ELKHART ECI
View complaints and recalls by year, or see all recent reports below.
ELKHART ECI Summary
9
Model Years
0
Total Complaints
17
Total Recalls
2005 - 2013
Year Range
Select Year
Recent Recalls
2013 ELKHART ECI
336 vehicles affected
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
Elkhart Coach is recalling certain model year 2010-2013 ECI, and ECII transit buses built on Ford cutaway chassis equipped with Ford 5.4L or 6.8L engines and Trans/Air-brand air compressors. In the affected vehicles, depending on the routing of the alternator harness and the orientation of the heater hose spring clamp at the front of the intake manifold, the alternator harness may be pinched between the spring clamp and the air conditioner compressor mounting bracket.
Risk: As a result, the charging system may fail which could lead to the vehicle stalling while driving, increasing the risk of a crash. Additionally, the spring clamp could pierce both the positive and negative wires of the alternator harness creating a short circuit which could result in a fire.
2009 ELKHART ECI
761 vehicles affected
EQUIPMENT ADAPTIVE/MOBILITY
ELKHART COACH IS RECALLING CERTAIN BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED. A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP.
Risk: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR¬ÃS OCCUPANT COULD FALL AND SUSTAIN INJURY.
2010 ELKHART ECI
125 vehicles affected
EQUIPMENT:APPLIANCE:AIR CONDITIONER
ELKHART IS RECALLING CERTAIN MODEL YEAR 2006-2010 ECI AND ECII VEHICLES MANUFACTURED FROM JANUARY 1, 2006, THROUGH DECEMBER 31, 2010, AND EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS (EM-1). DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.
Risk: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND MAY BE ACCOMPANIED BY FLAME, SMOKE AND POTENTIAL FIRE.
2006 ELKHART ECI
52 vehicles affected
EQUIPMENT
ELKHART COACH IS RECALLING CERTAIN BUSES EQUIPPED WITH TRANS AIR TA 73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE.
Risk: THIS WOULD CAUSE THE RESISTOR TEMPERATURE TO RISE TO A POINT WHERE IT WILL MELT AND POSSIBLY IGNITE THE PLASTIC BLOWER HOUSING TO WHICH IT IS MOUNTED. THE OVERHEATING CAN RESULT IN A FIRE.
Recent Complaints
No recent complaints found.