failure, while driving though a puddle less than 6 inches deep. Cost over $1900 to replace. My wife's 2014 volkswagen passat is able to drive though deeper water.. on 8/13 I was unable to move over on a road that had some puddles due to oncoming traffic. After driving though the small puddle my power steering went out. Took to the mechanic and he said its a known issue due to how Ford did not seal their wiring well under the trucks and it hangs lower allowing the water to seep into the cables and cause the powering steering rack to fail.. this is unacceptable its a truck a puddle should not cause a truck to loose power steering.

2021 FORD F-150

ID: 2121113

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. The check engine warning light was illuminated. The contact stated that prior to the failure, the vehicle hesitated to start. In addition, the contact stated that the vehicle failed to restart or shift out of neutral(N). The vehicle was towed to a local residence, where it was diagnosed with a fuel pump failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 51,000.

2021 FORD F-150

ID: 2121002

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

2021 FORD F-150

ID: 2120991

EXTERIOR LIGHTING

The contact owns a 2021 Ford F-150. The contact remote started the vehicle from the office and walked up to the vehicle, and became aware that the front driver‚Äôs side vertical daytime running lights failed to function as intended. No warning lights were illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The contact was informed that the failure might be related to the headlight assembly and that the headlight assembly needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, and the contact was informed that the repair would be an out-of-pocket expense for the replacement of the headlight module because the failure was not covered under recall or warranty. The failure mileage was approximately 52,000.

2021 FORD F-150

ID: 2120433

POWER TRAIN

Last Monday, I was driving [XXX] near Jacksonville, Fl. While in an outer lane the truck pulled to the right during rain, not like a hydroplaning. I could not regain control and hit a barrier. Airbags deployed. After, I got out saw the rear passenger tire was somehow off. When PSA arrive they found it ~200 feet down the road. It had snapped off. Complete break at the axle hub. Given the recall issued on 2023-2025 models I thought I should report this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Crash 1 Injured

2021 FORD F-150

ID: 2120395

SUSPENSION

The contact owns a 2021 Ford F-150. The contact stated that while driving at various speeds, the rear-end of the vehicle was making an abnormally loud sound. The vehicle was taken to an independent mechanic, where it was determined that the rear-end had failed and needed to be replaced. The dealer was contacted and informed the contact the vehicle was not covered under a related recall or under an extended warranty. The vehicle was repaired by the independent mechanic. Additionally, the contact stated that while reversing, the rear-view camera image was black. The contact stated that while reversing and towing a trailer on one occasion, the failure recurred, causing the tailgate of the vehicle to hit the trailer, and the tailgate sustained damage. The contact received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention), and the vehicle was taken to the dealer, where the recall repair was performed; however, the failure recurred the following day. The dealer and the manufacturer were notified of the failure, but no assistance was provided. The failure mileage was approximately 85,000.

2021 FORD F-150

ID: 2120394

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact stated that while driving at various speeds, the rear-end of the vehicle was making an abnormally loud sound. The vehicle was taken to an independent mechanic, where it was determined that the rear-end had failed and needed to be replaced. The dealer was contacted and informed the contact the vehicle was not covered under a related recall or under an extended warranty. The vehicle was repaired by the independent mechanic. Additionally, the contact stated that while reversing, the rear-view camera image was black. The contact stated that while reversing and towing a trailer on one occasion, the failure recurred, causing the tailgate of the vehicle to hit the trailer, and the tailgate sustained damage. The contact received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention), and the vehicle was taken to the dealer, where the recall repair was performed; however, the failure recurred the following day. The dealer and the manufacturer were notified of the failure, but no assistance was provided. The failure mileage was approximately 85,000.

2021 FORD F-150

ID: 2120332

VISIBILITY

The contact owns a 2021 Ford F-150. The contact stated that the windshield wipers were hesitating while operating, before becoming inoperable. While driving in the rain, it was difficult to see due to the failure. The vehicle was taken to the local dealer and repaired under NHTSA Campaign Number: 23V163000 (Visibility). The vehicle was repaired, but the failure recurred. The vehicle was taken to another Ford dealer, Ted Britt Ford of Chantilly Service (4175 Auto Park Cir, Chantilly, VA 20151); to be diagnosed, and the wiper arms were replaced for not working properly. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no additional assistance was provided. The manufacturer stated the repairs were outside of the warranty or recall parameters. The failure mileage was approximately 60,000.

2021 FORD F-150

ID: 2120037

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that while in reverse and reversing out of the driveway at 5 MPH, the vehicle detected that a door was being opened and activated the safety feature and shifted the vehicle into park. While the safety feature was activated, the gear shifter was over-shifted, and the gear shifter remained in reverse. The dealer was contacted and notified of the failure. The dealer confirmed there was no recall on the VIN related to the power train. Additionally, parts for the recall repair was not yet available. The vehicle was towed to a certified mechanic and was in the process of being diagnosed. The vehicle was not repaired. The manufacturer was informed of the failure and confirmed that there was no recall on the VIN for the powertrain. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 62,000.

2021 FORD F-150

ID: 2120036

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that while in reverse and reversing out of the driveway at 5 MPH, the vehicle detected that a door was being opened and activated the safety feature and shifted the vehicle into park. While the safety feature was activated, the gear shifter was over-shifted, and the gear shifter remained in reverse. The dealer was contacted and notified of the failure. The dealer confirmed there was no recall on the VIN related to the power train. Additionally, parts for the recall repair was not yet available. The vehicle was towed to a certified mechanic and was in the process of being diagnosed. The vehicle was not repaired. The manufacturer was informed of the failure and confirmed that there was no recall on the VIN for the powertrain. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 62,000.

2021 FORD F-150

ID: 2119989

FUEL/PROPULSION SYSTEM

My truck completely shut down while leaving the shop and I was only going about 6-10mph. The dash alert stated "fuel accessory" or something in orange, sorry, I panicked a little:) I took it to Bradley Ford the next day and they couldn't fix it as they didn't know the issue. This happened a second time, but didn't shut off completely, it just felt like I was running out gas (full tank). I do live in Lake Havasu City, Az and it's hot here so I don't let my truck go below 1/2 tank hoping this will help avoid a major accident. Thank you! [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 FORD F-150

ID: 2119988

ENGINE

My truck completely shut down while leaving the shop and I was only going about 6-10mph. The dash alert stated "fuel accessory" or something in orange, sorry, I panicked a little:) I took it to Bradley Ford the next day and they couldn't fix it as they didn't know the issue. This happened a second time, but didn't shut off completely, it just felt like I was running out gas (full tank). I do live in Lake Havasu City, Az and it's hot here so I don't let my truck go below 1/2 tank hoping this will help avoid a major accident. Thank you! [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 FORD F-150

ID: 2119651

EXTERIOR LIGHTING

Very premature headlight failure that ford refuses to acknowledge or repair under warranty. One headlight is more than $1200. Major safety concern.

2021 FORD F-150

ID: 2119606

EXTERIOR LIGHTING

The DRL has gone out on one of my headlights. The other has started to flicker. This is uncovered by their extended warranty and over $1600 per side to replace. It is becoming common to see many 2021-2023 with LED reflector headlamps with burned out DRL. It is an unserviceable part as well. Only can replace the entire assembly but no warranty will cover it as lighting is exempt as standard wear items.

2021 FORD F-150

ID: 2118817

EXTERIOR LIGHTING:HEADLIGHTS:DAYTIME RUNNING LIGHTS:BULBS

The contact owns a 2021 Ford F-150. The contact stated that the vertical daytime running lights on the driver‚Äôs and passenger‚Äôs side failed to operate as needed. Upon investigation, the contact discovered that the headlight module needed to be replaced. The manufacturer was notified of the failure, and the contact was informed that the repair would be an out-of-pocket expense to replace the headlight module because the failure was not covered under recall or warranty. The vehicle was not repaired. The failure mileage was 49,000.

2021 FORD F-150

ID: 2118634

STEERING

Getting multiple messages like service advancetrac, pre collision assistance not available, and steering assist fault. Vehicle makes noice randomly when turning but not every time

2021 FORD F-150

ID: 2117747

POWER TRAIN

Mostly when pulling out of parking lot but entering traffic at slow speeds complete loss of power for 4 to 5 seconds or longer.

2021 FORD F-150

ID: 2117461

POWER TRAIN

We had our truck in SEVERAL times when under warranty for repair because the truck back axle was jumping and jerking at low speeds (30-40). of course our luck, they can't find anything wrong. then it goes out of warranty and the back right axle goes out and it is undriveable. We repair it at an expense of 1400.00 in 2024 and now the other back axle went out and it cost 1200.00. Talking with other Ford owners and mechanics, this is a known issue and Ford isn't doing anything about it. Is there any help we can get in matter, Ford says there isn't.

2021 FORD F-150

ID: 2117344

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. No warning light was illuminated. In addition, the transmission shuddered. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure; however, the contact was informed that the parts were not available. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, parts were not yet available. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 88,000.

2021 FORD F-150

ID: 2117275

BACK OVER PREVENTION: WARNINGS

Computer screen goes black. Sometimes this happen right when I start the truck, sometimes when put it in reverse and sometimes just while driving down the road. This started shortly after i purchased the truck in Feb 2025 and seems to be getting worse.

2021 FORD F-150

ID: 2117267

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

While driving (on the highway or in town) get and error message "Intelligent Cruse Control Speed Sign Recognition Not Available" This results in the cruse control not adjusting for change in speed. Such as getting off a highway onto a side road, the Cruse Control continues at the old speed. It has been happening ever since early July 2025

2021 FORD F-150

ID: 2117187

UNKNOWN OR OTHER

On Sunday, [XXX], I was driving on a state highway in my 21 Ford F150 FX4 with my family. 67mph, 73 degrees sunny outside. The front portion of my moonroof/sunroof exploded, shooting glass shards internally all over my truck/passengers and externally into the bed of my truck, and into the boat I was towing. Multiple people had glass shards embedded in their skin. There were no other vehicles nearby, and there was no prior damage to the sunroof/moonroof of the vehicle. The truck gave no warning or signs of malfunction prior to the event. The sunroof was closed, and all windows in the vehicle were closed. On Monday morning ([XXX]), I took my truck to the local Ford service center, and they inspected it, shocked at the results. They filed a claim that Ford denied because the windows are not covered by my extended warranty. They wanted to charge me $ 4,000 for the repair/replacement of the glass and track. I have been on the phone with Ford Protection and Ford Customer Service (Aug 6th, 2025), trying to get something resolved, and Ford continues to deny responsibility. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2 Injured

2021 FORD F-150

ID: 2116980

EXTERIOR LIGHTING

The DRL on the passenger side of my truck have already begun to go out, I have noticed a ton of these 14th generation F150's on the road with dead/dying DRL and mine began to die after 4 years and 61k miles.

2021 FORD F-150

ID: 2116794

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact stated that while reversing, the rearview camera image was black, and the message "Return Vehicle to Dealer for Camera Malfunction" was displayed on the infotainment screen. The vehicle was taken to a local dealer to be diagnosed, but the failure could not be replicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,000.

2021 FORD F-150

ID: 2116544

ENGINE

The contact owns a 2021 Ford F-150. The contact stated that while reversing, the rearview camera image was black. Additionally, the contact stated while driving 5-8 MPH, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was able to restart, and the contact drove to the residence. The contact also stated that while driving from a complete stop, the vehicle sputtered. The contact received notification of NHTSA Campaign Numbers: 25V315000 (Back Over Prevention) and 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer, but was not diagnosed or repaired. The dealer referred the contact to the NHTSA Hotline for assistance. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The failure mileage was approximately 32,899.

2021 FORD F-150

ID: 2116543

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F-150. The contact stated that while reversing, the rearview camera image was black. Additionally, the contact stated while driving 5-8 MPH, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was able to restart, and the contact drove to the residence. The contact also stated that while driving from a complete stop, the vehicle sputtered. The contact received notification of NHTSA Campaign Numbers: 25V315000 (Back Over Prevention) and 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer, but was not diagnosed or repaired. The dealer referred the contact to the NHTSA Hotline for assistance. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The failure mileage was approximately 32,899.

2021 FORD F-150

ID: 2116542

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact stated that while reversing, the rearview camera image was black. Additionally, the contact stated while driving 5-8 MPH, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was able to restart, and the contact drove to the residence. The contact also stated that while driving from a complete stop, the vehicle sputtered. The contact received notification of NHTSA Campaign Numbers: 25V315000 (Back Over Prevention) and 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer, but was not diagnosed or repaired. The dealer referred the contact to the NHTSA Hotline for assistance. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The failure mileage was approximately 32,899.

2021 FORD F-150

ID: 2115820

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact stated that while reversing, the rearview camera image was black intermittently. The contact related the failure to NHTSA Campaign Number: 25V315000 (Back Over Prevention). The dealer was contacted and confirmed that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and confirmed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 42,700.

2021 FORD F-150

ID: 2115611

UNKNOWN OR OTHER

About 1 hour into a commute, I attempted to connect to a call while using the Car Play function of the SYNC system. Upon connection, the speakers blasted as loud as they could possibly go, a terrible pulsing static sounds that scared me and the passenger and almost caused us to have an accident. The volume knob was indicating 0 and would not move and I could not lower the volume of the terrible sound. I pulled over and tried to restart the car a few times, but the sound would not stop until I left the car off for about 10 minutes. I've not connected my phone via Bluetooth or Car Play since for fear that the sound may return when I am not expecting it, startle me and cause an accident. Though I am not certain of the cause. After about 10 minutes of the sound, I also noticed that the speakers were getting hot and I could smell the electronics or wiring overheating. I have a video of the sound but the dealer could not replicate it.

2021 FORD F-150

ID: 2115479

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 25V315000 (Back Over Prevention) and 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recalls repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

2021 FORD F-150

ID: 2115478

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 25V315000 (Back Over Prevention) and 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recalls repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

2021 FORD F-150

ID: 2114609

POWER TRAIN

I own a 2021 Ford F-150 [Lariat PowerBoost] affected by recall 23S65 (rear axle bolt). The bolts have severed. Ford has advised that my truck is unsafe to drive until repaired. When I brought the vehicle in, I was told parts were available. I drove the car home and later discovered from paperwork that the repair was not completed only the parts had been ordered. I was told not to take the Truck on my upcoming vacation pulling my camper. I opened a case with Ford Customer Care and was originally told parts would arrive before my scheduled use, but now I am told they will not be available for weeks. This creates a serious safety and hardship issue. My family is scheduled to leave for a trip this Thursday that requires this vehicle to transport my family and tow our camper. Ford has not provided a rental or loaner vehicle capable of replacing my truck, despite advising it is unsafe to drive. I am requesting that NHTSA investigate Ford‚Äôs failure to provide a timely remedy or interim solution for a safety-critical recall that removes my vehicle from safe use.

2021 FORD F-150

ID: 2114608

WHEELS

I own a 2021 Ford F-150 [Lariat PowerBoost] affected by recall 23S65 (rear axle bolt). The bolts have severed. Ford has advised that my truck is unsafe to drive until repaired. When I brought the vehicle in, I was told parts were available. I drove the car home and later discovered from paperwork that the repair was not completed only the parts had been ordered. I was told not to take the Truck on my upcoming vacation pulling my camper. I opened a case with Ford Customer Care and was originally told parts would arrive before my scheduled use, but now I am told they will not be available for weeks. This creates a serious safety and hardship issue. My family is scheduled to leave for a trip this Thursday that requires this vehicle to transport my family and tow our camper. Ford has not provided a rental or loaner vehicle capable of replacing my truck, despite advising it is unsafe to drive. I am requesting that NHTSA investigate Ford‚Äôs failure to provide a timely remedy or interim solution for a safety-critical recall that removes my vehicle from safe use.

2021 FORD F-150

ID: 2113570

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated that while the vehicle was parked, there was fluid leaking from the front of the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the gasket on the rear differential had failed and needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic, where the vehicle was diagnosed that the driver‚Äôs and passenger‚Äôs side rear axle shaft assemblies had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 69,000.

2021 FORD F-150

ID: 2112746

VISIBILITY/WIPER

AC quits working while on the road. Air does not come out of the vents no matter how high the fan setting is. This is dangerous because it also applies to the defrost vents and becomes difficult to see out of the front windshield. Ford has issued a TSB (22-2089) so they are aware of the issue but no recall yet.

2021 FORD F-150

ID: 2112700

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F-150. The contact stated while driving approximately 45 MPH and ascending a hill, the vehicle stalled. The contact was able to restart the vehicle. There were no warning lights illuminated. The contact had taken the vehicle to a local dealer who was unable to diagnose the vehicle and the vehicle was not repaired. The vehicle experienced a similar failure, and the vehicle was taken to another dealer. The dealer was unable to diagnose the vehicle, and the vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The contact researched online and related the failure to NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline), however, the VIN was not included in the recall. The failure mileage was approximately 26,000.

2021 FORD F-150

ID: 2112681

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that there was a scraping sound coming from the rear of the vehicle. The dealer confirmed that the failure was related to the recall; however, parts were on back order. The failure mileage was 51,000. Parts distribution disconnect.

2021 FORD F-150

ID: 2112523

STEERING

When driving across railroad tracks, or at lower speeds primarily when turning sharp or into parking spaces, a power steering assist fault light flashes and steering becomes difficult unless truck is moving. The only remedy that I know is to put the truck in park, turn off, and restart. This corrects the issue until the criteria mentioned above is met and then it happens again, and again...... The vehicle has been taken to a repair shop where they recommended a new rack and pinion. They mentioned this is a very common issue with ford vehicles. This vehicle has 34k miles and has been well maintained. I'm very disappointed that it consistently has this issue and worry about the loss of steering at a higher rate of speed.

2021 FORD F-150

ID: 2112424

VISIBILITY/WIPER

Complaint Regarding Wiper Motor Recall ‚Äì 2021 Ford F-150 VIN [XXX] I am filing this complaint regarding a serious safety issue with my 2021 Ford F-150 (VIN [XXX] ). The wipers sometimes stop mid-sweep or malfunction during operation, creating a major hazard during rain and poor visibility. This appears to be related to Ford Recall 22S12, which addresses defective wiper motors on this vehicle model. I contacted a local Ford dealership and asked if this recall had been completed. They could not confirm it. Instead, they told me that the problem might have been caused by an oil change shop replacing the wiper blades ‚Äî and that I would be responsible for paying $200 for an inspection and up to $400 for repairs, even though the issue appears to be recall-related. Replacing wiper blades is routine maintenance and should not affect the motor‚Äôs function. I can find no technical data or public documentation that supports the dealership‚Äôs claim that improper blade installation causes a wiper motor to fail or stop mid-cycle. This sounds like an excuse to avoid honoring the recall. I am unsure whether the recall was ever completed on my truck. If it wasn‚Äôt, it needs to be done now. If it was, and the motor is still failing, that indicates a faulty or incomplete recall repair. Either way, Ford should not charge me for diagnosing or fixing a known recall-related defect. I am requesting: ‚Ä¢Written confirmation of whether Recall 22S12 was completed ‚Ä¢Immediate inspection and proper repair if the motor was not replaced ‚Ä¢Coverage under recall or warranty if the part remains defective I‚Äôm also reporting this to the Better Business Bureau to document what I believe is an unfair attempt to shift responsibility and costs for a known safety issue. Sincerely, [XXX] [XXX] [XXX] VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 FORD F-150

ID: 2112361

STRUCTURE

The contact owns a 2021 Ford F-150. The contact stated that the exhaust baffles were making an abnormal ticking sound while the vehicle was idling. The contact also stated that the A/C outlet vent tab had separated from the vehicle, and the other tabs were loose. Additionally, the contact stated that while accelerating from a complete stop, the vehicle hesitated while responding. The contact stated that the vehicle made an abnormal squealing sound while driving at various speeds and while idling. The vehicle was taken to the dealer, where it was diagnosed that the serpentine belt and one of the pulleys needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact the repairs could not be covered under the powertrain warranty. The failure mileage was approximately 48,000.

2021 FORD F-150

ID: 2112360

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

The contact owns a 2021 Ford F-150. The contact stated that the exhaust baffles were making an abnormal ticking sound while the vehicle was idling. The contact also stated that the A/C outlet vent tab had separated from the vehicle, and the other tabs were loose. Additionally, the contact stated that while accelerating from a complete stop, the vehicle hesitated while responding. The contact stated that the vehicle made an abnormal squealing sound while driving at various speeds and while idling. The vehicle was taken to the dealer, where it was diagnosed that the serpentine belt and one of the pulleys needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact the repairs could not be covered under the powertrain warranty. The failure mileage was approximately 48,000.

2021 FORD F-150

ID: 2112359

ENGINE

The contact owns a 2021 Ford F-150. The contact stated that the exhaust baffles were making an abnormal ticking sound while the vehicle was idling. The contact also stated that the A/C outlet vent tab had separated from the vehicle, and the other tabs were loose. Additionally, the contact stated that while accelerating from a complete stop, the vehicle hesitated while responding. The contact stated that the vehicle made an abnormal squealing sound while driving at various speeds and while idling. The vehicle was taken to the dealer, where it was diagnosed that the serpentine belt and one of the pulleys needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact the repairs could not be covered under the powertrain warranty. The failure mileage was approximately 48,000.

2021 FORD F-150

ID: 2112051

ENGINE

My f150 has 47k miles and it‚Äôs been serviced every time it was supposed to and the engine failed. Oil leaking into the engine destroyed it. I looked up 2021 F150 v8 coyote engine and it‚Äôs a known issue

2021 FORD F-150

ID: 2111812

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the infotainment center failed to function as intended. The contact stated that the infotainment center displayed a black screen. The contact stated that during one failure, the infotainment center screen displayed a black screen; however the radio continued to play. The contact stated that the vehicle was turned off. The vehicle was started, and the system independently reset. In addition, the contact stated that when the vehicle was started, the engine was idling roughly. The vehicle was taken to the dealer; however, the contact stated that the computer system was reprogrammed, but the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. In addition, the contact feared driving the vehicle with his family inside the vehicle due to the failure. The contact received notifications of NHTSA Campaign Numbers: 25V315000 (Back Over Prevention) and 25V455000 (Fuel system, Gasoline); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was 15,000. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2111811

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the infotainment center failed to function as intended. The contact stated that the infotainment center displayed a black screen. The contact stated that during one failure, the infotainment center screen displayed a black screen; however the radio continued to play. The contact stated that the vehicle was turned off. The vehicle was started, and the system independently reset. In addition, the contact stated that when the vehicle was started, the engine was idling roughly. The vehicle was taken to the dealer; however, the contact stated that the computer system was reprogrammed, but the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. In addition, the contact feared driving the vehicle with his family inside the vehicle due to the failure. The contact received notifications of NHTSA Campaign Numbers: 25V315000 (Back Over Prevention) and 25V455000 (Fuel system, Gasoline); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was 15,000. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2111435

FORWARD COLLISION AVOIDANCE: WARNINGS

Issue Date 2025-06-13 Campaign 25S65/25V404 Description On your vehicle, in the event of unexpected 12V battery discharge, the front door electronic latches retain their last lockunlock status. If the driver or front passenger exit the front doors using the mechanical inside release handles, the doors may remain locked when they are closed. This may result in an unexpected lock-out condition for the driver and front passenger without the ability to immediately re-enter the vehicle.

2021 FORD F-150

ID: 2111434

POWER TRAIN

Issue Date 2025-06-13 Campaign 25S65/25V404 Description On your vehicle, in the event of unexpected 12V battery discharge, the front door electronic latches retain their last lockunlock status. If the driver or front passenger exit the front doors using the mechanical inside release handles, the doors may remain locked when they are closed. This may result in an unexpected lock-out condition for the driver and front passenger without the ability to immediately re-enter the vehicle.

2021 FORD F-150

ID: 2111285

STEERING

Trucks steering randomly goes out mainly when backing up or right after backing up and start to move forward.

2021 FORD F-150

ID: 2111215

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Ford F150. The contact received notifications of NHTSA Campaign Numbers: 25V315000 (BACK OVER PREVENTION) and 25V455000 (FUEL SYSTEM, GASOLINE); however, the parts to do the recall repairs were not yet available. The contact stated that while her friend was driving, the rearview camera turned off while the vehicle was in reverse(R). The contact stated that the failure compromised the back-over prevention system. The contact stated that an unknown message about the brakes was displayed. The vehicle was not diagnosed or repaired. The contact stated that on a separate occasion, while her friend was driving 55 MPH, the vehicle vibrated abnormally, and failed to accelerate as intended while depressing the accelerator pedal. The contact stated that recently, the vehicle accelerated independently and then returned to normal functionality. There was no warning light illuminated. The vehicle was not diagnosed or repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts are not available.

2021 FORD F-150

ID: 2111214

BACK OVER PREVENTION

The contact owns a 2021 Ford F150. The contact received notifications of NHTSA Campaign Numbers: 25V315000 (BACK OVER PREVENTION) and 25V455000 (FUEL SYSTEM, GASOLINE); however, the parts to do the recall repairs were not yet available. The contact stated that while her friend was driving, the rearview camera turned off while the vehicle was in reverse(R). The contact stated that the failure compromised the back-over prevention system. The contact stated that an unknown message about the brakes was displayed. The vehicle was not diagnosed or repaired. The contact stated that on a separate occasion, while her friend was driving 55 MPH, the vehicle vibrated abnormally, and failed to accelerate as intended while depressing the accelerator pedal. The contact stated that recently, the vehicle accelerated independently and then returned to normal functionality. There was no warning light illuminated. The vehicle was not diagnosed or repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts are not available.

2021 FORD F-150

ID: 2111032

EXTERIOR LIGHTING:HEADLIGHTS

The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the contact was informed by another driver that the front headlights were not functioning as intended. The contact stated that when the vehicle was parked, the contact inspected the vehicle and confirmed that the front headlights were extremely dim. The vehicle was taken to the dealer where the vehicle was diagnosed with headlight assembly failures. The contact was informed that the headlight assemblies needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 95,000.

2021 FORD F-150

ID: 2110739

VEHICLE SPEED CONTROL

Drove it out to CA from Texas. Purchased for Planet Ford who told me the truck was k to drive and no axel problem. Drove it out to CA from Texas when we moved in late April - after that went to Santa Barbara and dashboard controls went dead. Speedometer and may other controls stopped working. Truck felt sluggish. Took it into Tuttle Click Ford Lincoln in Irvine and they said they real axel was about to fall off and took the truck away. They've had it for a month and said they may have it for another 2-4 week or longer.

2021 FORD F-150

ID: 2110738

WHEELS

Drove it out to CA from Texas. Purchased for Planet Ford who told me the truck was k to drive and no axel problem. Drove it out to CA from Texas when we moved in late April - after that went to Santa Barbara and dashboard controls went dead. Speedometer and may other controls stopped working. Truck felt sluggish. Took it into Tuttle Click Ford Lincoln in Irvine and they said they real axel was about to fall off and took the truck away. They've had it for a month and said they may have it for another 2-4 week or longer.

2021 FORD F-150

ID: 2110737

ELECTRICAL SYSTEM

Drove it out to CA from Texas. Purchased for Planet Ford who told me the truck was k to drive and no axel problem. Drove it out to CA from Texas when we moved in late April - after that went to Santa Barbara and dashboard controls went dead. Speedometer and may other controls stopped working. Truck felt sluggish. Took it into Tuttle Click Ford Lincoln in Irvine and they said they real axel was about to fall off and took the truck away. They've had it for a month and said they may have it for another 2-4 week or longer.

2021 FORD F-150

ID: 2110736

EQUIPMENT:ELECTRICAL:INFOTAINMENT

The contact owns a 2021 Ford F-150. The contact stated that while driving 45-50 MPH on the freeway, the navigation screen turned blank, and the speedometer decreased to zero. There was no warning light illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the rear end of the vehicle was detaching. The dealer determined that the vehicle was unsafe to drive. The vehicle was then taken to unknown local dealer, where it was determined that the rear axle was in good condition. The vehicle was not repaired. The manufacturer was notified of the failure and denied the contact's buyback request. The failure mileage was approximately 32,000.

2021 FORD F-150

ID: 2110735

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

The contact owns a 2021 Ford F-150. The contact stated that while driving 45-50 MPH on the freeway, the navigation screen turned blank, and the speedometer decreased to zero. There was no warning light illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the rear end of the vehicle was detaching. The dealer determined that the vehicle was unsafe to drive. The vehicle was then taken to unknown local dealer, where it was determined that the rear axle was in good condition. The vehicle was not repaired. The manufacturer was notified of the failure and denied the contact's buyback request. The failure mileage was approximately 32,000.

2021 FORD F-150

ID: 2110734

SUSPENSION

The contact owns a 2021 Ford F-150. The contact stated that while driving 45-50 MPH on the freeway, the navigation screen turned blank, and the speedometer decreased to zero. There was no warning light illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the rear end of the vehicle was detaching. The dealer determined that the vehicle was unsafe to drive. The vehicle was then taken to unknown local dealer, where it was determined that the rear axle was in good condition. The vehicle was not repaired. The manufacturer was notified of the failure and denied the contact's buyback request. The failure mileage was approximately 32,000.

2021 FORD F-150

ID: 2110558

EXTERIOR LIGHTING

1: HEADLIGHT : vertical sealed beam went out. 2: yes it sure ready for inspection. 3: reduced lighting in the front driver side at night. 4 : yes, was brought to the dealership. was told the whole headlight needs to be replaced in order to fix the issue. 5: only warning was the day before it was dim. the next day it was completely out. last week of May 2025.

2021 FORD F-150

ID: 2110078

ENGINE AND ENGINE COOLING

The contact owns a 2021 Ford F-150. The contact stated that while driving at various speeds, there was an abnormal knocking or ticking sound coming from the engine compartment. The contact stated that while depressing the accelerator pedal, the sound became louder. The contact stated there was no warning light illuminated. The contact had the vehicle towed to a local dealer. The dealer diagnosed the vehicle and determined that a connecting rod had failed, and the engine needed to be replaced. The vehicle was not repaired. The contact had not informed the manufacturer of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the recall only covered 2.7L and 3.0L Nano EcoBoost engines. The contact stated that the engine size of his was a 3.5L EcoBoost engine. The failure mileage was approximately 99,000.

2021 FORD F-150

ID: 2109533

POWER TRAIN:AUTOMATIC TRANSMISSION

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power, leaving the contact stuck in the middle of the roadway. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 127,000. The VIN was not available.

2021 FORD F-150

ID: 2109325

EXTERIOR LIGHTING

The passenger side daytime running light vertical led strip in the passenger side headlight assembly has quit working as of 7/11/2025. I noticed that there seemed to be a reduction in the lighting on the passenger side of my vehicle that night. When I checked my vehicle lighting, I noticed that the above mentioned part of the headlight assembly was not working. This seems to be an integral part of the headlight assembly and I cannot find any replaceable bulb or lighting strip. After searching online, this seems to be a common problem with this series of trucks. The only remedy seems to be replacement of the entire headlight assembly vs. simply replacing a bulb or led strip.

2021 FORD F-150

ID: 2108486

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000(Power Train); however, the part to do the repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

2021 FORD F-150

ID: 2108454

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V315000(Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that upon starting the vehicle and shifting to reverse(R), the rearview camera image was black. The contact stated that the rearview camera image was distorted while reversing recently. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 22,000. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2108282

POWER TRAIN

When I drive at highway speeds and going to slow down this transmission will sometimes shift very hard on down shift from 9th to 8th gear and it jolts the truck. Also sometimes when I am in town going from 4th to 5th gear it is delayed in 4th making the RPM go high then shifting hard into 5th. Getting out of 1st going into 2nd is sometimes clunky and sometimes it is not. All these issues are intermittent. I got this truck a few weeks ago. 35,500 miles on it. Got it because I needed something reliable for family needs and work. Im not rich either so of course I had to finance it 72 months. I feel like I bought myself a big headache and I drive this thing around like I am walking on egg shells and I feel like I ended up with something not reliable because of this 10R80 transmission. I baby it the best I can. I wont take it to the dealership because I know they wont do anything. Thank you for all that you guys do.

2021 FORD F-150

ID: 2108200

VEHICLE SPEED CONTROL

I was turning left from a side street onto a divided highway and stopped in the middle to wait for an opening in traffic. When one came I hit the gas and nothing happened. Pressed it again, to the floor and nothing happened. I then put the truck into reverse to back out of the way of traffic because the truck rolled forward a bit when I attempted to accelerate. I then waited for a very large opening and attempted to accelerate again. Pushed the pedal and again nothing. I then pressed it to the floor and held it there. The truck very slowly began to accelerate and then after about 20 seconds accelerated like normal. The truck seemed normal the rest of the way home.

2021 FORD F-150

ID: 2108199

FUEL/PROPULSION SYSTEM

I was turning left from a side street onto a divided highway and stopped in the middle to wait for an opening in traffic. When one came I hit the gas and nothing happened. Pressed it again, to the floor and nothing happened. I then put the truck into reverse to back out of the way of traffic because the truck rolled forward a bit when I attempted to accelerate. I then waited for a very large opening and attempted to accelerate again. Pushed the pedal and again nothing. I then pressed it to the floor and held it there. The truck very slowly began to accelerate and then after about 20 seconds accelerated like normal. The truck seemed normal the rest of the way home.

2021 FORD F-150

ID: 2108198

ENGINE

I was turning left from a side street onto a divided highway and stopped in the middle to wait for an opening in traffic. When one came I hit the gas and nothing happened. Pressed it again, to the floor and nothing happened. I then put the truck into reverse to back out of the way of traffic because the truck rolled forward a bit when I attempted to accelerate. I then waited for a very large opening and attempted to accelerate again. Pushed the pedal and again nothing. I then pressed it to the floor and held it there. The truck very slowly began to accelerate and then after about 20 seconds accelerated like normal. The truck seemed normal the rest of the way home.

2021 FORD F-150

ID: 2107951

SERVICE BRAKES

The contact owns a 2021 Ford F-150. The contact stated that while his father was driving 70 MPH, the driver's side rear brakes locked up. The ‚ÄúParking Brake Service Now‚Äù message was displayed. The driver was able to continue driving. The driver heard an abnormal beeping sound coming from the vehicle. The vehicle was taken to an independent mechanic who determined that the wiring harness had failed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was unknown. The VIN was not available.

2021 FORD F-150

ID: 2107769

STRUCTURE:BODY

The dash pad in front of steering wheel is coming apart and peeling back. It appears to a defect in installation, material use or wasn't glued down properly

2021 FORD F-150

ID: 2107709

STEERING

When starting the vehicle a message displayed stating "Power Steering Fault Service Required". I was able to shut off the vehicle and restart with no issue. Currently, restarting the vehicle no longer has any affect and the power steering is out completely. An appointment has been scheduled with Ford in two weeks. Unfortunately, this is my only means of transportation. I was at work when the power steering went out completely and had to drive home. On my drive home, the traction control tripped jerking the wheel and it felt like the whole vehicle jumped.

2021 FORD F-150

ID: 2107542

POWER TRAIN

My complaint is in regards to my truck not being repaired in a timely manner. My truck is over 4 years old and I still don‚Äôt have recall 23V896 completed. I called my dealer on June 10 to as per the recall letter to confirm they had the parts in stock. They said they were. I made an appointment for June 18 to get the recall completed. The service advisor then told me they had to send photos of my door sticker to Ford so they could order the parts that they told me 9 days prior that they had. They said it would take a couple of days. Here we are 20 more days later and no parts to perform the recall. This is totally Rediculous and unacceptable. My truck is into its 5th year. Does the NHTSA not have authority to enforce these recalls? I also got a letter about my rear camera freezing (25V315). It says there is no fix available, unbelievable!

2021 FORD F-150

ID: 2107483

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated while driving 25 MPH, while depressing the brake pedal and attempting to make a right turn, the power train or 4WD warning lights illuminated. The contact stated that the transmission was stuck in sixth gear; the contact was unsure of the high gear. The contact stated that the transmission unexpectedly shifted into a lower gear, skipped gears, and the vehicle surged forward. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed that the CDF cylinder had failed, and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified on the failure and transferred the contact to NHTSA Hotline to report the failure. The approximate failure mileage was 107,000.

2021 FORD F-150

ID: 2107438

FORWARD COLLISION AVOIDANCE: WARNINGS

A few months ago, my 2021 F150 started sending me repeating dashboard messages that there's a front camera fault and service is requested followed up with a message about how the pre-collision assist is not available. It's bad enough that this is a problem on a late model vehicle, but my real gripe is that the message repeats over and over non-stop, with a repeating chime to go along with it. It is a terrible distraction for a feature that I've never needed in a vehicle. I asked the Ford dealership about this issue, they said that it would be several thousand dollars to replace and calibrate. So now I'm stuck with a truck that chimes and flashes messages, over and over, every time I drive it. I can provide video evidence of the issue.

2021 FORD F-150

ID: 2107437

UNKNOWN OR OTHER

A few months ago, my 2021 F150 started sending me repeating dashboard messages that there's a front camera fault and service is requested followed up with a message about how the pre-collision assist is not available. It's bad enough that this is a problem on a late model vehicle, but my real gripe is that the message repeats over and over non-stop, with a repeating chime to go along with it. It is a terrible distraction for a feature that I've never needed in a vehicle. I asked the Ford dealership about this issue, they said that it would be several thousand dollars to replace and calibrate. So now I'm stuck with a truck that chimes and flashes messages, over and over, every time I drive it. I can provide video evidence of the issue.

2021 FORD F-150

ID: 2107290

UNKNOWN OR OTHER

Rear view camera and the 360 camera does not work at all on my 2021 Ford F-150 It says return to dealership for repair

2021 FORD F-150

ID: 2107082

ELECTRICAL SYSTEM

Black screen on main vehicle screen. Ford has a Customer Satisfaction Program (12M02) that extended the warranty coverage for the Accessory Protocol Interface Module (APIM), a key component of the SYNC system in certain Ford vehicles. This program covers the APIM for 5 years from the warranty start date, regardless of mileage, which is a longer coverage than the vehicle's original warranty provisions for this part. The coverage automatically transfers to subsequent owners. However, Ford is saying that I do not qualify and cannot define the qualification criteria. If some affected vehicles are eligible for repair under this CSP, then all affected vehicles should be.

2021 FORD F-150

ID: 2106823

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Numerous times my vehicle has suddenly came to a stop pit itself in park and turned off the engine while I was driving at a speed of 25 mph. Several times while cruise control was active my vehicle increased in speed and pressing the break didn't deactivate my cruise control I had to manually turn it off. My crash detection has gone off several times when there was nothing around my vehicle.

2021 FORD F-150

ID: 2106822

VEHICLE SPEED CONTROL

Numerous times my vehicle has suddenly came to a stop pit itself in park and turned off the engine while I was driving at a speed of 25 mph. Several times while cruise control was active my vehicle increased in speed and pressing the break didn't deactivate my cruise control I had to manually turn it off. My crash detection has gone off several times when there was nothing around my vehicle.

2021 FORD F-150

ID: 2106821

FORWARD COLLISION AVOIDANCE: WARNINGS

Numerous times my vehicle has suddenly came to a stop pit itself in park and turned off the engine while I was driving at a speed of 25 mph. Several times while cruise control was active my vehicle increased in speed and pressing the break didn't deactivate my cruise control I had to manually turn it off. My crash detection has gone off several times when there was nothing around my vehicle.

2021 FORD F-150

ID: 2106785

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact stated that the rearview camera displayed a distorted image while the vehicle was in reverse(R). In addition, the contact stated that while driving 25 MPH, the screen turned off, or a black or blue screen was displayed. The contact stated that the failure obstructed the driver's visibility, preventing the driver from safely operating the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 53,000.

2021 FORD F-150

ID: 2106696

UNKNOWN OR OTHER

What component or system failed or malfunctioned, and is it available for inspection upon request? -The electrical system malfunctioned causing a complete system failure and shutdown of the vehicle. The vehicle came to a sudden stop in an intersection and could not be moved. How was your safety or the safety of others put at risk? -The vehicle instantly died going through an intersection causing the steering column to lock up, the parking brake to engage and transmission to remain in drive while the vehicle was stopped without any power. This was a sudden and abrupt stop where all control over the vehicle was lost, and I came to an immediate stop in the middle of an intersection. The vehicle would not restart. I could not disengage the parking brake to move the vehicle out of the intersection due to the complete loss of power. The transmission would not shift into Neutral due to the complete loss of power. The hazard lights would not turn on due to the complete loss of power. If this happened on the interstate, I would have very likely been in a serious life threatening /taking accident. This is as big of a near miss that I can think of, and only because it happened on a neighborhood street when no other vehicles were approaching from in front or behind. This is a major safety issue. Has the problem been reproduced or confirmed by a dealer or independent service center? -The vehicle is currently at the dealer for a diagnostic review. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -in process at the ford dealership Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -the vehicle had been running for 30-45 minutes prior to this happening without any warning lights / symptoms.

2021 FORD F-150

ID: 2106695

POWER TRAIN

What component or system failed or malfunctioned, and is it available for inspection upon request? -The electrical system malfunctioned causing a complete system failure and shutdown of the vehicle. The vehicle came to a sudden stop in an intersection and could not be moved. How was your safety or the safety of others put at risk? -The vehicle instantly died going through an intersection causing the steering column to lock up, the parking brake to engage and transmission to remain in drive while the vehicle was stopped without any power. This was a sudden and abrupt stop where all control over the vehicle was lost, and I came to an immediate stop in the middle of an intersection. The vehicle would not restart. I could not disengage the parking brake to move the vehicle out of the intersection due to the complete loss of power. The transmission would not shift into Neutral due to the complete loss of power. The hazard lights would not turn on due to the complete loss of power. If this happened on the interstate, I would have very likely been in a serious life threatening /taking accident. This is as big of a near miss that I can think of, and only because it happened on a neighborhood street when no other vehicles were approaching from in front or behind. This is a major safety issue. Has the problem been reproduced or confirmed by a dealer or independent service center? -The vehicle is currently at the dealer for a diagnostic review. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -in process at the ford dealership Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -the vehicle had been running for 30-45 minutes prior to this happening without any warning lights / symptoms.

2021 FORD F-150

ID: 2106694

ELECTRICAL SYSTEM

What component or system failed or malfunctioned, and is it available for inspection upon request? -The electrical system malfunctioned causing a complete system failure and shutdown of the vehicle. The vehicle came to a sudden stop in an intersection and could not be moved. How was your safety or the safety of others put at risk? -The vehicle instantly died going through an intersection causing the steering column to lock up, the parking brake to engage and transmission to remain in drive while the vehicle was stopped without any power. This was a sudden and abrupt stop where all control over the vehicle was lost, and I came to an immediate stop in the middle of an intersection. The vehicle would not restart. I could not disengage the parking brake to move the vehicle out of the intersection due to the complete loss of power. The transmission would not shift into Neutral due to the complete loss of power. The hazard lights would not turn on due to the complete loss of power. If this happened on the interstate, I would have very likely been in a serious life threatening /taking accident. This is as big of a near miss that I can think of, and only because it happened on a neighborhood street when no other vehicles were approaching from in front or behind. This is a major safety issue. Has the problem been reproduced or confirmed by a dealer or independent service center? -The vehicle is currently at the dealer for a diagnostic review. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -in process at the ford dealership Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -the vehicle had been running for 30-45 minutes prior to this happening without any warning lights / symptoms.

2021 FORD F-150

ID: 2106040

BACK OVER PREVENTION

The contact called on behalf of the owner of a 2016 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V315000 (BACK OVER PREVENTION). However, the part to do the recall repair was not yet available. The contact was the caller's son. The contact's mother stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact's mother stated that the failure had obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. Due to the failure, the contact stated that her son had been involved in a low-speed, parking lot accident. Unknown if any warning lights were illuminated. The contact stated that her son suffered from minor back pain. The contact's son has been going to a chiropractor. A police report was filed. Unknown if the vehicle was taken to a dealer or an independent mechanic. The vehicle was not repaired. Unknown if the failure persisted. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

Crash 1 Injured

2021 FORD F-150

ID: 2105946

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact stated that while reversing into their driveway, the back over prevention display rear view camera was frozen, no warning lights were illuminated, and in the process, the contact crashed into the corner of their house with the rear passenger tail light. The image displayed 20 feet away in distance, however the house was closer than the image display. Property damage was not reported. The vehicle came to a stop upon impact. The air bags did not deploy. The vehicle was going less than 5 MPH at the time of the crash. The vehicle did not need to be towed. No warning lights were illuminated. A police report was not filed. The vehicle was not destroyed. No injuries were reported. The vehicle was taken to a local dealer where the vehicle was inspected however, it was not diagnosed, and the vehicle was not repaired. The contact referenced NHTSA Campaign Number : 25V315000 (BACK OVER PREVENTION) as probable cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.

Crash

2021 FORD F-150

ID: 2104072

ENGINE

My engine failed. They recalled this engine but mine wasn't recalled. My engine did the same thing as the recalled engine did. Excessive oil consumption. When I first took it to Ford dealership it was under 60K. I have had problems with my truck since Easter have taken it to them a few times. The problem was never fixed and now Ford will only cover 4,950. The engine is 12k. I feel since the engine in my truck was a recall on alot of engines. Mine should be covered under recall or warranty up to 60,000 miles. I have nothing but problems since I bought the truck. I started taking the truck to have it looked at since March to other places they couldn't help me so they told me to take it to the dealership. They keep fixing something on the truck but never the part that was broken. They told me it would be ok to drive it and so now I am over the mileage for my warranty. I don't think I should have to pay to replace my engine when it only has 61K miles on it. so they told me to drive it and then it started knocking and the engine failed. The service manger told me it was a failed bearing. certanily no lack of maintenance so why am I stuck paying for this when it wasn't my fault. they found some damge on one of the rod bearings on the bottom. 2021 Ford F-150 V8 that engine had a recall on it. Not sure why mine wasn't recalled. Can you please help me. My truck is at Larry H Miller Ford in Draper Utah. It has been there for 5 weeks this time. Still no engine in it.

2021 FORD F-150

ID: 2103826

POWER TRAIN

Headlight DRL went out causing less visibility: Transmission is always losing slamming into gears and searching.

2021 FORD F-150

ID: 2103825

EXTERIOR LIGHTING

Headlight DRL went out causing less visibility: Transmission is always losing slamming into gears and searching.

2021 FORD F-150

ID: 2103464

ENGINE

The contact owns a 2021 Ford F-150. The contact became aware of oil underneath the vehicle. The contact stated that after turning off the vehicle, the steering wheel failed to lock as designed. The vehicle was taken to a mechanic for an oil change, and it was determined that there was an oil leak; however, the mechanic was unsure where the oil was located. The vehicle was taken to the dealer, who was unable to determine the cause of failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 60,600.

2021 FORD F-150

ID: 2103454

SERVICE BRAKES, HYDRAULIC

The contact owns a 2021 Ford F-150. The contact stated while driving 65 MPH, the brake pedal became significantly hard to depress. There was no warning light illuminated. The contact was able to stop the vehicle by depressing the brake pedal with added force. The contact stated that the failure recurred while driving. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 40,000.

2021 FORD F-150

ID: 2102911

SERVICE BRAKES

Brake trailer module failure leading to loss of trailer brakes. Second incident.

2021 FORD F-150

ID: 2102749

WHEELS

The rear axle hub bolt on my 2021 Ford F-150 PowerBoost failed to meet design safety standards and is subject to Recall 23S65. The vehicle is currently at a Ford dealership and is available for inspection upon request. My safety was put at risk because the bolt can shear off without warning, causing the rear axle shaft to disengage. This can result in sudden loss of propulsion or vehicle rollaway, especially if parked on an incline. Ford has acknowledged this risk but has not made a final repair available for PowerBoost models. I was not offered a loaner, and I cannot confirm if the vehicle is safe to drive. The problem has been confirmed by the dealership. They told me they are unable to perform even the interim repair until at least July 22 and that there is no ETA at all for the final fix specific to hybrid (PowerBoost) models. The vehicle was inspected by a Ford dealer but not by Ford Motor Company representatives directly. Ford customer service has failed to provide any meaningful support or confirmation of safety. There were no warning lamps or messages prior to the recall. Ford states the failure may occur without symptoms, which makes the defect more dangerous. I have not personally experienced a failure yet, but I'm being asked to either drive the vehicle in this condition or go without transportation indefinitely.

2021 FORD F-150

ID: 2102748

UNKNOWN OR OTHER

The rear axle hub bolt on my 2021 Ford F-150 PowerBoost failed to meet design safety standards and is subject to Recall 23S65. The vehicle is currently at a Ford dealership and is available for inspection upon request. My safety was put at risk because the bolt can shear off without warning, causing the rear axle shaft to disengage. This can result in sudden loss of propulsion or vehicle rollaway, especially if parked on an incline. Ford has acknowledged this risk but has not made a final repair available for PowerBoost models. I was not offered a loaner, and I cannot confirm if the vehicle is safe to drive. The problem has been confirmed by the dealership. They told me they are unable to perform even the interim repair until at least July 22 and that there is no ETA at all for the final fix specific to hybrid (PowerBoost) models. The vehicle was inspected by a Ford dealer but not by Ford Motor Company representatives directly. Ford customer service has failed to provide any meaningful support or confirmation of safety. There were no warning lamps or messages prior to the recall. Ford states the failure may occur without symptoms, which makes the defect more dangerous. I have not personally experienced a failure yet, but I'm being asked to either drive the vehicle in this condition or go without transportation indefinitely.

2021 FORD F-150

ID: 2102747

POWER TRAIN

The rear axle hub bolt on my 2021 Ford F-150 PowerBoost failed to meet design safety standards and is subject to Recall 23S65. The vehicle is currently at a Ford dealership and is available for inspection upon request. My safety was put at risk because the bolt can shear off without warning, causing the rear axle shaft to disengage. This can result in sudden loss of propulsion or vehicle rollaway, especially if parked on an incline. Ford has acknowledged this risk but has not made a final repair available for PowerBoost models. I was not offered a loaner, and I cannot confirm if the vehicle is safe to drive. The problem has been confirmed by the dealership. They told me they are unable to perform even the interim repair until at least July 22 and that there is no ETA at all for the final fix specific to hybrid (PowerBoost) models. The vehicle was inspected by a Ford dealer but not by Ford Motor Company representatives directly. Ford customer service has failed to provide any meaningful support or confirmation of safety. There were no warning lamps or messages prior to the recall. Ford states the failure may occur without symptoms, which makes the defect more dangerous. I have not personally experienced a failure yet, but I'm being asked to either drive the vehicle in this condition or go without transportation indefinitely.

2021 FORD F-150

ID: 2101392

EXTERIOR LIGHTING

Vertical headlight seems to have burned out on both sides after reading online and couple forms. It seems to be a common issue and Ford should be held accountable.

2021 FORD F-150

ID: 2101247

VEHICLE SPEED CONTROL

My gear shifter was sticking, making hard to shift gears. I had to pay $1100. 00 dollars to get it fixed. The truck has only 37,000 miles. This seems like a defect not a random component gone bad.

2021 FORD F-150

ID: 2101246

UNKNOWN OR OTHER

My gear shifter was sticking, making hard to shift gears. I had to pay $1100. 00 dollars to get it fixed. The truck has only 37,000 miles. This seems like a defect not a random component gone bad.

2021 FORD F-150

ID: 2100987

UNKNOWN OR OTHER

My transmission has failed and is slipping it's jolting and has cling sound. The rpms indicator fluctuates. Sometimes stays on 10 speed.

2021 FORD F-150

ID: 2100986

POWER TRAIN

My transmission has failed and is slipping it's jolting and has cling sound. The rpms indicator fluctuates. Sometimes stays on 10 speed.

2021 FORD F-150

ID: 2100182

POWER TRAIN

When driving the vehicle there is a hard shift condition from 2-3 3-4 4-5 and 6-5. This condition worsened to where the vehicle we entering an intersection in a 4 lane road and when shifting into 3rd the transmission would not engage. It then shifted to 4th then 5th still not engaging. The rpm increased and truck was out of fear in the intersection then engaged in 2nd while rolling at roughly 30mph in a 10r80. Tires sheared traction for a moment as it dropped to a gear lower than the speed it was going. Hard shifting was followed by a Malfunction indicator light (MIL). Truck was shut off then restarted and MIL was no longer present but hard shifting continued then the above incident. Truck was taken to dealer for confirmation. Mileage 61,159.

2021 FORD F-150

ID: 2100076

UNKNOWN OR OTHER

The side rails that come out when door is opened to assist with getting inside the truck does not work properly. It has come out and will not go back in. The door is closed and I have to drive the truck with the rails hanging down. That is a hazard.

2021 FORD F-150

ID: 2100075

STRUCTURE:BODY

The side rails that come out when door is opened to assist with getting inside the truck does not work properly. It has come out and will not go back in. The door is closed and I have to drive the truck with the rails hanging down. That is a hazard.

2021 FORD F-150

ID: 2100007

PARKING BRAKE

The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 21V653000 (SEAT BELTS), 23V509000 (PARKING BRAKE), 22V142000 (VISIBILITY) and 23V163000 (VISIBILITY). The contact stated that while driving 60 MPH, the parking brake independently activated. The contact pulled over to the side of the road. The contact turned off the vehicle and, after waiting for a short while, the vehicle was restarted. The message "Service Parking Brake" was displayed. The contact stated that on a separate occasion, while turning off the vehicle, the parking brake fail to function as intended. The contact stated that recently the seat belt failed to retract and remained loose. The vehicle was taken to the dealer; however, the dealer refused to repair the vehicle under the Seat Belts and Parking Brake recalls. The contact stated that the recall repairs for Visibility were performed. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000. Parts distribution disconnect.

2021 FORD F-150

ID: 2100006

SEAT BELTS

The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 21V653000 (SEAT BELTS), 23V509000 (PARKING BRAKE), 22V142000 (VISIBILITY) and 23V163000 (VISIBILITY). The contact stated that while driving 60 MPH, the parking brake independently activated. The contact pulled over to the side of the road. The contact turned off the vehicle and, after waiting for a short while, the vehicle was restarted. The message "Service Parking Brake" was displayed. The contact stated that on a separate occasion, while turning off the vehicle, the parking brake fail to function as intended. The contact stated that recently the seat belt failed to retract and remained loose. The vehicle was taken to the dealer; however, the dealer refused to repair the vehicle under the Seat Belts and Parking Brake recalls. The contact stated that the recall repairs for Visibility were performed. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000. Parts distribution disconnect.

2021 FORD F-150

ID: 2099910

ENGINE

Vehicle is consuming excessive amounts of motor oil, requiring the addition of 1-2 quarts every 1,200-1,500 miles. Check engine light has illuminated once when engine was five quarts low, this was when I realized the problem. Ford has attempted to correct with TECHNICAL SERVICE BULLETIN 19-2365, (5.0L - Excessive Oil Consumption) which I had performed on my vehicle and it did nothing to correct the issue. My greatest concerns are with premature parts failure and unexpected engine failure. I have written letters to Ford regarding this issue and have not received any response to date. I do have records of additional oil added since first realizing the issue existed.

2021 FORD F-150

ID: 2099553

POWER TRAIN

Transmission failure Transmission slips between 4th and 7th gears Yes its available for inspection Yes its been diagnosed by FORD No there were no warning lamps or messages, just noticed the shifting problem and took it in.

2021 FORD F-150

ID: 2099437

ENGINE

My truck falls in the recall for the valve failures and they finally have parts to do the test but there is tons of documents and articles saying Ford agreed with NHTSA to provide a 10 year 150k warranty to people who fall in this recall. per you guys investigation EA23007 under 24N12. When I talked to Ford and the dealer they say that's not a number. Just on principle this is crazy. I bought my truck thinking well atleast Ford is taking care of people on this. After reading the states summary saying Ford would provide that.

2021 FORD F-150

ID: 2098240

ELECTRICAL SYSTEM

Related to TECHNICAL SERVICE BULLETIN Various Gear Shift Module Concerns 25-2045 I experienced an issue where my truck was stuck in drive and the engine off. The truck could not be turned on if it wasn't in park, but couldn't be shifted unless it was on. This appears to be a very common issue as I made a post on Reddit [XXX] ) and many other users noted the same issue (low milage, relatively new tucks) with the same fix - a tow to a ford dealer and a $1000+ replacement of the shift module. The service manager told me it was "a common issue". It should be categorically impossible for a $70k+ tuck with less than 40K miles to be unable to shift gears due to faulty computer components. Ford didn't consider this issue under warrantee. Ford should have this module recalled - it is unfair for consumers to foot the bill to replace what should be a life time/never fail component. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 FORD F-150

ID: 2097978

SERVICE BRAKES

The same brake booster that allegedly only had 51 vehicles included in it? Same exact issue as this link: [XXX] not working seems like a pretty big safety issue. DTC Code: C0594 Brake Booster Motor "A" Performance DTC Code: C0594 Right rear solenoid circuit INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 FORD F-150

ID: 2097344

POWER TRAIN

The contact owns a 2012 Ford F-150. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the contact stated that the transmission shifted hard, and the vehicle jerked while moving forward. The contact stated the vehicle jerked extremely hard and the contact's head jerked forward. The dealer was made aware of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 62,000.

2021 FORD F-150

ID: 2097148

ENGINE AND ENGINE COOLING

The contact owns a 2021 Ford F-150. The contact stated that while driving approximately 60-65 MPH, there was fluid leaking from the vehicle, and the engine was overheating. There were no warning lights illuminated. The contact checked the Ford Pass App and became aware that the transmission had been serviced four times. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.

2021 FORD F-150

ID: 2097147

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated that while driving approximately 60-65 MPH, there was fluid leaking from the vehicle, and the engine was overheating. There were no warning lights illuminated. The contact checked the Ford Pass App and became aware that the transmission had been serviced four times. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.

2021 FORD F-150

ID: 2096848

POWER TRAIN

The Ford 10R80 transmission in my 2021 F-150 removes all confidence in the dependability of this truck. The transmission will slip and not engage for about 3-5 seconds and then lurch forward after finally finding the gear. This happened multiple times now and the 2 most dangerous were while taking an unprotected, but authorized left turn on a busy highway. Vehicles in the opposing lane had to slow down because as I started to turn, the truck hardly moved as I hit the accelerator. The gear finally engaged and I was able to get out of the way before being hit. Many technicians have told me this is almost certainly due to the widely known faulty CDF drum on 2021-2022 F-150's. Ford has since revised the CDF drum, but anyone who owns a 2021-2022 will have to pay out of pocket after this part inevitably fails and causes catastrophic damage. This is a VERY dangerous and serious fault with an essential part of the vehicle. Ford needs to address this issue as soon as possible.

2021 FORD F-150

ID: 2096744

UNKNOWN OR OTHER

Since my truck was brand new, the infotainment screen very often blacks out so that I can not see navigation, back up camera, radio, etc. It keeps resetting itself until it comes back on. A couple of times when I brought it in for service I asked them to check it out and it was always "Seems to be working fine". Today I backed into a sign as the back up camera was frozen and I did not notice that it was not real time. After I hit the sign, the screen went black and then the Ford insigna came up and it repeated 3 times and then everything was fine. Ford service has never been able to fix it as the don't see it when they start the vehicle. I will start taking videos with my phone. Anyway now that the extended warranty just ran out, it is getting worse where it happens almost all the time. I talked to some friends and they tell me they have the same issue so you need to be aware that this dangerous situation might be a common problem.

2021 FORD F-150

ID: 2096563

FORWARD COLLISION AVOIDANCE: WARNINGS

While stopped at a traffic light or in an intersection preparing to make a turn, the vehicle‚Äôs engine will randomly shut off. Simultaneously, a pre-collision warning appears on the display. This causes the vehicle to become temporarily disabled, even as oncoming traffic approaches. To recover, the driver must shift the vehicle into park, restart the engine, and quickly accelerate out of the way to avoid a potential collision.

2021 FORD F-150

ID: 2096562

ENGINE

While stopped at a traffic light or in an intersection preparing to make a turn, the vehicle‚Äôs engine will randomly shut off. Simultaneously, a pre-collision warning appears on the display. This causes the vehicle to become temporarily disabled, even as oncoming traffic approaches. To recover, the driver must shift the vehicle into park, restart the engine, and quickly accelerate out of the way to avoid a potential collision.

2021 FORD F-150

ID: 2096248

ENGINE AND ENGINE COOLING

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2095652

UNKNOWN OR OTHER

The step bar that come out whenever a door opens ro assist with getting inside the truck does not come out everytime. Sometime the bar will come down once door is open and remain down when the door closes. The bar is supposed to go ba k in once the door is closed. This happens several times in a week.

2021 FORD F-150

ID: 2095623

POWER TRAIN

Ford's 10 Speed Transmissions (10R80) built before 2022 have a common CDF Drum design defect that will cause hard shifts, gear searching, failure to shift, and lagging shifts. On two occasion my truck was unable to find the gear while shifting and lost acceleration. There was no indications (warning lights or messages) that the vehicle wasn't operating normally. It simply just was unable to move under its own power for 2-3 seconds before the transmission found the next gear and began accelerating. Both instances created a hazard for myself and others as other drivers were forced to take evasive actions due to the sudden onset of the issue. Both instances were while making an authorized but unprotected left-hand turn. Had the other drivers in each of these instances not taken evasive action I would have been T-boned by them. This common failure put both myself and other drivers at risk. My local Ford dealer has troubleshot the issue and stated they believe it is the CDF Drum and recommended a complete transmission replacement. This issue is so common, that Ford issued a Technical Service Bulletin implementing a redesigned CDF Drum. That being said, Ford has left owners of pre-2022 vehicles like mine with an unsafe component and have taken no ownership of their design flaw.

2021 FORD F-150

ID: 2095274

ELECTRICAL SYSTEM

In December 2024, I brought my vehicle to my local Ford service center to address an infotainment/display screen issue. My display screen went completely black giving me no access to basic vehicle functions like radio controls, climate, and most importantly, cameras. Since this time, my vehicle has been back for service on 4 separate occasions without any success. The longest service visit being 2-months while "Ford Engineering investigated the issue". During this time, they ran diagnostics, replaced the infotainment screen, and finally the APIM unit but to no avail. Ford assured me that this was an isolated issue and the first of it's kind. I am scheduled to go back to my service center on June 3rd to have "tokens" installed on my vehicle. This will allow Ford's Engineering team to recreate the issue on their end. Today I read that Ford opened a recall for 1.1m vehicles for display/camera software issues. Although I feel like I've been gaslit by Ford for +6 months, I'm happy to hear I'm not the only one that's been living through this ordeal.

2021 FORD F-150

ID: 2095118

UNKNOWN OR OTHER

I was driving my 62000 miles truck on the highway while trying to pass another car which was driving slower, I was at a speed close to 60mph, the engine ran at 5000 and I lost power, a truck just behind me has to swerve to avoid me. No warning lamp was on. No accident occurred hopefully. Went to the dealership and they said that the issue was caused by a defective transmission. Ford had denied to pay for the repair or replacement as the warranty is a only covering the first 60000 miles.

2021 FORD F-150

ID: 2094693

ENGINE

Received safety recall October 2024 stating vehicle may crash - have not received any further notice about repairs

2021 FORD F-150

ID: 2094530

ENGINE AND ENGINE COOLING

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2094509

PARKING BRAKE

The contact owns a 2021 Ford F-150. The contact stated that occasionally while driving at various speeds, the parking brake was independently activated. The brake warning light was illuminated. Several local dealers were contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 55,100.

2021 FORD F-150

ID: 2094474

STEERING

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the steering wheel became stiff and hesitated while turning to the left or the right. The steering assist, traction control, and collision assist warning lights were illuminated. The vehicle was taken to a local dealer where the battery was replaced; however, the failure persisted. The vehicle was not repaired and needed to be towed back to the local dealer for further investigation. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 21V407000 (Steering); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 91,000.

2021 FORD F-150

ID: 2094302

STRUCTURE:BODY

The saggy diaper is a hazard and major manufacturer defect that must be corrected ASAP. It needs to be metal period the end. The paper like cover bolted on the undercarriage is an awful engineering hazard. I have changed this item four times. The dealerships well established pattern of services for this issue and Google searches speak for themselves. I don‚Äôt know why Ford refuses to address this concern and blow me off.

2021 FORD F-150

ID: 2094145

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated that while driving at various speeds, the vehicle jerked abnormally, and the transmission was slipping into park, causing the vehicle to come to an unintended, immediate stop. There were several messages displayed on the instrument panel, and the ‚ÄúService Vehicle Soon‚Äù warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was informed that the gear shift module was faulty and would need to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 22V188000 (POWER TRAIN) as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 21,500.

2021 FORD F-150

ID: 2093586

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated that while her son was driving at an undisclosed speed, the vehicle hesitated and jerked. The driver depressed the accelerator pedal, but the vehicle failed to respond and lost motive power. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.

2021 FORD F-150

ID: 2092869

STEERING

Steering assist, faults and adaptive steering not available lights up. Power steering goes away. Program update with dealer did not solve the problem. Looks like it‚Äôs a faulty gear.

2021 FORD F-150

ID: 2091788

ENGINE

This safety recall was issued in August of 2024 on an engine valve, this is the only vehicle I have. The engine valve has the potential to crack increasing my risk of crashing, I have a 3 year old. I called Tomball Ford last year in November and was informed they would have the parts by January 2025. It is now May 2025 and no parts or correspondence for the dangerous matter. In fact another recall has been issued

2021 FORD F-150

ID: 2091747

ENGINE

The engine can fail at any time. The truck has not been fixed in a timely manor. I pull trailer with livestock. I need to declare the lemon law on this vehicle to get one that is reliable.

2021 FORD F-150

ID: 2091717

EXTERIOR LIGHTING

The headlight module failed in the middle of driving at night and caused me to pull over and get the vehicle towed. Took to the dealership and apparently it‚Äôs been an issue with these trucks and the headlight module fails and then burns out both headlights. There is no recall and is not covered by my factory warranty.

2021 FORD F-150

ID: 2091551

UNKNOWN OR OTHER

I drove approx 50 miles. Parked, Return to truck approx 45 mins later and the battery was DEAD. No turn over at all.Called AAA purchased new battery which was installed roadside in a parking lot. Upon starting the engine I noticed the ac was not blowing and hot air only if it did. I took vehicle to Mac Maik Ford. I was told the ac was in need of new parts and $FREON$ ? The repair was approx $4500.00 then add freon fee. I declined. Returned to Gullo Ford where I purchased truck and I was told it would take up to a week or more to leave it for just evaluation. They offered a rental vehicle for $65/ day .i was not going to pay$800 In rental fees to wait for an evaluation not even repair?! I returned home in the hot truck and stopped by the private garage in neighborhood.RUSTYS.They kept it half a day&said upon investigation numerous complaints were filed for the same situation.Rusty stated he would order the part and be completed in abt 3-4 days max>.OK, order parts. I get in the truck after the small independent garage guys went over it in 1/2 a day & THE AC WAS WORKING.I again refused to leave it at Rustys garage. He said he would order the part because site stated numerous ppl had the same thing I had had.battery dying and a/c malfunction combo. IF I HAD NOT BEEN INFORMED OF THE RECALL POTENTIAL OF THE TYPE OF REOCCURRING INCIDENT ON VEHICLES LIKE MINE I WOULD HAVE BEEN RIPPED OFF FOR THOUSANDS!! Rusty ordered the part but kept part b/c my ac is good but tapping the battery? 3 days after his diagnosis being different from the dealers my a/c is still witking..However, The potential remains high for ac failure at this point to reoccur.There is obviously a malfunction in the a/c that kills the battery. I AM NOT THE ONLY PERSON WITH THIS ISSUE. This warrants a recall on whatever it is that drains the battery and kills the a/c function and lets the dealers profit! Please address & recall. Bust the dealers who want THOUSANDS TO FIX THIS TOO! Recall the ripoff...

2021 FORD F-150

ID: 2091550

ELECTRICAL SYSTEM

I drove approx 50 miles. Parked, Return to truck approx 45 mins later and the battery was DEAD. No turn over at all.Called AAA purchased new battery which was installed roadside in a parking lot. Upon starting the engine I noticed the ac was not blowing and hot air only if it did. I took vehicle to Mac Maik Ford. I was told the ac was in need of new parts and $FREON$ ? The repair was approx $4500.00 then add freon fee. I declined. Returned to Gullo Ford where I purchased truck and I was told it would take up to a week or more to leave it for just evaluation. They offered a rental vehicle for $65/ day .i was not going to pay$800 In rental fees to wait for an evaluation not even repair?! I returned home in the hot truck and stopped by the private garage in neighborhood.RUSTYS.They kept it half a day&said upon investigation numerous complaints were filed for the same situation.Rusty stated he would order the part and be completed in abt 3-4 days max>.OK, order parts. I get in the truck after the small independent garage guys went over it in 1/2 a day & THE AC WAS WORKING.I again refused to leave it at Rustys garage. He said he would order the part because site stated numerous ppl had the same thing I had had.battery dying and a/c malfunction combo. IF I HAD NOT BEEN INFORMED OF THE RECALL POTENTIAL OF THE TYPE OF REOCCURRING INCIDENT ON VEHICLES LIKE MINE I WOULD HAVE BEEN RIPPED OFF FOR THOUSANDS!! Rusty ordered the part but kept part b/c my ac is good but tapping the battery? 3 days after his diagnosis being different from the dealers my a/c is still witking..However, The potential remains high for ac failure at this point to reoccur.There is obviously a malfunction in the a/c that kills the battery. I AM NOT THE ONLY PERSON WITH THIS ISSUE. This warrants a recall on whatever it is that drains the battery and kills the a/c function and lets the dealers profit! Please address & recall. Bust the dealers who want THOUSANDS TO FIX THIS TOO! Recall the ripoff...

2021 FORD F-150

ID: 2091142

VISIBILITY

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed in a rainstorm, the windshield wipers suddenly stopped functioning. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V163000 (Visibility), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 39,000.

2021 FORD F-150

ID: 2091072

STRUCTURE:BODY

What component or system failed or malfunctioned, and is it available for inspection upon request? The exterior door handles and latching mechanism failed due to freezing in cold weather. When temperatures drop, the door handles become stuck or the latch mechanism fails to engage or disengage properly. This issue is reproducible during cold weather and the affected components are available for inspection upon request. How was your safety or the safety of others put at risk? The malfunction poses a safety risk in multiple ways. The doors may not close securely, which could result in a door opening while driving. Conversely, frozen latches can prevent doors from opening, which is a serious concern in the event of an emergency where rapid exit from the vehicle is required. This could endanger both the driver and passengers. Has the problem been reproduced or confirmed by a dealer or independent service center? The issue has not yet been confirmed by a dealer, but it is a widely documented problem among 2021 Ford F-150 owners, and it occurs consistently during cold weather conditions. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No formal inspection by the manufacturer, police, or insurance representatives has been conducted to date. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or dashboard messages. The issue was first noticed during freezing temperatures in the winter season. The symptoms are physical‚Äîfrozen or stuck handles and malfunctioning door latches.

2021 FORD F-150

ID: 2090731

ENGINE

Harsh shifting, abrupt or hard shifts. Hesitation and delays when accelerating feels unsafe, especially at highway speeds. This is an ongoing issue and has been going on for quite some time. Cannot pinpoint a specific date.

2021 FORD F-150

ID: 2090381

ELECTRICAL SYSTEM

Rearview camera does black out sometimes takes 10 minutes to load any info including radio and camera. Radio and camera tries to reload but usually takes 5 minutes for the screen to load up. Causing no rearview camera visibility

2021 FORD F-150

ID: 2090167

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated that occasionally while attempting to accelerate from a stop, the vehicle started to jerk, and the contact stated that the transmission was slipping. There were no warning lights were illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the gears were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 74,200.

2021 FORD F-150

ID: 2089812

ELECTRICAL SYSTEM

The contact owns a 2021 Ford F-150. The contact stated that upon taking the vehicle for the State Inspection, the contact was informed that the computer failed to communicate with the State Inspection testing equipment. Due to the issue, the vehicle failed the State Inspection. There were no warning lights illuminated. The vehicle was taken to the dealer, who determined that a software update was required. The vehicle was not repaired. After investigating the failure, the contact related the failure to SSM: 51411. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 77,000.

2021 FORD F-150

ID: 2088696

EXTERIOR LIGHTING

Part DG9Z13A018E (Ambient Light Sensor) fails to properly read Daylight during warm months. Inverted value (reading of VERY DARK) persists for at least 10 minutes. Appears to be temperature dependent; meaning, the temperature of the sensor/dash/housing is very hot and skewing the reading. Instrument panel dim. 12" screen dim. Reverse image (parking assist) dim as 12" screen is dim. When occurs, can be disabled by turning auto-headlights to OFF position. When cycled back to AUTOMATIC, condition reasserts and dims both the cluster and screen. Issue has been verified at dealership since 2023. Cannot replicate issue when stored indoors, raining, overcast, cold, etc. Requires full sun and warm day. Vehicle cannot be spared for additional diagnostics without rental/loaner provision. Will ask to attempt to replicate during upcoming recall maintenance and other TSB/SSM diagnostics to correct lingering OTA update/software issues that cause low state of charge conditions.

2021 FORD F-150

ID: 2088695

ELECTRICAL SYSTEM

Part DG9Z13A018E (Ambient Light Sensor) fails to properly read Daylight during warm months. Inverted value (reading of VERY DARK) persists for at least 10 minutes. Appears to be temperature dependent; meaning, the temperature of the sensor/dash/housing is very hot and skewing the reading. Instrument panel dim. 12" screen dim. Reverse image (parking assist) dim as 12" screen is dim. When occurs, can be disabled by turning auto-headlights to OFF position. When cycled back to AUTOMATIC, condition reasserts and dims both the cluster and screen. Issue has been verified at dealership since 2023. Cannot replicate issue when stored indoors, raining, overcast, cold, etc. Requires full sun and warm day. Vehicle cannot be spared for additional diagnostics without rental/loaner provision. Will ask to attempt to replicate during upcoming recall maintenance and other TSB/SSM diagnostics to correct lingering OTA update/software issues that cause low state of charge conditions.

2021 FORD F-150

ID: 2088495

POWER TRAIN

Consistent issues with the 10 speed transmission. There a delay in shifting from 1st to 2nd gear then slams into gear causing a jerky acceleration of speed. Also constant clunking throughout the gears. Extremely flawed adaptive learning system for their 10 speed automatic transmission.

2021 FORD F-150

ID: 2087494

PARKING BRAKE

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V509000 (Parking Brake). The contact called the local dealer on several occasions to have the recall repair performed and was informed that the vehicle needed to be inspected before the part could be ordered to perform the recall repair. The contact was also informed that the vehicle needed to remain with the dealer, and that a loaner vehicle would not be provided. The manufacturer was made aware of the issue and informed the contact that the dealer information was incorrect, and that parts for the repair are available for the recall repair. The contact stated that the dealer was the nearest dealer and that calling another dealer would be an inconvenience. The contact had not experienced a failure. Parts distribution disconnect.

2021 FORD F-150

ID: 2087221

STEERING

The contact owns a 2021 Ford F-150. The contact stated that while attempting to complete a turn, the steering wheel seized, with the "Steering Assist Fault Detected" message displayed. The vehicle was restarted and returned to normal functionality, but the failure became a regular occurrence. The power steering warning light was illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V407000 (Steering), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 19,000.

2021 FORD F-150

ID: 2086978

ENGINE AND ENGINE COOLING

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V635000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2086066

UNKNOWN OR OTHER

Trucks been in to Ford for repairs 38 times for force motor shuts down while driving. Ford wasn‚Äôt able to duplicate so they kept blowing me off. Finally morries of Okemos actually drove truck 45 minutes like I requested because it only shuts down after truck warms up. They have got it to finally shut down and have realized the panic of not being able to start back up until it‚Äôs in park and how dangerous it is to be driving 70 on highway and if you break it does force motor shut down. Ford refuses buy back and vehicles not safe to drive. They still have no answers. At this point I‚Äôve went 245 days without a vehicle while being in and out of shop. Mine isn‚Äôt the only one out there. There telling people if they can‚Äôt duplicate when they drive it they can‚Äôt fix it. Problem is these dealerships aren‚Äôt driving consecutive enough to fix it. Thankfully mirrors did thinking I was crazy and dealership says they have never seen this actually happen. Just from talking I know several people with same issue.

2021 FORD F-150

ID: 2086065

ENGINE

Trucks been in to Ford for repairs 38 times for force motor shuts down while driving. Ford wasn‚Äôt able to duplicate so they kept blowing me off. Finally morries of Okemos actually drove truck 45 minutes like I requested because it only shuts down after truck warms up. They have got it to finally shut down and have realized the panic of not being able to start back up until it‚Äôs in park and how dangerous it is to be driving 70 on highway and if you break it does force motor shut down. Ford refuses buy back and vehicles not safe to drive. They still have no answers. At this point I‚Äôve went 245 days without a vehicle while being in and out of shop. Mine isn‚Äôt the only one out there. There telling people if they can‚Äôt duplicate when they drive it they can‚Äôt fix it. Problem is these dealerships aren‚Äôt driving consecutive enough to fix it. Thankfully mirrors did thinking I was crazy and dealership says they have never seen this actually happen. Just from talking I know several people with same issue.

2021 FORD F-150

ID: 2086033

ENGINE

Failure to remedy engine valve recall. Was informed that a remedy would be ready by Q1 of 2025. That deadline has passed and nobody at Ford has any information.

2021 FORD F-150

ID: 2086008

POWER TRAIN

Transmission slipping when accelerating from complete stop and through 4th gear

2021 FORD F-150

ID: 2085551

ELECTRICAL SYSTEM

The contact owns a 2021 Ford F-150. The contact stated that on several occasions, the vehicle failed to start up. There was no warning light illuminated. The contact stated that the failure had occurred after the vehicle had not been driven for several days. The contact stated that the battery had been replaced several times; however, the failure returned shortly after the battery replacement. Upon investigation, the contact suspected that the failure may be caused by a parasitic drain inside the vehicle, which would run the battery even while the vehicle was turned off. The contact stated that recently,y there was an abnormal ticking sound coming from the engine relay. The vehicle was taken to a dealer however, the dealer was unable to determine the cause of the failure. The manufacturer was notified of the failure, and the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 30,000.

2021 FORD F-150

ID: 2085133

ENGINE AND ENGINE COOLING

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2084745

UNKNOWN OR OTHER

Had ac on on the way out of town when the air from the vents smelled like mold and mildew and the smell is not healthy for any human beings and the ac drain has no elbow on it witch is the cause of water getting back into the system the smell made me sick and called ford and was told I would have to pay for it since it was pass 3 years truck has 29k miles on it should not be making that smell at so little miles it is a health Hazzard

2021 FORD F-150

ID: 2084308

FUEL/PROPULSION SYSTEM

Due to a defective door (cheap plastic pin), the check engine light comes on with associated warnings on the fuel door not being shut. It is shut but not locked due to the defective pin (I believe plastic) that interacts with the warning light and warning message.

2021 FORD F-150

ID: 2084217

WHEELS

On Saturday (April 19th), I looked at my rear tire, passenger side, and noticed a bolt inside my hub. After seeing that I parked my vehicle. This morning I called Al Packer Ford East, told them I had this issue and know its a recall, the lady told me I needed to drive my vehicle in for them to be serviced, when I told her it was unsafe, she well that not my problem.

2021 FORD F-150

ID: 2084149

ELECTRICAL SYSTEM

The contact owns a 2021 Ford F-150. The contact stated that after attaching a trailer to the vehicle, the brakes were inoperable while driving at various speeds. The contact stated that the trailer not connected message was displayed. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 22V193000 (Electrical System) and 25V132000 (Electrical System); however, the VIN was not included. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 57,425.

2021 FORD F-150

ID: 2084095

POWER TRAIN

Still no remedy from Ford regarding NHTSA Recall Number 23V896. They had stated the resolution would be in place by Q1 2025, and I have still not received any documentation with the fix. They already pushed it back once and looks like they are doing it again as I have waited nearly 2.5 years for a fix since the first bolt broke. This vehicle is not dependable and has no resale value due to this recall not being resolved. Thank you

2021 FORD F-150

ID: 2082924

POWER TRAIN

Sometimes goes into neutral when accelerating. In a couple seconds, will then find a gear. From a dead stop, will sometimes shift to tenth gear, making it seem like the transmission is in neutral. Hard shift from 1st to 3rd.

2021 FORD F-150

ID: 2082876

POWER TRAIN

I pulled out of my driveway and the truck rapidly downshifted from 5th to second gear upon coming to a stop sign and threw my wife and I up in our seats and me into the steering wheel. . Then upon accelerating to come into the highway the truck RPM went way up but the truck didn‚Äôt accelerate and then it slammed into gear and took off. This happened on multiple occasions before I could get it into service.

2021 FORD F-150

ID: 2082671

VISIBILITY/WIPER

Windshield wiper motor failure during a heavy rain driving down [XXX] at night with children in truck on the way to a soccer tournament in Tulsa Oklahoma. Had new wiper motor replaced at dealership due to failure. No symptoms or warning prior to the failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 FORD F-150

ID: 2082615

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

The contact owns a 2021 Ford F-150. The contact stated that while the vehicle was parked, the tailgate opened unexpectedly. There were no warning lights illuminated. The contact stated that the tailgate unintendedly opened and closed independently. The vehicle was taken to a dealer and was diagnosed with a fault in the tailgate switch. The vehicle was not repaired. The dealer was made aware of the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 72,000.

2021 FORD F-150

ID: 2082474

SUSPENSION

The leaf spring on the rear driver side is not lined up and off centered. Other trucks of this model year have also been reported on numerous forums.

2021 FORD F-150

ID: 2082383

SERVICE BRAKES, HYDRAULIC

The contact owns a 2021 Ford F-150. The contact stated while driving at various speeds, the vehicle suddenly decelerated and could only be driven at an excessively slow speed. The traction control, brakes, and ABS warning lights were illuminated. The vehicle was towed to Kings Auto, where it was diagnosed that the ABS pump had failed and needed to be replaced. The mechanic related the failure to NHTSA Campaign Number: 21V533000 (Service Brakes, Hydraulic). The vehicle was not repaired. The dealer was notified of the failure and informed the contact that the VIN was not included in the recall. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 45,000.

2021 FORD F-150

ID: 2082113

POWER TRAIN

Once transmission gets to operating temperature it shifts funny between 8 9 &10, and when downshifting 7,6 and 5. It's really jerky when downshifting and goes into a kind of neutral on the highway when shifting into 10th

2021 FORD F-150

ID: 2082056

VEHICLE SPEED CONTROL

Multiple times now while driving at low speed and usually making a right hand turn, the throttle becomes totally unresponsible to driver input. Pressing the throttle does not increase ICE rpm and does not accelerate the vehicle. This has occured while entering active roadways and has created a dangerous situation multiple times. Someone will be injured with these vehicles, it is only a matter of time if this failure to accelerate issue is not recalled and fixed. The date below is only the last incident. I now have over 120K miles and it has done this well over 50 times.

2021 FORD F-150

ID: 2082055

ENGINE

Multiple times now while driving at low speed and usually making a right hand turn, the throttle becomes totally unresponsible to driver input. Pressing the throttle does not increase ICE rpm and does not accelerate the vehicle. This has occured while entering active roadways and has created a dangerous situation multiple times. Someone will be injured with these vehicles, it is only a matter of time if this failure to accelerate issue is not recalled and fixed. The date below is only the last incident. I now have over 120K miles and it has done this well over 50 times.

2021 FORD F-150

ID: 2082054

POWER TRAIN

Multiple times now while driving at low speed and usually making a right hand turn, the throttle becomes totally unresponsible to driver input. Pressing the throttle does not increase ICE rpm and does not accelerate the vehicle. This has occured while entering active roadways and has created a dangerous situation multiple times. Someone will be injured with these vehicles, it is only a matter of time if this failure to accelerate issue is not recalled and fixed. The date below is only the last incident. I now have over 120K miles and it has done this well over 50 times.

2021 FORD F-150

ID: 2081914

WHEELS

Ford refuses / is unable to resolve Safety Recall 23S65/23V896. Ford has stated solution will be available by 1st quarter 2025. It is now April 12, 2025 and Ford reports no solution date. Recall 23S65/23V896 is a Safety recall. Ford's description: Safety Risk This may initially result in a clicking noise as the bolt becomes loose and a rattle noise from the wheel cap if the bolt breaks. Vehicles with damaged axle hub splines may roll in park without the parking brake applied, or, alternatively, lose drive power, both of which may increase the risk of injury or a crash.

2021 FORD F-150

ID: 2081913

POWER TRAIN

Ford refuses / is unable to resolve Safety Recall 23S65/23V896. Ford has stated solution will be available by 1st quarter 2025. It is now April 12, 2025 and Ford reports no solution date. Recall 23S65/23V896 is a Safety recall. Ford's description: Safety Risk This may initially result in a clicking noise as the bolt becomes loose and a rattle noise from the wheel cap if the bolt breaks. Vehicles with damaged axle hub splines may roll in park without the parking brake applied, or, alternatively, lose drive power, both of which may increase the risk of injury or a crash.

2021 FORD F-150

ID: 2081909

POWER TRAIN

When driving the truck slips out of gear, most often when coasting at low speed, on at least 3 occasions while waiting for oncoming traffic to clear so I can make left turn across oncoming traffic.I ease forward and when coast is clear i hit the accelerator and the engine Revs up but truck does not accelerate until after I let off of the gas pedal and truck RPM go down and I press on gas again. The truck jerks and then the Transmission Grabs. Also when I'm driving and I Switch from normal mode to sport mode the truck says this option is not available and a little wrench icon shows up on the dash, this happened the first week I when purchased the truck, I took it back to the dealership I bought it from and they solved it. But now this(wrench warning) issue has started occur again and I get a message in my fordpass app. If piwertrain malfunction see dealer. When I take it to a Ford dealer they say that they can't reproduce the problem so in their eyes there is no issue, and a week later light comes back on, so I park the truck and make apartment with dealership but the next morning when I get in and start the truck the issue is gone the service power train light goes away. It happens at least 2 times a month lately, and I can't afford to pay the Ford Dealers $400.00 again just to tell me that they can't recreate the issue. Also my recall 23v896 has yet to be addressed and I think this(Powertrain)issue has something to do with it, im hearing the sound that the recall warns about. But all I get from Ford Dealers is a $400.00 BILL.

2021 FORD F-150

ID: 2081396

STEERING

power steering assist randomly stops working. has been going on for a while. The fault clears by stopping, shutting off the truck and restarting it. last time it occurred 05APR2025, it would not clear. Had to drive to dealer without power assist.

2021 FORD F-150

ID: 2081215

UNKNOWN OR OTHER

The plastic clips that hold the keypad on the driver‚Äôs side door to the truck have failed allowing access to the trucks wiring and potentially gaining entry to the truck. Concerned with break-ins

2021 FORD F-150

ID: 2081211

VISIBILITY/WIPER

The windshield wipers stop working after 1 wipe

2021 FORD F-150

ID: 2081159

VISIBILITY/WIPER

The contact owns a 2012 Ford F-150. The contact stated that while the vehicle turned off on several occasions, the message "Parking Brake Fault" was displayed. The contact stated that each time the vehicle was started, the message was no longer displayed. Additionally, the contact stated that on another occasion, the windshield wipers stopped midway and kicked back. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.

2021 FORD F-150

ID: 2081158

PARKING BRAKE

The contact owns a 2012 Ford F-150. The contact stated that while the vehicle turned off on several occasions, the message "Parking Brake Fault" was displayed. The contact stated that each time the vehicle was started, the message was no longer displayed. Additionally, the contact stated that on another occasion, the windshield wipers stopped midway and kicked back. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.

2021 FORD F-150

ID: 2080845

POWER TRAIN

the bolt on the recall has completely broke. we need a safe vehicle to drive. as stated in recall if continue to drive with broken part it may result in a crash. Manufacturer Recall Number23S65 NHTSA Recall Number23V896

2021 FORD F-150

ID: 2080515

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2079026

ENGINE AND ENGINE COOLING

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2078947

FORWARD COLLISION AVOIDANCE

The contact owns a 2021 Ford F-150. The contact stated while shifting to reverse(R), the rear camera image was distorted. The contact stated that the image was blank, and blue intermittently. The vehicle was not taken to the dealer, or an independent mechanic, and was not diagnosed. The local dealer was contacted; however, the vehicle was not repaired because it was not under recall. On a separate occasion, the console screen ceased to function and would not display data and shut off intermittently and turned on independently. The headlight warning lights, and Forward Collision Avoidance warning light was illuminated, and a message that the center sensor not active was displayed. The vehicle was taken to the dealer and the dealer made several software updates; however, the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 35,000. The VIN was not available.

2021 FORD F-150

ID: 2078946

ELECTRICAL SYSTEM

The contact owns a 2021 Ford F-150. The contact stated while shifting to reverse(R), the rear camera image was distorted. The contact stated that the image was blank, and blue intermittently. The vehicle was not taken to the dealer, or an independent mechanic, and was not diagnosed. The local dealer was contacted; however, the vehicle was not repaired because it was not under recall. On a separate occasion, the console screen ceased to function and would not display data and shut off intermittently and turned on independently. The headlight warning lights, and Forward Collision Avoidance warning light was illuminated, and a message that the center sensor not active was displayed. The vehicle was taken to the dealer and the dealer made several software updates; however, the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 35,000. The VIN was not available.

2021 FORD F-150

ID: 2078945

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

The contact owns a 2021 Ford F-150. The contact stated while shifting to reverse(R), the rear camera image was distorted. The contact stated that the image was blank, and blue intermittently. The vehicle was not taken to the dealer, or an independent mechanic, and was not diagnosed. The local dealer was contacted; however, the vehicle was not repaired because it was not under recall. On a separate occasion, the console screen ceased to function and would not display data and shut off intermittently and turned on independently. The headlight warning lights, and Forward Collision Avoidance warning light was illuminated, and a message that the center sensor not active was displayed. The vehicle was taken to the dealer and the dealer made several software updates; however, the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 35,000. The VIN was not available.

2021 FORD F-150

ID: 2078882

ENGINE

The contact owns a 2021 Ford F-150. The contact stated while driving 45 MPH, the vehicle made an abnormal knocking sound. The transmission warning light was illuminated. The contact stated that the vehicle was experiencing erratic transmission shifts and was making an abnormal knocking sound while driving. The vehicle was taken to a dealer, where the cause of the abnormal knocking sound could not be determined; however, the failure persisted. The vehicle was taken back to the dealer, where an unknown diagnosis was provided, and unknown repairs were performed. Additionally, the contact stated that the vehicle was difficult to start. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

2021 FORD F-150

ID: 2078881

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated while driving 45 MPH, the vehicle made an abnormal knocking sound. The transmission warning light was illuminated. The contact stated that the vehicle was experiencing erratic transmission shifts and was making an abnormal knocking sound while driving. The vehicle was taken to a dealer, where the cause of the abnormal knocking sound could not be determined; however, the failure persisted. The vehicle was taken back to the dealer, where an unknown diagnosis was provided, and unknown repairs were performed. Additionally, the contact stated that the vehicle was difficult to start. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

2021 FORD F-150

ID: 2078813

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2078708

UNKNOWN OR OTHER

Ford stated a solution to this would be available Q1 2025, but has not provided one. They had already pushed this back once before. THE WHEEL END HUB BOLT IN THE REAR AXLE MAY BECOME LOOSE OR BREAK. CONTINUED DRIVING WITH A BROKEN BOLT MAY LEAD TO WEAR WITHIN THE AXLE AND DAMAGE THE AXLE HUB SPLINES. THIS MAY INITIALLY RESULT IN A CLICKING NOISE AS THE BOLT BECOMES LOOSE AND A RATTLE NOISE FROM THE WHEEL CAP IF THE BOLT BREAKS. VEHICLES WITH DAMAGED AXLE HUB SPLINES MAY ROLL IN PARK WITHOUT THE PARKING BRAKE APPLIED, OR, ALTERNATIVELY, LOSE DRIVE POWER, BOTH OF WHICH MAY INCREASE THE RISK OF INJURY OR A CRASH.

2021 FORD F-150

ID: 2078707

WHEELS

Ford stated a solution to this would be available Q1 2025, but has not provided one. They had already pushed this back once before. THE WHEEL END HUB BOLT IN THE REAR AXLE MAY BECOME LOOSE OR BREAK. CONTINUED DRIVING WITH A BROKEN BOLT MAY LEAD TO WEAR WITHIN THE AXLE AND DAMAGE THE AXLE HUB SPLINES. THIS MAY INITIALLY RESULT IN A CLICKING NOISE AS THE BOLT BECOMES LOOSE AND A RATTLE NOISE FROM THE WHEEL CAP IF THE BOLT BREAKS. VEHICLES WITH DAMAGED AXLE HUB SPLINES MAY ROLL IN PARK WITHOUT THE PARKING BRAKE APPLIED, OR, ALTERNATIVELY, LOSE DRIVE POWER, BOTH OF WHICH MAY INCREASE THE RISK OF INJURY OR A CRASH.

2021 FORD F-150

ID: 2078669

VISIBILITY/WIPER

I was driving to in the morning and my entire rear window randomly shattered and glass flew everywhere in my truck and on me in the drivers seat.

2021 FORD F-150

ID: 2078668

UNKNOWN OR OTHER

I was driving to in the morning and my entire rear window randomly shattered and glass flew everywhere in my truck and on me in the drivers seat.

2021 FORD F-150

ID: 2078596

POWER TRAIN

I‚Äôm reporting that this recall repair is overdue and not completed in a timely manner. I was first alerted to the recall in December 2023. There was supposed to be a fix by the first quarter of 2025 and I‚Äôve heard nothing. I have been driving a truck with a defective axle for 4 years. Rediculous!

2021 FORD F-150

ID: 2078258

ELECTRICAL SYSTEM

Daytime running lights quit working.

2021 FORD F-150

ID: 2078257

EXTERIOR LIGHTING

Daytime running lights quit working.

2021 FORD F-150

ID: 2078255

UNKNOWN OR OTHER

The factory-installed panoramic sunroof mesh air deflector is causing a water drainage issue. Water accumulates in the main channels, saturating the mesh and allowing it to retain moisture for an extended period. This prolonged dampness leads to mold growth, creating a health concern due to the mold odor inside the cabin after any rainstorm.

2021 FORD F-150

ID: 2078157

ELECTRICAL SYSTEM

My rearview backup camera blacks out won't load, cuts off and on. When in drive it still takes a while for it to still load the radio and navigation. It blacks out and won't load when I start the truck. By the time I back up, still not loading, and start to drive it takes a few minutes maybe 10 for it to finally start working and displaying the navigation and the radio. I've had this issue for a while. And if other makes and models are having the same issues, it has to also be affecting my make and model being it's the same issue.

2021 FORD F-150

ID: 2078065

UNKNOWN OR OTHER

This recall has been out since August of 2024, this recall is extremely serious and should not be taken lightly, a remedy should absolutely already be developed!!!!!!!!!! This can cause serious accidents resulting in death especially at a high rate of speed!!!!!! Solve this issue!!!!!

2021 FORD F-150

ID: 2077768

UNKNOWN OR OTHER

The back window of the Panoramic sunroof exploded, and spider webbed across the entire glass windowpane while going down the road. Pieces of glass shards immediately fell all over the truck interior and then a piece of glass fell out of the middle of the sunroof panel. I notified my Ford dealer immediately and took it in for observation and review. I also took pictures of the glass right away.

2021 FORD F-150

ID: 2077656

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2077435

BACK OVER PREVENTION

The contact owns a 2021 Ford F-150. The contact stated that while reversing, the rear-view camera failed to display an image, compromising the backup prevention system. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the rear-view camera. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 29,000.

2021 FORD F-150

ID: 2077356

POWER TRAIN

10 Speed Transmission has very harsh shifting when accelerating as well as when downshifting. Dealer has looked at it and have been told over and over that it is normal. When downshifting there are time where the shifting creates a lunge affect making you feel that you are going to hit the car in front of you.

2021 FORD F-150

ID: 2077098

POWER TRAIN

Transmission, hard shifting,shifting out of gear wrong when towing sometimes when not Transmission was already overhauled under factory powertrain warranty at around 42000 miles

2021 FORD F-150

ID: 2077073

POWER TRAIN

Terrible hard shifting

2021 FORD F-150

ID: 2076729

ELECTRICAL SYSTEM

The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the rearview camera intermittently was inoperative. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that an unknown module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 25,000.

2021 FORD F-150

ID: 2076633

POWER TRAIN

While traveling on a local highway in the far left lane, the engine completely died (no engine light came on). I was trying to negotiate traffic while getting to the shoulder of the road, and the transmission began shifting itself into park. I grabbed the shift lever trying to prevent it from going into park; however, it did just as I reached the shoulder of the road. At this point, I had slowed to ~25 MPH, but it still locked the tires up and slid a few feet. After turning the key off, removing it from the truck, and opening the door, I was finally able to restart it and I went straight to my local mechanic. He attached a code reader; however, there were no codes displayed. He stated they probably cleared out when I restarted the truck. This happened a couple of months ago, but my wife has been fussing at me to report it.

2021 FORD F-150

ID: 2076632

ENGINE

While traveling on a local highway in the far left lane, the engine completely died (no engine light came on). I was trying to negotiate traffic while getting to the shoulder of the road, and the transmission began shifting itself into park. I grabbed the shift lever trying to prevent it from going into park; however, it did just as I reached the shoulder of the road. At this point, I had slowed to ~25 MPH, but it still locked the tires up and slid a few feet. After turning the key off, removing it from the truck, and opening the door, I was finally able to restart it and I went straight to my local mechanic. He attached a code reader; however, there were no codes displayed. He stated they probably cleared out when I restarted the truck. This happened a couple of months ago, but my wife has been fussing at me to report it.

2021 FORD F-150

ID: 2076594

ENGINE AND ENGINE COOLING

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2076137

POWER TRAIN

Manufacturer Recall Number23S65 NHTSA Recall Number23V896 Recall StatusRecall Incomplete, remedy not yet available Mine has already failed once last year all the dealer did was put new parts in but said they still are not updated I tow a camper and it is soon time to tow and I am going on a long trip just want to see when the fix will be in

2021 FORD F-150

ID: 2075498

STRUCTURE

The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the contact noticed an abnormal swishing sound in the front and rear passenger's side door panels. The contact inspected the vehicle and discovered water in the front and rear passenger side door panels. The vehicle was taken to the dealer. The contact was informed that the water leak was coming from the roof of the vehicle. The vehicle was repaired; however, the failure reoccurred. The contact stated while the vehicle was parked, the contact noticed the water entering the interior of the vehicle through the rear passenger's side seat belt. The vehicle was taken to the dealer. The contact was informed that the water leak was due to a failed rear exhaust panel. The contact was informed that the rear exhaust panel needed to be replaced. The vehicle was repaired. Additionally, the contact stated that due to the failure, the carpet and the seats needed to be cleaned. The failure reoccurred. The contact stated while driving, there was an abnormal swishing sound in the front and rear passenger's side door panels again. The contact became aware of electrical switching sounds, and the horn failed to operate as intended. The vehicle was taken back to the dealer, where it was diagnosed with sunroof assembly failure. The contact was informed that the sunroof assembly needed to be replaced. The vehicle was being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,000.

2021 FORD F-150

ID: 2075497

VISIBILITY:SUN/MOON ROOF ASSEMBLY

The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the contact noticed an abnormal swishing sound in the front and rear passenger's side door panels. The contact inspected the vehicle and discovered water in the front and rear passenger side door panels. The vehicle was taken to the dealer. The contact was informed that the water leak was coming from the roof of the vehicle. The vehicle was repaired; however, the failure reoccurred. The contact stated while the vehicle was parked, the contact noticed the water entering the interior of the vehicle through the rear passenger's side seat belt. The vehicle was taken to the dealer. The contact was informed that the water leak was due to a failed rear exhaust panel. The contact was informed that the rear exhaust panel needed to be replaced. The vehicle was repaired. Additionally, the contact stated that due to the failure, the carpet and the seats needed to be cleaned. The failure reoccurred. The contact stated while driving, there was an abnormal swishing sound in the front and rear passenger's side door panels again. The contact became aware of electrical switching sounds, and the horn failed to operate as intended. The vehicle was taken back to the dealer, where it was diagnosed with sunroof assembly failure. The contact was informed that the sunroof assembly needed to be replaced. The vehicle was being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,000.

2021 FORD F-150

ID: 2074029

POWER TRAIN

Whining or whistling noise at idle. Bangs when shifts to lowest gear.

2021 FORD F-150

ID: 2074028

ENGINE

Whining or whistling noise at idle. Bangs when shifts to lowest gear.

2021 FORD F-150

ID: 2073490

AIR BAGS

Confirmed through dealership that the Clock Spring in the steering column needs to be replaced as it is defective. Ford has indicated that my vehicle vin is not a part of the current clock spring recall.

2021 FORD F-150

ID: 2073472

UNKNOWN OR OTHER

I did not have an incident. However, we have been waiting 7 months for a remedy. I am scared to drive the vehicle until it is fixed. How long do we have to wait for a solution?

2021 FORD F-150

ID: 2073297

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated that while driving at 40 MPH, the rear end of the vehicle started vibrating abnormally. No warning light was illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the alignment had failed. The vehicle was not repaired. The contact took the vehicle to an independent mechanic where it was diagnosed that the rear axle hub bolts were worn and had shifted. The vehicle was not repaired. The contact took the vehicle to the local dealer where it was diagnosed that there was a leak in the rear axle seals. The repair was pending. The manufacturer was notified of the failure, but no assistance was offered. The contact related the failure to NHTSA Campaign Number: 23V896000 (Power Train); however, the VIN was not included. The failure mileage was 28,000.

2021 FORD F-150

ID: 2072276

POWER TRAIN

I received this recall December of 2023. I was originally advised that a fix would be ready during the 1st quarter of 2024. I inquired on two occasions about the safety of driving my truck with the axle bolt breaking issue recall. Two separate techs advised me that I could continue driving my truck until a fix to the issue is found but both techs advised not to tow a trailer until it's repaired. I mainly use my truck to tow and usually a couple hundred miles at a time, so this doesn't help me and its now mid-March of 2025.

2021 FORD F-150

ID: 2070756

ENGINE

My truck has a 2.7 eco boost engine than has failed around 134,000 miles. The truck had a couple of misfires over the last couple of months, but otherwise no issues. I drove the truck one Saturday, did not drive Sunday, and on Monday I am told the engine is completely seized and I am responsible for replacing the engine. Ford will not attempt to determine if the recall for the valve intake stem has caused the issue and now I am spending over $12,000 to replace a 4 year old engine with no other issues.

2021 FORD F-150

ID: 2069070

POWER TRAIN

The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the transmission experienced hard shifting, gear grinding, and slipping gear while accelerating from a red light. The contact stated that the gear shift indicator showed that the transmission was in 10th gear and the vehicle started drifting backward. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 32,000.

2021 FORD F-150

ID: 2067144

ENGINE AND ENGINE COOLING

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The check engine warning light was illuminated. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

2021 FORD F-150

ID: 2066724

STRUCTURE:BODY

DRIVER DOOR WON'T LOCK OR UNLOCK IN EXTREME COLD. TO EXIT AND ENTER TRUCK, I HAVE TO USE THE PASSENGER DOOR AND SLIDE INTO DRIVER SEAT, WHICH IS VERY DIFFICULT B/C OF THE CENTER CONSOLE. NO WAY I COULD GET OUT OF THE TRUCK IN A HURRY IF I HAD TO. TOOK TO A DEALER BUT OF COURSE IT COULDN'T BE DUPLICATED. INTERNET SEARCH SHOWS THIS IS A PROBLEM WITH THE 2021 FORD F150.

2021 FORD F-150

ID: 2065845

STEERING

The power steering assist model failed rendering the truck without power steering. I called my dealership and they told me that the part is not available until sometime after February but could not give new a more precise date. I called Ford customer service on [XXX] and they could not give me an availability date on the part (Ford customer service case # [XXX]). They also informed me that the part is not under recall. This leaves me with an truck that is basically safe to drive for the last 60 days. I am the ogival owner of the truck and it has only 5300 miles on it. Can you help me Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 FORD F-150

ID: 2064823

UNKNOWN OR OTHER

During cold weather the Driver and both back door locks will and cannot be locked or unlocked and the doors cannot be opened from inside or out if locked. Temperatures under 28 degrees Fahrenheit the locks become sluggish. Below 20 Fahrenheit the locks and door will not function at all. The dealer ship has checked out this issue but say that if replaced with current parts the problem will most likely continue. With this issue I have been locked in the car twice and had to exit the passenger door (which works for some reason). I now leave the truck unlocked which leaves me open to theft.

2021 FORD F-150

ID: 2063661

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Rear backup camera and distance sensors stopped working. The issue is intermittent This issue could have resulted in an accident or injury/fatality due to no image sensor information No dealer involvement at this time No outside inspections at this time No prior warnings or messages were given before the failure

2021 FORD F-150

ID: 2063660

BACK OVER PREVENTION: WARNINGS

Rear backup camera and distance sensors stopped working. The issue is intermittent This issue could have resulted in an accident or injury/fatality due to no image sensor information No dealer involvement at this time No outside inspections at this time No prior warnings or messages were given before the failure

2021 FORD F-150

ID: 2063659

UNKNOWN OR OTHER

Rear backup camera and distance sensors stopped working. The issue is intermittent This issue could have resulted in an accident or injury/fatality due to no image sensor information No dealer involvement at this time No outside inspections at this time No prior warnings or messages were given before the failure

2021 FORD F-150

ID: 2063164

EXTERIOR LIGHTING

The contact owns a 2021 Ford F-150. The contact stated that the C-shaped LED light at the outer corners of the driver's side headlight was significantly dimmed, which reduced the road visibility. The contact stated that the failure had progressively worsened. The dealer was notified of the failure and charged a repair fee for the headlight replacement. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 97,500.

2021 FORD F-150

ID: 2062983

EXTERIOR LIGHTING

The daytime running lights are malfunctioning. I have seen this is a common issue with this style truck.

2021 FORD F-150

ID: 2061191

VISIBILITY/WIPER

Just bought this truck. I was driving down the highway and my sunroof had exploded and blew off the top of my truck. I also noticed that my windshield is wavy and hard to see through.

2021 FORD F-150

ID: 2061190

UNKNOWN OR OTHER

Just bought this truck. I was driving down the highway and my sunroof had exploded and blew off the top of my truck. I also noticed that my windshield is wavy and hard to see through.

2021 FORD F-150

ID: 2060754

POWER TRAIN:DRIVELINE:DRIVESHAFT

The contact owns a 2021 Ford F-150. The contact stated that while driving on the highway at 35 MPH, there was a loud pop from the rear end of the vehicle, and the rear end of the vehicle started vibrating abnormally. No warning light was illuminated. The contact immediately parked on the side of the road to inspect the vehicle and became aware that the driveshaft had fractured in half. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was informed that the drive shaft had fractured in half and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 80,200.

2021 FORD F-150

ID: 2060499

STEERING

The contact owns a 2021 Ford F-150. The contact stated that while making left and right turns on several occasions, the steering wheel vibrated with the "Steering Assist Fault - Service Required" message displayed. The vehicle was towed to the dealer where it was diagnosed, and a software update was performed. The vehicle was repaired but the failure reoccurred on the way to the residence. The vehicle was taken back to the same dealer where it was then diagnosed that the battery needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was then taken to the same dealer for the third time and it was diagnosed that the PSCM steering control module and steering gear needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 19,888.

2021 FORD F-150

ID: 2059949

STEERING

The contact owns a 2021 Ford F-150. The contact stated that while the vehicle was parked, the contact attempted to start the vehicle, and the electric steering fault message was displayed. A dealer was contacted. The vehicle was towed to the dealer where is was diagnosed that the steering gear assembly needed to be replaced. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 21V407000 (STEERING). The manufacturer was not notified of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 38,008.

2021 FORD F-150

ID: 2059766

POWER TRAIN

Transmission suddenly downshifted from 7th to 1st gear when driving along a highway. This significantly slowed the vehicle down and almost caused a following vehicle to collide with me. The vehicle will also shift from 4th to 3rd violently, revving the engine then slammining into gear. This throws the heads of all occupants a d causes significant early wear and tear on power train components.

2021 FORD F-150

ID: 2058058

LATCHES/LOCKS/LINKAGES

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the door opened independently. The contact stated upon inspecting the vehicle, he noticed that the door latches was frozen, and the contact was unable to enter or exit the vehicle. The dealer was contacted. The vehicle was taken to a dealer where it was diagnosed that the door latch needed to be replaced. The contact was provided an estimate for the repair. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The contact related the failure to NHTSA Campaign Number: 17V652000 (LATCHES/LOCKS/LINKAGES); however, the VIN was not included in the recall. The approximate failure mileage was 98,000.

2021 FORD F-150

ID: 2057140

WHEELS

Unable to rotate tires or change a flat tire because per dealer Ford lug nuts are swollen and they can not come off with standard tool (lug wrench). Dealer informed me this has been an issue for years but there are no recalls. I was shocked to find out a simple issue like a flat tire can not be fixed due to the simplest designed piece of equipment on the vehicle (lug nut). Dealer stated i can buy replacement lug nuts from Ford for about $200.00 but they will do the same thing over time. I just found many write ups about this ongoing problem and wonder why NHTSA allows this to not be a recall ... this is a safety issue. Get Ford to redesign the Lug Nut, make it a simple one piece design and relace at no charge. If I or one of my family members get a flat tire and is stranded that would not be good!

2021 FORD F-150

ID: 2056528

UNKNOWN OR OTHER

In the cold winter of Bismarck, ND, all of my truck's door handles are frozen, so I am unable to get in or out of my truck (NHTSA SSM XXXXX). I have been climbing in and out of my window to get into my truck. This is already a safety concern recognized by your organization, so why doesn‚Äôt my truck qualify for a recall? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 FORD F-150

ID: 2056479

EXTERIOR LIGHTING

Passenger side headlights assembly has a daytime running light that stopped working properly. There is no longer a fully functioning running light that decreases visibility to other vehicles. The manufacturer will not replace and the it cannot be repaired without a full headlight assembly replacement that is not affordable.

2021 FORD F-150

ID: 2056194

STEERING

The ford is a ford F150 2021 with only 47,000 miles on it. It is a well taken care of truck with all routine maintenance done. The power control steering module has completely gone out in my truck. Unfortunately this problem began to occur with my children in the car when a warning light came on and then the power steering completely went out making it extremely difficult to turn and steer the car. Thankfully this occurred on a backroad and not the highway. Needless to say, it is not safe to drive my car and is now sitting in the shop. Ford has confirmed the problem but is unable to get a new PSCM because it is back ordered meaning many people are facing the same issue. We are told they are unsure if the part will become available in a month or 6 months which means we are out a car for that long. With the part being on such a back order, I would hope this would be a red flag to not only ford but to the NHTSA that this is a common problem and error on a faulty part which is extremely dangerous.

2021 FORD F-150

ID: 2056046

EXTERIOR LIGHTING

Both drl leds around the housing failed. Twice now. This is a know issues with 21+ f150s

2021 FORD F-150

ID: 2056007

EXTERIOR LIGHTING

Both Front headlight DRL failed at 40K miles. This poses a safety risk for other vehicles on the road

2021 FORD F-150

ID: 2055990

EXTERIOR LIGHTING

Front DRL on the headlights no longer work making it difficult for other vehicles to have a clear sight of vehicle.

2021 FORD F-150

ID: 2055267

STEERING

The steering wheel would not turn. Similar to when cars did not have power steering but much worse. Had the truck taken to the Ford Dealership. They reprogrammed the computer and said that fixed the problem . Started to leave and didn‚Äôt even get off the lot when it basically‚Äôfroze up‚Äô again. They kept the vehicle for a second time. When they called and said it was fixed, I was able to drive it but discovered to will ‚Äòfreeze up‚Äô when trying to make a sharp turn(almost all the way to the stop), either to the right or left

2021 FORD F-150

ID: 2053781

FUEL/PROPULSION SYSTEM

Ford Motor Company has issued a safety recall, identified by letter NEF-107DG and recall number 24V-957, due to the potential failure of the CP4 fuel pump in certain vehicle models. The recall affects the following makes, models, and model years: FORD/F-250 SD (2020-2022), FORD/F-350 SD (2020-2022), FORD/F-450 SD (2020-2022), FORD/F-550 SD (2020-2022), FORD/F-600 SD (2020-2022), FORD/F-650 (2021-2022), and FORD/F-750 (2021-2022). This action addresses concerns that the CP4 pump may fail prematurely, potentially leading to engine stalling and increasing the risk of a crash. Notably, my 2021 Ford F-150 XLT with a 3.0L diesel engine is equipped with the same CP4 fuel pump as the models listed above. As such, it should logically be included in this recall to ensure consistent safety measures and address the risks associated with this known defect.

2021 FORD F-150

ID: 2053044

EXTERIOR LIGHTING

The day time running light on the driver side is out and is a known problem for the 2021+ F-150‚Äôs with LED headlights that I have seen. It would be in everyones best interest if we could have this recalled and have Ford fix this issue that is not covered by warranty and without having to scavenge $2100 to replace one side of a headlight which is a safety feature for the truck.

2021 FORD F-150

ID: 2053043

ELECTRICAL SYSTEM

The day time running light on the driver side is out and is a known problem for the 2021+ F-150‚Äôs with LED headlights that I have seen. It would be in everyones best interest if we could have this recalled and have Ford fix this issue that is not covered by warranty and without having to scavenge $2100 to replace one side of a headlight which is a safety feature for the truck.

2021 FORD F-150

ID: 2052607

ELECTRICAL SYSTEM

The contact called about a 2021 Ford F-150 company vehicle. The company received notification of NHTSA Campaign Number: 22V193000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

2021 FORD F-150

ID: 2051929

UNKNOWN OR OTHER

Driver door latch and lock failure at extreme cold temperatures. Failed last year could not exit vehicle at Ford dealership. Ford dealership added grease and problem did not occur again for 11 months. Same problem occurred this December. Door latch stays open and will not latch so door has to be held shut by driver while moving down the road. Problem occurred on 4 different days of single digit temperatures during the past 2 years. The ford dealership in Gaylord observed the stuck latch and door not latching. Warning light of door ajar when put into gear and constant warning beeping while driving with an unlatched door.

2021 FORD F-150

2021 FORD F-150 Summary

Recalls

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

Complaints

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150

2021 FORD F-150