2018 CHRYSLER PACIFICA PLUG-IN HYBRID

HYBRID PROPULSION SYSTEM

Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.

Risk: A vehicle fire increases the risk of injury.

HYBRID PROPULSION SYSTEM

Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.

Risk: A vehicle fire increases the risk of injury.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.

Risk: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.

Risk: A control arm separation could increase the risk of a crash.

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.

Risk: A vehicle stall can increase the risk of a crash.

UNKNOWN OR OTHER

I was traveling at south bound on TOLL 130 going 80MPH (which is the speed limit on that road) when my Pacifica immediately slowed down and my accelerator gave out. In addition to my dash flashing that the cruise control was no longer available, but the van also said "Service Charging System" and "Shift to P to Start", the engine light and batter light both came on. I am sure that I almost died as I was in the middle lane and cars were whipping around me since I had slowed down so much, there was an 18 wheeler behind me and one of my righthand side, which is the shoulder I was trying to get to. I was finally able to coast to the shoulder and came to a stop, put the car in park and turned it off. I immediately started researching what the problem could be and I was alarmed to find out that this is an issue that others have had and that Chrysler has failed to issue a recall...I was able to start the car once more and get on to a little back road, after pushing through a barricade off the toll just for safety's sake, and my van broke down again, this time on a little 2 lane road, which thankfully had a little bit of a gravel shoulder. This time, my van took quite a bit longer to get started, but I was not safe where I was. I started it once more and was able to get to a Wal-Mart parking lot where my brother-in-law picked me up so that I could have a chance of making it to see my grandmother who was on her deathbed, I missed my window of opportunity to make it to see her, she died that afternoon. I had to pay an additional tow fee to get the vehicle moved from the parking lot to a Chrysler dealership since it was so far from where I usually go.

ELECTRICAL SYSTEM

I was traveling at south bound on TOLL 130 going 80MPH (which is the speed limit on that road) when my Pacifica immediately slowed down and my accelerator gave out. In addition to my dash flashing that the cruise control was no longer available, but the van also said "Service Charging System" and "Shift to P to Start", the engine light and batter light both came on. I am sure that I almost died as I was in the middle lane and cars were whipping around me since I had slowed down so much, there was an 18 wheeler behind me and one of my righthand side, which is the shoulder I was trying to get to. I was finally able to coast to the shoulder and came to a stop, put the car in park and turned it off. I immediately started researching what the problem could be and I was alarmed to find out that this is an issue that others have had and that Chrysler has failed to issue a recall...I was able to start the car once more and get on to a little back road, after pushing through a barricade off the toll just for safety's sake, and my van broke down again, this time on a little 2 lane road, which thankfully had a little bit of a gravel shoulder. This time, my van took quite a bit longer to get started, but I was not safe where I was. I started it once more and was able to get to a Wal-Mart parking lot where my brother-in-law picked me up so that I could have a chance of making it to see my grandmother who was on her deathbed, I missed my window of opportunity to make it to see her, she died that afternoon. I had to pay an additional tow fee to get the vehicle moved from the parking lot to a Chrysler dealership since it was so far from where I usually go.

VEHICLE SPEED CONTROL

I was traveling at south bound on TOLL 130 going 80MPH (which is the speed limit on that road) when my Pacifica immediately slowed down and my accelerator gave out. In addition to my dash flashing that the cruise control was no longer available, but the van also said "Service Charging System" and "Shift to P to Start", the engine light and batter light both came on. I am sure that I almost died as I was in the middle lane and cars were whipping around me since I had slowed down so much, there was an 18 wheeler behind me and one of my righthand side, which is the shoulder I was trying to get to. I was finally able to coast to the shoulder and came to a stop, put the car in park and turned it off. I immediately started researching what the problem could be and I was alarmed to find out that this is an issue that others have had and that Chrysler has failed to issue a recall...I was able to start the car once more and get on to a little back road, after pushing through a barricade off the toll just for safety's sake, and my van broke down again, this time on a little 2 lane road, which thankfully had a little bit of a gravel shoulder. This time, my van took quite a bit longer to get started, but I was not safe where I was. I started it once more and was able to get to a Wal-Mart parking lot where my brother-in-law picked me up so that I could have a chance of making it to see my grandmother who was on her deathbed, I missed my window of opportunity to make it to see her, she died that afternoon. I had to pay an additional tow fee to get the vehicle moved from the parking lot to a Chrysler dealership since it was so far from where I usually go.

ELECTRICAL SYSTEM

I have a 2018 Chrysler Pacifica Hybrid.  I purchased it brand new in 2018.  This van has had sooo many problems, it has been in and out of the shop, countless recalls.  Last year it was in the shop for almost the entire year, I think I had possession of the van for less than 3 months of the year.  I just brought my van in for a recall related to the hybrid battery and it was returned to me in December, within 2 weeks there were check engine lights on and when I googled the code that was showing I found a ton of blogs about how people had the same recall done and within a short period of time this code came up and it meant the hybrid battery needs to be replaced.  I reached out to the dealer and brought it in to get looked at.  After a couple weeks I was told that the replacement of the battery would not be covered under the recall since part of the recall solution is testing the battery, and it tested good.  I literally had only had the van back for 2 weeks.  And I have countless records of engine codes showing up for years. I currently have 8 active engine codes showing. I know there is an open investigation concerning the recall I just had the remedy done for and I am 100% sure that this defect is related to that recall.

FUEL/PROPULSION SYSTEM

Had check engine code p1c5e and vehicle would not charge. Dealership has confirmed that the lithium battery has failed and needs to be replaced. They communicated with Chrysler, opened a STAR case, and are in process of replacing the battery

ENGINE

Vehicle states "Stop Safely Vehicle Will Shut Off Soon" with a red turtle logo. I have restarted the vehicle, and the warning persists. I am bringing in the car to the dealer next.

UNKNOWN OR OTHER

Vehicle states "Stop Safely Vehicle Will Shut Off Soon" with a red turtle logo. I have restarted the vehicle, and the warning persists. I am bringing in the car to the dealer next.