2011 FORD F-150

POWER TRAIN:AUTOMATIC TRANSMISSION

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Risk: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

POWER TRAIN:AUTOMATIC TRANSMISSION

Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.

Risk: An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 “LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT.” THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.

Risk: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE “R” POSITION AND THE VEHICLE’S TRANSMISSION DOES GO IN REVERSE, THE “R” MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLE’S NOT SIGNALING IT IS IN REVERSE.

POWER TRAIN:AUTOMATIC TRANSMISSION

FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150 VEHICLES MANUFACTURED FROM SEPTEMBER 9, 2011, THROUGH SEPTEMBER 22, 2011, AND MODEL YEAR 2012 F-250, F-350, F-450 AND F-550 HEAVY DUTY VEHICLES MANUFACTURED FROM SEPTEMBER 12, 2011, THROUGH SEPTEMBER 22, 2011. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 114, “THEFT PROTECTION.” THE TRANSMISSION CAN BE SHIFTED OUT OF THE PARK POSITION WITHOUT PRESSING THE BRAKE PEDAL DUE TO BRAKE SHIFT INTERLOCK SWITCH PROBLEM.

Risk: THIS WILL ALLOW THE OPERATOR TO INADVERTENTLY SHIFT THE VEHICLE INTO GEAR WITHOUT THE BRAKE PEDAL BEING DEPRESSED, INCREASING THE RISK OF A CRASH OR INJURY TO A NEARBY PEDESTRIAN.

ELECTRICAL SYSTEM:SOFTWARE

FORD IS RECALLING CERTAIN MODEL YEAR 2011 FORD F-150, F-250, F-350, F-450, F-550, EDGE, AND LINCOLN MKX TRUCKS MANUFACTURED FROM OCTOBER 25, 2010, THROUGH NOVEMBER 20, 2010. THESE VEHICLES WERE INSPECTED USING INTEGRATED DIAGNOSTIC SYSTEM (IDS) THAT HAD A CUSTOM SOFTWARE ROUTINE TO READ THE SUSPECT BODY CONTROL MODULE (BCM) SERIAL NUMBER. BASED ON THE SERIAL NUMBER THE BCM WAS EITHER NOT AFFECTED OR REPLACED. THE CUSTOM SOFTWARE ROUTINE WAS NOT READING THE CORRECT SET OF CHARACTERS, AND WAS NOT ABLE TO IDENTIFY A BCM THAT REQUIRED REPLACEMENT AFFECTED BCMS MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.

Risk: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH COULD RESULT IN A VEHICLE FIRE.

STEERING

The power steering goes out randomly. While driving forward , backing up, parking, turning. Very dangerous to drive.

SUSPENSION

Was in a car Collison not wherein setbelt and airbags did not deploy or come out at all

STEERING

Was in a car Collison not wherein setbelt and airbags did not deploy or come out at all

AIR BAGS

Was in a car Collison not wherein setbelt and airbags did not deploy or come out at all

VEHICLE SPEED CONTROL

Hard downshifts from 5 to 4. At low speeds, like parking lots it shifts hard from 1 to 2. At freeway speeds while attempting to pass instead of dropping a gear to passs it downshifts to 1st, rpm’s shoot up and it results in having to pull off stop and place in park. Once in park back to D and able to take off. At any speed from 30 mph or more there is a sort of “tap of brakes” feeling every .15 of a mile.

POWER TRAIN

Hard downshifts from 5 to 4. At low speeds, like parking lots it shifts hard from 1 to 2. At freeway speeds while attempting to pass instead of dropping a gear to passs it downshifts to 1st, rpm’s shoot up and it results in having to pull off stop and place in park. Once in park back to D and able to take off. At any speed from 30 mph or more there is a sort of “tap of brakes” feeling every .15 of a mile.

ENGINE

The display will show a wrench icon and check engine light. The transmission will suddenly downshift and lose power. The RPMs will either rise or remain the same but unable to accelerate. The wheels will intermittently lock up. This occurs at high speeds on the highway and on back roads at slower speeds. Stopping the tuck, shutting it off and turning it back on will "reset" and it will run ok but the timing between incidents is intermittent. There is a recall for this issue however the dealership (Greico Ford in Raynham) refuses to make the repairs, instead telling me this is no longer covered by recall: Transmission molded leadframe extended coverage [XXX] Today was the latest event, however this has been ongoing since December 2024. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

Entering the highway, the transmission shifted into 1st, the gauges blanked out and a service light came on. Upon taking it in for inspection, FORD compliant 19N01 already existed but had limited mileage/date that has now expired. The problem and solution is the same found under 19N01

POWER TRAIN

Speedometer stopped working and automatic transmission would not shift out of first gear without manually shifting. Transmission then would not come out of third gear.

POWER TRAIN

I own a 2011 Ford F-150. While driving at highway speed, the transmission unintendedly downshifted to first gear, causing the vehicle to lose motive power. This can, by Fords admission, cause accidents and Injury. The check engine warning light and Wrench Symbol was illuminated. Sometimes it is able to restart and reset sometimes not. This problem has occurred several times while driving. I took it to my normal mechanic, where it was diagnosed with an output shaft speed sensor failure. He said that the transmission lead frame needed to be replaced. The vehicle has not yet been repaired. I spoke to Ford customer service and they refuse to fix it and said my VIN was not included. See NHTSA Safety Recall Report 16V-248

VEHICLE SPEED CONTROL

When driving on the interstate with the normal flow of traffic at 55mph, the vehicle abruptly downshifted from 6th gear to 1st gear causing the the vehicle to lock up an nearly caused an accident. This was followed by a a mechanic warning light and the speedometer to lock out and no longer work. Once pulled over, the vehicle was powered down. When the vehicle was turned back on operation returned in a limp state.

POWER TRAIN

When driving on the interstate with the normal flow of traffic at 55mph, the vehicle abruptly downshifted from 6th gear to 1st gear causing the the vehicle to lock up an nearly caused an accident. This was followed by a a mechanic warning light and the speedometer to lock out and no longer work. Once pulled over, the vehicle was powered down. When the vehicle was turned back on operation returned in a limp state.

POWER TRAIN

What is happening is a KNOWN issue that effects Ford F-150's from 2011-2013 Models with the 6-Speed transmissions. The issue is with the Molded Lead Frames. The fault causes hard downshifts out of now where. I was driving on a highway, at highway speeds, when the truck downshifted to 1st Gear. Incredibly unsafe, jolted the truck to an immediately forced reduced speed, luckily no one was behind me. Ford is aware of this, but is not correcting affected vehicles. My vehicle is a 2011 F-150, I tried to have it fixed while it was still under the "extended coverage" but Ford denied it due to it only being a "possible malfunction" at the time. Roughly 2 years later, the malfunction & defect is now on full force, rendering the truck unsafe to drive due to sudden down shifts at random intervals, multiple times a day while driving, yet now it is "passed the coverage." That is unacceptable, and is safety issue for the many of these generation models of F-150's that are still out driving.

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated while driving approximately 60 MPH, there was an abnormal sound coming from the engine. The RPM fluctuated, and the transmission shifted roughly. The gear shifter indicator was randomly illuminated on the instrument panel. The contact pulled over to the side of the road and turned off the vehicle. The contact stated that after a while, the vehicle failed to start. The contact stated that after several attempts, the vehicle restarted. The vehicle was not diagnosed or repaired. The contact used a scanner and retrieved DTC: P0705 (Transmission Range Sensor Circuit Malfunction (PRNDL Input)" was provided. The vehicle was not repaired. The failure recurred, and the contact parked the vehicle and the vehicle was no longer driven due to safety concerns. The manufacturer was not notified of the failure. The failure mileage was approximately 79,000.

POWER TRAIN

The transmission unexpectedly downshift's to 1st gear, instrument gauges go dark, wheels have locked up, motor then lacks power. The issues have been going on for a while and recently had to stop on the side of the road 5 times in the 20 mile trip home from work. 2011 F-150 is unsafe to drive. Called Ford Customer Service on July 2, 2025. Case Number [XXX]. Was informed a prior Recall 16S19 addressing these issues was performed in 2016. A second recall 19S07 was issued for the same reasons. The service rep said this vin number is not listed; apparently it does not cover this vehicle. Ford customer service rep suggested filing a complaint with NHTSA.gov as this has been an ongoing safety issue. Unless NHTSA is made aware of an issue can it be addressed or in this case readdressed because the repairs by Ford has failed as a long term solution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact received notification of NHTSA Campaign Number: 19V075000 (Power Train). The contact stated that while driving at approximately 50 MPH, the transmission was shifting rough. The contact stated that that there was a grinding sound coming from underneath the vehicle, with the check engine warning light illuminated. The contact stated that a mobile mechanic visited residence to diagnose the vehicle and the contact was informed that the transmission was slipping out of gear and downshifting unexpectedly. The vehicle was taken to a dealer where it was diagnosed that the transmission needed to be repaired and an unknown recall repair needed to be performed. The vehicle was repaired; however, the failure persisted while driving. Additionally, the contact stated that the rear end occasionally locked up while driving. The manufacturer was notified of the failure. The failure mileage was approximately 228,000.

POWER TRAIN

As i was driving around 45 mph this Sunday, my 2011 f150 suddenly shifted hard down to first gear. i thought someone hit me from behind at first, i don't think i have ever been so scared in a vehicle in my life! this truck has been so good to my family otherwise. Anyway, i started researching online and found there was a recall for this but has ended. I called Ford thinking maybe they would stand behind a problem that was a known ford issue. whether its been 10 years or 20. this is my 7th f150. i have dealt with all there issues in the past. From blown out sparkplugs in the 4.6 to the leaking intake manifold to cam phasers. you may ask why i keep buying them, but its because i love ford. Is there anything you can do for me? I'm scared i could kill myself or someone. This is a dangerous problem and i don't see how this recall could have ever had a deadline on it. Thank you for you time, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

I am having a lead frame issue as many of these models had but it never affected me until now. I can be doing highway speeds, upwards of 70mph and the vehicle will just down shift to first gear, locking the tires and causing a hazard for other drivers which could be a very dangerous situation

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated while driving at various speeds over a bumpy road surface, the vehicle jerked, downshifted to first gear unexpectedly and stalled. The ABS warning light, the power train warning light, the traction control warning light, and other unknown warning lights were illuminated. The message "Check Braking System" was displayed. The contact stated that the failure had been recurring intermittently. The contact was able to pull over to the side of the road on several occasions. The vehicle was taken to the dealer but was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 19V075000 (Power Train); however, the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2011 Ford F-150. The contact stated that while the vehicle was parked on an incline, the contact started the vehicle and depressed the brake pedal; however, the vehicle started to roll backwards. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, where it was determined that the vacuum booster pump had failed. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was contacted and confirmed that the vacuum booster was previously replaced in 2018. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 85,000.

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the check engine warning light was illuminated. The contact pulled shoulder of the road, turned the vehicle and waited for several minutes before restarting the vehicle and continuing to drive to the destination. The vehicle was later taken to an independent mechanic where it was diagnosed and DTC: P0720 and P0722 were retrieved for transmission leadframe failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact referenced Customer Satisfaction Program: 16N02; as a possible cause for the failure; however, the vehicle was not eligible for the repair. The contact was informed that the vehicle was 7,000 miles over the mileage limitation. The failure mileage was approximately 151,000. The VIN was unavailable.

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated while driving 45 MPH, the transmission unexpectedly downshifted to first gear. There was no warning light illuminated. The contact was able to pull over to the side the road. The contact stated that upon depressing the accelerator pedal to resume driving, the vehicle failed to exceed 10 MPH. The vehicle was towed to the dealer, where it was diagnosed and determined that the transmission molded lead frame had failed and needed to be replaced. The dealer informed the contact that the vehicle could not be repaired under Ford Campaign Number: 19N01, because the campaign had expired. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 180,000.

ELECTRICAL SYSTEM

The electronic power steering locked up while driving & could not turn the wheel at all. Yes this has been inspected & confirmed by an independent service center. There were no warning lamps or messages prior to this incident. The vehicle is render useless with the locked up steering.

STEERING

The electronic power steering locked up while driving & could not turn the wheel at all. Yes this has been inspected & confirmed by an independent service center. There were no warning lamps or messages prior to this incident. The vehicle is render useless with the locked up steering.

BACK OVER PREVENTION

The contact owns a 2011 Ford F-150. The contact stated while shifted into reverse, the rear-view camera image was reversed. The contact stated that objects on the right side of the vehicle appeared on the left side on the screen. The contact stated that before the image was reversed, the camera image was pixelating. The contact stated that the failure was intermittent but became a recurring failure. The contact stated there was no warning light illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to several recalls related to the back-over prevention camera. However, neither the vehicle year nor the model was included. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 145,000.

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated that while the vehicle was parked, the vehicle failed to start as intended. In addition, several warning lights illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact referenced NHTSA Campaign Number: 16V248000 (Power Train), which had a similar failure description, however the contact's VIN was not associated with the recall. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 135,000.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Transmission shifts into lower gear,and speedometer quits working. Stopped truck , turned truck off and turned truck on and it drives normal,

POWER TRAIN

Transmission shifts into lower gear,and speedometer quits working. Stopped truck , turned truck off and turned truck on and it drives normal,

VEHICLE SPEED CONTROL

While driving at about 50 MPH truck suddenly down shifted to 1st gear locked up rear wheels and sent engine into a roar. Instrument panel not showing speed or any information. Had transmission shop trouble shoot and determined frame rail failure. replaced frame rail and serviced.

POWER TRAIN

While driving at about 50 MPH truck suddenly down shifted to 1st gear locked up rear wheels and sent engine into a roar. Instrument panel not showing speed or any information. Had transmission shop trouble shoot and determined frame rail failure. replaced frame rail and serviced.

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

The contact owns a 2011 Ford F-150. The contact stated while driving 25 MPH, the driver's side side-view mirror detached from the vehicle and was hanging down tethered by the wiring harness. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 196,000. The VIN was not available.

VEHICLE SPEED CONTROL

Unexpectedly downshifting into first gear result in a loss of vehicle control happened on September 20, 2024 and continue on and off.

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 16V248000 (Power Train); however, the repair failed to prevent the failure. The contact stated that two days after the recall repair was completed, while driving at undisclosed speeds, the vehicle unexpectedly decelerated while the accelerator pedal was depressed. An unknown message was displayed on the instrument panel. In addition, the contact stated that the speedometer was no longer illuminated. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

The contact owns a 2011 Ford F-150. The contact stated while driving 30 MPH, the transmission unexpectedly downshifted to a lower gear. The contact stated that the odometer became inoperable. The contact stated that the failure was linked to NHTSA Campaign Number: 19V075000 (Power Train). The contact called the local dealer and was informed that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 160,000.

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated while driving 30 MPH, the transmission unexpectedly downshifted to a lower gear. The contact stated that the odometer became inoperable. The contact stated that the failure was linked to NHTSA Campaign Number: 19V075000 (Power Train). The contact called the local dealer and was informed that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 160,000.

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission seized in third gear. The contact pulled over and turned off and restarted the vehicle ten times. The contact stated that the instrument panel became inoperable. The transmission was also downshifting hard and failed to shift out of first gear. The contact stated that the failure was related to NHTSA Campaign Number: 19V075000 (Power Train). The vehicle was taken to an independent mechanic and local dealer who were unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. While driving, the vehicle went from reverse to fifth. The driver pulled the shifter towards herself and was able to drive manually. The manufacturer was contacted and confirmed there was no recall coverage on the VIN for the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 132,000.

STEERING

I was driving when the steering locked up with no warning light on the dash or fault messages. Was driving on a road and taking a turn when I went straight into the woods not allowing control of vehicle

POWER TRAIN

Driving 40mph the truck down shifted to 1st gear

POWER TRAIN

Transmission indicator lights are not functioning and vehicle doesn’t go into gear properly. I read there was a recall on certain 2011 F150s for this problem but mine does not appear to be included. I can’t tell what gear my vehicle is in now so it is obviously dangerous to drive.

VEHICLE SPEED CONTROL

At highway speeds speedometer started occasionally dropping to zero while actually going 55-65 mph. Then it became quite frequent AND the truck started spontaneous downshifting causing the rear wheels to break loose and the rear of truck to fishtail. It was terrifying.

POWER TRAIN

At highway speeds speedometer started occasionally dropping to zero while actually going 55-65 mph. Then it became quite frequent AND the truck started spontaneous downshifting causing the rear wheels to break loose and the rear of truck to fishtail. It was terrifying.

ENGINE

The contact owns a 2011 Ford F-150. The contact stated while driving at an undisclosed speed, the transmission unintendedly downshifted to first gear, causing the vehicle to lose motive power. The check engine warning light was illuminated. The vehicle was able to restart and reset. The contact stated that the failure had recurred several times while driving. The vehicle was taken to an independent mechanic, where it was diagnosed with an output shaft speed sensor failure. The contact was informed that the transmission lead frame needed to be replaced. The vehicle was not repaired. No further information was available. The manufacturer was made aware of the failure, but no assistance was provided. The manufacturer advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 133,456.

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated while driving at an undisclosed speed, the transmission unintendedly downshifted to first gear, causing the vehicle to lose motive power. The check engine warning light was illuminated. The vehicle was able to restart and reset. The contact stated that the failure had recurred several times while driving. The vehicle was taken to an independent mechanic, where it was diagnosed with an output shaft speed sensor failure. The contact was informed that the transmission lead frame needed to be replaced. The vehicle was not repaired. No further information was available. The manufacturer was made aware of the failure, but no assistance was provided. The manufacturer advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 133,456.

POWER TRAIN

On or about March 26 2025 while operating this truck at about 35 MPH the 6 speed transmission shifted to first gear causing the tires to chirp the vehicle to a near stop and red line the engine. This is a known defect that Ford supposedly fixed years ago but apparently was not a proper fix. The vehicle was taken to Medford Ford, Medford NJ on 3/31/2025 where the dealer said transmission should be replaced my expense for $8500 plus tax and the cost of estimate of approximately $202.63. They did not offer an option to repair an otherwise perfectly functioning transmission. This makes me feel like a very unsafe approach. My experience caused such an abrupt stop that under different circumstances there could have been a serious accident.

VEHICLE SPEED CONTROL

2011 F-150 super crew Laredo is sifting gears down by its self at high spends causing immediate car speedometer cluster going to zero and not be able to accelerate. There was a customer satisfaction program 19N01 it was 10 yr 150,0000 miles

POWER TRAIN

2011 F-150 super crew Laredo is sifting gears down by its self at high spends causing immediate car speedometer cluster going to zero and not be able to accelerate. There was a customer satisfaction program 19N01 it was 10 yr 150,0000 miles

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated that while driving at undisclosed speeds, the transmission unexpectedly downshifted while the accelerator pedal was depressed. No warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 19V075000 (Power Train); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 124,000.

POWER TRAIN

Driving normal speed and normal RPM when all a sudden the RPM's will go up double than what it was and the speedometer drops to 0, It feels like truck in down shifting , but the RPM's stay high. No engine light comes on, no other warning. This has happen on several ocassions

SUSPENSION

Rear left axle snapped in half. Heard hissing noise which turned out to be fluids spraying. Purchased vehicle from Anderson Ford dealership in Kingman in 2022 with 95995 miles on it. I've only put 12,000 miles on it in 3 years. I'm [XXX] and do not drive aggressively. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

While driving on highway the transmission will bang really hard when shifting upshifting and downshifting while vehicle is in motion. This is a safety concern. I seen that there is over a million Ford vehicles recalled over this same problem. I need my vehicle put on this recall list immediately. This is an emergency and I will be keeping copies of all documents I sent and receive for further measures. Thank you for your time and please contact me back as soon as possible.

POWER TRAIN

vehicle puts itself into theft mode and wont crank or anything. There is a customer satisfaction program Campaign# 19N01 that ford will not honor says vehicle is too old. it is a 2011 and has 105000 miles currently at the shop for repair. There is a software recall that effects this but the issue itself is not covered

SERVICE BRAKES

Brake system alarm. When the mechanic put the computer reader on it, it’s saying it’s a vacuum issue. This issue has been recalled on several 2011 FordF150’s, but when I look up my VIN, it says there isn’t a recall on mine

POWER TRAIN

Transmission light came on and downshifted to first gear

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated while driving at an undisclosed speed, the transmission unexpectedly shifted from third gear to first gear. The contact stated that the failure was persistent. The vehicle was taken to the dealer where it was diagnosed with a failed main control lead frame. The contact was informed that the main control lead frame needed to be replaced. The vehicle was not repaired. The contact was informed that the repair was not covered under any recall or special coverage programs. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 144,000.

SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

The contact owns a 2011 Ford F-150. The contact stated while driving on an access road 30 MPH, the transmission unexpectedly downshifted to first gear, and the “Maintenance Required” warning light was illuminated. The contact immediately stopped the vehicle. The vehicle was restarted and driven to a local independent mechanic where the vehicle was diagnosed, and the contact was informed that the output shaft speed sensor was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 157,000.

ENGINE

The contact owned a 2011 Ford F-150. The contact stated while driving at 15 MPH and making a left turn, in the middle of the turn, the instrument panel turned off, and the vehicle jerked forward before losing automotive power. The contact was not able to clear the intersection in time and the vehicle crashed into another vehicle on the passenger’s side. The contact stated that the vehicle rolled over onto the driver’s side. The contact was thrown halfway through the window while the vehicle was flipping over onto the side of the vehicle, and the contact lay underneath the vehicle. Soldiers arrived at the scene and lifted the vehicle to release the contact out of the driver-side door. The air bags had deployed. The vehicle was towed to a tow yard. The contact was unaware if a police report was filed. The vehicle was destroyed. The contact sustained a crushed pelvis, six fractured ribs, and nerve damage. Medical attention was required for the injuries. The local dealer was contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 170,000.

ELECTRICAL SYSTEM

I’ve had this specific issue happened a few times over the last year. Basically, my truck will get stuck in first gear, a wrench will pop up on the dashboard, and my odometer will go blank. Usually, my truck will stay in first gear until I put it in park and shut off the truck (to kind of “reset it”) and then crank it back up. Sometimes it takes multiple cycles of this. One time, I got stuck in third gear and had to use manual to shift it down to first gear (while driving), and then do the steps previously mentioned to “reset it”. Because of this, my truck has thrown a P0720 code. After research, it seems like the problem is with the molded lead frame. I have contacted multiple Ford dealerships, and they are definitely aware of the issue because each time they tell me that this issue used to be covered under warranty. The problem is, every dealership has said that this warranty expired some time ago (before I own the truck and before this started happening). Now they are saying the only way to prevent it is to spend $1600 for them to fix it. I don’t have $1600 to drop on a safety issue that is beyond my control. Especially since Ford knows about it. I have a video showing the last time it happened. I really hope this gets fixed because I do not want to be driving 60 miles an hour on the highway and suddenly drop into first gear.

POWER TRAIN

I’ve had this specific issue happened a few times over the last year. Basically, my truck will get stuck in first gear, a wrench will pop up on the dashboard, and my odometer will go blank. Usually, my truck will stay in first gear until I put it in park and shut off the truck (to kind of “reset it”) and then crank it back up. Sometimes it takes multiple cycles of this. One time, I got stuck in third gear and had to use manual to shift it down to first gear (while driving), and then do the steps previously mentioned to “reset it”. Because of this, my truck has thrown a P0720 code. After research, it seems like the problem is with the molded lead frame. I have contacted multiple Ford dealerships, and they are definitely aware of the issue because each time they tell me that this issue used to be covered under warranty. The problem is, every dealership has said that this warranty expired some time ago (before I own the truck and before this started happening). Now they are saying the only way to prevent it is to spend $1600 for them to fix it. I don’t have $1600 to drop on a safety issue that is beyond my control. Especially since Ford knows about it. I have a video showing the last time it happened. I really hope this gets fixed because I do not want to be driving 60 miles an hour on the highway and suddenly drop into first gear.

POWER TRAIN

On my.2011 ford f150 xlt the electrical power steering asssist failed completely while driving in traffic... It was incredibly hard to maintain control of the vehicle ... I had to use all my strength to get the wheel to turn what so ever. It was u credibly lucky that I didn't cause an accident because it made me steer into oncoming traffic and would.not let the vehicle.tur. the opposite direction. ..the warning light said service advance Trac and then said power steering assist failure.

STEERING

On my.2011 ford f150 xlt the electrical power steering asssist failed completely while driving in traffic... It was incredibly hard to maintain control of the vehicle ... I had to use all my strength to get the wheel to turn what so ever. It was u credibly lucky that I didn't cause an accident because it made me steer into oncoming traffic and would.not let the vehicle.tur. the opposite direction. ..the warning light said service advance Trac and then said power steering assist failure.

VEHICLE SPEED CONTROL

While operating vehicle at highway speeds the speedometer suddenly drops to zero and the transmission downshifts to first gear without warning. Apparently a failure of the transmission speed sensor. (?) A driver unaware of this issue that continues to drive results in excessive heat and pressure developing in the differential..A recall has been issued by NHTSA but Ford and the local dealer refused to address the problem because my VIN was not included in the recall.

POWER TRAIN

While operating vehicle at highway speeds the speedometer suddenly drops to zero and the transmission downshifts to first gear without warning. Apparently a failure of the transmission speed sensor. (?) A driver unaware of this issue that continues to drive results in excessive heat and pressure developing in the differential..A recall has been issued by NHTSA but Ford and the local dealer refused to address the problem because my VIN was not included in the recall.

ELECTRICAL SYSTEM

While operating vehicle at highway speeds the speedometer suddenly drops to zero and the transmission downshifts to first gear without warning. Apparently a failure of the transmission speed sensor. (?) A driver unaware of this issue that continues to drive results in excessive heat and pressure developing in the differential..A recall has been issued by NHTSA but Ford and the local dealer refused to address the problem because my VIN was not included in the recall.

POWER TRAIN

Transmission downshifted to 1st gear causing the rear wheel to lock momentarily while driving 40mph on the highway and then shifted back to 5th gear. Transmission will occasionally stay on 3rd or 5th gear when at a complete stop. Dealership refuses to remedy recall issue for my truck. I have complained multiple times.

VEHICLE SPEED CONTROL

Transmission downshifted to 1st gear causing the rear wheel to lock momentarily while driving 40mph on the highway and then shifted back to 5th gear. Transmission will occasionally stay on 3rd or 5th gear when at a complete stop. Dealership refuses to remedy recall issue for my truck. I have complained multiple times.

POWER TRAIN

Vehicle suddenly downshifts to a lower gear slowing the vehicle down rapidly and surprisingly

ELECTRICAL SYSTEM

The contact owns a 2011 Ford F-150. The contact stated that while driving at various speeds, the vehicle unexpectedly downshifted. The contact stated that the wheels were shaking. Upon starting the vehicle, the vehicle failed to shift out of first gear. The contact stated that the odometer was inoperable. The contact pulled over and restarted the vehicle, and the vehicle operated as designed. The contact stated that while driving at an undisclosed speed, the powertrain warning light illuminated. The contact stated that the failure was like NHTSA Campaign Number: 16V248000 (Power Train). The local was dealer was contacted but the vehicle was not diagnosed or repaired. The contact called another local dealer, Hacienda Ford of Kingsville (2501 US-77, Kingsville, TX 78363); but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the local dealer and the NHTSA Hotline. The failure mileage was approximately 105,000.

POWER TRAIN

The contact owns a 2011 Ford F-150. The contact stated that while driving at various speeds, the vehicle unexpectedly downshifted. The contact stated that the wheels were shaking. Upon starting the vehicle, the vehicle failed to shift out of first gear. The contact stated that the odometer was inoperable. The contact pulled over and restarted the vehicle, and the vehicle operated as designed. The contact stated that while driving at an undisclosed speed, the powertrain warning light illuminated. The contact stated that the failure was like NHTSA Campaign Number: 16V248000 (Power Train). The local was dealer was contacted but the vehicle was not diagnosed or repaired. The contact called another local dealer, Hacienda Ford of Kingsville (2501 US-77, Kingsville, TX 78363); but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the local dealer and the NHTSA Hotline. The failure mileage was approximately 105,000.

UNKNOWN OR OTHER

I have a wrench üîß showing up in the screen, the gears downshift,the gears shift from 3 to 6

ENGINE

I have a wrench üîß showing up in the screen, the gears downshift,the gears shift from 3 to 6

UNKNOWN OR OTHER

The back window in my truck shattered right as I was exiting it in the garage. After it happened I read online that this is a very widespread issue with these trucks. My rear defroster was turned on. I haven’t replaced the window yet. PLEASE make Ford do a recall for this. It’s happening to way too many trucks solely because of poor design. People shouldn’t have to foot the high cost of replacement. Thank you.