ELKHART ECII

ELECTRICAL SYSTEM:WIRING:RELAYS/SOLENOIDS

Forest River, Inc. (Forest River) is recalling certain 2021 Battisti Coach; Federal Coach-Spirit; StarCraft Quest XL; 2022 StarTrans P/S2; Elkhart Coach; Glaval Concord II, Legacy, Primetime; StarCraft Allstar MVP, Allstar XLT; Eldorado Advance; 2021-2022 Eldorado National(K-s)-Advantage; StarTrans Senator II, Senator II HD, Candidate II; StarCraft Starquest, Starlite; Glaval Commute, Entourage, Universal; Berkshire Coach Ultra; and 2021-2023 StarCraft Allstar and Allstar XL Transit Buses. The Programmable Relay Power Center (PRC) module can fail.

Risk: A PRC module failure can increase the risk of a fire.

EQUIPMENT ADAPTIVE/MOBILITY

Forest River, Inc. (Forest River) is recalling certain 2012-2016 Elkhart Coach ECII, Glaval Apollo and Sport buses, 2017-2018 Glaval Commute buses, 2012-2018 Glaval Entourage, Titan and Universal, StarCraft Bus Allstar and Starlite buses, 2013-2018 Glaval Legacy, Primetime and Titan II buses, 2015-2016 Allstar XL MVP buses, 2014-2016 StarCraft Prodigy buses, 2014 StarCraft Quest and Starquest buses, 2017 StarCraft Quest buses and 2016 StarCraft Senator II buses. These vehicles are equipped with certain Ricon S-Series and K-Series Titanium Wheel chair Lifts that have a wheelchair lift positioning input cam that may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.

Risk: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.

EQUIPMENT ADAPTIVE/MOBILITY

Forest River, Inc. (Forest River) is recalling certain model year 2006-2014 Elkhart ECII transit buses manufactured January 1, 2006, to September 26, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts built by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Risk: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

ELECTRICAL SYSTEM

Elkhart Coach (Elkhart) is recalling certain model year 2009-2010 ECII transit buses manufactured August 1, 2009, through March 31, 2010, and equipped with A&M Systems-brand electric door actuators. Voltage spikes may damage electrical components and electrical circuits within the actuator, causing the circuit board to develop high resistance.

Risk: High resistance may cause the circuit board to overheat, increasing the risk of a fire.

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Elkhart Coach is recalling certain model year 2010-2013 ECI, and ECII transit buses built on Ford cutaway chassis equipped with Ford 5.4L or 6.8L engines and Trans/Air-brand air compressors. In the affected vehicles, depending on the routing of the alternator harness and the orientation of the heater hose spring clamp at the front of the intake manifold, the alternator harness may be pinched between the spring clamp and the air conditioner compressor mounting bracket.

Risk: As a result, the charging system may fail which could lead to the vehicle stalling while driving, increasing the risk of a crash. Additionally, the spring clamp could pierce both the positive and negative wires of the alternator harness creating a short circuit which could result in a fire.

EQUIPMENT ADAPTIVE/MOBILITY

ELKHART COACH IS RECALLING CERTAIN BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED. A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP.

Risk: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR’S OCCUPANT COULD FALL AND SUSTAIN INJURY.

EQUIPMENT:APPLIANCE:AIR CONDITIONER

ELKHART IS RECALLING CERTAIN MODEL YEAR 2006-2010 ECI AND ECII VEHICLES MANUFACTURED FROM JANUARY 1, 2006, THROUGH DECEMBER 31, 2010, AND EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS (EM-1). DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Risk: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND MAY BE ACCOMPANIED BY FLAME, SMOKE AND POTENTIAL FIRE.