2020 FORD EXPEDITION

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2020 Expedition and Navigator vehicles that were repaired incorrectly under recall 20V262. The Pre-Collision Assist features, such as forward collision warning and automatic emergency braking, are not functional due to a software error.

Risk: Inoperative pre-collision assist features that fail to perform as expected can increase the risk of a crash or injury.

SEAT BELTS:PRETENSIONER

Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.

Risk: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.

SEAT BELTS:PRETENSIONER

Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently deploy and lock the seat belt, which will not allow the belt to retract or extend.

Risk: Seat belts that do not retract or extend may fail to restrain an occupant as intended, increasing the risk of injury in a crash.

EQUIPMENT:OTHER:LABELS

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."

Risk: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.

SEAT BELTS

Ford Motor Company (Ford) is recalling certain 2020 Expedition vehicles. The front passenger seatbelt buckle's Belt Tension Sensor (BTS) may malfunction and may result in the seat occupant being misclassified.

Risk: In the event of a crash, the restraint system may not provide the intended level of protection, increasing the risk of injury.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk: Reduced rearward visibility can increase the risk of a crash.

SEAT BELTS

Ford Motor Company (Ford) is recalling certain 2020 Expedition vehicles. The seat belt tension sensor may incorrectly classify a child occupant as an adult.

Risk: In the event of a crash, the incorrect classification would enable the passenger air bag to deploy instead of disabling it, increasing the risk of injury to the seat occupant.

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.

Risk: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.

Risk: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.

SEATS:MID/REAR ASSEMBLY

Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles. The attachment bracket for the driver's side second-row seat headrest may not have been sufficiently welded to the seat frame. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 202, "Head Restraints."

Risk: An improperly welded headrest bracket may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

POWER TRAIN

While driving on the interstate (I-35) and attempting to pass a vehicle, the transmission went out of gear and felt like it was in neutral for a few seconds and then ‘clunked” back into gear finally. This happened 4 times that day. This happens almost every time we go on a trip with this vehicle and is extremely dangerous to my family as well as other drivers. This seems to be a common issue with this model/year. It’s been reported to our dealer multiple times and they attempt to reprogram but doesn’t change anything. They said there’s no other fix. I have extended warranty.

SEAT BELTS

The contact owns a 2020 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V197000 (Seat Belts); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts for the recall repair were on back order. The dealer was unable to confirm when the vehicle would be repaired. The manufacturer was made aware of the issue. The contact had not experienced a failure.

POWER TRAIN

Transmission has exhibited harsh/delayed engagement and/or harsh/delayed shift during lane changes, almost causing me to crash on two occasions.

POWER TRAIN

Ongoing problem already had 2 repairs done to transmission. Gears o not shift properly when the gears go from 3-4 and 6-7. If I am not careful when I press on the gas and try to accelerate it does not shift gears and gets stuck on and my truck will not move more than 5-10 mph while I am trying to get on the highway at times with trailers coming full speed ahead behind me. I have reported this issue many times. There has been no remedy. The gears get stuck and make a jerking motion and movement causing truck to slow and barely move. It is not just a one time thing so I cant give a specific date as it happens often.

ENGINE

Ongoing problem already had 2 repairs done to transmission. Gears o not shift properly when the gears go from 3-4 and 6-7. If I am not careful when I press on the gas and try to accelerate it does not shift gears and gets stuck on and my truck will not move more than 5-10 mph while I am trying to get on the highway at times with trailers coming full speed ahead behind me. I have reported this issue many times. There has been no remedy. The gears get stuck and make a jerking motion and movement causing truck to slow and barely move. It is not just a one time thing so I cant give a specific date as it happens often.

POWER TRAIN

Recall issue with Catalytic converters causing check engine light to come on. I took in for recall to reset check engine light. Repair did not do anything to vehicle as check engine light comes on for a few days and goes away for a few days and the cycle repeats up until this day it continues to happen. When they did the reset Ford let me know that they reset the check engine issue for recall but I would have to pay about $5k for getting new converters if I wanted to because light would still be one since it was diagnosed that converters were bad.

ENGINE

Recall issue with Catalytic converters causing check engine light to come on. I took in for recall to reset check engine light. Repair did not do anything to vehicle as check engine light comes on for a few days and goes away for a few days and the cycle repeats up until this day it continues to happen. When they did the reset Ford let me know that they reset the check engine issue for recall but I would have to pay about $5k for getting new converters if I wanted to because light would still be one since it was diagnosed that converters were bad.

SEAT BELTS

The contact owns a 2020 Ford Expedition. The contact stated that while driving at 45 MPH, there was a loud pop, and smelled a burning odor inside the cabin of the vehicle, and the contact’s child cried out in pain, prompting the contact to pull over to the shoulder of the roadway. Upon inspection, the contact observed that the front passenger’s side seat belt had tightened excessively and locked, causing a small cut on the child’s chest. The air bag warnig light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the seat belt locking mechanism. The vehicle was not repaired due to the recall being a "Advance Notice Recall" which was not yet an official recall, and the contact would have to pay out of pocket for the repairs. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V197000 (Seat Belts). The VIN was included, but parts were not yet available. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 82,000.

AIR BAGS

The contact owns a 2020 Ford Expedition. While the contact's wife was driving at an undisclosed speed, the front passenger’s side air bag deployed unexpectedly. The contact stated that his twelve-year-old daughter was seated in the front passenger’s side seat during the failure. The daughter sustained a seat belt injury to the neck. The vehicle was taken to the dealer and the unintended deployment of the passenger’s side air bag was confirmed. The contact was informed that the air bag needed to be replaced. The vehicle was not repaired. The contact was informed that there was no recall coverage for the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 73,682.

FUEL/PROPULSION SYSTEM

We own a Ford Expedition 2020. In 2023, we started noticing jerky, harsh, and aggressive “slips” when the vehicle was trying to change gears - upon multiple occasions. But, in 2024, we experienced three, major, different instances - all were extremely scary and it was miraculous they didn’t cause accidents, car pile ups, or worse! The first instance, the vehicle jerked and sputtered just as I was pulling out into a busy intersection. I thought it was going to die in the middle of the road. The second instance, several weeks later, it happened, again, as our family was driving in pouring rain down the interstate; it jerked so hard it felt like we hit a small wall. The third and final instance, we were on our way to vacation - 9 hours away with our family. It sputtered, jerked, and laid in 1st gear. Thank God, we were right at a hotel and able to pull in. We found a local mechanic to take the Expedition in and begin work on it. He was so kind to loan us his car to take on to PA to the Sight & Sound Theater so we wouldn’t lose our money on the tickets. We ended up losing 2 full days of our 4 day vacation; had to rent a vehicle to drive back home; and left our Expedition in VA for 6 weeks while they rebuilt a transmission and cleaned the catalytic converter. $12,160 to the mechanic + $1000 in car rentals. Here we are, now in August 2025, and there’s been a recall on the Powertrain Control Module and that’s being replaced. Lo, and behold, what does the PCM do? It acts as the vehicle’s main computer, managing and controlling various engine and TRANSMISSION functions (adjusting engine parameters like fuel injection, ignition timing, and transmission shift points) - imagine that!

ENGINE

We own a Ford Expedition 2020. In 2023, we started noticing jerky, harsh, and aggressive “slips” when the vehicle was trying to change gears - upon multiple occasions. But, in 2024, we experienced three, major, different instances - all were extremely scary and it was miraculous they didn’t cause accidents, car pile ups, or worse! The first instance, the vehicle jerked and sputtered just as I was pulling out into a busy intersection. I thought it was going to die in the middle of the road. The second instance, several weeks later, it happened, again, as our family was driving in pouring rain down the interstate; it jerked so hard it felt like we hit a small wall. The third and final instance, we were on our way to vacation - 9 hours away with our family. It sputtered, jerked, and laid in 1st gear. Thank God, we were right at a hotel and able to pull in. We found a local mechanic to take the Expedition in and begin work on it. He was so kind to loan us his car to take on to PA to the Sight & Sound Theater so we wouldn’t lose our money on the tickets. We ended up losing 2 full days of our 4 day vacation; had to rent a vehicle to drive back home; and left our Expedition in VA for 6 weeks while they rebuilt a transmission and cleaned the catalytic converter. $12,160 to the mechanic + $1000 in car rentals. Here we are, now in August 2025, and there’s been a recall on the Powertrain Control Module and that’s being replaced. Lo, and behold, what does the PCM do? It acts as the vehicle’s main computer, managing and controlling various engine and TRANSMISSION functions (adjusting engine parameters like fuel injection, ignition timing, and transmission shift points) - imagine that!

POWER TRAIN

We own a Ford Expedition 2020. In 2023, we started noticing jerky, harsh, and aggressive “slips” when the vehicle was trying to change gears - upon multiple occasions. But, in 2024, we experienced three, major, different instances - all were extremely scary and it was miraculous they didn’t cause accidents, car pile ups, or worse! The first instance, the vehicle jerked and sputtered just as I was pulling out into a busy intersection. I thought it was going to die in the middle of the road. The second instance, several weeks later, it happened, again, as our family was driving in pouring rain down the interstate; it jerked so hard it felt like we hit a small wall. The third and final instance, we were on our way to vacation - 9 hours away with our family. It sputtered, jerked, and laid in 1st gear. Thank God, we were right at a hotel and able to pull in. We found a local mechanic to take the Expedition in and begin work on it. He was so kind to loan us his car to take on to PA to the Sight & Sound Theater so we wouldn’t lose our money on the tickets. We ended up losing 2 full days of our 4 day vacation; had to rent a vehicle to drive back home; and left our Expedition in VA for 6 weeks while they rebuilt a transmission and cleaned the catalytic converter. $12,160 to the mechanic + $1000 in car rentals. Here we are, now in August 2025, and there’s been a recall on the Powertrain Control Module and that’s being replaced. Lo, and behold, what does the PCM do? It acts as the vehicle’s main computer, managing and controlling various engine and TRANSMISSION functions (adjusting engine parameters like fuel injection, ignition timing, and transmission shift points) - imagine that!

VEHICLE SPEED CONTROL

The contact owns a 2020 Ford Expedition. The contact stated that while depressing the accelerator pedal, the vehicle failed to respond as intended and the vehicle lost power. A dealer was contacted. The vehicle was taken to a dealer to be diagnosed; however, the diagnostic result was not provided. The vehicle was not repaired. The manufacturer was not notified on the failure. The approximate failure mileage was 106,000.

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated that while depressing the accelerator pedal, the vehicle failed to respond as intended and the vehicle lost power. A dealer was contacted. The vehicle was taken to a dealer to be diagnosed; however, the diagnostic result was not provided. The vehicle was not repaired. The manufacturer was not notified on the failure. The approximate failure mileage was 106,000.

VEHICLE SPEED CONTROL

The contact owns a 2020 Ford Expedition. The contact stated while driving 40 MPH and attempting to accelerate, the vehicle went into LIMP Mode and the vehicle lost motive power. The contact was able to pull over to the shoulder of the roadway and turned off the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 55,000.

POWER TRAIN

Driving and transmission gear bumping hard when shifting gears. Have pulled out twice to pass and transmission made hard bump and I could not go anywhere. The last time this happened was 7/29/25 and it made a lot of clanking noise and the faulty light came on. I let off the gas and it went back in gear and I made it home and have not drove it since. Ford dealership said there was no recall on transmission but I have read alot of complaints from other 2020 Expedition owners about this problem I have 70,000. plus miles and have taken extreme care of this vehicle.

POWER TRAIN

Failure of transmission, leading to unsafe operation on roadway.

POWER TRAIN

Info sent to Ford in working with cust service w/o action: Our 2020 Expedition had 4 separate instances of slipping out of gear during a road trip (2 instances on 7/11 and 2 on 7/19). During each incident, the vehicle slipped gear at highway speed, RPMs maxed out on the dial, lost all acceleration and significant speed, and the vehicle remained unresponsive for several (3-5) seconds until finally accelerating after the unresponsive period. It goes without saying that completely losing gear at highway speed while navigating traffic is a serious life and safety issue. Having that occur four times on a single round trip presents unreasonable risk. We documented the mileage and engine conditions by taking a picture of the dash after recovering from each occurrence. Those details were shared with the Krieger Ford service center on 7/22. That Ford service team was not able to recover fault codes from this information. Without being able to identify a root cause based on lack of fault codes, Ford Service performed a transmission relearn on 7/22. The service team confirmed this step is an initial measure due to lack of codes and not being able to see inside the sealed transmission. Abandoning further assessment in favor of a potential but unlikely quick-fix may be appropriate with an inconvenience issue, but not acceptable on one with such serious consequences. I recognize that further assessment will require additional cost. The assessment cost relative to the risk associated with not properly addressing the root cause of this dangerous issue is clearly justified. I’ve previously communicated this same situation to Ford when it occurred on a road trip in July of 2024. We contacted the dealership (Germain Ford of Dublin) and were deferred multiple months due to Ford's transmission tech backlog. The codes were not available by the time a service appointment was open. Without error codes and a single occurrence at that time, Ford service was unable to investigate further.

ELECTRICAL SYSTEM

Just about every time we get in the vehicle the center screen won’t light up and requires a power and fast forward button to reset. Sometimes this needs to be done twice in one drive.

POWER TRAIN

Hard downshift, loss of power.

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated that while driving at various speeds, the vehicle failed to accelerate properly while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer; however, the dealer failed to duplicate the failure. The contact stated that after several visits to the dealer, the dealer acknowledged the failure, and a valve body replacement was performed. The contact stated that the failure returned, and the failure became more frequent. The vehicle was taken to a dealer, and the ignition coils and spark plugs were replaced. The vehicle was valeted back to the residence, and the valet informed the contact that the failure was still present. The valet brought the vehicle back to the dealer, where it remained. The vehicle was diagnosed with a defective transmission, and the contact was informed that the vehicle was no longer covered under warranty. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 60,000.

POWER TRAIN

The contact owns a 2020 Ford Expedition The contact stated while depressing the accelerator pedal, the vehicle failed to respond as intended. The contact stated that the gear shifter operated independently. A dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified on the failure and transferred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 127,000.

POWER TRAIN

See attached document for complaint.

POWER TRAIN:AUTOMATIC TRANSMISSION

See attached document for complaint.

FUEL/PROPULSION SYSTEM

On several occasions the engine has slipped/stalled. Vehicle has only 27k miles on it, single owner. When moving from a stoplight the engine "slipped", all lights came on "service alert" or something similar. Vehicle recovered but I am very uneasy as I am a [XXX] female usually [XXX] and often on a very busy section of [XXX]. (This has occurred multiple times) When increasing speed, as to pass a vehicle or otherwise, vehicle is unresponsive or lags. To be clear this happens at speeds of 40-50 mph. It is unpredictable when this will occur nor why. I will likely sell this vehicle due to this safety issue. I spoke with a service rep at the local ford dealership who was able to look into the vehicle computer remotely but there was no record of the "Alert" or otherwise. I took the vehicle to my local mechanic who drove it and was able to replicate the danger/slipping. I was advised to do "zip code" driving only. I believe this "engine slipping" is related to the Recall just issued except the 2020 Ford Expedition is not included in this recall. Others have noted this issue as well with NHTSA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

On several occasions the engine has slipped/stalled. Vehicle has only 27k miles on it, single owner. When moving from a stoplight the engine "slipped", all lights came on "service alert" or something similar. Vehicle recovered but I am very uneasy as I am a [XXX] female usually [XXX] and often on a very busy section of [XXX]. (This has occurred multiple times) When increasing speed, as to pass a vehicle or otherwise, vehicle is unresponsive or lags. To be clear this happens at speeds of 40-50 mph. It is unpredictable when this will occur nor why. I will likely sell this vehicle due to this safety issue. I spoke with a service rep at the local ford dealership who was able to look into the vehicle computer remotely but there was no record of the "Alert" or otherwise. I took the vehicle to my local mechanic who drove it and was able to replicate the danger/slipping. I was advised to do "zip code" driving only. I believe this "engine slipping" is related to the Recall just issued except the 2020 Ford Expedition is not included in this recall. Others have noted this issue as well with NHTSA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

On several occasions the engine has slipped/stalled. Vehicle has only 27k miles on it, single owner. When moving from a stoplight the engine "slipped", all lights came on "service alert" or something similar. Vehicle recovered but I am very uneasy as I am a [XXX] female usually [XXX] and often on a very busy section of [XXX]. (This has occurred multiple times) When increasing speed, as to pass a vehicle or otherwise, vehicle is unresponsive or lags. To be clear this happens at speeds of 40-50 mph. It is unpredictable when this will occur nor why. I will likely sell this vehicle due to this safety issue. I spoke with a service rep at the local ford dealership who was able to look into the vehicle computer remotely but there was no record of the "Alert" or otherwise. I took the vehicle to my local mechanic who drove it and was able to replicate the danger/slipping. I was advised to do "zip code" driving only. I believe this "engine slipping" is related to the Recall just issued except the 2020 Ford Expedition is not included in this recall. Others have noted this issue as well with NHTSA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

What component or system failed or malfunctioned, and is it available for inspection upon request? The Powertrain Control Module (PCM), which manages engine-transmission communication and regulates cooling system performance, malfunctioned, resulting in a cascade of related failures: Transmission system: Delayed shifting, hesitation, and eventually a “transmission stuck in park” code. Cooling system: Repeated overheating that led to a ruptured radiator. These issues stem from the faulty PCM referenced in Ford Recall 24E13, issued on April 25, 2025. Yes, the failed components remain in the possession of Harbin Motor Company in Scottsboro, AL, where the vehicle is still located. The vehicle has not been repaired and is available for inspection upon request. How was your safety or the safety of others put at risk? This vehicle was operated while exhibiting documented powertrain and overheating symptoms—including while transporting children. Harbin Ford repeatedly instructed continued use despite: Diagnostic scans on April 10, 2025 confirming PCM-related failures including “transmission stuck in park” and overheating. A coolant leak that occurred without warning lamps, leading to the radiator bursting. These failures put occupants at serious risk of breakdown or fire, especially in high-traffic or high-temperature driving conditions. Operating a vehicle with a malfunctioning PCM increases the likelihood of gear slippage, sudden deceleration, or complete transmission failure. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue has been repeatedly confirmed by Harbin Motor Company, an authorized Ford dealer: On April 10, 2025, a scan identified “transmission stuck in park,” overheating, and a third unidentified code. On May 15, 2025, the service manager Craig Davis confirmed the transmission had an internal issue requiring a full rebuild and located a coolant leak. These confirmations were documented via servi

UNKNOWN OR OTHER

What component or system failed or malfunctioned, and is it available for inspection upon request? The Powertrain Control Module (PCM), which manages engine-transmission communication and regulates cooling system performance, malfunctioned, resulting in a cascade of related failures: Transmission system: Delayed shifting, hesitation, and eventually a “transmission stuck in park” code. Cooling system: Repeated overheating that led to a ruptured radiator. These issues stem from the faulty PCM referenced in Ford Recall 24E13, issued on April 25, 2025. Yes, the failed components remain in the possession of Harbin Motor Company in Scottsboro, AL, where the vehicle is still located. The vehicle has not been repaired and is available for inspection upon request. How was your safety or the safety of others put at risk? This vehicle was operated while exhibiting documented powertrain and overheating symptoms—including while transporting children. Harbin Ford repeatedly instructed continued use despite: Diagnostic scans on April 10, 2025 confirming PCM-related failures including “transmission stuck in park” and overheating. A coolant leak that occurred without warning lamps, leading to the radiator bursting. These failures put occupants at serious risk of breakdown or fire, especially in high-traffic or high-temperature driving conditions. Operating a vehicle with a malfunctioning PCM increases the likelihood of gear slippage, sudden deceleration, or complete transmission failure. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue has been repeatedly confirmed by Harbin Motor Company, an authorized Ford dealer: On April 10, 2025, a scan identified “transmission stuck in park,” overheating, and a third unidentified code. On May 15, 2025, the service manager Craig Davis confirmed the transmission had an internal issue requiring a full rebuild and located a coolant leak. These confirmations were documented via servi

POWER TRAIN

What component or system failed or malfunctioned, and is it available for inspection upon request? The Powertrain Control Module (PCM), which manages engine-transmission communication and regulates cooling system performance, malfunctioned, resulting in a cascade of related failures: Transmission system: Delayed shifting, hesitation, and eventually a “transmission stuck in park” code. Cooling system: Repeated overheating that led to a ruptured radiator. These issues stem from the faulty PCM referenced in Ford Recall 24E13, issued on April 25, 2025. Yes, the failed components remain in the possession of Harbin Motor Company in Scottsboro, AL, where the vehicle is still located. The vehicle has not been repaired and is available for inspection upon request. How was your safety or the safety of others put at risk? This vehicle was operated while exhibiting documented powertrain and overheating symptoms—including while transporting children. Harbin Ford repeatedly instructed continued use despite: Diagnostic scans on April 10, 2025 confirming PCM-related failures including “transmission stuck in park” and overheating. A coolant leak that occurred without warning lamps, leading to the radiator bursting. These failures put occupants at serious risk of breakdown or fire, especially in high-traffic or high-temperature driving conditions. Operating a vehicle with a malfunctioning PCM increases the likelihood of gear slippage, sudden deceleration, or complete transmission failure. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue has been repeatedly confirmed by Harbin Motor Company, an authorized Ford dealer: On April 10, 2025, a scan identified “transmission stuck in park,” overheating, and a third unidentified code. On May 15, 2025, the service manager Craig Davis confirmed the transmission had an internal issue requiring a full rebuild and located a coolant leak. These confirmations were documented via servi

POWER TRAIN

I’ve owned my 2020 Ford Expedition for just over a year. Initially, the transmission performed flawlessly. However, over time I’ve noticed a few concerning issues: At low speeds, the transmission shifts very hard. While accelerating at interstate speeds, it feels like the transmission is slipping. When I shift the vehicle into gear, it makes a loud clicking or knocking sound.

POWER TRAIN

I was driving pulling off an exit incoming to a highway that needed me to speed up to catch a 65 MPH traffic while I was going 35MPH the car while on D for drive somehow engine REV went up to 5500 RPM no power to drive vehicle slow down to 30MPH and all of the sudden a Violent engine and all the body clunk as if another gear or Park all of the sudden! Tires stop spinning as you can hear tires screeching and this lasted a second and then transmission caught up again and started to accelerate again normally. We were almost hit from a moving truck behind us with 3 small kids in the car! This already happened 3 separate times while we are out traveling out of our hometown. 98 degrees outside dry conditions flat surface in Florida Got it all on Dash Camera on VIDEO and Audio Hope to get this fixed before someone gets KILLED!

POWER TRAIN

Transmission hesitated when entering traffic almost causing accident. This is not the first time this has happened. After the first incident I addressed the issue with the service manager. He said it’s common that this model transmission shifts rough, and has some hick ups but, nothing to worry about. It also randomly shifts into neutral randomly.

POWER TRAIN

The transmission is consistently hesitating to switch gears, very jerky gear shift, and will sometimes completely fall out of gear. You could so easily lose control if this happened on the highway. Thank goodness we weren’t on a busy street. This isn’t the first reporting according to a simple search online and there should be a recall for safety reasons. This could be life or death for someone driving on the highway.

ENGINE

The transmission is consistently hesitating to switch gears, very jerky gear shift, and will sometimes completely fall out of gear. You could so easily lose control if this happened on the highway. Thank goodness we weren’t on a busy street. This isn’t the first reporting according to a simple search online and there should be a recall for safety reasons. This could be life or death for someone driving on the highway.

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated while driving 40 MPH and attempting to overtake a semi-truck, the vehicle shuddered, lost motive power, and made an abnormal clunking and winding sound. The contact stated that the failure had occurred several times while driving and depressing the accelerator pedal and while driving from a complete stop. The check engine warning light was illuminated. The vehicle was taken to the dealer; however, failure could not be duplicated. The contact stated that the failure reoccurred. The vehicle was taken to Krapohl Ford (1415 E Pickard St, Mt Pleasant, MI 48858), where the transmission shifter cables were reset through a computer update; however, the failure persisted. The vehicle was taken back to the dealer, where the cause of the failure could not be determined; however, the dealer recommended the transmission be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated while driving at an undisclosed speed, the transmission shifted hard between gears. The contact stated an unknown warning light was illuminated and then went off. In addition, the contact stated that the transmission hesitated while shifting between gear and then unexpectedly downshifted. The contact stated that the transmission seemed not to identify the intended gear. The contact stated that the failure had become persistent. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The vehicle was scheduled for a diagnostic test. The contact stated that when the failure started, the vehicle was taken to the dealer several times, however the failure was not duplicated. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 35,000.

POWER TRAIN

The contact owns a 2020 Ford Expedition. While the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission unexpectedly downshifted from tenth gear to first gear. The contact's wife drove the vehicle to the shoulder of the road. The contact's wife was almost rear-ended by a tractor trailer. The vehicle was driven to the residence with the hazard lights activated. The contact test drove the vehicle and the failure reoccurred. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. In addition, the contact stated that in 2024, two transmission software updates were performed by the dealer. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 55,000.

POWER TRAIN

i bought a 2020 ford expedition with the 10r80 transmission last july. They have used this transmission since 2017 and continue to put it in vehicles depite having many issues with them. When i was sold this vehicle i was told it had a new transmission just put in it (by another dealership than who i was buying it from) and the carfax (that i still have) shows that the transmission had been replaced. In the last month or so ive been having a hard shift at 4th and 8th gear. i figured it would be covered under warranty so i take it back to the dealership that did the work. They said it didnt have a new transmission only the cdf clutch was replaced. now when i look at the carfax it only shows the tranmission was rebuilt. Thats Fraud. a dealership shouldnt be able to change a entry. i was only 2231 miles over the powertrain warranty and ford will not help. the part that was fixed only had a year warranty and it just a month past a year since it was repaired. Ford knows this tranmission has problems and should be held accountable. i look forward to hearing from someone.

ENGINE

Transmission has extremely hard downshifting which has required the tea be replaced. Vehicle will downshift so hard it feels like you have been rear ended. Vehicle has to be put into neutral and then back into drive. This is very hazardous.

POWER TRAIN

Transmission has extremely hard downshifting which has required the tea be replaced. Vehicle will downshift so hard it feels like you have been rear ended. Vehicle has to be put into neutral and then back into drive. This is very hazardous.

POWER TRAIN

My check engine lights comes on and off reading that it is a failure with the catalytic converter. Check engine light had been on for 2 weeks I had already called Ford to set up appt. The evening before taking truck in check engine light went off. I called Ford 5/13/25 that light had gone off do I still take truck in. Since I received letter for recall, I took truck in for service . They say they only need to reprogram the PCM but now they are saying that the Catalytic Converter is bad and needs to be replaced costing $5000. What is Ford thinking this truck has been nothing but problems. I told tech that truck has been running accelerated for a few weeks when driving. Problem with check engine light could not be reproduced since it turned off the day before I had appt set. Rep told me that they just needed to see if they could read that it was the recall issue and they would just reprogram it.

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated the transmission was slipping while driving at an undisclosed speed. The contact stated that on one occasion, while her daughter was driving 60 MPH, the transmission started slipping and the vehicle failed to accelerate above 60 MPH. There were no warning lights illuminated. The contact stated that the failure was related to TSB: 23-2120. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The dealer informed the contact that the vehicle needed to be test-driven. The manufacturer was contacted and opened a case. The failure mileage was approximately 85,000.

VEHICLE SPEED CONTROL

The contact owns a 2020 Ford Expedition. The contact stated the transmission was slipping while driving at an undisclosed speed. The contact stated that on one occasion, while her daughter was driving 60 MPH, the transmission started slipping and the vehicle failed to accelerate above 60 MPH. There were no warning lights illuminated. The contact stated that the failure was related to TSB: 23-2120. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The dealer informed the contact that the vehicle needed to be test-driven. The manufacturer was contacted and opened a case. The failure mileage was approximately 85,000.

POWER TRAIN

At highway speed 70mph, I accelerated and the vehicle downshifted to 1st, followed by loss of gear with a loud clunk. Then alarming for transmission. After coasting to about 30mph the teansmission clunked again and powere cane back. Happened while passing a semi truck. This was reproduced multiple times, on demand and I have video documentation. Dealer eventually rehauled the transmission. But now its starting to miss gears / have hard shifts. This transmission is a Huge safety risk.

ENGINE

This suv has 10 speed transmission that has faulty harsh shifting hesitation, acceleration problem when shifting on highway or in situations when you need to slow down and or accelerate. This has happened many times while trying to get on the highway and switching lanes. I have almost been run over because it stalled someone is going to get killed. I have had the Powertrain control module pcm reprogramed twice and it keeps happening. Ford is aware of this. They need to get this trucks off of the road!

POWER TRAIN

This suv has 10 speed transmission that has faulty harsh shifting hesitation, acceleration problem when shifting on highway or in situations when you need to slow down and or accelerate. This has happened many times while trying to get on the highway and switching lanes. I have almost been run over because it stalled someone is going to get killed. I have had the Powertrain control module pcm reprogramed twice and it keeps happening. Ford is aware of this. They need to get this trucks off of the road!

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated while driving 65 MPH and depressing the accelerator pedal, the vehicle turned off and downshifted independently. The vehicle was not diagnosed by a dealer or independent mechanic. The vehicle was not repaired. The contact stated that the vehicle had experienced the failure listed in NHTSA Campaign Number: 20V197000 (Power Train); however, the VIN was not included. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 88,000.

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated that occasionally, while putting the vehicle into drive or attempting to accelerate from a stop, the vehicle first hesitated or jerked before shifting into gear. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the CDF drums and seal in the transmission were faulty and needed to be replaced. Additionally, a transmission strategy download and transmission shift adapt tables needed to be performed. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 71,000.

STRUCTURE

The contact owns a 2020 Ford Expedition. The contact stated that upon entering the rear passenger’s side of the vehicle, the folding seat gap hider panel was missing, leaving a deep hole on the floor, approximately 19 inches deep. The contact believed that was a serious safety concern for a small child. No warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 87,000.

ENGINE

The contact owns a 2020 Ford Expedition. The contact stated that there was an abnormal rattling sound coming from the vehicle at start-up. There was no warning light illuminated. The vehicle was taken to a dealer and was diagnosed with a defective cam phaser. The manufacturer was notified of the failure and informed the contact that there were no recalls on the vehicle for the failure and a case was filed. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 97,000.

POWER TRAIN

When accelerating quickly, such as to pass, the truck feels as if it is in neutral. when the gas pedal is pushed down, the RPMs jump up, but the truck doesn't accelerate. After letting off the gas, the RPMs will drop, there is a loud "clunk" in the rear end and then power will be restored. No codes are being stored to diagnose issue. Happens intermittently and all speeds.

UNKNOWN OR OTHER

The rear back up camera has recently been glitching and most times has a solid blue screen when car is in reverse. It was in for diagnostics, report came back stating: Verified customer concern; screen turns blue when vehicle is placed in reverse. Retrieved CMDTC B115E 08 stored current in IPMB. Verified gear selected matches commanded data in IPMB. Removed and tested circuit with known good camera, and rear view image works each time vehicle is placed in reverse, confirming circuit is good.

POWER TRAIN

At 45000 miles the transmission started slipping gears, we took into our local ford dealership for a warranty repair. They had it for a month and a half stated the computer just needed reprograming. Well now we sit at 72000 miles and the vehicle needs a WHOLE new transmission. They are stating that due to axial movement of the CDF clutch cylinder bushing it has caused failure of the transmission. My vehicle has came to a complete stop no warning multiple times in the middle of the roadway, I have been stopped at a red light and when I hit the gas, the car rolled backwards. There were ZERO warning lights, only a hard shift every now and than. The car is currently at the dealership and ford is refusing to help even with multiple other vehicles with this same issue. They have sent me a 10k bill. From my understanding this same transmission has already been recalled in other ford vehicles.

ELECTRICAL SYSTEM

The contact owns a 2020 Ford Expedition. The contact stated that when the A/C was activated, there was condensation pooling on the passenger’s side fuse box, causing the transmission to not be able to shift out of park(P). The contact stated that he was able to start the vehicle. The contact stated that numerous warning lights were illuminated. Additionally, the contact was unable to turn off the headlights. The vehicle was towed to a local dealer, who diagnosed the vehicle and determined that condensation had damaged the fuse box and caused the body control module to fail. The vehicle was not repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to Technical Service Bulletin: 20-2170 Water Leaking on Right Front Floor After A/C Use (Electrical System). The failure mileage was approximately 63,000.

POWER TRAIN

The vehicle's transmission shutters upon rapid acceleration, especially at high speeds. It feels like it goes into neutral while trying to shift and jerks into the next gear. The RPMs shoot up and back down when this happens. You can also feel the car lose power (decelerate) when this happens.

SEAT BELTS

Safety recall issued but no parts and no date set. Go on record as stating the safety recall was issued, dealer contacted but no repair available and no estimated date.

POWER TRAIN

We have replaced our transmission twice and sending the truck in for a third replacement. The transmission does not run smooth and when it shifts from 3rd to 4th gear it drops into gear very roughly. The last time it did this the TCM also faulted which stuck the truck in 7th gear while driving on a highway. Ford will only replace with the same part in a manufactured condition.

POWER TRAIN

A 2020 vehicle with 80K miles is in need of a new transmission, after having hard shifting problems a few months previous. Rarely used for any towing. Appears to have a defective transmission.

POWER TRAIN

My 2020 Ford Expedition was repaired by Ford (under the power train warranty) in early 2024 for down shifting and loss of power when attempting to accelerate. That repair took multiple weeks. Last week (March 2025), while driving on the highway at 75mph, the vehicle lost all acceleration and the power train warning light came on. We pulled over since we could not accelerate. The vehicle was brought to the same Ford dealership where they diagnosed another transmission issue. The vehicle remains at the dealership until Ford determines an exact diagnosis and how they will proceed. The vehicle has now had two major transmission issues, the second of which occurred at highway speeds. The vehicle was purchased new in June 2020 and currently has 56k miles.

SEAT BELTS

use this car for business as part of my income. Ford has issued an Advance Recall Notice. In March 2025. I have not been able earn money because of the recall notice. Manufacturer recall number: 25S31 NHTSA Recall number: pending From legal advice, the Advance Recall Notice is for the dealers and is not an Official Recall Notice. Since the notice, I have been unable to rent out my vehicle. I have another Advance Recall Notice on my other vehicle a 2018 Explorer. I need to make a living. What actions can be taken.? I've called numerous times first to times, no answer phone just rang after initial message. The following times, a human answered after message but i was disconnected or inadvertently put on hold. Then steered to this page. Looking for some assistance. I have 2 vehicles down due to Advanced Recall Notices. I can't afford to have 2 cars down. What is going on here.

UNKNOWN OR OTHER

Sunroof explosion while driving on the highway. Loud bang rattled the driver and passenger. Driver was able to maintain control of the vehicle, but it could have been catastrophic for our vehicle and the vehicles around us if control was not maintained. Our Ford dealer said he has heard of sunroof explosions before. Dealership has the vehicle and is awaiting authorization to repair. Allstate Insurance is also involved. There was no warning anything was wrong. This vehicle was bought brand new (1 owner) and is now 5 years old, has run great and has been properly maintained at our local Ford dealership.

SEAT BELTS

The contact owns a 2020 Ford Expedition. The contact received notification of Manufacturer Recall Number: 25S31; NHTSA Campaign Number: (AWAITING); regarding seat belts; however, the parts to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

POWER TRAIN

The Shift Cable is not seating correctly causing the vehicle to slip out of gear. This mostly occurs if you are at cruising speed and then accelerate to pass a slow vehicle. The Transmission slips out of gear and then you have to decelerate to allow it to find gear. It also makes a hard clunking noise when shifting out of park into drive. This is the same exact issue that was recalled for the police versions. However, my vehicle has the exact same issue and concern, verified by the Ford Technician. Mine is not covered under the recall as it only covers Police versions. So I was asked to pay $9,859 for a new transmission. I am 6,000 miles outside of warranty and have no vehicle to drive now as my 4 year old vehicle is basically totaled over a transmission. Ford Corporate declined any financial assistance even though it is a known product issue.

POWER TRAIN

First my vehicle kept saying service shift system fault, then when the dealership did something to repair that, the next week they told me I need a new transmission. This put my family of seven at risk because the transmission started stalling while we were going on a trip and also had a hard time shifting to different gears and would make a clunking sound. We also started rolling backwards down a hill and barely made it up the hill. The car also started stalling while I was driving it on the interstate which almost made us get into a multi car accident at night. When I took my vehicle to one ford dealership they told me it was the transmission but when I took it to a different one they told me something else just for them to fix it and then a week later tell me it’s the transmission. My Expedition has been at the Ford dealership for over two weeks now because I’m trying to get goodwill assistance from the Ford corporate office. The warning sign that came on was service system fault and a wrench light.

POWER TRAIN

My vehicle without notice just pops into neural and i get a warning on my dash it has happened several times and every time it has happened it has been on a busy freeway. Very dangerous conditions . I have taken into the ford place to get checked out. also my Ford app had notifications.

POWER TRAIN

While driving on a highway at approximately 40mph, attempted to pass a slower vehicle. I accelerated and the vehicle dropped down in gear, started shuddering, lost power and the MIL light started flashing. I pulled to the side of the road and the vehicle shifted into another gear and seemed to operate normally. Vehicle is currently at the Ford dealership, where they say that I need a new transmission.

POWER TRAIN

Transmission, it is available for inspections. Loss of acceleration power while at interstate speed, the otr driver behind us could barely stop quick enough. Two more occurrences happened same trip while driving from New Orleans to Lake Charles. Driving 75 in left lane, took foot off accelerator to coast and navigate into right lane and while transmission was supposed to be downshift, I lost power again and watched my RPM’s rise suddenly. Ford dealership ran diagnostics, and told me the valve body needs replaced at roughly 2k, I am 15000 out of warranty and they acted like they knew but wouldn’t help me. An independent transmission dealer in Lake Charles told me to trade the vehicle in or put a 2025 ford transmission in at 7k, the problem is, I don’t have that kind of money, and this should absolutely not be happening at 85k miles. He insisted the transmission was damaged and dangerous to be driving, and this is prevalent with the type of transmission in fords and chevy’s from 2019-2024. No warning lights or alarms came on at the time of these incidents that I recall, honestly I was too busy making sure I didn’t kill my wife and 4 kids. Apparently, this is a well known issue with these transmission, but now I’m faced with having to either trade in a vehicle that I am most likely upside down on, to no fault of my own, having to purchase a new vehicle that fits my family, or purchasing a 2025 ford transmission at the recommendation of local transmission dealer, there is no history on ford 2025 transmissions so idk if this the way to go. While I will get this figured out, I am taking the time to express my personal concern and experience in this matter and hope there are no future casualties related to this issue, which I’m afraid Ford will only address if there is, sadly.

POWER TRAIN

I was driving my vehicle at 48 mph and went to accelerate; the car slips out of gear and drops into neutral, started smelling smoke. This is the 5th occurrence. Previous occurrence happened while traveling in dark, rainy weather on the interstate. I am lucky that no accident occurred. I had car serviced for this same issue in 8/2024, but they did not fix the transmission issue. The vehicle is currently at the dealership service department. The dealer has been unable to reproduce the issue as it has happened a handful of times and does not give the service department a diagnostic code upon diagnosing. The dealer service department inspected the vehicle and is saying that I need a whole new transmission, although the first time I took it in for the same issue they fixed the throttle body, which is completely unrelated to the transmission. At the time of all of the incidents, the car flashes a "system fault/failure". It happens so quickly I cannot remember exactly what it says. When service department tries to diagnose there are no diagnostic codes. No warning symbols appear on dash after car is shut-off and restarted. This seems to be a known issue with Ford 10-speed transmissions (10R80). Why have they not had to recall these? I am lucky that I have not injured in these incidents. Are they waiting for someone to get critically hurt??

ENGINE

The contact owns a 2020 Ford Expedition. The contact stated while driving approximately 60 MPH, the check engine warning light illuminated, and the vehicle lost motive power. The vehicle was taken to a local dealer who diagnosed the vehicle and determined that the transmission had failed and needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle lost motive power with the check engine warning light illuminated. The contact returned the vehicle to the same dealer. The dealer diagnosed the vehicle and determined that a hose on the transmission had not been installed correctly. The vehicle was repaired; however, the failure reoccurred two more times, and the vehicle was returned to the same dealer. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 99,000.

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated while driving approximately 60 MPH, the check engine warning light illuminated, and the vehicle lost motive power. The vehicle was taken to a local dealer who diagnosed the vehicle and determined that the transmission had failed and needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle lost motive power with the check engine warning light illuminated. The contact returned the vehicle to the same dealer. The dealer diagnosed the vehicle and determined that a hose on the transmission had not been installed correctly. The vehicle was repaired; however, the failure reoccurred two more times, and the vehicle was returned to the same dealer. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 99,000.

EXTERIOR LIGHTING:HEADLIGHTS

The contact owns a 2020 Ford Expedition. The contact stated that the front headlights were very dim while in use. The vehicle was taken to an independent mechanic and the contact was informed that the projector inside the headlight assemblies were defective, causing the headlights to not illuminate as needed. The contact was provided an estimate for the repair. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 60,000.

POWER TRAIN

Several times per month, At normal highway speeds, vehicle slips out of gear into first gear. Vehicle also grinds through gears when searching for correct gear. Transmission shifts hard under normal conditions when up shifting to third gear.

LANE DEPARTURE: BLIND SPOT DETECTION

Hello, my name is [XXX] and I’m writing in regards to the transmission issues with my Ford expedition. I have reached out to the customer service line and currently my vehicle is at confidence Ford in Norman, OK. I’ve had issues with this vehicle since I bought it New and I’ve tried multiple times to have the transmission repaired. It has been to Patriot Ford in Purcell, OK(No longer in business), Zeke Ford in Purcell, OK (No longer in business) Woody Ford in Madill, OK.I’ve tried multiple times to get it into other dealerships, lastly it has ended up at Confidence Ford, Norman, OK. Due to the nature of the transmission, it has caused multiple problems and almost deadly situations. This vehicle has been stalling out and losing power since the day we bought it. CUSTOMER SERVICE said that they cannot help us because it is over the hundred thousand miles mark, but I have continued to seek Support and Repair Services since I bought it new in 2021. If you recall during this time, it was after Covid when there was limited resources for repairs and dealerships to offer loaner vehicles or to even rent loaner vehicles. So in the situation of not being able to keep it in service they would give it back. Before I bought this vehicle new, I owned the exact same vehicle that I had bought preowned from Seth Wadley Ford in Pauls Valley, OK. The previous vehicle had the exact same issues and was a Complete LEMON. The previous vehicle had to be traded in for a new one. We thought that buying a new one hoping It would not be a lemon, and with a warranty that we would not have a problem and that the previous one was a fluke. Sadly it was not. I have almost been T-bone, rear ended and hit head on with my 3 young children in the car on multiple occasions, too many to count. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SEAT BELTS

Hello, my name is [XXX] and I’m writing in regards to the transmission issues with my Ford expedition. I have reached out to the customer service line and currently my vehicle is at confidence Ford in Norman, OK. I’ve had issues with this vehicle since I bought it New and I’ve tried multiple times to have the transmission repaired. It has been to Patriot Ford in Purcell, OK(No longer in business), Zeke Ford in Purcell, OK (No longer in business) Woody Ford in Madill, OK.I’ve tried multiple times to get it into other dealerships, lastly it has ended up at Confidence Ford, Norman, OK. Due to the nature of the transmission, it has caused multiple problems and almost deadly situations. This vehicle has been stalling out and losing power since the day we bought it. CUSTOMER SERVICE said that they cannot help us because it is over the hundred thousand miles mark, but I have continued to seek Support and Repair Services since I bought it new in 2021. If you recall during this time, it was after Covid when there was limited resources for repairs and dealerships to offer loaner vehicles or to even rent loaner vehicles. So in the situation of not being able to keep it in service they would give it back. Before I bought this vehicle new, I owned the exact same vehicle that I had bought preowned from Seth Wadley Ford in Pauls Valley, OK. The previous vehicle had the exact same issues and was a Complete LEMON. The previous vehicle had to be traded in for a new one. We thought that buying a new one hoping It would not be a lemon, and with a warranty that we would not have a problem and that the previous one was a fluke. Sadly it was not. I have almost been T-bone, rear ended and hit head on with my 3 young children in the car on multiple occasions, too many to count. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

Hello, my name is [XXX] and I’m writing in regards to the transmission issues with my Ford expedition. I have reached out to the customer service line and currently my vehicle is at confidence Ford in Norman, OK. I’ve had issues with this vehicle since I bought it New and I’ve tried multiple times to have the transmission repaired. It has been to Patriot Ford in Purcell, OK(No longer in business), Zeke Ford in Purcell, OK (No longer in business) Woody Ford in Madill, OK.I’ve tried multiple times to get it into other dealerships, lastly it has ended up at Confidence Ford, Norman, OK. Due to the nature of the transmission, it has caused multiple problems and almost deadly situations. This vehicle has been stalling out and losing power since the day we bought it. CUSTOMER SERVICE said that they cannot help us because it is over the hundred thousand miles mark, but I have continued to seek Support and Repair Services since I bought it new in 2021. If you recall during this time, it was after Covid when there was limited resources for repairs and dealerships to offer loaner vehicles or to even rent loaner vehicles. So in the situation of not being able to keep it in service they would give it back. Before I bought this vehicle new, I owned the exact same vehicle that I had bought preowned from Seth Wadley Ford in Pauls Valley, OK. The previous vehicle had the exact same issues and was a Complete LEMON. The previous vehicle had to be traded in for a new one. We thought that buying a new one hoping It would not be a lemon, and with a warranty that we would not have a problem and that the previous one was a fluke. Sadly it was not. I have almost been T-bone, rear ended and hit head on with my 3 young children in the car on multiple occasions, too many to count. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

The transmission on my Ford Expedition is "slipping" and causing safety concern when there is a need to accelerate or decelerate, but the transmission is struggling to shift into 8th gear and then when it finally does, it causes an abrupt jerk. This has put my family in at risk several times, but we had an incident this morning and I decided it needed to be reported. The dealer was able to inspect, diagnose, and confirm that the issue was that the "CDF drum that holds the gears in the transmission." The issue was repaired under the existing powertrain warranty, however, the exact same issue is now occurring again for a second time a few months after the initial repair. This leads me to believe the parts are faulty and need to be replaced with a different/better part. I also want to share that this issue is being experienced by other people that I know who drive newer Fords. There were no warning messages or lights the initial time or this current time.

ENGINE

While driving on a highway at approximately 70mph, attempted to pass a slower vehicle. I accelerated and the vehicle dropped down in gear, started shuddering, lost power and the MIL light started flashing. I pulled to the side of the road and the vehicle shifted into another gear and seemed to operate normally. Vehicle is currently at the Ford dealership, where they say that I need a new transmission, due to the CDF drum failure.

POWER TRAIN

While driving on a highway at approximately 70mph, attempted to pass a slower vehicle. I accelerated and the vehicle dropped down in gear, started shuddering, lost power and the MIL light started flashing. I pulled to the side of the road and the vehicle shifted into another gear and seemed to operate normally. Vehicle is currently at the Ford dealership, where they say that I need a new transmission, due to the CDF drum failure.

SEAT BELTS

The contact owns a 2020 Ford Expedition. The contact stated that while driving on the highway at 30 MPH with his wife seated in the front passenger’s seat, the seat belt snapped into the socket of the door and was no longer able to be used. The contact stated that the seat belt failed to expand or release from the buckle. No warning light was illuminated. The vehicle was taken to a local dealer however, the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 66,000.

POWER TRAIN

The transmission has been having problems for a year. Ford changed the valve plate in transmission due to hesitation and then jerky gear shifting. Problem is still happening. Car hesitates when shifting gears and then jerks. Sometimes the car will no shift gears and go when needed. Almost got in a wreck because it would not accelerate.

ELECTRICAL SYSTEM

The rear camera started to work intermittently, when taken to the dealer it was not on the recall list, when I believe it should have been. Dealer could not identify which of (4) possible cameras where in the vehicle by the VIN, stating he had to disassemble the car to visually identify which camera it was. Why wasn't this VIN included in the recall when Ford can't even identify which camera was in the vehicle when manufactured. Looking forward to your response.

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated while driving at approximately 5 MPH and depressing the accelerator pedal, the vehicle was hesitating and then hard shifting into gear while gaining forward momentum. The contact stated that the hard shifting and hesitation had occurred at various speeds. Additionally, the contact stated that the vehicle had started to hesitate while shifting into drive(D) or reverse(R) after a cold start. The contact stated no warning lights were illuminated. The contact stated that the failures were intermittent but were occurring more frequently in the past several months. The contact had taken the vehicle to a local dealer where it was diagnosed and determined that the TCU needed to be re-flashed. The vehicle was repaired; however, the failure reoccurred. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 80,000.

POWER TRAIN

The contact owns a 2020 Ford Expedition. The contact stated while driving 60-65 on the highway, changing lanes, the accelerator pedal was depressed, but the transmission unexpectedly downshifted from eighth gear to first gear. The vehicle lost motive power. The contact stated that several unknown warning lights were illuminated. The message to “Service Immediately” was displayed and then turned off. The vehicle was taken to the local dealer, and the computer was reset. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 20,000.