2017 DODGE GRAND CARAVAN

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.

Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

ENGINE

The engine began stalling and reving while driving. It is at the shop with an estimate of 2500.00 to 4000.00 to repair due to faulty cylinder #2. Researching this, we are not the first to have issues. As stated by my repair place, it’s a ticking time bomb waiting for it to cause a serious major incident and possible injuries. Vehicle is less than 8 years old and less than 100,000 miles

UNKNOWN OR OTHER

I first had this happen months ago and now I found another place to post about it. The locking and unlocking motor on the passenger sliding door is making a horrible noise and buzzing sound. This happens every time you lock or unlock it. It also happens when it locks automatically when you drive. It is horribly loud that it wakes up the baby and toddler every time. My mechanic has looked at it and knew exactly what was wrong right away. The motor is just and needs replaced. He said it's very common for the dodge motor in the sliding doors to need replacing. He's shocked it hasn't been recalled yet. He's also had many people have kids locked in the vans due to the motor basically burning out. He said it definitely needs replaced and should've been recalled by now. Also be prepared to climb over seats to get the baby and toddler out when they finally stop working all together. The fact that my small mechanics shop has seen many issues with the locking motor definitely tells me dodge isn't putting safety first at all.

ELECTRICAL SYSTEM

I first had this happen months ago and now I found another place to post about it. The locking and unlocking motor on the passenger sliding door is making a horrible noise and buzzing sound. This happens every time you lock or unlock it. It also happens when it locks automatically when you drive. It is horribly loud that it wakes up the baby and toddler every time. My mechanic has looked at it and knew exactly what was wrong right away. The motor is just and needs replaced. He said it's very common for the dodge motor in the sliding doors to need replacing. He's shocked it hasn't been recalled yet. He's also had many people have kids locked in the vans due to the motor basically burning out. He said it definitely needs replaced and should've been recalled by now. Also be prepared to climb over seats to get the baby and toddler out when they finally stop working all together. The fact that my small mechanics shop has seen many issues with the locking motor definitely tells me dodge isn't putting safety first at all.

SEATS

SEAT HEADREST EXPLODED RANDOMLY. THERE WAS NO ACCIDENT OR CAUSE FOR THIS. IT JUST DEPLOYED OUT OF NOWHERE. THIS WAS THE FRONT PASSENGER SEAT HEAD REST. LUCKILY NO ONE WAS SITTING IN THE SEAT AT THE TIME.

SEATS

The headrest on the driver’s seat burst open and deployed while waiting in a parking lot.. A very loud and awful exploded to the back of my head and ringing of the ears.

UNKNOWN OR OTHER

The driver's side sliding door on this minivan became stuck shut. I had to remove my disabled son through the open window. Not being able to remove him quickly in an emergency because the door has become sealed shut is unacceptable. I cannot believe there is no manual override. I was able to solve this issue by forcing the unlock lever while pressing 'unlock' on the keyfob. However, the main reason I write this complaint, numerous people on various forums report an actuator shorting out in their doors causing this issue, meaning they cannot open the door, by any means, without this actuator being repaired. I cannot for the life of me believe that a system was engineered to not have a simple manual override on a car door. This is beyond me how this got cleared by any sort of regulatory body. If that actuator gets cooked in a fire, I guess the occupants of the car will too.

STRUCTURE:BODY

The driver's side sliding door on this minivan became stuck shut. I had to remove my disabled son through the open window. Not being able to remove him quickly in an emergency because the door has become sealed shut is unacceptable. I cannot believe there is no manual override. I was able to solve this issue by forcing the unlock lever while pressing 'unlock' on the keyfob. However, the main reason I write this complaint, numerous people on various forums report an actuator shorting out in their doors causing this issue, meaning they cannot open the door, by any means, without this actuator being repaired. I cannot for the life of me believe that a system was engineered to not have a simple manual override on a car door. This is beyond me how this got cleared by any sort of regulatory body. If that actuator gets cooked in a fire, I guess the occupants of the car will too.

ELECTRICAL SYSTEM

The contact owns 2017 Dodge Grand Caravan. The contact stated that upon reversing and shifting to drive(D), the vehicle lost motive power. The contact turned off the vehicle, and four bystanders assisted the contact in pushing the vehicle into a parking spot. There was no warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed that an unknown computer software chip needed to be replaced. The vehicle was not repaired. The contact related the failure NHTSA Campaign Number: 18V524000(Electrical System); however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was 115,000.

ELECTRICAL SYSTEM

Vehicle: 2017 Dodge Grand Caravan Component/System: Sliding door lock actuator Is the part available for inspection upon request? Yes Description of the Issue: The sliding door lock actuator failed, causing the door to remain locked at all times. The door cannot be opened manually or using the power door controls. This renders the door completely inoperable. Safety Risk: This is a significant safety hazard. In the event of an emergency, passengers—especially children seated in the rear—cannot exit the vehicle through this door. It severely limits evacuation routes and could result in injury or death if occupants are trapped during an accident or fire. Has the issue been reproduced or confirmed by a dealer or service center? Not yet. Issue is ongoing and appointment is pending. Has the vehicle or component been inspected by the manufacturer, police, insurance, or others? No Were there any warning lamps, messages, or symptoms before the failure? No warning lamps or messages appeared. The door simply stopped responding to manual or power lock/unlock commands. When did the issue occur? June 2025. The door has remained inoperable since. Assessment: Based on consumer forums and other reports, this appears to be a known and widespread issue with this model, likely caused by a defective actuator design.

STRUCTURE:BODY

Vehicle: 2017 Dodge Grand Caravan Component/System: Sliding door lock actuator Is the part available for inspection upon request? Yes Description of the Issue: The sliding door lock actuator failed, causing the door to remain locked at all times. The door cannot be opened manually or using the power door controls. This renders the door completely inoperable. Safety Risk: This is a significant safety hazard. In the event of an emergency, passengers—especially children seated in the rear—cannot exit the vehicle through this door. It severely limits evacuation routes and could result in injury or death if occupants are trapped during an accident or fire. Has the issue been reproduced or confirmed by a dealer or service center? Not yet. Issue is ongoing and appointment is pending. Has the vehicle or component been inspected by the manufacturer, police, insurance, or others? No Were there any warning lamps, messages, or symptoms before the failure? No warning lamps or messages appeared. The door simply stopped responding to manual or power lock/unlock commands. When did the issue occur? June 2025. The door has remained inoperable since. Assessment: Based on consumer forums and other reports, this appears to be a known and widespread issue with this model, likely caused by a defective actuator design.

SUSPENSION

Transmission

POWER TRAIN

Transmission

ELECTRICAL SYSTEM

Door lock actuator on passenger sliding door beginning to make noise before it likely will fail and not automatically lock door as vehicle accelerates. This is a recall item on the two prior years of this same vehicle.

POWER TRAIN

The contact owns a 2017 Dodge Grand Caravan. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of automotive power. The contact stated that several unknown warning lights were illuminated. The contact pulled over to the shoulder of the road and shift the vehicle into park(P); however, the vehicle was stuck in reverse(R), and failed to shift to neutral(N). The vehicle was towed to a local independent mechanic, where it was diagnosed and DTC: P1602 (PCM not Programmed) and P0606 (Error with PCM) were retrieved. The local dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

The contact owns a 2017 Dodge Grand Caravan. The contact stated while driving at an undisclosed speed, the front passenger's side headrest unexpectedly deployed. The contact stated that there was no impact to the vehicle that caused the headrest to deploy. There were no injuries sustained. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 123,244.

ELECTRICAL SYSTEM

Driver side sliding door lock jammed shut! No way to use the door causing safety issue in an emergency. Lock will not release. There was no warning signs and dealer cannot get my car in for another month. Passenger side sliding door has done this intermittently.

STRUCTURE:BODY

Beginning at about 75,000 miles (1st lock actuator), my lock actuators seized and rendered the backseat passenger doors unusable. The second lock actuator on the passenger side followed at about 95,000 miles. This is extremely unsafe, because if I have my children as passengers, they must climb in through the back hatch of the minivan. In addition, passengers cannot exit the vehicle from their seats in case of a wreck. Dodge has issued an extended warranty recently, but I am not eligible because my vehicle is now over 100,000 miles. (It was under 100,000 miles at the time of malfunction, but there was no extended warranty or recall at the time.) This common issue with the Dodge Grand Caravan is extremely unsafe, and all defective lock actuators should be replaced/repaired as part of a recall. A warranty that excludes certain users is unsafe.

ELECTRICAL SYSTEM

Power door is broke and won’t open. There was a notice sent out about it but no repairs appeared

LATCHES/LOCKS/LINKAGES:ELECTRONIC LOCK/LATCH ACTUATOR

The contact owns a 2017 Dodge Grand Caravan. The contact stated that while the vehicle was parked, his children attempted to exit the vehicle through the passenger's side and driver's side sliding doors; however, both sliding doors failed to open. The contact's children exited the vehicle though the front passenger's side and driver's side doors. The contact stated that the failure persisted. The dealer was notified of the failure and advised the contact to schedule an appointment for inspection. The vehicle was not diagnosed or repaired. The contact related the failure to Chrysler Warranty Extension: X98 (Driver and Passenger Sliding Door Power Lock Actuators). The manufacturer was not notified of the failure. The failure mileage was approximately 115,000.

UNKNOWN OR OTHER

The door lock actuators on BOTH sliding doors do not work properly. about 3 years ago the drivers side door lock actuator stopped unlocking and could not be used. about 7 or 8 months later, it suddenly unlocked but now makes a loud buzzing sound every time it locks. Then about a year later, the passenger side door stopped unlocking and has remained locked for many months now leaving that door unusable. if there were an emergency or accident where the drivers side could not be accessed, passengers in the back of the vehicle would not be able to exit the car safely without climbing over seats. We also are concerned that the drivers side door will fail again and the rear of the vehicle would no longer be accessible. This is a known issue through the manufacturer that they refuse to recall or repair. There is even a current class action lawsuit for this make and model. several similar makes and models through the manufacturer have been affected by this issue for many years. We have not had this inspected by anyone, we bought new door actuator mechanisms but have not replaced them ourselves yet. every indication is this is a difficult and lengthy repair at home and costly if done through an auto repair shop or dealership. With such a well known issue, this should have been investigated, resolved and corrected by the manufacturer and notices for recalls released to the public. This is completely unacceptable that the safety of passengers in these cars are not important to the manufacturer!

UNKNOWN OR OTHER

My driver's side rear sliding door will not open or unlock. The locking mechanism inside the door panel is seized up and will not release the lock, so the door cannot be opened. This is unsafe because I now only have one door that passengers can exit from the back and if something were to happen to the other back door, people could be trapped. I regularly transport my nieces that are [XXX] , [XXX] , and [XXX] and it makes it very difficult to reach them and if there were an accident on the right side of the car we would not be able to reach them from the left and they would not be able to get out due to the fact that they are in car seats and would need to be taken out by an adult. I have received documentation that states this is a known issue for my Year, Make, and Model, and there is apparently a class action lawsuit about it, but based on the mileage of my car, I won't qualify to have it fixed. I was just made aware that this is a known issue and the car had 70,000 miles on it when I bought it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

The contact owns a 2017 Dodge Grand Caravan. The contact stated that the passenger's side sliding door failed to close properly. The contact had to force the door closed. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 52,000.

ENGINE

The vehicle has cut off twice since purchased two days ago while turning. No warning signs I almost hit a sign and another car. There's no way to control the car once the power stops.

POWER TRAIN

I noticed some shifting issues, and some power loss along with an oil leak and the vehicle is not getting enough lubrication. The vehicle is only at 114010 miles and according to the dealership a new engine is needed. A new engine oil cooler was replaced however not the hoses and the problem still exists.

ENGINE

I noticed some shifting issues, and some power loss along with an oil leak and the vehicle is not getting enough lubrication. The vehicle is only at 114010 miles and according to the dealership a new engine is needed. A new engine oil cooler was replaced however not the hoses and the problem still exists.

UNKNOWN OR OTHER

The rear sliding door lock actuator on the passenger stopped working. The door will not open or unlock.

ELECTRICAL SYSTEM

A few weeks ago, our passenger side rear sliding door stopped locking. Yesterday when I unlocked the doors, a very loud noise came from the door. It has happened every time I have unlocked the doors since & it scares my kids every time. I assumed the issue was with the locking mechanism, also known as the actuator. Upon doing some more research I found that MOPAR had actually issued an extended warranty on this part but my VIN is not included in the extended warranty.

ENGINE AND ENGINE COOLING

The contact owns a 2017 Dodge Grand Caravan. The contact stated while coming to a complete stop on an incline or on a leveled roadway, the vehicle stalled. There was no warning light illuminated. The contact was able to restart the vehicle. Additionally, the contact stated that the vehicle jerked intermittently while depressing the brake pedal. The vehicle was taken to Triple A, where the radiator was replaced; however, the failure persisted. Additionally, the contact stated that the message "Oil Change" was displayed while there was sufficient oil in the vehicle. The dealer was contacted and informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 95,500.

ELECTRICAL SYSTEM

The contact owns a 2017 Dodge Grand Caravan. The contact stated while coming to a complete stop on an incline or on a leveled roadway, the vehicle stalled. There was no warning light illuminated. The contact was able to restart the vehicle. Additionally, the contact stated that the vehicle jerked intermittently while depressing the brake pedal. The vehicle was taken to Triple A, where the radiator was replaced; however, the failure persisted. Additionally, the contact stated that the message "Oil Change" was displayed while there was sufficient oil in the vehicle. The dealer was contacted and informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 95,500.

UNKNOWN OR OTHER

My rear passenger sliding door lock is stuck in the unlock position. My concern is my van is at all times unlocked. Also since it won’t lock at all even when I’m driving is that anyone could approach my van while I’m at a light or a parking lot and get inside. My biggest fear is that since it won’t lock it will just pop open one day while I’m driving. My grandchildren or my dogs could be severely injured if this happened. I’ve read online about this being an issue with the Dodge GCV. People suggested writing to you and try to get a recall done for this issue. The dealer wants around $1100 to fix problem. I don’t have that kind of money to spend. My other issue is if I disconnect the cable so I can lock the door is what if my passengers or animals need to get out of back of van in a emergency their going to be trapped back there. Also unrelated to the lock issues. My van is having a hard time shifting and has cut out multiple times on me. And when I turn on my blinkers it turns on the wipers. So possible electrical issue there.

UNKNOWN OR OTHER

Driver side rear sliding door is stuck closed. Cannot be operated manually, will not lock or unlock with the other car door locks which work fine. My children’s safety is at risk. I bought a van because I have 3 children, and in the event of an accident could delay their rescue. One of my children is a Type 1 diabetic and in event of an accident he’s in even more danger if rescue teams cannot get to him. The problem has not been confirmed by a mechanic, as both Dodge dealerships I have reached out to told me I would have to pay a diagnostic fee, but it’s a known problem with their vehicles. The vehicle has not been inspected by police, or insurance. There was no warning to the part malfunctioning, just stopped opening and noticed when my children tried to use the door to get out at school. My car currently has 109,000 miles on it but there are is a recall for up to 100,000 miles but Dodge states it cannot extend the warranty although I’ve see ln that Mopar extended the warranty for this exact issue but Dodge says it’s misinformation and “good luck”.

POWER TRAIN

My car is stalling. There is a recall for the same year as my car. I called and check if my car was a part of the recall and it wasn’t. Clearly I am having the same issue. They should put all 2017 dodge grand caravan in this recall.

AIR BAGS

The air bag for passenger tubes going off and on. I don't know why sometimes it will stay off and then other times it will ding all day long while I'm driving? I don't know if it's safe. Enough for anyone to write in it or not