2015 FORD F-150

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

Tenneco Automotive (DRiV) is recalling certain MOOG K500359 ball joints, for aftermarket installation on 2015-2018 Ford F-150 trucks. The ball joint may have a misaligned dust boot and may be missing alignment hole and installation warning tag, which may lead to improper alignment of the ball joint.

Risk: An incorrectly installed ball joint may cause the ball joint stud to break, which can compromise front wheel control, increasing the risk of a crash.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST

Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.

Risk: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.

EQUIPMENT:ELECTRICAL

Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibly resulting in a damaged cable.

Risk: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

EQUIPMENT:ELECTRICAL

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.

Risk: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Risk: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

STRUCTURE:BODY:ROOF AND PILLARS

Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.

Risk: A vehicle fire could result if materials ignite inside the vehicle.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.

Risk: A door that opens while driving can increase the risk of injury.

SEAT BELTS:REAR/OTHER

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Risk: If the left rear inflatable seat belt buckle separates from it's mounting bracket, the seat occupant may not be adequately restrained, increasing their risk of injury.

STRUCTURE:BODY:DOOR

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."

Risk: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.

SEAT BELTS:FRONT:ANCHORAGE

Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 SuperCrew trucks manufactured January 22, 2015, to March 17, 2015. The affected vehicles may be equipped with driver or front passenger seat belt anchorage assemblies whose pretensioner cable was not properly crimped. As a result, the seat belts may not properly restrain the seat occupant in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies" and 210, " Seat Belt Assembly Anchorages."

Risk: An occupant that is not be properly restrained is at an increased risk of injury in the event of a crash.

STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 vehicles manufactured January 30, 2015, to January 31, 2015. The affected vehicles may have loose or missing underbody heat shields.

Risk: A missing underbody heat shield can lead to degradation or melting of the fuel or vapor lines, increasing the risk of a fire.

STEERING

Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 trucks manufactured March 19, 2015, to March 30, 2015. The affected vehicles may have been built with a steering upper intermediate shaft that was improperly riveted.

Risk: If the intermediate shaft was improperly riveted, it could separate from the intermediate shaft flex coupling, resulting in a loss of steering control and increasing the risk of a vehicle crash.

UNKNOWN OR OTHER

Transmission on my F150 suddenly dropped to a lower gear as I was pulling out on a highway which significantly lowered my acceleration. Luckily the oncoming traffic slowed until I could safely get across to my lane. Eventually it jumped back into the proper gear. From what I have found on the internet this seems to be a common defect. Only a matter of time before someone is seriously injured or killed. This is not the first time the transmission has done this. I took my F150 to the dealership to be checked and they didn’t find anything wrong. P0706 and P0707 codes.

POWER TRAIN

Transmission on my F150 suddenly dropped to a lower gear as I was pulling out on a highway which significantly lowered my acceleration. Luckily the oncoming traffic slowed until I could safely get across to my lane. Eventually it jumped back into the proper gear. From what I have found on the internet this seems to be a common defect. Only a matter of time before someone is seriously injured or killed. This is not the first time the transmission has done this. I took my F150 to the dealership to be checked and they didn’t find anything wrong. P0706 and P0707 codes.

POWER TRAIN

warning light wrench came on truck suddenly downshifted into low gear

VEHICLE SPEED CONTROL

gears dropped fast on the highway, rpm's went up because my foot was on gas because I was on the highway, rear end locked up and I skidded going from 60MPH to 30 in a second.

WHEELS

gears dropped fast on the highway, rpm's went up because my foot was on gas because I was on the highway, rear end locked up and I skidded going from 60MPH to 30 in a second.

SERVICE BRAKES

gears dropped fast on the highway, rpm's went up because my foot was on gas because I was on the highway, rear end locked up and I skidded going from 60MPH to 30 in a second.

POWER TRAIN

I was driving my 2015 F150 with the 5.0 liter engine and 6 speed transmission at approximately 60 mph in 6th gear when without warning the transmission downshifted into 1st gear causing a sudden deceleration causing my passengers and myself to be thrown forward being caught by our seatbelts. The transmission then worked its way back up the gears into 2nd and then 3rd and so on. I took the truck to a dealership (Cooper Ford of Edmond, Oklahoma) and started to tell the service manager what happened and before I even got to the downshift part he told me right away what had happened and that I will need a new main control and lead frame. It cost me $2,766.16 to have the vehicle repaired.

POWER TRAIN

Erratic shifting. Code p0717. Down shift from 5th to 1st.

STEERING

This is the 2nd time this has happened in 2 years. I have my truck turned off completely and locked and go to get back in it a few hours later and I open my door and the gas from the airbag has completely filled up the cab of my 2015 f150. I turn the truck on and it’s like it’s been in a wreck, all the lights on the dash are on, and it’s saying my airbags are deployed which the gas that fills the airbag did deploy, and it keeps telling me to contact 911. How does this keep happening without ford making a recall or not taking responsibility. It could seriously hurt or I hurt me or my family.

ELECTRICAL SYSTEM

This is the 2nd time this has happened in 2 years. I have my truck turned off completely and locked and go to get back in it a few hours later and I open my door and the gas from the airbag has completely filled up the cab of my 2015 f150. I turn the truck on and it’s like it’s been in a wreck, all the lights on the dash are on, and it’s saying my airbags are deployed which the gas that fills the airbag did deploy, and it keeps telling me to contact 911. How does this keep happening without ford making a recall or not taking responsibility. It could seriously hurt or I hurt me or my family.

AIR BAGS

This is the 2nd time this has happened in 2 years. I have my truck turned off completely and locked and go to get back in it a few hours later and I open my door and the gas from the airbag has completely filled up the cab of my 2015 f150. I turn the truck on and it’s like it’s been in a wreck, all the lights on the dash are on, and it’s saying my airbags are deployed which the gas that fills the airbag did deploy, and it keeps telling me to contact 911. How does this keep happening without ford making a recall or not taking responsibility. It could seriously hurt or I hurt me or my family.

UNKNOWN OR OTHER

Coolant hoses defect. I have had non stop issues with coolant hoses blowing out on the highway due to the couplings they use. Plastic is not designed to withstand heat from the coolant and the constant temperature changes. I have to replace the couplings every 6month plus the heater core hoses because of the failure of the plastic couplings they use there isn’t an aftermarket option that is not plastic either this is a real issue due to being stranded on the road and not to mention the issues of environmental damage due to the coolant leaking all over the ground!!!

POWER TRAIN

Truck started to get shifting gremlins. 4 instances of spontaneous shift out of gear or into lower gear below 35mph. Transmission then shifted to 3rd gear at 60 mph on interstate without warning. Gear and shift indicator on dash blinking wildly. Vehicle behind me had to make evasive maneuver to avoid collision as I moved to emergency lane. Online research said it was a bad lead frame in transmission. Took to local repair shop and confirmed bad lead frame. Replaced for $1200 and truck now shifts correctly.

POWER TRAIN

While traveling down the highway and merging onto the interstate, if you excelerate just the slightest bit, the truck will start to violently shake and not gain speed,almost stalls a bit,causing a dangerous situation if you're trying to merge into moving traffic.Through reading and my own research on various forums. This is called transmission stutter and is a common problem with Ford's 6 speed automatic transmissions, that is not specific to vehicle or trim level or year model.

VISIBILITY/WIPER

I have a 2015 ford f150. It is equipped like many others with a power sliding rear glass. The issue is the upper track for the sliding portion becomes unattached from the rear glass and falls forward. I've had this happen 2 times in the last 2 years. Specifically in the summer. The track is originally installed cheaply with 2 sided tape and a little adhesive. The local glass shop wants 85 dollars just to glue it back. I have seen multiple trucks with the same issue with the window taped up or just covered with cardboard. My concern, is if someone has an infant in the center of the rear seat with a rear facing car seat, the slide portion of the glass could come out and fall on the baby. Not to mention, it gets a little pricey to repair it every few years. The only solution from ford was to replace the back glass at my expense, which was around $1200 dollars the last time I looked into it. I believe this is a manufacturer design flaw that Ford should have to resolve and replace. I've seen way to many of these trucks with this issue for it to Not be a manufacturer problem. Thank you.

STRUCTURE:BODY

Track of rear cabin sliding door came unglued and popped off track while driving down highway in rain. Water entered vehicle. Looked online and found numerous complaints for 2015-2020 Ford F-150. Why is there no repair for this? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

BACK OVER PREVENTION

The contact owns a 2015 Ford F-150. The contact stated that in reverse, the rearview camera failed to display an image of the rear of the vehicle as intended. The message "Caution - Camera Unavailable - Please Contact Dealer" was displayed. The contact stated that the screen displayed a small image of the vehicle with the surrounding sensors' warnings displayed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact related the failure to an undisclosed recall; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 120,000.

POWER TRAIN

When driving the transmission tends to constantly down shift and feels like a vibration/and grinding when doing so. Also the rear wheels sometimes lock up briefly when when accelerating. (the symptoms are very similar to the 2014 f150 transmission issues). This has been going on for appx 1 yr and tends to happen more frequently.

UNKNOWN OR OTHER

A mechanic confirmed the truck has an issue with the speed sensor. On the daily, the truck will experience shifting issues, gets stuck in 3rd, and will not go past 5th. I have to turn off the vehicle and restart and it resets. I've read this is a known issue, and F150s for model years prior to and after 2015 have been recalled for this same thing. I also believe there are already a significant number of complaints for the 2015 model year for this exact issue. Please issue a recall.

VEHICLE SPEED CONTROL

A mechanic confirmed the truck has an issue with the speed sensor. On the daily, the truck will experience shifting issues, gets stuck in 3rd, and will not go past 5th. I have to turn off the vehicle and restart and it resets. I've read this is a known issue, and F150s for model years prior to and after 2015 have been recalled for this same thing. I also believe there are already a significant number of complaints for the 2015 model year for this exact issue. Please issue a recall.

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact purchased a 2015 Ford F-150. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 127,000 and at the time of registration, it was discovered that the mileage was 195,000.

POWER TRAIN

Having issues with lead frame. Truck is a 2015 F150 3.5 Ecoboost with the 6R80 transmission. Every so often the orange wrench appears and dash looses what gear and where it is in the column. Have taken pictures as well as pulled the codes that appear P0707, P0706, P1702. It will randomly happen from time to time. Currently buying all the parts to replace the issue part and seeing if there’s a recall for said part

VEHICLE SPEED CONTROL

Transmission randomly down shifts and then shifts back up a gear. Then speed control randomly drops and won’t respond

POWER TRAIN

Transmission randomly down shifts and then shifts back up a gear. Then speed control randomly drops and won’t respond

POWER TRAIN

My vehicle has the 6r80 transmission and has random down shift and up shift associated with a lead frame going bad in the transmission

STRUCTURE:FRAME AND MEMBERS

The contact owns a 2015 Ford F-150. The contact stated that while an independent mechanic was servicing the vehicle, the mechanic informed the contact that the frame was severely rusted, and the contact then noticed the failure. The mechanic informed the contact that water had intruded into the frame and had become stagnant at the lower point of the frame, causing the severe rust. The vehicle was taken to several auto body repair shops, where the contact was informed that the vehicle could not be repaired, and the failure could be related to a recall. The contact stated that CT Frameworks was contacted, and an appointment was scheduled for the frame repair. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 60,000.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that while driving approximately 75 MPH, the transmission erroneously downshifted from 6th gear to 1st gear, causing the vehicle to abruptly decelerate. The contact stated that after the failure, the transmission failed to shift out of 1st gear. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The local dealer was contacted, but no assistance was offered. The manufacturer was not yet contacted. The contact was made aware of NHTSA Action Number: PE25002 (POWER TRAIN). The contact stated that the vehicle had experienced the failure listed in the investigation. The failure mileage was 105,000. The VIN was not available.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that while driving 25 MPH, the transmission unexpectedly downshifted to 3rd gear, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. The message “Hill Start Assist Unavailable” was displayed, and the traction control warning light was illuminated. The message Automatic Cruise Active turned off was displayed. The contact stated that on another occasion, while driving at 20 MPH, the transmission unexpectedly downshifted. The contact stated that before the transmission downshifted, the accelerator pedal felt loose. The message “Hill Start Assist Unavailable” was displayed, and the traction control warning light was illuminated. The message Automatic Cruise Active turned off was displayed. The vehicle was taken to the dealer but was not diagnosed due to the cost. Most recently, the contact stated that while driving at a slow speed, the transmission unexpectedly downshifted. The contact stated that the vehicle stalled. The contact was able to restart the vehicle; however, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle was not diagnosed or repaired after the most recent failure. The manufacturer was not notified of the failure. The failure mileage was 124,950.

POWER TRAIN

The transfer case is leaking, caused by galvanic corrosion. Ford used steel bolts on the aluminum transfer case housing which created the corrosion.

UNKNOWN OR OTHER

The transfer case is leaking, caused by galvanic corrosion. Ford used steel bolts on the aluminum transfer case housing which created the corrosion.

ELECTRICAL SYSTEM

While driving at 60 mph my vehicle went from the 6th gear down to 1st gear on its own bringing the truck speed down very quickly the vehicle behind me almost hit me in the rear I pulled over speedometer stopped working and a imagine of a wrench was on the dashboard I cleared the wrench üîß image on the dashboard and tried to restart the truck turned the key and nothing happened tried again and truck started pulled out and started driving home 4 miles away and it happened again when I got home I googled it and found it is a known problem with the transmission in the 2015 ford f150 where the sensors in the transmission fail to read your speed and then reacts as if the vehicle is stopped so it then puts the transmission into 1st gear where it would be when you are stopped which creates a very dangerous situation especially if you are on a crowded road at higher speeds

POWER TRAIN

While driving at 60 mph my vehicle went from the 6th gear down to 1st gear on its own bringing the truck speed down very quickly the vehicle behind me almost hit me in the rear I pulled over speedometer stopped working and a imagine of a wrench was on the dashboard I cleared the wrench üîß image on the dashboard and tried to restart the truck turned the key and nothing happened tried again and truck started pulled out and started driving home 4 miles away and it happened again when I got home I googled it and found it is a known problem with the transmission in the 2015 ford f150 where the sensors in the transmission fail to read your speed and then reacts as if the vehicle is stopped so it then puts the transmission into 1st gear where it would be when you are stopped which creates a very dangerous situation especially if you are on a crowded road at higher speeds

POWER TRAIN

Transmission down shifts while accelerating, slips when starting from a dead stop, and shifts extremely hard when shifting. It is a safety risk especially when pulling out at an intersection, as it stops (or will slip) in the middle of the intersection. It has not been confirmed by the manufacturer or dealer, only by the article from USA Today. The vehicle has not been inspected by anyone, as it just started yesterday. There were no early indications or warning signs prior to it starting yesterday (08/06/2025).

POWER TRAIN

My transmission down shifts while driving and locks up my rear wheels. It almost caused me to wreck on the highway today.

POWER TRAIN

Erratic shifting of the transmission while driving. Dropped into lower gear causing me to skid on a wet surface. Luckily was only driving at 45 mph or it could have been worse or caused an accident.

POWER TRAIN

Galvanic corrosion of transfer case.

POWER TRAIN

I have 80,000 and my transmission went out driving up a mountain road No waring light no over heating it just stop going . My shop believes it was from the factory the trans pump went out.I see your looking into this year for trans problem.

POWER TRAIN

Transmission slips into third at high rate of speed exceeding 45 mph. Transmission will stay in third causing slow acceleration on turns.

POWER TRAIN:AUTOMATIC TRANSMISSION

The contact owns a 2015 Ford F-150. The contact stated that while driving on the highway at 65 MPH, the transmission downshifted to 1st gear from 6th gear, causing the rear wheels to lock up temporarily, and the check engine warning light illuminated. The contact pulled over and restarted the vehicle; however, while driving, the transmission only shifted from 3rd to 5th gear. The following day, the vehicle continued to drive normally through all the gears as designed. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that the transmission was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 115,000.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that while driving at 45 MPH, the gear shifter independently shifted out of the intended position. The check engine warning light was illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed, and determined that the transmission range sensor needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 24V444000 (POWER TRAIN); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 112,000.

STRUCTURE

The contact owns a 2015 Ford F-150. The contact stated that upon taking the vehicle for State Inspection, the contact was informed that the frame was severely rusted and that the vehicle would fail inspection. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 110,000.

POWER TRAIN

Seems to be the same Lead Frame issues as previous years. Rough downshifts, flickering gear indicator on the screen, shuts off when in park (not safety related) for short term, fails to initially crank after previous unintended shut off.

STEERING

For the past 3 days, I have had intermittent loss of steering from a power steering failure while driving on interstates/highways. Almost completely unable to steer it to safety on the side of the road. Ford has a recall(15S18), but I was told its vin-specific. My truck's vin does not fall under the recall, yet im having the same problems as the recall claims. Reaching out to see if this can be resolved and have a recall initiated. Thank you

VEHICLE SPEED CONTROL

The contact owns a 2015 Ford F-150. The contact stated that while driving 75 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the check engine warning light illuminated, and the vehicle stalled. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure; however, the contact was requested to pay a diagnostic fee. The contact stated that due to the persistent failure, the contact was fearful of driving the vehicle. The contact stated that the failure had occurred four times. The manufacturer was made aware of the failure, and a case was filed. The contact referenced an unknown recall; however, the VIN was not included in the recall. The contact was advised to contact the NNHTSA Hotline to report the failure. The failure mileage was approximately 80,000.

ENGINE

The contact owns a 2015 Ford F-150. The contact stated that while driving 75 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the check engine warning light illuminated, and the vehicle stalled. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure; however, the contact was requested to pay a diagnostic fee. The contact stated that due to the persistent failure, the contact was fearful of driving the vehicle. The contact stated that the failure had occurred four times. The manufacturer was made aware of the failure, and a case was filed. The contact referenced an unknown recall; however, the VIN was not included in the recall. The contact was advised to contact the NNHTSA Hotline to report the failure. The failure mileage was approximately 80,000.

VEHICLE SPEED CONTROL

i was driving my truck down the highway and all of a sudden my rears wheels locked up making me lose control of my truck take goodness i did'nt rollover no my transmission is shifting threw gears from 1st to 6th to 3rd this is my second f150 that i have had my old one had the same problem but my old one didnt lock up my tires my phone number is [XXX] [XXX] but please text because at work you cant use my phone my truck is parked in the garage im afraid to drive it need assistance in fixing it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

i was driving my truck down the highway and all of a sudden my rears wheels locked up making me lose control of my truck take goodness i did'nt rollover no my transmission is shifting threw gears from 1st to 6th to 3rd this is my second f150 that i have had my old one had the same problem but my old one didnt lock up my tires my phone number is [XXX] [XXX] but please text because at work you cant use my phone my truck is parked in the garage im afraid to drive it need assistance in fixing it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

Began experiencing hard shifting unexpectedly. Took it into dealership and they advised my lead frame assembly needed replacement. In research, I found this is currently under investigation by the NHTSA's office for my year and transmission model.

FUEL/PROPULSION SYSTEM

While parked and shut off at a gas station in Lakeside, CA, my 2015 Ford F‚Äë150 XLT spontaneously caught fire under the hood. The fire appeared to originate in the fuse box area, specifically where the fuel pump relay is integrated. The incident posed significant risk, occurring near a fuel pump while my child was in the vehicle. A gas station employee assisted with extinguishing the fire. The cause is believed to be an electrical short. There were no modifications or recent repairs.

ELECTRICAL SYSTEM

While parked and shut off at a gas station in Lakeside, CA, my 2015 Ford F‚Äë150 XLT spontaneously caught fire under the hood. The fire appeared to originate in the fuse box area, specifically where the fuel pump relay is integrated. The incident posed significant risk, occurring near a fuel pump while my child was in the vehicle. A gas station employee assisted with extinguishing the fire. The cause is believed to be an electrical short. There were no modifications or recent repairs.

UNKNOWN OR OTHER

The engine while operating at normal speed loses power to a rough idle and is remedied by putting the vehicle in park and restarting the engine. The engine never fails to start after restarting, but could fail at any moment, short or long term.

ELECTRICAL SYSTEM

The engine while operating at normal speed loses power to a rough idle and is remedied by putting the vehicle in park and restarting the engine. The engine never fails to start after restarting, but could fail at any moment, short or long term.

ENGINE

The engine while operating at normal speed loses power to a rough idle and is remedied by putting the vehicle in park and restarting the engine. The engine never fails to start after restarting, but could fail at any moment, short or long term.

POWER TRAIN

First time this incident happened (around April 2025) while driving on the highway. Going about 70 mph and the truck dropped down into second or first gear almost causing an accident. Had to pull over on the side of the road. Check engine light was on the dash. Turned off the truck And let it sit a little bit and restarted it and it seemed to be OK. This most recent incident happened on Saturday, July 5th 2025 , truck kept dropping down into first gear and then just would not go anywhere. Had it towed to Auto clinic and they diagnosed the truck with not recognizing the gear selection position. They stated that this truck should have fell under the recall status for 2015-2017 f150’s as it is doing the exact same thing that they have seen many trucks get fixed for because of the recall. The Auto clinic recommended I file a safety report and also contact Ford.

ENGINE

The contact owns a 2015 Ford F-150. The contact stated that while operating the vehicle, the check engine warning light remained illuminated. The vehicle was taken to an independent mechanic who replaced the catalytic converter and Oxygen sensors. The vehicle was repaired; however, the failure reoccurred. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure and informed the contact that the vehicle was not under an Extended Warranty coverage related to the failure. The failure mileage was 90,000.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

The contact owns a 2015 Ford F-150. The contact stated that while operating the vehicle, the check engine warning light remained illuminated. The vehicle was taken to an independent mechanic who replaced the catalytic converter and Oxygen sensors. The vehicle was repaired; however, the failure reoccurred. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure and informed the contact that the vehicle was not under an Extended Warranty coverage related to the failure. The failure mileage was 90,000.

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

The contact owns a 2015 Ford F-150. The contact stated that the front passenger's side and seat heater and cooler were inoperable. The contact stated that upon inspecting underneath the passenger's side seat, the contact noticed that the module wiring was burned and melted. The vehicle was taken to the dealer, where it was determined that the wiring and a connector underneath the front passenger's side seat had melted. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 120,000.

ELECTRICAL SYSTEM

The contact owns a 2015 Ford F-150. The contact stated that the front passenger's side and seat heater and cooler were inoperable. The contact stated that upon inspecting underneath the passenger's side seat, the contact noticed that the module wiring was burned and melted. The vehicle was taken to the dealer, where it was determined that the wiring and a connector underneath the front passenger's side seat had melted. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 120,000.

ELECTRICAL SYSTEM

electronic throttle body has failed and been replaced 2 times in 51756 miles. when failure occurs while in traffic truck engine loses power leaves me in dangerous situation. The latest time was [XXX] at 51756 miles in the mountains of Colorado. Repair done at Mike Maroone Ford of Longmont, Colorado. Feel this should be a recalled part. No prior warning before failure occured00 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

BACK OVER PREVENTION

The contact owns a 2015 Ford F-150. The contact stated that the rearview camera displayed a distorted image while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. In addition, the screen had turned black, but the alarm beeped as designed. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unavailable.

ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL

The contact owns a 2015 Ford F-150. The contact stated that while towing a trailer and driving approximately 30 MPH, the electronic trailer braking system erroneously activated, causing the vehicle to abruptly stop. The contact stated that minutes later there was a burning odor inside the cabin of the vehicle. The contact removed the main fuse, and the electronic trail brake was released. The contact determined that the Electronic Trailer Brake Control Module had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 94,000.

ENGINE

Problem: Engine unexpectedly goes to idle speed after accelerating up to highway speeds. Cruise control was not engaged at time of failure. This has happened three times, all after a cold start up, and all within 2 miles of home. The most recent occurrence being 6-19-25. At time of failure, multiple warning screens come up on the dash, including "Hill Start Assist Not Available", "Service Advance Trac", "See Manual" (with a picture of a wrench). No check engine light comes on, and no error codes are set. Engine does not respond to accelerator pedal, engine will only idle roughly. When this occurs, the only remedy is to pull over to the side of the road, shut off the engine, then restart the vehicle. Each time this has happened, the engine starts and runs normally with all warning messages cleared from dash. Safety Concern: Unexpected loss of power can increase the likelihood of an accident, especially in heavy traffic. This truck is used frequently for towing, and an unexpected loss of power can create a loss of trailer control. Dealer Contact: Last September when this issue initially cropped up, the truck was taken to our Ford dealer for diagnosis. They kept the truck for approximately two weeks, driving it daily without having the issue reoccur. They performed diagnostics on electronic modules but found no concrete issue. Inspection: Truck has not been inspected by the manufacturer, only the dealer. Warning Lamps and Messages: "Hill Start Assist Not Available", "Service Advance Trac", "See Manual" (with a picture of a wrench)

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that while driving at various speeds, the transmission was slipping while downshifting from 5th to 4th gear while attempting to slow down, causing the rear tires to lock up momentarily. Additionally, the front differential made an abnormal sound. There was no warning light illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was advised that the forward clutch and the transmission were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 128,350.

UNKNOWN OR OTHER

Broken clock spring

POWER TRAIN

Transmission constantly shifts erratically. When this happens, the transmission gets stuck between 3rd and 5th gears and sometimes only stays in 5th gear, no matter how fast the truck is going or even if it is not moving. About half the time when this happens it causes a rough "jerk" and could cause loss of control. If you must stop at a stop sign or stop light when this happens then you're impeding traffic just trying to get back up to speed after your stop, which could lead to an accident. This also causes the check engine light to come on.

VEHICLE SPEED CONTROL

Today, [XXX] while driving at highway speed this vehicle experienced a unrequested transmission downshift, from 6th to 3rd, causing unexpected rapid vehicle deceleration. I was located in the center lane of an Interstate and travelling at 70 mph when this incident happen which force the traffic behind me to take rapid accident avoidance actions. I did not hear any audible or see any visual warnings that this incident was about to happen. This vehicle will be taken to Starling Ford located at 3000 Cheney Hwy, Titusville, Fl 32780 on June 16, 2025. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

Today, [XXX] while driving at highway speed this vehicle experienced a unrequested transmission downshift, from 6th to 3rd, causing unexpected rapid vehicle deceleration. I was located in the center lane of an Interstate and travelling at 70 mph when this incident happen which force the traffic behind me to take rapid accident avoidance actions. I did not hear any audible or see any visual warnings that this incident was about to happen. This vehicle will be taken to Starling Ford located at 3000 Cheney Hwy, Titusville, Fl 32780 on June 16, 2025. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

Truck is at 135,000 miles and needs its 3rd oil pan due to faulty engineering. Ford is not covering repairs or offering assistance for previously repaired products. I bought truck certified pre-owned with extended warranty. The oil pan was cracked at that time and needed to be replaced at first service. On average oil pans are lasting less then 70,000 miles. How is this allowed to continue to occur.

VISIBILITY:GLASS, SIDE/REAR

The contact owns a 2015 Ford F-150. The contact stated while the driving at an undisclosed speed, there was an abnormal sound coming from the rear sliding glass. The contact stated that the rear sliding glass frame had fractured. The fractured frame caused the rear sliding glass to push out from the frame. Additionally, the contact stated that due to the failure, water was entering into the rear of the vehicle. The dealer was made aware of the failure and provided the contact with the cost for the diagnostic test. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 50,000.

ENGINE

Intake manifold actuator fails prematurely. Code P2007 and P2005

POWER TRAIN

Transmission is downshifting at high speeds unexpectedly and without apparent cause. Ford has issued a recall already for the same year and model for the same issue, but my VIN is not associated with the recall.

POWER TRAIN

At highway speeds, under moderate acceleration, the vehicle downshifts unexpectedly. It causes sudden loss of torque. Has happened when trying to overtake and caused sudden vehicle deceleration in the passing lane, which is dangerous.

UNKNOWN OR OTHER

This vehicle was purchased by a friend with the factory tow package. No modifications were made before my purchase three years ago. I installed a factory brake controller for a travel trailer I purchased. The software was enabled with Forscan, and the dealer updated the software to the latest available. Even with a new seven way plug, the truck displays "trailer disconnected" when using the slide brake and also never shows any output when braking. The brakes do engage but very mildly. The travel trailer brakes normally on my other vehicle. There are no fault codes and no obvious connection issues. The dealership today said they do no know the cause and would likely be unable to resolve it.

ELECTRICAL SYSTEM

This vehicle was purchased by a friend with the factory tow package. No modifications were made before my purchase three years ago. I installed a factory brake controller for a travel trailer I purchased. The software was enabled with Forscan, and the dealer updated the software to the latest available. Even with a new seven way plug, the truck displays "trailer disconnected" when using the slide brake and also never shows any output when braking. The brakes do engage but very mildly. The travel trailer brakes normally on my other vehicle. There are no fault codes and no obvious connection issues. The dealership today said they do no know the cause and would likely be unable to resolve it.

SERVICE BRAKES

This vehicle was purchased by a friend with the factory tow package. No modifications were made before my purchase three years ago. I installed a factory brake controller for a travel trailer I purchased. The software was enabled with Forscan, and the dealer updated the software to the latest available. Even with a new seven way plug, the truck displays "trailer disconnected" when using the slide brake and also never shows any output when braking. The brakes do engage but very mildly. The travel trailer brakes normally on my other vehicle. There are no fault codes and no obvious connection issues. The dealership today said they do no know the cause and would likely be unable to resolve it.

LANE DEPARTURE: BLIND SPOT DETECTION

On or around May 28, 2024. My husband and, I were going to a recital. He was already in the truck.I told him. Pick me up at the mailbox.( I had mail to go in box).I started walking down the driveway(paved). The next thing, I was on the cement screaming. I had been hit, with the truck. My husband ran to help. He said, he didn’t see me. And, the beepers ( sensors)didn’t go off.Rescue was called, checked me out. Did not transport. But, I went to hospital later. Bruises and a broken right arm. Several weeks went by. I really didn’t believe the sensors,didn’t work.We were in a parking spot. But, the truck in reverse. Waited for people to go by. Sometimes it worked, sometimes it didn’t. We did see people on the camera. Recently, I was behind the truck again. The sensors did not go off! We are very cautious now. Aware of the problem. Why hasn’t this truck been in the recall lists?. The accident was visible on our ring. I have video. But could not figure out to download. I can sent by email.

VEHICLE SPEED CONTROL

The transmission jumps gears at any speed, I was researching the topic and saw the NHTSA is probing some F150s for a similar problem. And I was wondering if my vehicle was in the affected line of production.

POWER TRAIN

The transmission jumps gears at any speed, I was researching the topic and saw the NHTSA is probing some F150s for a similar problem. And I was wondering if my vehicle was in the affected line of production.

POWER TRAIN

an unrequested transmission downshift that allegedly causes the vehicle to decelerate rapidly.

ENGINE

The contact owns a 2015 Ford F-150. The contact stated that while driving in cold weather and attempting to depress the brake pedal, there was a rattling sound coming from the engine. The contact stated that the check engine warning light was illuminated. A dealer was contacted. The vehicle was taken to a dealer where it was diagnosed and determined that the rattling sound was coming from the cam phasers and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact was transferred to NHTSA Hotline to report the failure. The approximate failure mileage was 116,000.

UNKNOWN OR OTHER

Upper rail for sliding rear window came off causing the rear slider to fall into the back seat. This is a known problem with 2015 and newer F150's with a rear sliding windows. Ford refuses to acknowledge the issue and take responsibility for it. It is a failure of the adhesive that holds the top rail for the slider to the window.

ENGINE

Truck down shifts hard while driving. Hill assist warning light comes on and truck goes into limp mode and looses power going 60 mph. Pull over truck runs very rough. Turn truck off and back on screen says hill assist not available. Press ok and truck runs normal again. Happens every few days. Definitely could be dangerous if it happens on a bigger highway. Has happened 5 times over last few weeks at different speeds.

ELECTRICAL SYSTEM

Truck down shifts hard while driving. Hill assist warning light comes on and truck goes into limp mode and looses power going 60 mph. Pull over truck runs very rough. Turn truck off and back on screen says hill assist not available. Press ok and truck runs normal again. Happens every few days. Definitely could be dangerous if it happens on a bigger highway. Has happened 5 times over last few weeks at different speeds.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated while driving 65 MPH and depressing the accelerator pedal, the vehicle failed to respond as needed. The contact was able to coast over to the right side of the road and waited for tow assistance. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and opened a case. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was 96,000.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that while driving at various speeds, the transmission unexpectedly downshifted. The contact stated that during the failure, the check engine, and service warning lights were illuminated. Additionally, the transmission failed to shift into 2nd and 3rd gear, making it difficult to haul a trailer. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the transmission lead frame needed to be replaced. The vehicle was not yet repaired. The contact was informed of NHTSA Action Number: PE25002. The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was approximately 95,000.

POWER TRAIN

When traveling down a steep hill at about 35 mph I shifted from drive to 3rd for engine braking, the truck went into first gear instead of 3rd and the rear wheels temporarily slid/screeched. I did it before without issues but I never did that again as I’m afraid of damaging something.

POWER TRAIN

Shortly after I bought the vehicle in 2015, the transmission would frequently make a loud metal on metal sound when accelerating as the transmission downshifted from 5 gear to 3rd. I took it to the dealer several times. They said it was a manufacturers fault from a bad batch of transmissions and not something the dealer could permanently fix or was responsible for. No other indications. I am concerned the transmission could lock up and cause an accident. Date of the incidents is from November 2015 to present.

POWER TRAIN

Driving home today, my truck just started downshifting without warning. My truck was almost rear ended. I had about 5 min until I got home. It would take off and drive fine for a moment, and then out of nowhere drop all the way down to first gear. Very dangerous!

WHEELS:HUB

The contact owns a 2015 Ford F-150. The contact stated while driving at highway speeds, there was a hissing sound coming from the steering column. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The failure persisted, and the vehicle was taken back to the dealer to be diagnosed. The contact was informed that the front driver side wheel hub and vacuum line to the integrated wheel end (IWE) actuator were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 30,000.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated while driving at highway speeds, there was a hissing sound coming from the steering column. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The failure persisted, and the vehicle was taken back to the dealer to be diagnosed. The contact was informed that the front driver side wheel hub and vacuum line to the integrated wheel end (IWE) actuator were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 30,000.

POWER TRAIN

Lead body failure. Causing it to downshift suddenly when driving, higher rpm, and non-start condition.

ELECTRICAL SYSTEM

Lead body failure. Causing it to downshift suddenly when driving, higher rpm, and non-start condition.

VEHICLE SPEED CONTROL

I noticed in the fall of 2024 that my transmission stared shifting hard between 30-40 mph during acceleration. I had the local Ford dealership check out the issue and they stated I needed a new transmission and included an estimate. I decided to seek information from 2 independent transmission shops and they could not confirm that I needed the transmission replaced at that time. The vehicle has been driving fine and I recently started to notice the hard shift again at 30 mph. Every once in a while, when the hard shift occurs, it seems like I lose power to the drive train and my vehicle slows down to about 15 mph and vehicles need to go around me. It only lasts for a few seconds and then the acceleration will continue to drive normal. I do notice an increase in RPM's from time to time as well while shifting around 30 mph but does not feel like it is slipping. Once through this area of shifting, the vehicle operates normally shifting through other gears. There were no warning lights or other symptoms leading to this issue. I did notice that there was an article posted with a possible transmission issue from this year vehicle that is being investigated concerning sudden down shifting while driving. Here is the article [XXX]. I am wondering if this is part of this issue? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

I noticed in the fall of 2024 that my transmission stared shifting hard between 30-40 mph during acceleration. I had the local Ford dealership check out the issue and they stated I needed a new transmission and included an estimate. I decided to seek information from 2 independent transmission shops and they could not confirm that I needed the transmission replaced at that time. The vehicle has been driving fine and I recently started to notice the hard shift again at 30 mph. Every once in a while, when the hard shift occurs, it seems like I lose power to the drive train and my vehicle slows down to about 15 mph and vehicles need to go around me. It only lasts for a few seconds and then the acceleration will continue to drive normal. I do notice an increase in RPM's from time to time as well while shifting around 30 mph but does not feel like it is slipping. Once through this area of shifting, the vehicle operates normally shifting through other gears. There were no warning lights or other symptoms leading to this issue. I did notice that there was an article posted with a possible transmission issue from this year vehicle that is being investigated concerning sudden down shifting while driving. Here is the article [XXX]. I am wondering if this is part of this issue? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

A recent recall on F250’s, 350’s and other ford fleets on the reverse camera not operating intermittently. It’s a known issue. I reported it to my local ford dealer back in 2019 and they said I would need to drop the truck off for over a week just for diagnosis. Single vehicle family here. It’s a big loss of situational awareness in areas like parking lots and with more people walking around with their phones in their faces like zombies, and with the camera inoperative, has greater potential of loss of life or damage to property.

UNKNOWN OR OTHER

Driving with cruise control engaged, on dry road, no significant weather or wind gust, cruise control disengaged. Tried to reengage but took numerous tries. Once engaged, Tried to CNCL the cruise control and it would not disengage. Had to jump on the brakes. Seconds matter.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

The contact owns a 2015 Ford F-150. The contact stated that while driving at undisclosed speeds, there was a misfire coming from the engine. The contact stated that the ignition coils had melted and were replaced four times. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the PCM needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 153,000.

ENGINE

The contact owns a 2015 Ford F-150. The contact stated that while driving at undisclosed speeds, there was a misfire coming from the engine. The contact stated that the ignition coils had melted and were replaced four times. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the PCM needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 153,000.

ENGINE

Pulled into traffic and car had sudden loss of power, several alerts showed up and car could not move and just idled.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that the vehicle failed to shift out of the drive as needed. The vehicle was taken to an independent mechanic, where it was diagnosed that the speed sensor in the transmission needed to be replaced. The vehicle was not repaired. The contact stated that a software update was performed for the rear-view camera. The manufacturer was notified of the failure but offered no assistance. The contact related the failure to NHTSA Campaign Number: 24V444000 (POWER TRAIN); however, the VIN was not included in the recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 140,000.

POWER TRAIN

The transmission will downshift from 6th to 5th at hwy speed....it also at other times , will only go from 1st to 2nd gear and no farther...wrench light comes on each time.I have to pull off hwy and slowly try to take off to get transmission to shift correctly. A lot of times pulling to side of road puts me in a dangerous situation.When it won't shift past 2nd gear I have to try to pull over immediately as it over-revs.I am taking it to an independent service center and dropping it off for their confirmation as sometimes tranny will shift fine for 2-3 days and then go back to malfunctioning. It started this about a year ago, but I had neck surgery then and am now just getting back to driving.The wrench light comes on each time , along with the transmission fan.The truck is available for inspection any time.

POWER TRAIN

Vehicle suddenly downshifts into a lower gear while accelerating from a stop or cruising at constant speed. Wrench icon comes on the dash and check engine light comes on. Turning off the engine and back on will stop the issue and restore the power.

ENGINE

The contact owns a 2015 Ford F-150. The contact stated that while the vehicle was at the dealer for routine service, the contact was informed that the engine oil pan was faulty, and oil was leaking from the oil pan. The contact was informed that the oil pan needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 33,000. The VIN was not available.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated while driving at approximately 70 MPH, the vehicle shuddered and unexpectedly downshifted. The contact pulled over to the side of the road and waited for several minutes until the vehicle had returned to normal operation. The failure had occurred on several occasions. No warning lights were illuminated. The vehicle was taken to a dealer to be diagnosed. The dealer made the contact aware of an undisclosed recall however, the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 120,000.

UNKNOWN OR OTHER

Transmission abruptly shifted down from high gear to low gear causing it to lock up at a fast speed. My son hit his chest on steering wheel bc it was so abrupt

POWER TRAIN

Transmission abruptly shifted down from high gear to low gear causing it to lock up at a fast speed. My son hit his chest on steering wheel bc it was so abrupt

ENGINE

Transmission abruptly shifted down from high gear to low gear causing it to lock up at a fast speed. My son hit his chest on steering wheel bc it was so abrupt

UNKNOWN OR OTHER

Sunroof was replaced under warranty due to track being broken. Now the sunroof is leaking and the shade will not open. There has been several recalls for sunroof issues. Dealership says my vin is not included. This seems to me to be a recall issue for safety. If the sunroof is broken it could cave in or fly off. Especially since it is leaking and won’t open and cannot see the problem. Dealership wants to charge me over $200 just to look at it. This is unacceptable.

POWER TRAIN:AUTOMATIC TRANSMISSION

The contact owns a 2015 Ford F-150. The contact stated while driving 20 MPH and crossing an intersection, the accelerator was depressed and there was an abnormal sound coming from the transmission. The contact stated that the transmission unexpectedly shifted out of the intended gear into neutral(N). The “Service Vehicle Soon” warning light was illuminated. The vehicle was taken to an independent mechanic where the vehicle was diagnosed, and the contact was informed that the valve body plate was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.

UNKNOWN OR OTHER

My truck downshifted into 2nd gear after i was in 6th gear, now my transmission is slipping into 4th gear. But when i press the accelerator a little harder it’ll shift better but it’s not practical in a city

POWER TRAIN

I was driving down a mountain road and the truck downshifted. At a speed of 70 mile an hour. Very scary for sure.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that while his son was driving 60 MPH on the highway, the transmission unexpectedly downshifted into second gear while depressing the accelerator pedal. The contact stated that an unknown warning light had illuminated. The accelerator pedal was depressed again however, the vehicle remained in first gear. The vehicle was taken to an independent mechanic to be diagnosed and the contact was informed that the OSS sensor on the transmission needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 125,000.

POWER TRAIN

The transmission is a safety issue and is available for inspection. The six speed automatic has a 5th to 4th downshift that is regularly rough and can be jarring at times. A few weeks ago on my way home from work while driving 30 mph around a small bend the truck shifted from 4th to 2nd on its own and bucked so hard that it scared me and brought my hands off the steering wheel and made my back sore for the next day. This is a blind bend because of the shrubbery in the front yard at the bend and it is also at the beginning of a school zone. This could've been a worse situation if there would've been a car or school bus going in the opposite direction. This was certainly the worst one yet but there have been similar situations where the truck jarringly shifted from 4th to 3rd on its own. The problem has not been reproduced, confirmed or inspected as mentioned above. I have read multiple stories stating very similar or even the same occurrences on the forums. The lead frame in the transmission seems to be the leading cause for this issue. Others have been to the dealer, had the computer reflashed and were told it just needs to relearn their driving, only to have the issue return. After seeing these stories and now reading about the investigation into the issue I've been holding off to see what happens as I do not want to waste time and money to not have the issue fixed. There were not any warning lamps, etc before or after this issue. I have noticed that when the jarring shifts occur the small area of the cluster that shows gears one through six goes black and remains that way until manually pressing the button on the shifter to make the image reappear. To this point these shifting issues almost always occur at low speeds while gently resting my foot on the gas to keep a steady speed. It feels as though the transmission shifts into fifth too early, the rpms slowly lower and then it downshifts to fourth in a jarring manner.

POWER TRAIN

2015 Ford F150 XLT 2.7L, 6 speed auto, Crew CAB, short bed. Yes, you can inspect. Going down highway around 45-50 MPH, without warning or warning indicators, transmission suddenly downshifted, rear wheels locked momentarily, RPM's ran up high and vehicle slowed down abruptly in the middle of traffic. Wrench light on dash appeared and disappeared. About 5 minutes later driving on freeway, transmission would not automatically shift up to the next gear, stayed in a low gear for a minute, then finally shifted up. Vehicle is currently at Ford getting inspected. Did not drive the vehicle since the incident on 3-29-24, except to go to the Ford dealer.

POWER TRAIN

Transmission malfunction by sudden downshifting to first gear at highway speeds. This caused my rear wheels to lock up and skid as if I had slammed on the brakes and temporary lose control of the vehicle, which is extremely dangerous on the highway. It has occurred multiple times. There were no warning lights the first several times this happened. They check engine light did come on after about the 6th time it occurred.

POWER TRAIN

While driving at random times trans will go into a limp mode and have only 3 gear speeds. Sometimes either a wrench symbol will come up or a check engine light will come one. When this happens it’ll stay in a limp mode til ignition is cycled for it to reset. Also while at low speeds it has dropped me from 4th gear to 1st.

POWER TRAIN

I have owned my 2015 F150 SPORT 2.7 ECO BOOST since it was new, and occasionally it downshift's mainly in town from 5th gear to 1st gear. I thought this was my fault until I heard about the safety concern. I have mentioned it to ford, but was told that downshift's were normal? Anyway I an now concerned this could happen on the interstate which I don't drive on regularly. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

It’s been several times that I’ll be driving, sometimes on residential roads and once getting onto the highway. The transmission will suddenly drop down into first gear and I’ll have to limp off the side of the road until I’m going slow enough to be in first gear, then I can go again. Or I’ll lose 1,2 and 6th gears so I’ll have to pull over, turn the truck off and start it again. Then I’ll have gears 1-6 again.

ENGINE

I was driving at around 45mph and my truck suddenly downshifted automatically and almost brought me to a complete stop. It finally shifted back up and I was able to return to the proper speed. If this would have happened at higher speeds I could have been in an accident. Event at 45mph, had I not had my seatbelt on it would have thrown me into the steering wheel.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that while her husband was driving 35 MPH, the transmission downshifted to a lower gear unexpectedly. There were no warning lights illuminated. The contact stated that initially, the vehicle would sporadically downshift to a lower gear. After a year, the vehicle started to sporadically downshift more frequently. The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission needed to be replaced. The vehicle was repaired with the installation of a new transmission. The dealer was not made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

ENGINE

Truck will on occasion downshift into a low gear out of nowhere and feels like the rear axle is going to rip out of the truck.

ENGINE

Broken exhaust bolt on passenger manifold. Exhaust leak... Felt as though Carbon monoxide gas was entering cabin portion of truck. Smelling of exhaust in cabin of vehicle. Made wife and kids nauseated and lightheaded. Did research and found out that ford had a poorly designed manifolds and didn't utilize all exhaust bolts. In turn caused the #8 bolt to snap and manifold to warp and release exhaust fumes

POWER TRAIN

Truck while turning right or forward will for no reason goes into lost traction(dry road) and truck downshifts and loses power. Very dangerous as there is no warning and potentially can be hit from behind since no brake lights are engaged. Recently read article that other trucks of this year and make are having same issue. I have taken into shop and awaiting what is the problem.

ENGINE

I have had the gasket for the oil pan fix two times. It is leaking again and told by ford that it will happen again. It is 1200 to have it fixed plus they have to keep it for a few days to make sure the seal is dry. If you do not check the oil all the time it could be low and lock up. I know other people that have had this problem. It is on the 2.7 Eco boost.

POWER TRAIN

Transmission downshift during constant cruise speed.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that while driving approximately 70 MPH, the transmission unexpectedly downshifted from 5th gear to 2nd gear, causing the vehicle to abruptly decelerate. During the failure, the driver almost lost control of the steering wheel and the rear wheels locked up and the vehicle skidded. The contact stated that while driving at various speeds, the failure recurred, and the wrench icon was displayed. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was made aware of NHTSA Action Number: PE25002 (POWER TRAIN). The contact stated that the vehicle had experienced the failure listed in the NHTSA Action Number. The failure mileage was 202,000.

ELECTRICAL SYSTEM

The contact owns a 2015 Ford F-150. The contact stated that while driving 60 MPH on several occasions with or without the cruise control feature activated, the transmission unexpectedly downshifted to first gear, and the rear wheels locked up. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the transmission circuit board and valve body assembly needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 105,000.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated that while driving 60 MPH on several occasions with or without the cruise control feature activated, the transmission unexpectedly downshifted to first gear, and the rear wheels locked up. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the transmission circuit board and valve body assembly needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 105,000.

VEHICLE SPEED CONTROL:CRUISE CONTROL

The contact owns a 2015 Ford F-150. The contact stated that while driving approximately 70 MPH with the cruise control activated, the vehicle independently decelerated while driving next to other vehicles. No warning lights were illuminated. The vehicle was taken to a local dealer where unknown repairs were performed. The vehicle was repaired; however, approximately 7 years after repairs the failure reoccurred. The vehicle was taken to the same local dealer where unknown repairs were made. The manufacturer was not made aware of the failure. The failure mileage was approximately 25,000.

POWER TRAIN

The contact owns a 2015 Ford F-150. The contact stated while driving approximately 65 MPH, the transmission unexpectedly downshifted to third gear almost causing the contact to lose control of the vehicle. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact stated that prior to the failure the vehicle was hesitating while depressing the accelerator pedal. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 24V444000 (Power Train); however, the VIN was not included in the recall. The failure mileage was approximately 200,000.

ELECTRICAL SYSTEM

A few years back, I was having an issue with my truck shifting hard. I actually took it to a friend's shop and he repaired it, for about $1600. They changed a "chip" in it. The vehicle was never inspected by Ford, or the police, or my insurance company. The problem was identified by the repair shop and taken care of, or so I thought. The issue seemed fixed for a while but within the last year the issue has begun again. The transmission will not shift at times. It seems stuck, which causes the engine to rev very high. I worry about causing lasting damage to the engine as a result of the transmission sticking.

POWER TRAIN

A few years back, I was having an issue with my truck shifting hard. I actually took it to a friend's shop and he repaired it, for about $1600. They changed a "chip" in it. The vehicle was never inspected by Ford, or the police, or my insurance company. The problem was identified by the repair shop and taken care of, or so I thought. The issue seemed fixed for a while but within the last year the issue has begun again. The transmission will not shift at times. It seems stuck, which causes the engine to rev very high. I worry about causing lasting damage to the engine as a result of the transmission sticking.

ENGINE

I was traveling [XXX] near Liverpool, PA at 60mph, the truck flashed a quick code on the dash and then suddenly downshifted from 6th gear to 1st almost spinning the truck as the rear wheels locked up momentarily. It would not upshift past 3rd gear and had to travel 35 miles home like that. I called my local Ford dealer (Parsons) and they said bring the truck in for diagnostic testing, so I did. Meanwhile I searched the internet to see if others had the issue. Turns out they did, BUT my 2015 with the 6R80 was NOT in the recall notice. Ford said it was the lead frame and needed to be replaced. IF it was a known problem, why not inform owners of these trucks. That said, Ford wanted $1500 to fix it, BUT they did not have the part. So I drove the truck (never with my family in it ever again) after I cleared the code with my reader...again traveling [XXX] @ 75mph it downshifted IN TRAFFIC. Luckily I was in the right lane and made a quick move to the shoulder to avoid being run over. In Carlisle, PA there are hundreds of trucking companies and warehouses, so the truck traffic is very heavy. That was it. I searched out the part, paid for it myself and had a Ford mechanic that does work on the side fix the truck. I have been a loyal Ford guy for over 30 years...I reached out to Ford via telephone, chat and even Facebook. All they say is it is NOT under any recall. Hard to swallow that when I am driving a $75K truck THEY built and they will NOT stand behind a $2K fix. Well goodbye Ford, as a business owner for over 25 years. If I make an error I fix it NO MATTER what. I gave Ford the opportunity to stand behind truck and they did...JUST FAR behind it and passed me as I sit on the shoulder of the road. This in my opinion INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VEHICLE SPEED CONTROL

I was traveling [XXX] near Liverpool, PA at 60mph, the truck flashed a quick code on the dash and then suddenly downshifted from 6th gear to 1st almost spinning the truck as the rear wheels locked up momentarily. It would not upshift past 3rd gear and had to travel 35 miles home like that. I called my local Ford dealer (Parsons) and they said bring the truck in for diagnostic testing, so I did. Meanwhile I searched the internet to see if others had the issue. Turns out they did, BUT my 2015 with the 6R80 was NOT in the recall notice. Ford said it was the lead frame and needed to be replaced. IF it was a known problem, why not inform owners of these trucks. That said, Ford wanted $1500 to fix it, BUT they did not have the part. So I drove the truck (never with my family in it ever again) after I cleared the code with my reader...again traveling [XXX] @ 75mph it downshifted IN TRAFFIC. Luckily I was in the right lane and made a quick move to the shoulder to avoid being run over. In Carlisle, PA there are hundreds of trucking companies and warehouses, so the truck traffic is very heavy. That was it. I searched out the part, paid for it myself and had a Ford mechanic that does work on the side fix the truck. I have been a loyal Ford guy for over 30 years...I reached out to Ford via telephone, chat and even Facebook. All they say is it is NOT under any recall. Hard to swallow that when I am driving a $75K truck THEY built and they will NOT stand behind a $2K fix. Well goodbye Ford, as a business owner for over 25 years. If I make an error I fix it NO MATTER what. I gave Ford the opportunity to stand behind truck and they did...JUST FAR behind it and passed me as I sit on the shoulder of the road. This in my opinion INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

I was traveling [XXX] near Liverpool, PA at 60mph, the truck flashed a quick code on the dash and then suddenly downshifted from 6th gear to 1st almost spinning the truck as the rear wheels locked up momentarily. It would not upshift past 3rd gear and had to travel 35 miles home like that. I called my local Ford dealer (Parsons) and they said bring the truck in for diagnostic testing, so I did. Meanwhile I searched the internet to see if others had the issue. Turns out they did, BUT my 2015 with the 6R80 was NOT in the recall notice. Ford said it was the lead frame and needed to be replaced. IF it was a known problem, why not inform owners of these trucks. That said, Ford wanted $1500 to fix it, BUT they did not have the part. So I drove the truck (never with my family in it ever again) after I cleared the code with my reader...again traveling [XXX] @ 75mph it downshifted IN TRAFFIC. Luckily I was in the right lane and made a quick move to the shoulder to avoid being run over. In Carlisle, PA there are hundreds of trucking companies and warehouses, so the truck traffic is very heavy. That was it. I searched out the part, paid for it myself and had a Ford mechanic that does work on the side fix the truck. I have been a loyal Ford guy for over 30 years...I reached out to Ford via telephone, chat and even Facebook. All they say is it is NOT under any recall. Hard to swallow that when I am driving a $75K truck THEY built and they will NOT stand behind a $2K fix. Well goodbye Ford, as a business owner for over 25 years. If I make an error I fix it NO MATTER what. I gave Ford the opportunity to stand behind truck and they did...JUST FAR behind it and passed me as I sit on the shoulder of the road. This in my opinion INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

Full transmission failure after switching to 4 high on snowy highway. Speed during shift was about 50 mph. We were left stranded on a busy highway outside of Steamboat Springs, CO in wintry conditions for almost 2 hours while waiting for roadside assistance. Vehicle was towed to Phil Long Ford in Littleton, CO. There was no warning on the dashboard until the “wrench” light went on as the truck lost power. The mileage on the vehicle at the time of incident was 100,368. Response from Ford was that the vehicle was beyond the warranty period. I was given a repair estimate of $9701.90 plus an inspection bill of $250.00. The truck has been towed to an independent garage for a new transmission. I have not been given an explanation for the transmission failure as yet. ( date of event: [XXX]) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The contact owns a 2015 Ford F-150. The contact stated while driving at various speeds, the vehicle failed to maintain the desired speed while the accelerator pedal was depressed. Several unknown warning lights were illuminated. The vehicle was taken to a local independent mechanic, where it was diagnosed; however, the cause of the failure was unknown. The contact stated that unknown repairs were completed by the local independent mechanic. The vehicle was repaired but the failure reoccurred. The vehicle was scanned with an OBD2 scanner and DTC: P061C was retrieved. The local dealer was contacted. The vehicle was not diagnosed or repaired for the recent failure. The manufacturer was made aware of the failure. The failure mileage was approximately 147,000.

POWER TRAIN

The transmission will down shift without warning. It has occurred 4 times in the last 60 days. Near miss accident in one occasion.

VEHICLE SPEED CONTROL

[XXX]: check engine light was on and codes P2196 and P2198 were present. The dealer suspected it was the purge valve, causing the problem so they replaced it and reset the codes. 10/10/24: I brought the truck in to have it looked at due to the check engine light being on again. I was told the lead frame needed to be replaced but was on backorder. The bill to diagnose this was 196.80 and I was told I could still drive it. On [XXX], I had to bring my truck in to be inspected because while I was going about 70 mph it all of a sudden downshifted and jerked me forward like it was going to abruptly stop. The check engine light came on and I had to drive pretty slow to avoid a breakdown on the interstate. Very scary to have this happen in interstate traffic It could have easily caused an accident. At this time, It was brought to my attention that the downshifting could also be related to technical bulletin 1495. Since we couldn’t get a real definitive answer on what was going on and the lead frame was on backorder, I decided to try and have the case connector in the bulletin removed and replaced as well as do a transmission tuneup on 10/23/24. This bill cost me $383.77. All codes were cleared and all appeared to be working correctly. On [XXX], I was driving on the interstate at about 70 mph and my truck seized up again and jerked forward, again scaring me and potentially causing an accident. I drove it very slowly directly to a repair shop. It was there until November 7, 2024 after the lead frame was replaced. That bill cost me $1321.68. I decided to file this complaint after I had seen a news article that this downshifting was being investigated for the same year as my 2015 Ford F150 for a safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

[XXX]: check engine light was on and codes P2196 and P2198 were present. The dealer suspected it was the purge valve, causing the problem so they replaced it and reset the codes. 10/10/24: I brought the truck in to have it looked at due to the check engine light being on again. I was told the lead frame needed to be replaced but was on backorder. The bill to diagnose this was 196.80 and I was told I could still drive it. On [XXX], I had to bring my truck in to be inspected because while I was going about 70 mph it all of a sudden downshifted and jerked me forward like it was going to abruptly stop. The check engine light came on and I had to drive pretty slow to avoid a breakdown on the interstate. Very scary to have this happen in interstate traffic It could have easily caused an accident. At this time, It was brought to my attention that the downshifting could also be related to technical bulletin 1495. Since we couldn’t get a real definitive answer on what was going on and the lead frame was on backorder, I decided to try and have the case connector in the bulletin removed and replaced as well as do a transmission tuneup on 10/23/24. This bill cost me $383.77. All codes were cleared and all appeared to be working correctly. On [XXX], I was driving on the interstate at about 70 mph and my truck seized up again and jerked forward, again scaring me and potentially causing an accident. I drove it very slowly directly to a repair shop. It was there until November 7, 2024 after the lead frame was replaced. That bill cost me $1321.68. I decided to file this complaint after I had seen a news article that this downshifting was being investigated for the same year as my 2015 Ford F150 for a safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

[XXX]: check engine light was on and codes P2196 and P2198 were present. The dealer suspected it was the purge valve, causing the problem so they replaced it and reset the codes. 10/10/24: I brought the truck in to have it looked at due to the check engine light being on again. I was told the lead frame needed to be replaced but was on backorder. The bill to diagnose this was 196.80 and I was told I could still drive it. On [XXX], I had to bring my truck in to be inspected because while I was going about 70 mph it all of a sudden downshifted and jerked me forward like it was going to abruptly stop. The check engine light came on and I had to drive pretty slow to avoid a breakdown on the interstate. Very scary to have this happen in interstate traffic It could have easily caused an accident. At this time, It was brought to my attention that the downshifting could also be related to technical bulletin 1495. Since we couldn’t get a real definitive answer on what was going on and the lead frame was on backorder, I decided to try and have the case connector in the bulletin removed and replaced as well as do a transmission tuneup on 10/23/24. This bill cost me $383.77. All codes were cleared and all appeared to be working correctly. On [XXX], I was driving on the interstate at about 70 mph and my truck seized up again and jerked forward, again scaring me and potentially causing an accident. I drove it very slowly directly to a repair shop. It was there until November 7, 2024 after the lead frame was replaced. That bill cost me $1321.68. I decided to file this complaint after I had seen a news article that this downshifting was being investigated for the same year as my 2015 Ford F150 for a safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

During the course of driving on the interstate at 70mph the vehicle decelerated and went to a lower gear. The dash panel of the truck did not show all of the gears available. An emergency stop on the side of the road and turning the vehicle off and back on temporarily resolved the issue. It occurred intermittently and without warning. The truck continued to show problems and was taken to a transmissions shop which checked the transmission, replaced a line for a small leak and said everything seemed to be in order. The cause was not found to be a lack of transmission fluid as the levels were normal. The truck continued to intermittently decelerate. The last time that occurred, the back wheels locked up while on the road. The truck is now sitting due to the safety risk it poses and the locked up transmission on the rear end. It is available for inspection upon request. My safety and that of others was at risk. The problem was not replicated in a service center. The vehicle was inspected beforehand but not after the last issue, (it needs a tow as the back wheels are frozen). There was a warning light for the engine camshaft that came on and the problem was diagnosed at Ford as a camshaft issue though they could not understand the deceleration issue. The truck was taken first to Ford then to an independent transmission shop. Due to the issue the truck is not in use.

POWER TRAIN

During the course of driving on the interstate at 70mph the vehicle decelerated and went to a lower gear. The dash panel of the truck did not show all of the gears available. An emergency stop on the side of the road and turning the vehicle off and back on temporarily resolved the issue. It occurred intermittently and without warning. The truck continued to show problems and was taken to a transmissions shop which checked the transmission, replaced a line for a small leak and said everything seemed to be in order. The cause was not found to be a lack of transmission fluid as the levels were normal. The truck continued to intermittently decelerate. The last time that occurred, the back wheels locked up while on the road. The truck is now sitting due to the safety risk it poses and the locked up transmission on the rear end. It is available for inspection upon request. My safety and that of others was at risk. The problem was not replicated in a service center. The vehicle was inspected beforehand but not after the last issue, (it needs a tow as the back wheels are frozen). There was a warning light for the engine camshaft that came on and the problem was diagnosed at Ford as a camshaft issue though they could not understand the deceleration issue. The truck was taken first to Ford then to an independent transmission shop. Due to the issue the truck is not in use.

ENGINE

During the course of driving on the interstate at 70mph the vehicle decelerated and went to a lower gear. The dash panel of the truck did not show all of the gears available. An emergency stop on the side of the road and turning the vehicle off and back on temporarily resolved the issue. It occurred intermittently and without warning. The truck continued to show problems and was taken to a transmissions shop which checked the transmission, replaced a line for a small leak and said everything seemed to be in order. The cause was not found to be a lack of transmission fluid as the levels were normal. The truck continued to intermittently decelerate. The last time that occurred, the back wheels locked up while on the road. The truck is now sitting due to the safety risk it poses and the locked up transmission on the rear end. It is available for inspection upon request. My safety and that of others was at risk. The problem was not replicated in a service center. The vehicle was inspected beforehand but not after the last issue, (it needs a tow as the back wheels are frozen). There was a warning light for the engine camshaft that came on and the problem was diagnosed at Ford as a camshaft issue though they could not understand the deceleration issue. The truck was taken first to Ford then to an independent transmission shop. Due to the issue the truck is not in use.

ELECTRICAL SYSTEM

Was traveling 75 MPH while towing a trailer. Truck was in 6th gear cruising. No fault codes whatsoever, no warning lamps etc. Suddenly the truck briefly downshifted into 1st gear, then upshifted back to 6th gear again. Issue occurred during heavy rain. I cleaned the bulkhead connector on the transmission afterwards and put dielectric grease on the connector o-ring. Connector Did not appear dirty or corroded. Issue had not occurred again for 8,000 miles.

POWER TRAIN

Was traveling 75 MPH while towing a trailer. Truck was in 6th gear cruising. No fault codes whatsoever, no warning lamps etc. Suddenly the truck briefly downshifted into 1st gear, then upshifted back to 6th gear again. Issue occurred during heavy rain. I cleaned the bulkhead connector on the transmission afterwards and put dielectric grease on the connector o-ring. Connector Did not appear dirty or corroded. Issue had not occurred again for 8,000 miles.

UNKNOWN OR OTHER

I was driving down the highway then my vehicle randomly dropped down to gear 2 from 6 and went from 65mph to 30 and redlined my vehicle. It was extremely scary and took it to the shop immediately and then they replaced my lead frame and cost me $2,000. I definitely believe it has damaged my transmission and won’t last as long now.

POWER TRAIN

The vehicle has downshifted to a low gear several times since I’ve owned it new in 2015. Usually has happened when starting to slow down to exit the highway. Driver and passengers were jarred and thrown forward unexpectedly. Driver was startled. Backend of truck swayed. Dealer service has been told over the years. They said they were aware but there were NO RECALLS and Ford didn’t have a FIX as of yet. They said it was COMOUTER RELATED causing the transmission to downshift. I also said sometimes it takes longer than normal to shift from the start position they claimed they were waiting for a fix from FORD. Dealer inspected. No warning lamps or messages appear on the dash as a warning. They said they would inform me of any fixes for the problem as they came down from the manufacturer.

POWER TRAIN

I am experiencing dangerous shifting failures with my 2015 Ford F-150 equipped with the 6R80 automatic transmission. My truck intermittently fails to shift properly, holds onto gears too long, or refuses to shift into 6th gear. It also enters fail-safe mode, displaying a wrench icon on the dashboard. Restarting the vehicle temporarily resolves the issue, but it keeps coming back. The truck recently threw diagnostic trouble codes P0720 and P0722, which are related to the Output Shaft Speed (OSS) sensor, a known failure point in the 6R80 transmission lead frame. Ford previously recalled 2011-2013 F-150s (Recall #19V-075, Ford Recall 19S07) for this exact issue because it can cause a catastrophic downshift from 6th gear to 1st at highway speeds, leading to loss of control. However, 2015 models were not included in the recall, despite using the same transmission and lead frame. I am concerned that Ford’s recall did not go far enough and that my 2015 F-150 should be included due to the identical symptoms and part failure. This is a serious safety hazard, as a sudden downshift at highway speeds could cause loss of control, an accident, or even fatalities. I am requesting that the NHTSA investigate this issue and expand the recall to include 2015 F-150s with the same 6R80 transmission and defective lead frame.

SERVICE BRAKES

brakes failed all fluid leaked out

UNKNOWN OR OTHER

The sliding rear window assembly which is attached with 4 adhesive tape strips have come loose. The sliding window comes out of the frame and could become airborne if hit from the rear or in a front end collision. It is a very poor way to attach a sliding rear window and the failure rate is high. The bad part of this is most people are probably not aware of the problem other than the window frame will rattle sometimes when your on a bumpy road. It is a poor design and could be dangerous in any collision. The body and glass repair shops are aware of the problem on the rear windows of Ford pickups. This should be fixed with a recall before someone dies from the window becoming airborne in a crash

VISIBILITY/WIPER

The sliding rear window assembly which is attached with 4 adhesive tape strips have come loose. The sliding window comes out of the frame and could become airborne if hit from the rear or in a front end collision. It is a very poor way to attach a sliding rear window and the failure rate is high. The bad part of this is most people are probably not aware of the problem other than the window frame will rattle sometimes when your on a bumpy road. It is a poor design and could be dangerous in any collision. The body and glass repair shops are aware of the problem on the rear windows of Ford pickups. This should be fixed with a recall before someone dies from the window becoming airborne in a crash

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Several extremely dangerous situations occured within 6 months of purchasing brand new 2015, F-150, 3.5, 4x4 ecoboost king ranch model. While driving on interstate, in rain, passing an 18 wheeler, without warning forward collision lights go off and truck begins slamming the brakes on by itself and the car behind me had to slam on his brakes to avoid a SEVERE crash. I brought truck to dealership they checked it out and said they wasnt sure why it happened and reset the computer, and put me back on the road. It continued to happen 2 or 3 more times until I realized it was only during rain, and when on side of 53' semi truck trailers. The last time it happened was a very dangerous and unnerving experience. truck suddenly begins slamming brakes on again going thru a major city on the freeway in heavy traffic. I brought the truck into dealer, and told them i wasnt driving it until they fixed it.The first year of ownership my truck was plauged with issues. IT constantly went into limp mode while on the freeway. I was working over 3 states and the truck would go into limp mode if I accelerated to pass. I went to every ford dealership shop along the interstate for a 300 mile stretch over the next 4 years while working away from home . Most of the problems were while under warranty. finally they updated software and it stopped. This was a very dangerous problem and the dealerships werent really very helpful. My truck stayed in the dealership shop more than 60 days the first year i owned it. I bought it brand new.

BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING

Several extremely dangerous situations occured within 6 months of purchasing brand new 2015, F-150, 3.5, 4x4 ecoboost king ranch model. While driving on interstate, in rain, passing an 18 wheeler, without warning forward collision lights go off and truck begins slamming the brakes on by itself and the car behind me had to slam on his brakes to avoid a SEVERE crash. I brought truck to dealership they checked it out and said they wasnt sure why it happened and reset the computer, and put me back on the road. It continued to happen 2 or 3 more times until I realized it was only during rain, and when on side of 53' semi truck trailers. The last time it happened was a very dangerous and unnerving experience. truck suddenly begins slamming brakes on again going thru a major city on the freeway in heavy traffic. I brought the truck into dealer, and told them i wasnt driving it until they fixed it.The first year of ownership my truck was plauged with issues. IT constantly went into limp mode while on the freeway. I was working over 3 states and the truck would go into limp mode if I accelerated to pass. I went to every ford dealership shop along the interstate for a 300 mile stretch over the next 4 years while working away from home . Most of the problems were while under warranty. finally they updated software and it stopped. This was a very dangerous problem and the dealerships werent really very helpful. My truck stayed in the dealership shop more than 60 days the first year i owned it. I bought it brand new.

FORWARD COLLISION AVOIDANCE: WARNINGS

Several extremely dangerous situations occured within 6 months of purchasing brand new 2015, F-150, 3.5, 4x4 ecoboost king ranch model. While driving on interstate, in rain, passing an 18 wheeler, without warning forward collision lights go off and truck begins slamming the brakes on by itself and the car behind me had to slam on his brakes to avoid a SEVERE crash. I brought truck to dealership they checked it out and said they wasnt sure why it happened and reset the computer, and put me back on the road. It continued to happen 2 or 3 more times until I realized it was only during rain, and when on side of 53' semi truck trailers. The last time it happened was a very dangerous and unnerving experience. truck suddenly begins slamming brakes on again going thru a major city on the freeway in heavy traffic. I brought the truck into dealer, and told them i wasnt driving it until they fixed it.The first year of ownership my truck was plauged with issues. IT constantly went into limp mode while on the freeway. I was working over 3 states and the truck would go into limp mode if I accelerated to pass. I went to every ford dealership shop along the interstate for a 300 mile stretch over the next 4 years while working away from home . Most of the problems were while under warranty. finally they updated software and it stopped. This was a very dangerous problem and the dealerships werent really very helpful. My truck stayed in the dealership shop more than 60 days the first year i owned it. I bought it brand new.

ENGINE AND ENGINE COOLING

The contact owns a 2015 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle made an abnormal screeching sound while accelerating. There was smoke coming from the passenger's side engine. No warning light was illuminated. The contact was able to drive to the residence. The vehicle was taken to an independent mechanic. The contact related the failure to the exhaust manifold; however, the vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 121,000.

UNKNOWN OR OTHER

Erratic shifting, lead frame sensor causing safety issues and causing truck to not start if shut off. Erratic downshifting at highway speed. Known safety problems with Ford and needs to be fixed. Significant loss of power and lose dashboard data. Issue starting to happen more frequently, almost every time driven

UNKNOWN OR OTHER

Drive mode lights on dash (P,R,N,D,M,2,1) start alternating while driving then vehicle will not stay engaged in any drive mode, vehicle appears to go into limp mode with no drive mode lit on dashboard. This is extremely dangerous. Vehicle codes found are P0706 and P0707. Ford case number is [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

Drive mode lights on dash (P,R,N,D,M,2,1) start alternating while driving then vehicle will not stay engaged in any drive mode, vehicle appears to go into limp mode with no drive mode lit on dashboard. This is extremely dangerous. Vehicle codes found are P0706 and P0707. Ford case number is [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

Drive mode lights on dash (P,R,N,D,M,2,1) start alternating while driving then vehicle will not stay engaged in any drive mode, vehicle appears to go into limp mode with no drive mode lit on dashboard. This is extremely dangerous. Vehicle codes found are P0706 and P0707. Ford case number is [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The contact owns a 2015 Ford F-150. The contact stated that while the vehicle was in for a routine oil change, the mechanic discovered that engine oil was leaking from the oil pan. The contact was informed that the oil pan needed to be replaced. The vehicle was not repaired. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not notified of the failure. The failure mileage was 102,000.

STRUCTURE:BODY

Driver side Door latch won’t latch when cold- below freezing temperatures. The door stays frozen in the open position and is unable to latch closed Stays open when driving

ENGINE

Exhaust manifold leak because of poor engineering at approximately 55000 miles

ENGINE AND ENGINE COOLING

The contact owns a 2015 Ford F-150. The contact stated that while the vehicle was parked, the vehicle started to leak coolant. The contact stated that while driving 65 MPH, the engine started to overheat. The temperature gauge registered a high temperature. The vehicle was not taken to be diagnosed. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 148,000.

ENGINE

The contact owns a 2015 Ford F-150. The contact stated that while the vehicle was parked, the vehicle started to leak coolant. The contact stated that while driving 65 MPH, the engine started to overheat. The temperature gauge registered a high temperature. The vehicle was not taken to be diagnosed. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 148,000.

FUEL/PROPULSION SYSTEM

It's the same issue as Recall Notice 22S02/NHTSA Recall 22v011. The replacement part is MR3Z-7583-A 1X ($2-$5 part with 30 second install), but they do not show it under parts for my truck, they would prefer to sell me the whole brake pedal assembly ($50+ part and labor probably diagnosis charge in addition to part replacement). The part becomes brittle and breaks. This caused dead battery, 5 hours from home, due to lights staying on, allowed me to start and put truck into gear without touching the brake, lost acceleration between 45 & 50 mph, cruise control would not turn on and message presents that hill assist is not available.

VEHICLE SPEED CONTROL

It's the same issue as Recall Notice 22S02/NHTSA Recall 22v011. The replacement part is MR3Z-7583-A 1X ($2-$5 part with 30 second install), but they do not show it under parts for my truck, they would prefer to sell me the whole brake pedal assembly ($50+ part and labor probably diagnosis charge in addition to part replacement). The part becomes brittle and breaks. This caused dead battery, 5 hours from home, due to lights staying on, allowed me to start and put truck into gear without touching the brake, lost acceleration between 45 & 50 mph, cruise control would not turn on and message presents that hill assist is not available.

EXTERIOR LIGHTING

It's the same issue as Recall Notice 22S02/NHTSA Recall 22v011. The replacement part is MR3Z-7583-A 1X ($2-$5 part with 30 second install), but they do not show it under parts for my truck, they would prefer to sell me the whole brake pedal assembly ($50+ part and labor probably diagnosis charge in addition to part replacement). The part becomes brittle and breaks. This caused dead battery, 5 hours from home, due to lights staying on, allowed me to start and put truck into gear without touching the brake, lost acceleration between 45 & 50 mph, cruise control would not turn on and message presents that hill assist is not available.

ENGINE

The contact owns a 2015 Ford F-150. The contact stated that upon taking the vehicle to the dealer for an oil change, the dealer informed the contact that the vehicle was experiencing an oil leak. There was no warning light illuminated. The vehicle was then taken to Mark's Auto Repair, where the contact was informed that the plastic-based oil pan was deformed and was leaking. The mechanic determined that the oil pan needed to be replaced. The vehicle was not repaired. The contact related the failure to TSB Number: 19-2205. The manufacturer was notified of the failure and informed the contact that the VIN was included in the TSB. The failure mileage was approximately 163,000.

UNKNOWN OR OTHER

Oil pan leaking due to having a plastic oil pan

POWER TRAIN

The vehicle will randomly shift into 1st or 2nd gear no matter what speed you are traveling. This causes a sudden slam of vehicle and slows town rapidly even causing the tires to skid. This feels extremely unsafe. There aren’t any recalls on my year and model specifically, however this is a very known issue with Ford 6-speed automatic transmissions. There is a safety recall on 2011-2013 Ford F150 models for the same issues I am having with my 2015 models. Occasionally the engine light will appear and the code reads transmission range sensor circuit. Also, occasionally the vehicle won’t start and the “see service manual” message will appear.

SUSPENSION

Unknown my truck at 65 to 69 shakes crazy bad and everybody i talk to says theirs does as well and Walter's Ford in pikeville ky has no clue y it is doing it therefore they couldn't fix it and it it's dangerous to drive

UNKNOWN OR OTHER

I cold started the engine from inside the house and when I opened the back passenger door there was smoke coming from behind the rear seat in the back area. I couldn’t get to where the smoke was coming from but from the smell it was wire related. I quickly went around to the driver side and turned on the truck and quickly turned it off. About 10-30 minutes later the ring camera showed the rear window of my truck shatter due to this incident in which I was informed that the rear auto defrost turns on due to a malfunction. I put a claim through my insurance and got the window fixed but I am still worried that this issue may happen again. I hope that by informing you of this situation going forward you can help others including myself be aware of this problem and how we can fix it. Thank you for your time and I like to say I love ford trucks and plan on staying a loyal customer.

ELECTRICAL SYSTEM

I cold started the engine from inside the house and when I opened the back passenger door there was smoke coming from behind the rear seat in the back area. I couldn’t get to where the smoke was coming from but from the smell it was wire related. I quickly went around to the driver side and turned on the truck and quickly turned it off. About 10-30 minutes later the ring camera showed the rear window of my truck shatter due to this incident in which I was informed that the rear auto defrost turns on due to a malfunction. I put a claim through my insurance and got the window fixed but I am still worried that this issue may happen again. I hope that by informing you of this situation going forward you can help others including myself be aware of this problem and how we can fix it. Thank you for your time and I like to say I love ford trucks and plan on staying a loyal customer.

POWER TRAIN

This vehicle started having periods of time that felt and sounded like you were running over rumble strips. This started happening at 38,000 miles and it would happen every 30 seconds to 1 min when going a steady speed. Also when shifting into different gears. Took it to a private mechanic and had the transmission fluid and filter changed which seemed to help a little. Then gradually started coming back more and more again. At 40,000 mi we decided to take it to the Ford dealership in portage, Wisconsin. They diagnosed the issue as a torque converter and torque converter solenoid. All together. This will be costing us $5,000. Upon looking up potential recalls for this problem, I noticed many F150 2015's with the same problem that were included in a recall. For some reason this vehicle is not but obviously should be. I contacted Ford and they told me to discuss the situation with the dealership that is doing the repair on the truck. Ford dealership told me to contact the Ford office. After getting bounced back and forth, I just decided to file this claim with you. I don't know what the next steps could be.

POWER TRAIN

I was driving at 65 mph when my 2015 F150 shifted into 1st gear. I started skidding sideways and almost flipped but was able to run through the gears quickly and got it into Neutral. This has happened a few other times since the initial incident. I constantly receive codes related to lead frame assembly issue: P0720, P0721, P0722, P161B, etc. I am in desperate need of a new lead frame assembly so my vehicle does not crash on the highway. Thanks!

VEHICLE SPEED CONTROL

I was driving at 65 mph when my 2015 F150 shifted into 1st gear. I started skidding sideways and almost flipped but was able to run through the gears quickly and got it into Neutral. This has happened a few other times since the initial incident. I constantly receive codes related to lead frame assembly issue: P0720, P0721, P0722, P161B, etc. I am in desperate need of a new lead frame assembly so my vehicle does not crash on the highway. Thanks!

ELECTRICAL SYSTEM

I was driving at 65 mph when my 2015 F150 shifted into 1st gear. I started skidding sideways and almost flipped but was able to run through the gears quickly and got it into Neutral. This has happened a few other times since the initial incident. I constantly receive codes related to lead frame assembly issue: P0720, P0721, P0722, P161B, etc. I am in desperate need of a new lead frame assembly so my vehicle does not crash on the highway. Thanks!

LATCHES/LOCKS/LINKAGES

The contact owns a 2015 Ford F-150. The contact stated that the front driver’s side door failed to unlock while using the key fob or the key. The contact stated that while inside the vehicle, the symbol showing that the door was ajar was displayed. The contact had to manipulate the door lock and click the fob several times to secure the door lock. The vehicle was taken to the dealer who diagnosed that the door locking mechanism had failed and needed to be replaced. The dealer notified the contact of NHTSA Campaign Numbers: 17V331000 (Latches/Locks/Linkages) and 17V652000 (Latches/Locks/Linkages); however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure. The manufacturer confirmed that the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 72,000.