DODGE DAKOTA

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Risk: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Fiat Chrysler Automobiles US LLC (Chrysler) is recalling certain 2005 Dodge Dakota pickup trucks equipped with heated seats. These driver and passenger seats may develop hot spots that can result in the seat cushion or seat back having burn holes.

Risk: The hot spots and burn holes can injure the seat occupant and can increase the risk of a fire.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Risk: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

ELECTRICAL SYSTEM:IGNITION:SWITCH

Chrysler Group LLC (Chrysler) is recalling certain model year 2006-2007 Dodge Ram 1500, 2500, 3500, Dakota, and 2006 Mitsubishi Raider vehicles manufactured July 1, 2005, to July 31, 2006 with manual transmissions. The return springs in the clutch ignition interlock switch may break.

Risk: Broken springs can result in a no-start condition, or cause unintended movement when the ignition is cranked, increasing the risk of a vehicle crash.

AIR BAGS

Chrysler Group LLC (Chrysler) is recalling certain model year 2004-2005 Dodge Ram 1500, 2500, and 3500, 2004-2005 Dodge Durango, 2005 Dodge Dakota, 2005 Dodge Magnum and 2005 Chrysler 300, 300C and 300 SRT8 vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Risk: In the event of a crash necessitating deployment of the passenger’s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

Chrysler is recalling certain model year 2009-2012 Ram 1500 trucks manufactured from February 27, 2008, through June 30, 2009, and from December 1, 2009, through October 20, 2011; model year 2009-2011 Dodge Dakota trucks manufactured from February 27, 2007, through June 30, 2009, and from December 1, 2009, through September 30, 2011; model year 2009 Chrysler Aspen trucks manufactured from January 3, 2008, through December 18, 2008; and model year 2009 Dodge Durango trucks manufactured from January 3, 2008, through December 18, 2008. The rear axle pinion nut may loosen due to an undersized pinion spline that can allow relative motion between the nut and companion flange.

Risk: If the rear axle pinion nut loosens, the axle can lock up and cause a loss of vehicle control and/or a vehicle crash with little warning.

EQUIPMENT:ELECTRICAL

NBC Truck Equipment, Inc. (NBC) is recalling certain model year 2007-2008 and model year 2010-2011 trucks equipped with Sure Power battery separator devices, due to overheating.

Risk: Overheating of the battery separator can result in smoke and possible fire.

POWER TRAIN

The contact owns a 2001 Dodge Dakota. The contact stated that after taking the vehicle to an independent mechanic to have the catalytic converter replaced, the vehicle stalled while driving at various speeds. There was no warning light illuminated. Due to the failure, the contact had to have the vehicle towed to the residence on nine separate occasions. The vehicle was also towed to a dealer, where the PCM was replaced; however, the failure persisted. The manufacturer was notified of the failure but offered no assistance. Upon investigation, the contact linked the failure to the Sentry Key Immobilizer Module (SKIM). The contact believed that a defect with the SKIM had caused the sudden stall with the security light flashing. The vehicle was not repaired. The failure mileage was 119,000.

ELECTRICAL SYSTEM

The contact owns a 2001 Dodge Dakota. The contact stated that after taking the vehicle to an independent mechanic to have the catalytic converter replaced, the vehicle stalled while driving at various speeds. There was no warning light illuminated. Due to the failure, the contact had to have the vehicle towed to the residence on nine separate occasions. The vehicle was also towed to a dealer, where the PCM was replaced; however, the failure persisted. The manufacturer was notified of the failure but offered no assistance. Upon investigation, the contact linked the failure to the Sentry Key Immobilizer Module (SKIM). The contact believed that a defect with the SKIM had caused the sudden stall with the security light flashing. The vehicle was not repaired. The failure mileage was 119,000.

FUEL/PROPULSION SYSTEM

My 2001 Dodge Dakota has a faulty SKIM system. The vehicle goes into No-Start/Stall while driving down the road. I have had it at a dealership and they do not have technical experience with these older vehicles that require an “antiquated software system”. This is a dangerous situation, particularly in foothills with winding roads.

ELECTRICAL SYSTEM

The contact owns a 2006 Dodge Dakota. The contact stated that while her son was at a complete stop at the red traffic light, the driver's side air bag deployed unexpectedly, and the driver noticed that there was white smoke and dark smoke coming from the air bag. There was no warning light illuminated. The contact stated that the air bag caught on fire. The contact stated that the driver attempted to exit the vehicle, but the doors remained locked and the vehicle failed to shift to park(P) for two minutes. The driver was able to shift to neutral(N). The driver broke the front passenger's side window glass and exited the vehicle. A sheriff deputy parked his vehicle behind the driver's vehicle to prevent the vehicle from moving. The contact stated that the air bag fire burned the entire steering wheel and the steering column, the windshield and the front driver's side seat. The fire was extinguished with four extinguishers and with the assistance of the fire department. A fire department report was filed. A police report was filed but the contact did not have the police report information available. The contact's son sustained intrusion of metal shards in his right leg and bruises on the stomach, arm, and chest. The contact's son also sustained migraine, insomnia, panic attacks, and PTSD. The contact's son did not receive medical assistance. The vehicle was towed to the residence. The dealer then towed the vehicle to their location and took pictures of the failure. The dealer then towed the vehicle back to the contact's residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and denied assistance. The failure mileage was approximately 221,000.

AIR BAGS

The contact owns a 2006 Dodge Dakota. The contact stated that while her son was at a complete stop at the red traffic light, the driver's side air bag deployed unexpectedly, and the driver noticed that there was white smoke and dark smoke coming from the air bag. There was no warning light illuminated. The contact stated that the air bag caught on fire. The contact stated that the driver attempted to exit the vehicle, but the doors remained locked and the vehicle failed to shift to park(P) for two minutes. The driver was able to shift to neutral(N). The driver broke the front passenger's side window glass and exited the vehicle. A sheriff deputy parked his vehicle behind the driver's vehicle to prevent the vehicle from moving. The contact stated that the air bag fire burned the entire steering wheel and the steering column, the windshield and the front driver's side seat. The fire was extinguished with four extinguishers and with the assistance of the fire department. A fire department report was filed. A police report was filed but the contact did not have the police report information available. The contact's son sustained intrusion of metal shards in his right leg and bruises on the stomach, arm, and chest. The contact's son also sustained migraine, insomnia, panic attacks, and PTSD. The contact's son did not receive medical assistance. The vehicle was towed to the residence. The dealer then towed the vehicle to their location and took pictures of the failure. The dealer then towed the vehicle back to the contact's residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and denied assistance. The failure mileage was approximately 221,000.

UNKNOWN OR OTHER

The manufacturer sent a third party to fix an airbag recall. Before the third-party technician touched my truck for the recall, both my horn and cigarette lighter worked. Now, after their repair, neither works. Therefore, something they did caused an electrical fault. I advised whoever sent the technician and they said they would send the guy back. No one will answer my calls and no one has fixed my issue.

STEERING

The manufacturer sent a third party to fix an airbag recall. Before the third-party technician touched my truck for the recall, both my horn and cigarette lighter worked. Now, after their repair, neither works. Therefore, something they did caused an electrical fault. I advised whoever sent the technician and they said they would send the guy back. No one will answer my calls and no one has fixed my issue.

AIR BAGS

The manufacturer sent a third party to fix an airbag recall. Before the third-party technician touched my truck for the recall, both my horn and cigarette lighter worked. Now, after their repair, neither works. Therefore, something they did caused an electrical fault. I advised whoever sent the technician and they said they would send the guy back. No one will answer my calls and no one has fixed my issue.

UNKNOWN OR OTHER

I was going to work and the transmission started slipping when I had cruise control on, and then when I got to a stop light my truck started revving and wouldn't move. When i put it in neutral it wouldn't roll either. It just kept on revving and screeching. So i out back into drive and it jerks. Also my trucks rear end locked up and wouldn't roll in neutral while the truck is on. You have to keep the truck off and then put it into neutral to roll it.