2023 FORD ESCAPE

ELECTRICAL SYSTEM

Ford Motor Company (Ford) is recalling certain 2024-2025 Lincoln Nautilus, 2023-2025 Escape, 2023 Lincoln Corsair, 2025 Lincoln Corsair, Maverick, and Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.

Risk: An overheated engine block heater can increase the risk of a fire.

ENGINE

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire increases the risk of injury.

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

ENGINE

Ford Motor Company (Ford) is recalling certain 2023-2025 Escape, and 2025 Bronco Sport vehicles. The cylinder head may have been improperly manufactured, which can cause the ball plugs to fail, resulting in an oil leak.

Risk: An oil leak can result in loss of drive power, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)

Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Risk: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Ford Motor Company (Ford) is recalling certain 2023-2024 Escape two-wheel drive vehicles equipped with adaptive cruise control. The cruise control radar module was misaligned during production.

Risk: Misalignment of the radar module can result in the Adaptive Cruise Control (ACC) misclassifying an overhead object as an object in the vehicle's path, causing the vehicle to unexpectedly slow and/or stop. Other safety systems that depend on the radar model (Pre-Collision Assist, Forward Collision Warning, and Auto Emergency Braking) could have diminished or lost function. These conditions increase the risk of a crash.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

EQUIPMENT:OTHER:LABELS

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Ford Motor Company (Ford) is recalling certain 2023 Escape, Super Duty F-250, Super Duty F-350, Super Duty F-450, and Super Duty F-550 vehicles equipped with a digital instrument panel cluster. The module may have been improperly soldered, preventing the instrument panel from illuminating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

Risk: An inoperable instrument panel cannot show critical safety information, such as the speedometer or warning lights, which may increase the risk of a crash.

ENGINE

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire increases the risk of injury.

VISIBILITY/WIPER

Sunroof molding roof drip rail. Ford part #LJ6Z5450036A. This part is held on with double stick tape. When it comes loose, it can interfere with the proper operation of the sunroof sunshade or fall into the passenger compartment. Mine has been replaced several times under warranty. Even though it was nearly detached, it did not fall. However, if it had, it has the potential of either damaging the sunshade or creating a driver distraction while driving.

ELECTRICAL SYSTEM

Campaign 23B56 Description Inspect front door check-arm reinforcement spot welds Next Steps Contact your dealer for next steps. ---------------------------------------------------------------------------------------------------------------- Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

UNKNOWN OR OTHER

Campaign 23B56 Description Inspect front door check-arm reinforcement spot welds Next Steps Contact your dealer for next steps. ---------------------------------------------------------------------------------------------------------------- Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

SEAT BELTS

Campaign 23B56 Description Inspect front door check-arm reinforcement spot welds Next Steps Contact your dealer for next steps. ---------------------------------------------------------------------------------------------------------------- Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

FORWARD COLLISION AVOIDANCE: WARNINGS

Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

ENGINE

Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

AIR BAGS

Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

ENGINE

For the last 2 weeks After accelerating my engine coolant overheat warning light goes off and i can't accelerate any further until light goes off. Also ford mechanic states there is metal shavings in the coolant that might be causing engine to overheat on top of the sensor issue.

LANE DEPARTURE: LANE KEEP: STEERING ASSIST

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds with the Adaptive Cruise Control Mode engaged, the vehicle failed to respond as needed after another vehicle pulled in front of the vehicle. The contact stated that the vehicle jerked and decelerated, and then revved up and accelerated unintendedly until the vehicle was within proximity of the other vehicle. Additionally, the contact stated that the Lane Keep Assist failed to keep the vehicle within the intended lane while driving, and the vehicle veered to the left unintendedly while the Lane Keep Assist was engaged. The vehicle was taken to the dealer to be diagnosed, but the cause of the failure could not be determined. Additionally, the dealer informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 24V440000 (Forward Collision Avoidance), which the contact related to the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 98,000.

FORWARD COLLISION AVOIDANCE

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds with the Adaptive Cruise Control Mode engaged, the vehicle failed to respond as needed after another vehicle pulled in front of the vehicle. The contact stated that the vehicle jerked and decelerated, and then revved up and accelerated unintendedly until the vehicle was within proximity of the other vehicle. Additionally, the contact stated that the Lane Keep Assist failed to keep the vehicle within the intended lane while driving, and the vehicle veered to the left unintendedly while the Lane Keep Assist was engaged. The vehicle was taken to the dealer to be diagnosed, but the cause of the failure could not be determined. Additionally, the dealer informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 24V440000 (Forward Collision Avoidance), which the contact related to the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 98,000.

UNKNOWN OR OTHER

Ear piercing sound coming from what appears to be the stereo speaker system. It was so loud it felt like it blew out my ear drums by the time I got it turned off. Days later my ears are still ringing with intermittent headaches. I have scheduled a warranty service with the local ford dealership. There was no warning and started as soon as I started the car. No one has inspected the vehicle. This took place on 6/14/2025.

ELECTRICAL SYSTEM

The contact owns a 2023 Ford Escape. The contact stated that while her husband was driving at an undisclosed speed, the vehicle experienced a loss of automotive power, and the steering wheel became difficult to turn in either direction. The contact stated that the messages "Electrical Power Saver Active" and "Service Charging System Warning" were displayed on the instrument panel. In addition, the contact's husband stated that the vehicle failed to come to a complete stop as intended, and the brake pedal felt firm while being depressed. The vehicle was towed to a local dealer and remained for further investigation. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,338.

UNKNOWN OR OTHER

Sunshade retracted all the way and center roof molding holding it was with double stick tape. Rolled all the back and cannot get it to go back.

BACK OVER PREVENTION

The contact owns a 2023 Ford Escape. The contact state while reversing, the back over prevention camera failed to function as intended. The contact stated that the back over prevention camera failed to display images of pedestrians or vehicles. The contact stated that due to the failure, the contact almost struck a pedestrian. The vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was then taken to another dealer where a software update was performed. The manufacturer was made aware of the failure. The contact was offered a buyback. The failure mileage was approximately 55,000.

UNKNOWN OR OTHER

Bad battery. Yes, the dealership did replace the 12V battery, however since I do not drive often, and not 60 miles a day. I was advised to install a battery maintainer, which I should have been told at the time of purchase. However, how inconvenient as I will have a power cord in the driveway, and I would have to connect and disconnect the battery maintainer, which to me is a safety issue. I see online Ford has had these problems with their battery. Is Ford doing anything about this problem to ensure this type of problem is fixed? I purchased a new vehicle so I would not have problems.

ELECTRICAL SYSTEM

12v battery system failure to keep 12v battery that boots operating system of car charged. This leads to a vehicle that cannot be started or moved unless jump started. This has happened daily, and sometimes multiple times a day, requiring a jump pack to get the car to turn on. This issue has been reproduced and confirmed via multiple revised manufacturer TSBs. This has likely been inspected by the ford dealership that sold the used vehicle to me. Multiple safety warnings appear when the vehicle determines the 12v battery is not sufficiently charged.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The contact owns a 2023 Ford Escape. The contact stated while driving 60 MPH, the Adaptive Cruise Control altered the speed after detecting the number on the Minnesota county road sign ending in the number 5. The Adaptive Cruise Control was changed without warning. The vehicle gradually accelerated after the failure. While driving at slow speeds, the speeds spontaneously increased from 30 MPH to 50 MPH. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, who referred the contact to the NHTSA Hotline. The failure mileage was approximately 19,280.

ELECTRICAL SYSTEM

The contact owns a 2023 Ford Escape. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was unavailable. The dealer was contacted. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that a second notice would be mailed whenever parts were available. The contact had not experienced a failure. VIN tool confirms parts not available.

ELECTRICAL SYSTEM

The contact owns a 2023 Ford Escape. The contact stated while the vehicle was parked, the check engine warning light illuminated. The contact took the vehicle to the dealer where the vehicle was diagnosed, and it was determined that rodents had damaged the coil wiring. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 23,106.

ELECTRICAL SYSTEM

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle failed to respond as needed. The contact stated that the RPM was not increasing on the gauge on the instrument cluster. There was no warning illuminated. The contact stated that the failure was intermittent but became a recurring failure. Additionally, the contact reported several electrical failures. The contact stated that the instrument cluster was blank, and the windows failed to respond while attempting to raise or lower the windows. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission software needed to be re-flashed, and the 12-Volt battery needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was taken back to the same dealer. The dealer replaced the 12-Volt battery; however, the failure recurred. The manufacturer was informed of the failure. The failure mileage was approximately 15,500.

POWER TRAIN

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle failed to respond as needed. The contact stated that the RPM was not increasing on the gauge on the instrument cluster. There was no warning illuminated. The contact stated that the failure was intermittent but became a recurring failure. Additionally, the contact reported several electrical failures. The contact stated that the instrument cluster was blank, and the windows failed to respond while attempting to raise or lower the windows. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission software needed to be re-flashed, and the 12-Volt battery needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was taken back to the same dealer. The dealer replaced the 12-Volt battery; however, the failure recurred. The manufacturer was informed of the failure. The failure mileage was approximately 15,500.

POWER TRAIN

The contact owns a 2023 Ford Escape. The contact stated that while driving approximately 30 MPH, the transmission overheated warning light illuminated. The contact stated that the vehicle went into LIMP Mode. The contact stopped and had the vehicle towed to the dealer. The dealer diagnosed the vehicle but could not duplicate the failure. The vehicle was not repaired. The contact stated that the failure reoccurred, and the vehicle was taken to another dealer who also was not able to duplicate the failure. The vehicle was not repaired. The contact stated that the transmission failed and was unable to shift into reverse(R) or park(P). The contact had the vehicle towed to an independent mechanic. The vehicle was diagnosed, and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 150,000.

POWER TRAIN

The contact owns a 2023 Ford Escape. The contact stated that while driving at various speeds, the transmission unexpectedly downshifted. There was no warning light illuminated. The dealer was notified of the failure, and the contact was instructed to bring the vehicle in for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer had not been notified of the failure. The failure mileage was approximately 41,000.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Summary of Issues: 1. March 2024 – First Incident: •Warning lights appeared on the dashboard while driving (including ABS and power steering). •Vehicle was taken to Camelback Ford. •Dealership diagnosed a software update failure due to low voltage. •Battery was recharged, software updated, and codes cleared. ⸻ 2. April 6, 2024 – Battery Replacement: •Vehicle continued to experience electrical issues. •Battery was replaced by dealership under warranty. ⸻ 3. June 11, 2024 – Second Incident: •Dashboard warning lights returned. •Dealership again cleared codes, no new repair or replacement performed. •Explanation given was “modern cars have more computers” and that these issues were “normal.” ⸻ 4. July 12, 2024 – Third Incident: •While stopped at a red light, the entire dashboard shut off and restarted on its own. •Engine remained on, but the sudden blackout raised serious safety and reliability concerns. •Vehicle was not moved after the incident. •Dealership advised to return only if issue happens again. ⸻ Ongoing Concern: This vehicle has experienced repeated electrical system failures including instrument cluster blackout and communication errors, despite warranty repairs and a new battery. These intermittent issues pose a potential safety risk, especially if they occur while driving. The lack of a consistent fix raises concerns about the vehicle’s electrical integrity and reliability.

ELECTRICAL SYSTEM

Summary of Issues: 1. March 2024 – First Incident: •Warning lights appeared on the dashboard while driving (including ABS and power steering). •Vehicle was taken to Camelback Ford. •Dealership diagnosed a software update failure due to low voltage. •Battery was recharged, software updated, and codes cleared. ⸻ 2. April 6, 2024 – Battery Replacement: •Vehicle continued to experience electrical issues. •Battery was replaced by dealership under warranty. ⸻ 3. June 11, 2024 – Second Incident: •Dashboard warning lights returned. •Dealership again cleared codes, no new repair or replacement performed. •Explanation given was “modern cars have more computers” and that these issues were “normal.” ⸻ 4. July 12, 2024 – Third Incident: •While stopped at a red light, the entire dashboard shut off and restarted on its own. •Engine remained on, but the sudden blackout raised serious safety and reliability concerns. •Vehicle was not moved after the incident. •Dealership advised to return only if issue happens again. ⸻ Ongoing Concern: This vehicle has experienced repeated electrical system failures including instrument cluster blackout and communication errors, despite warranty repairs and a new battery. These intermittent issues pose a potential safety risk, especially if they occur while driving. The lack of a consistent fix raises concerns about the vehicle’s electrical integrity and reliability.

ELECTRICAL SYSTEM

I purchased a Ford Escape 2023 in Green Bay, Wisconsin on [XXX] from Dorsch Ford Dealership. On October 7, 2023 I tried to start my vehicle and the battery was drained/dead. This continued through January of 2024, and I received a new battery. I thought the problem was fixed. Not so, and it has continued throughout the past two years. My vehicle will go into Deep Sleep Mode at different times of the day. I have to drive it to regenerate the battery. At times I do not even have lights when I start the Ford Escape. I have taken it to a Ford Dealership in Appleton. I am suppose to go again on March 25, 2025 and it will be my tenth time. The service person stated why should I even come because they can not find the problem. There is a parasitic draw and it needs to be found, or the battery is not operating properly, and needs to be replaced. I am a school teacher, and I thought I was buying a safe and reliable car. This is not the case. I have over 100 pages of documentation. I have filed complaints with Ford and with the State of Wisconsin Lemon Law to no avail. Also, I am close to warranty and then I will have to pay out of pocket. The Ford Motor Company is violating the consumer laws and not following their obligation to make repairs on my car. This is similar to the Bronco/Maverick battery issue. Something more electrical is happening under the hood. The service people I have dealt with even stated that I don't drive the car regularly. I have to now get up at 4am to get the battery charged. I can not access the added features such as remote start. I paid for something I didn't receive! Plus, what happens when I am driving and the vehicle decides to have a major malfunction? This is wrong on all levels. Please look into this matter immediately. I have had one recall concerning the door locks which were repaired last summer. I am worried and nervous to continue driving the Ford Escape 2023 because of its battery. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

LANE DEPARTURE: BLIND SPOT DETECTION

The contact owns a 2023 Ford Escape. The contact stated while driving 40 MPH, the "Blind Spot Detection System Fault" message was displayed. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the trailer tow wiring harness (Part Number: LX6Z-15A416-B). The contact was informed that the wiring harness was damaged by the heat shield. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 9,000.

ELECTRICAL SYSTEM

The contact owns a 2023 Ford Escape. The contact stated while driving 40 MPH, the "Blind Spot Detection System Fault" message was displayed. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the trailer tow wiring harness (Part Number: LX6Z-15A416-B). The contact was informed that the wiring harness was damaged by the heat shield. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 9,000.

LATCHES/LOCKS/LINKAGES

The contact owns a 2023 Ford Escape. The contact stated while the vehicle was parked, the contact attempted to close the front driver’s side door; however, the door failed to close securely. No warning light was illuminated. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.

FORWARD COLLISION AVOIDANCE

The contact owns a 2023 Ford Escape. The contact stated that the front driver's door window would not completely roll up and close. The vehicle was taken to the local dealer who replaced the front driver's side door window motor, and the vehicle was repaired but failure reoccurred. Additionally, while operating the vehicle, the message "Front Collision Camera Inoperable" was displayed. The vehicle was taken to the local dealer, but failure code could not be retrieved, and the cause of the failure was not yet determined. The manufacturer was notified of the failures, but no assistance was offered. The failure mileage was 13,000.

VISIBILITY

The contact owns a 2023 Ford Escape. The contact stated that the front driver's door window would not completely roll up and close. The vehicle was taken to the local dealer who replaced the front driver's side door window motor, and the vehicle was repaired but failure reoccurred. Additionally, while operating the vehicle, the message "Front Collision Camera Inoperable" was displayed. The vehicle was taken to the local dealer, but failure code could not be retrieved, and the cause of the failure was not yet determined. The manufacturer was notified of the failures, but no assistance was offered. The failure mileage was 13,000.

ELECTRICAL SYSTEM

While driving on an interstate, the Instrument cluster / digital gauge cluster screen behind my steering wheel turned off. I was driving with my adaptive cruise control on when all of a sudden I see the screen go black and I was no longer able to see how fast the car was going, the engine temperature, or how much fuel I had, as well as all of the other metrics on that dashboard. The car never lost power, because the entertainment screen in the middle of my dash remained on and responsive during the short period of time that my instrument cluster screen was off, and I never lost power steering. Instinctively, I pressed on the break pedal and pulled off of the road onto the shoulder, so I’m not sure if the cruise control would have stayed on. After a few minutes on the shoulder, the instrument cluster screen turned back on, not quite like it does when you turn on the car, but it flashed a bunch of the warning lights and slowly came back to normal. I was able to drive my car safely and without another incident back home, however I am very concerned about this happening again. There were no warning lights, signals, or sounds before this happened. Driving on any road, weather it’s a highway or an interstate, it is very important to be able to see how fast you are traveling for the safety of yourself, your children, and the other drivers. There is a popular recall among this same vehicle type, however mine was not included in the previous recall even though it just repeated the same problem the other ford escapes were having. My local dealership is not taking this problem seriously, and I am very concerned.