2025 CHEVROLET TRAX

ENGINE

Bought my car June 3 2025. 8-10-25 at the dealer for another issue I mentioned about hear a squeek in the engine compartment, more so with the air on. Dealer stats can't hear squeek. Had to take back again on 9-9 for the other issue again and told dealer about still hearing squeek. Dealer stats can't hear unless removing oil cap and that there is a tsb that it's normal? Stated my mother's 25 year old car does not squeek and I don't think a new car should squeek. Dealer stated again, said to be normal.

FUEL/PROPULSION SYSTEM

Bought my car June 3 2025. On 8-10-2025 my check engine light came on. My chevy app was showing evap issue. Dealer stated that the code was not active and they test for leaks and could not find any. Reset light. On 9-6-2025 check engine light on again. Same deal. 9-9 Dealer states not current again but there is a tsb to replace the fuel filler neck, 3 weeks to get the part.

ELECTRICAL SYSTEM

The contact owns a 2025 Chevrolet Trax. The contact stated that on two separate occasions while driving at highway speeds during sunset, the Forward Collision Avoidance feature engaged unintendedly. Due to the failure, the vehicle independently came to an abrupt stop with a RED light flashing on the windshield. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the diagnostic test indicated two lost connections, and the electrical system was reset. After the system reset the message "Service Side Detection System" was displayed. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 22,000.

FORWARD COLLISION AVOIDANCE

The contact owns a 2025 Chevrolet Trax. The contact stated that on two separate occasions while driving at highway speeds during sunset, the Forward Collision Avoidance feature engaged unintendedly. Due to the failure, the vehicle independently came to an abrupt stop with a RED light flashing on the windshield. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the diagnostic test indicated two lost connections, and the electrical system was reset. After the system reset the message "Service Side Detection System" was displayed. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 22,000.

UNKNOWN OR OTHER

Found Light to clear oily fluid leaking from passenger side under front fender well after moving vehicle from garage parked location. Unable to determine exact source of leak. Suspect either brake fluid or refrigerant oil. Taking to dealer to address under warranty.

ELECTRICAL SYSTEM

While driving, both dash screens will go black for 30 seconds or so and then restart. This blackout includes the speedometer, dash lights, radio etc (the entirety of both screens. When taken to the dealership, I was told that I would have to leave my car until the problem was reproduced. Even with picture proof of the incident. There is no way to make it produce the issue.

ELECTRICAL SYSTEM

The instrument cluster (speedometer etc.) and info system goes blank periodically while we are driving the vehicle. The entire cluster goes black, then after about 30 seconds to a minute it comes back on. This was a recalled item on the 2024 Chevy Trax, but apparently it the recall did not extend to the early 2025. This is very concerning issue, especially when driving on the freeway at night. I was advised by the service writer at the dealership that I need to leave the vehicle with them for 5 to 7 days so they can conduct diagnosis even though I schedule an appointment with them 2 months ahead of the appointment and described what the issue was.

FORWARD COLLISION AVOIDANCE: WARNINGS

Ran into a cemex block with no light pole. The parking lot was dark and cemex block was not marked. Forward collision detection system did not work and airbag ejected some shrapnel cutting my arm and shatter ing my bone in forearm and wrist. I’m lucky it did not hit me in the head or I would be dead today. By the grace of god I’m still alive Amen !

AIR BAGS

Ran into a cemex block with no light pole. The parking lot was dark and cemex block was not marked. Forward collision detection system did not work and airbag ejected some shrapnel cutting my arm and shatter ing my bone in forearm and wrist. I’m lucky it did not hit me in the head or I would be dead today. By the grace of god I’m still alive Amen !

ENGINE

We’ve only had the vehicle for a few months and while we were driving the engine rod basically broke in pieces damaging the engine and almost causing us to wreck. After looking at the other GM engines being recalled for engine rod issues and complete engine failure. This sounds like the same incident and needs to also be added to this. It’s put us out and almost caused us to wreck after only 11k miles on the vehicle.

POWER TRAIN

The contact owns a 2025 Chevrolet Trax. The contact stated while driving from a complete stop and while coming to a stop, the vehicle was jerking and the transmission experienced hard shifts. There was no warning light illuminated. The vehicle was taken to the dealer to be diagnosed, but the cause of the failure could not be determined. The dealer performed a required ECM software update; however, the failure recurred. The manufacturer was not notified of the failure. The failure mileage was approximately 5,000.

UNKNOWN OR OTHER

While driving, all of a sudden dash went blank. No gauges, no speedometer, just a blank screen. I was near the dealer where I had purchased it and drove in. Service dept was closing but a mechanic disconnected the battery and reconnected it and the dash worked. The mechanic said he never heard of this happening before, but when I got home and researched it it has happened before. My wife uses the car to transport our grandkids, and I cannot imagine the screen going blank on the freeway at 65.

UNKNOWN OR OTHER

My passenger side door is making a thumping noise and now I have to live with a passenger door thumping when closing

VISIBILITY/WIPER

I’m reporting a recurring issue with the windshield wiper blades on my brand-new 2025 Chevrolet Trax vehicle. The driver-side wiper blade consistently leaves streaks across the windshield, especially during rain. This significantly reduces visibility, particularly dangerous at night when glare from oncoming headlights worsens the problem. I’ve already had to replace the wiper blades multiple times in just a few months, yet the issue keeps coming back. This poses a serious safety risk, and I’m concerned that it may be a manufacturing or design defect affecting more vehicles. I am told by Chevy that I can only purchase the OEM wiper blades and I have yet to be able to find any aftermarkets that fit this car. I urge the NHTSA to investigate this issue before it leads to accidents or injuries.

ELECTRICAL SYSTEM

The contact owns a 2025 Chevrolet Trax. The contact stated while driving 75 MPH, the instrument panel and cluster became inoperable. The vehicle was taken to the dealer, where the failure could not be duplicated; however, the failure recurred, and the navigation system and other infotainment system functions engaged independently. The vehicle was taken back to the dealer, where an unknown wiring cable was replaced; however, the failure persisted. The vehicle was taken back to the dealer, where the contact was informed that an unknown wiring cable needed to be replaced, and the part was ordered. The vehicle was not repaired. The dealer denied vehicle rental assistance. The contact stated that the failure had been recurring intermittently. The manufacturer was not notified of the failure. The failure mileage was unknown.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

The contact owns a 2025 Chevrolet Trax. The contact stated while driving 75 MPH, the instrument panel and cluster became inoperable. The vehicle was taken to the dealer, where the failure could not be duplicated; however, the failure recurred, and the navigation system and other infotainment system functions engaged independently. The vehicle was taken back to the dealer, where an unknown wiring cable was replaced; however, the failure persisted. The vehicle was taken back to the dealer, where the contact was informed that an unknown wiring cable needed to be replaced, and the part was ordered. The vehicle was not repaired. The dealer denied vehicle rental assistance. The contact stated that the failure had been recurring intermittently. The manufacturer was not notified of the failure. The failure mileage was unknown.

UNKNOWN OR OTHER

Vehicle’s digital dash will go completely black, will not respond to touches, radio will intermittently disconnect from Apple CarPlay. Radio replaced, problem persists. Yes the problem has been duplicated on numerous occasions by two separate dealerships and no resolution has been reached. No warning lights, no notifications, just sudden disconnection and reconnection or disconnection without any reconnection of device with non-responsiveness and occasional blacking out of screen on car. This has been ongoing since the purchase of the vehicle in May 2024, still no resolution.

ELECTRICAL SYSTEM

Vehicle’s digital dash will go completely black, will not respond to touches, radio will intermittently disconnect from Apple CarPlay. Radio replaced, problem persists. Yes the problem has been duplicated on numerous occasions by two separate dealerships and no resolution has been reached. No warning lights, no notifications, just sudden disconnection and reconnection or disconnection without any reconnection of device with non-responsiveness and occasional blacking out of screen on car. This has been ongoing since the purchase of the vehicle in May 2024, still no resolution.

FORWARD COLLISION AVOIDANCE: WARNINGS

Vehicle will indicate a pedestrian or another vehicle in front of and activate forward collision detection with hard braking when there are no pedestrians or obstacles/objects on the road- problem persists after having a new radar system installed via dealership

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Vehicle will indicate a pedestrian or another vehicle in front of and activate forward collision detection with hard braking when there are no pedestrians or obstacles/objects on the road- problem persists after having a new radar system installed via dealership

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Vehicle will indicate a pedestrian or another vehicle in front of and activate forward collision detection with hard braking when there are no pedestrians or obstacles/objects on the road- problem persists after having a new radar system installed via dealership

UNKNOWN OR OTHER

I’ve had my 2025 Chevy tracks for less than a year at first having issues in January 2025. I was driving back from my son‘s birthday party and the entire dash just went black. I could not see the mile per hour I was going and I could not see my radio my entire front dash just blacked out for almost a minute. I was driving at the speed of 70 miles an hour when this occurred putting myself and others at risk I was able to pull over on the side of the highway to see the issue going on with my vehicle. I turned off my vehicle and turned it back on thank you. Maybe that would resolve the issue, but it clearly didn’t. I contact GM. I contact the dealership Dutch Miller and explain to them the issue that did did occur. I took it into a shop. The dealership looked at it. They updated it the system in my car. Which I thought that resolved the issue for a few months and now I’m back to the dash going black when I’m driving, took it back to the dealership again and they said that they couldn’t find any issues and we just gotta wait until a recall occurs with GM. Been contacting General motors about this issue. This is a safety hazard and extremely dangerous when you’re going speed limit at high speed and you cannot see anything on your dash it is terrifying and scary especially when you have your family in the car. Hopefully GM gets this fixed. It’s a brand new car should not have any issues.

ELECTRICAL SYSTEM

I’ve had my 2025 Chevy tracks for less than a year at first having issues in January 2025. I was driving back from my son‘s birthday party and the entire dash just went black. I could not see the mile per hour I was going and I could not see my radio my entire front dash just blacked out for almost a minute. I was driving at the speed of 70 miles an hour when this occurred putting myself and others at risk I was able to pull over on the side of the highway to see the issue going on with my vehicle. I turned off my vehicle and turned it back on thank you. Maybe that would resolve the issue, but it clearly didn’t. I contact GM. I contact the dealership Dutch Miller and explain to them the issue that did did occur. I took it into a shop. The dealership looked at it. They updated it the system in my car. Which I thought that resolved the issue for a few months and now I’m back to the dash going black when I’m driving, took it back to the dealership again and they said that they couldn’t find any issues and we just gotta wait until a recall occurs with GM. Been contacting General motors about this issue. This is a safety hazard and extremely dangerous when you’re going speed limit at high speed and you cannot see anything on your dash it is terrifying and scary especially when you have your family in the car. Hopefully GM gets this fixed. It’s a brand new car should not have any issues.

STRUCTURE:BODY

What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle’s rear structure and frame were compromised. After a low-speed rear-end collision (approximately 5 mph), the frame bent, and the vehicle was declared a total loss by the insurance company. The car is no longer available for inspection as it has been taken by insurance, but documentation including photos, insurance reports, and repair estimates is available upon request. 2. How was your safety or the safety of others put at risk? The fact that the frame sustained significant damage in such a low-speed collision raises concerns about the overall durability and crashworthiness of the vehicle. This could indicate that the vehicle might not provide adequate protection in more severe collisions, putting occupants at risk in real-world driving conditions. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the damage was confirmed by the insurance adjuster and an independent collision repair shop, both of whom concluded that the vehicle’s frame was bent. The repair facility stated that the vehicle could not be repaired due to the extent and nature of the frame damage. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, the vehicle was inspected by an insurance adjuster and an independent body shop. The manufacturer has not inspected the vehicle, and police were not involved as it was a minor collision without injuries. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there were no warning lamps or messages prior to the incident. The issue only became apparent after the vehicle was rear-ended, at which point the structural damage was assessed.

VEHICLE SPEED CONTROL

The contact owned a 2025 Chevrolet Trax. The contact stated while driving 35 MPH with cruise control mode disengaged, and approaching the red traffic light, the brake pedal was depressed. The contact stated that the vehicle responded temporarily, and then the vehicle accelerated unintendedly. There was no warning light illuminated. The contact stated that he shifted to park(P) in the hope that the vehicle would stop, but the vehicle failed to stop and the engine revved louder, causing the vehicle to crash into two occupied vehicles in the intersection of a highway. The air bags deployed. It was unknown whether there was a warning light illuminated after the crash. The contact sustained injuries and the emergency units transported the contact to the hospital, where he underwent a CT scan. The contact was informed that he had sustained two broken ribs. The contact was hospitalized for two weeks, and the contact was admitted to a rehabilitation center for a week and a half. One of the other drivers sustained three broken ribs, but it was unknown whether the driver received medical assistance. No further information was available. The vehicle was towed and totaled. The two other vehicles were totaled. A police report was filed. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 6,000.

UNKNOWN OR OTHER

The backup camera becomes a "fishbowl" along with inability to use radio features. Happens often. There are numerous forum topics via Facebook and Reddit about it happening. Dealership is no help.

UNKNOWN OR OTHER

The interior of this car includes many chrome accents. Chrome on the steering wheel, center console around the gear shift, and chrome around the touch screen. When driving, the sun reflects off of the chrome like a laser/mirror, impacting the visibility and safety of the driver. I am looking into ways to "black out" the chrome, but it truly is a safety hazard! Chevrolet should provide a "chrome delete" kit and keep chrome on the EXTERIOR, not on the INTERIOR.

ELECTRICAL SYSTEM

I am very unsure what is going on, but when I am in reverse my whole dash loudly rattles and vibrates the whole car. My front door speakers also keep going out with makes me think we may have a wiring issue.

UNKNOWN OR OTHER

I am very unsure what is going on, but when I am in reverse my whole dash loudly rattles and vibrates the whole car. My front door speakers also keep going out with makes me think we may have a wiring issue.

ENGINE

I am very unsure what is going on, but when I am in reverse my whole dash loudly rattles and vibrates the whole car. My front door speakers also keep going out with makes me think we may have a wiring issue.

AIR BAGS

Was making right hand turn which causes vehicle to straddle shoulder for a brief period of time because of how lines are painted. Auto steering resisted the manual steering to get into the lane properly and pulled vehicle onto shoulder further which lead vehicle to be pulled into the ditch.

STEERING

Was making right hand turn which causes vehicle to straddle shoulder for a brief period of time because of how lines are painted. Auto steering resisted the manual steering to get into the lane properly and pulled vehicle onto shoulder further which lead vehicle to be pulled into the ditch.

LANE DEPARTURE: ASSIST

Was making right hand turn which causes vehicle to straddle shoulder for a brief period of time because of how lines are painted. Auto steering resisted the manual steering to get into the lane properly and pulled vehicle onto shoulder further which lead vehicle to be pulled into the ditch.

ELECTRICAL SYSTEM

No cold AC only hot, car temps hit 107 as of 3/19/25 is believed to be the Evaporator system. I have an 8 month old baby this is very dangerous.

FORWARD COLLISION AVOIDANCE: WARNINGS

Vehicle will “disengage from adaptive cruise control” randomly and hard brake when there is nothing in front of the vehicle

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Vehicle will “disengage from adaptive cruise control” randomly and hard brake when there is nothing in front of the vehicle

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Vehicle will “disengage from adaptive cruise control” randomly and hard brake when there is nothing in front of the vehicle

VISIBILITY/WIPER

Unknown. The OEM wipers have a large streak in the main field of vision on the drivers side. They only last a FEW weeks with new OEM parts. I’ve tried getting aftermarket replacement s and they don’t fit properly.

POWER TRAIN

I am reporting a safety incident that occurred on [XXX] with my new GM vehicle, a 2025 Chevy Trax with roughly 3000 odometer miles. I was returning to Troy MI from Ann Arbor MI on [XXX] a roughly 50 mile drive, a driver with one passenger. The weather was good, no ice or debris on the roads. We exited the highway and proceeded north through several stoplights. Just before making a right turn into a destination, the vehicle seemed to slam to stop multiple times, causing loss of vehicle control. The abrupt behavior knocked the steering wheel out of driver hands and lurched us forward against the seatbelts. I parked and powered down, giving it a chance to reset. Then continuing to drive a short distance, the vehicle repeatedly abruptly halted at speeds over 30mph as if hitting a wall. There were no warning lights or alerts displayed on the instrument panel, and the vehicle had never behaved abnormally in any way prior to this incident. On Monday morning [XXX] the dealership immediately verified the condition, though offering no speculation to the cause. The service manager reported that upon test drive, the service tech said "he would have gone through the windshield if not belted in.” My passenger and I have between the two of us [XXX] years of experience working in automotive, for GM and suppliers, in production capacities, and for years driving dozens of leased vehicles and GM company cars. Neither of us have ever experienced a vehicle doing anything as dangerous as this brand new Trax did. Had the failure occurred during the highway portion of our drive that day - multiple congested highways [XXX] - we are certain we could have been killed and would have been a lethal danger to the drivers around us. An abrupt halt at high speed would have caused the car to roll and/or spin out of control. At the time of this report, the car is with the dealership with no root cause or repair estimation. We believe this is a transmission issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.

ELECTRICAL SYSTEM

After shifting from reverse to drive, the main dashboard display went completely black and stayed black for the remainder of my drive cycle. During this incident, the infotainment screen remained working as normal. The dashboard display returned to normal operation at the next key-cycle (I waited 10 minutes and started again). Incident occurred February 19, 2025. It was dangerous because I could not see my speed, the engine temperature, or be aware of any warnings (had there been any). The engine appeared to run normally. I haven't driven again to test if the problem reoccurs. I haven't had the opportunity to bring to the dealership to evaluation.

ENGINE

FUEL RAIL SYSTEM - The check engine light came on after only three days/156 miles! OnStar was contacted and a diagnostic was run indicating "The Engine and Transmission System is not performing as expected. An issue has been detected in the Fuel Management System used to maintain control and monitor fuel consumption." I took the vehicle back to the dealership and was advised that the fuel rail system needed to be replaced but the part(s) are not available and there is no projected date of arrival. NOTE: The vehicle has been sitting at the Service Center since December 28, 2024 awaiting necessary repairs.

FUEL/PROPULSION SYSTEM

FUEL RAIL SYSTEM - The check engine light came on after only three days/156 miles! OnStar was contacted and a diagnostic was run indicating "The Engine and Transmission System is not performing as expected. An issue has been detected in the Fuel Management System used to maintain control and monitor fuel consumption." I took the vehicle back to the dealership and was advised that the fuel rail system needed to be replaced but the part(s) are not available and there is no projected date of arrival. NOTE: The vehicle has been sitting at the Service Center since December 28, 2024 awaiting necessary repairs.