2019 CHEVROLET TRAX Complaints and Recall Information

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

General Motors LLC (GM) is recalling certain 2017-2019 Chevrolet Trax vehicles. A joint in one or both of the front lower-control arms may have been improperly welded. An improperly welded joint may break, resulting in the partial separation of the lower-control arm from the vehicle.

Risk: A partial separation of the lower-control arm from the vehicle could cause the attached front wheel to toe outward, impacting the vehicle's handling and steering and increasing the risk of crash.

ELECTRICAL SYSTEM

The screen that tells you all information on vehicle like; speed, miles on vehicle, tire pressure, oil, etc. is 100% broken. It’s a black screen. Car has been an issue since I got it with this. How am I supposed to know if my oil is getting low without opening the hood and checking manually? I’m not a very tall person so I can not access this part of my car.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR:RESISTOR/SPEED CONTROL

The contact owns a 2019 Chevrolet Trax. The contact smelled an abnormal burning odor and became aware that the A/C unit failed to operate past level 4. The vehicle was taken to an independent mechanic, who diagnosed that the connector for the A/C unit had failed and needed to be replaced. The independent mechanic became aware that the wire for the A/C unit was burned, causing the A/C unit to malfunction. The A/C resistor, connector, and A/C blower motor were replaced. The contact stated that the resistor and connector had been burned 3 times and needed to be replaced again. The failure persisted, and the A/C unit continued releasing the burning odor. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the dealer for assistance. The failure mileage was 71,200.

ELECTRICAL SYSTEM

The contact owns a 2019 Chevrolet Trax. The contact smelled an abnormal burning odor and became aware that the A/C unit failed to operate past level 4. The vehicle was taken to an independent mechanic, who diagnosed that the connector for the A/C unit had failed and needed to be replaced. The independent mechanic became aware that the wire for the A/C unit was burned, causing the A/C unit to malfunction. The A/C resistor, connector, and A/C blower motor were replaced. The contact stated that the resistor and connector had been burned 3 times and needed to be replaced again. The failure persisted, and the A/C unit continued releasing the burning odor. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the dealer for assistance. The failure mileage was 71,200.

ENGINE

The turbocharger in this vehicle cracked at around 50,000 miles and my mechanic predicts it will happen again after another 50,000. This makes the vehicle unable to accelerate at unpredictable times, making the safety of the driver of the vehicle, as well as others on the road, compromised. My mechanic believes this is a common problem with GM vehicles of this engine size. Please advise. Thank you.

POWER TRAIN

Turbocharger was replaced in October 2024. Now it is bad again as confirmed by the dealership. Check engine light was on. They had it in their repair shop and did a diagnostic test. Car stalled in the middle of the highway. The 2017 & 2018 Trax with the same engine have a recall for the turbocharger. The dealership would not honor the parts warranty because they said it was low on oil. No check oil light came on.

ENGINE

October 2024 the turbocharger was replaced. A few weeks ago check engine light came on. Bad turbocharger again while I was on a highway the car stopped running. Dealer said they will not replace it under the parts warranty. They said it was 3 quarts low on oil and I need to show receipts for last 3 oil changes. From previous times there they knew my son is a mechanic & did oil changes. They wanted me to call my son to ask him how much oil he put in üôÑ after looking online it is a very common problem with the Chevy turbochargers. It will but an excessive amount of oil and cause it to be black and sludgy. I emailed the general manager. He never responded. I also filed a complaint with GM and consumer protection. When they replaced it in October it was still under the extended warranty. It is now over the 100,000 miles. However, I think a turbocharger should last more than 6 months. I could have been killed on the highway while broken down due to a part they know is defective. Instead they treated me like trash. It is not the first time they have done this to me. The car already has a new radiator, transmission, faulty turbocharger, and something with the valves was fixed. The car is a lemon. I just want them to be held accountable since they know this is a common occurrence with the Chevy turbochargers

POWER TRAIN

October 2024 the turbocharger was replaced. A few weeks ago check engine light came on. Bad turbocharger again while I was on a highway the car stopped running. Dealer said they will not replace it under the parts warranty. They said it was 3 quarts low on oil and I need to show receipts for last 3 oil changes. From previous times there they knew my son is a mechanic & did oil changes. They wanted me to call my son to ask him how much oil he put in üôÑ after looking online it is a very common problem with the Chevy turbochargers. It will but an excessive amount of oil and cause it to be black and sludgy. I emailed the general manager. He never responded. I also filed a complaint with GM and consumer protection. When they replaced it in October it was still under the extended warranty. It is now over the 100,000 miles. However, I think a turbocharger should last more than 6 months. I could have been killed on the highway while broken down due to a part they know is defective. Instead they treated me like trash. It is not the first time they have done this to me. The car already has a new radiator, transmission, faulty turbocharger, and something with the valves was fixed. The car is a lemon. I just want them to be held accountable since they know this is a common occurrence with the Chevy turbochargers

UNKNOWN OR OTHER

The contact owned a 2019 Chevrolet Trax. The contact stated that the vehicle was parked on the right side of the 2 vehicle garage when it suddenly caught fire after approximately 1 hour of being parked. A popping sound alerted the contact and her spouse to the fire. The garage was unfinished with a gravel floor and no outlets when it caught fire, and there was property damage. No warning lights illuminated. The fire department was called to the scene and was able to extinguish the fire. The fire department had put fire department was unable to determine the cause of the fire. The vehicle was towed and totaled due to the vehicle being consumed by the fire. There were no injuries or medical attention needed. The dealer was contacted and informed of the failure. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The manufacturer had sent personnel to take pictures of the fire and have the vehicle inspected. The manufacturer opened a case for the failure however, the case was closed due to the manufacturer not finding a defect for the failure. The failure mileage was 41,000.

FUEL/PROPULSION SYSTEM

Turbo Charger/Super charger is not following sufficient air. The vehicle does not excelerate, and slowed down in the middle of traffic. I had to turn the car off for 15 minuetes. Before i could drive home. Check engine light continues to disappear and reappear for the last 60 days. Diagnostic code P0299. GMC will not cover the cost under special coverage, known issues with 2017-2018 which GMC has special coverage.

STEERING

Turbo Charger/Super charger is not following sufficient air. The vehicle does not excelerate, and slowed down in the middle of traffic. I had to turn the car off for 15 minuetes. Before i could drive home. Check engine light continues to disappear and reappear for the last 60 days. Diagnostic code P0299. GMC will not cover the cost under special coverage, known issues with 2017-2018 which GMC has special coverage.

ENGINE

Turbo Charger/Super charger is not following sufficient air. The vehicle does not excelerate, and slowed down in the middle of traffic. I had to turn the car off for 15 minuetes. Before i could drive home. Check engine light continues to disappear and reappear for the last 60 days. Diagnostic code P0299. GMC will not cover the cost under special coverage, known issues with 2017-2018 which GMC has special coverage.

UNKNOWN OR OTHER

Since purchasing vehicles it looses coolant I replaced the coolant pump due to small crack and thought that may have been the issue but it’s not I have to put coolant in it at least 2 to 4 times a month When check at the dealer they said they could see anything how ever I did my own looking up online and it said that these vehicles have issues with leaking water pump I have had this car hoping and praying no damages come from something that can’t be seen

ELECTRICAL SYSTEM

The 2016 through 2024 Chevy Trax all have an issue with the climate control fan resistor. It burns out on a regular basis. Very dangerous because as you can see in the pictures it got very hot. It's a bad design, the heat sink is not adequate to hold the voltage and or the motor is too small or bomdined. It's a serious issue that almost every Chevy Trax owner is experiencing. Please we really need your help to investigate this. My daughters drives this car and I need it to be safe. We only owned the car a month before this happened and someone already changed the fan motor and resistor before we got it. Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

Evaporative Emission Control System part had to be replaced 3/19/2025 at my repair service at which is a certified chevy dealership service center. my engine light came on so I had the service advisor check the codes, and I had poor fuel mileage as well, for about a month. apparently, the advisor didn't know there was a recall I only found out through my roommate

VEHICLE SPEED CONTROL

Truck has code P0299. Turbo underboost. Reduced acceleration, lack of power, and a check engine light.

ENGINE

Truck has code P0299. Turbo underboost. Reduced acceleration, lack of power, and a check engine light.

VEHICLE SPEED CONTROL

I turned on the vehicle and the check engine light came on *NOT BLINKING* for the first time. The traction control light also came on after a few minutes of driving. About a minute later, the vehicle began to slow from 40 to a near-complete stop in the middle of a busy road. No blinking lights or alerts. I pulled the vehicle into a parking lot and parked. The vehicle began shaking slightly. I turned off the vehicle for about 15 minutes or so and was able to drive back home with the check engine light still on. I called to have the vehicle towed to a dealership.

FUEL/PROPULSION SYSTEM

I turned on the vehicle and the check engine light came on *NOT BLINKING* for the first time. The traction control light also came on after a few minutes of driving. About a minute later, the vehicle began to slow from 40 to a near-complete stop in the middle of a busy road. No blinking lights or alerts. I pulled the vehicle into a parking lot and parked. The vehicle began shaking slightly. I turned off the vehicle for about 15 minutes or so and was able to drive back home with the check engine light still on. I called to have the vehicle towed to a dealership.

ELECTRICAL SYSTEM

I turned on the vehicle and the check engine light came on *NOT BLINKING* for the first time. The traction control light also came on after a few minutes of driving. About a minute later, the vehicle began to slow from 40 to a near-complete stop in the middle of a busy road. No blinking lights or alerts. I pulled the vehicle into a parking lot and parked. The vehicle began shaking slightly. I turned off the vehicle for about 15 minutes or so and was able to drive back home with the check engine light still on. I called to have the vehicle towed to a dealership.

ELECTRICAL SYSTEM

Our problem is with the blower motor not working. There is service bulletin released from Chevy MC-10155050-9999 There is an issue with temperature control cable causing some kind of electrical issue with the fan temperature speed setting. The fan does not operate causing fogginess onto pure on our windshield and unable to operate the car without having driving visibility issues. Which can cause an accident or worse death. Please can you look into this? Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

My check engine light came on after filling up with gas, after checking the purge valve cantilever was bad, I bought it and had licensed mechanic who owns his business replace it. Once again the check engine might came on. The error was cylinder 4 miss , I was told either the spark plug or coil was bad. My mechanic said ger coil and if that's not it he would replace spark plugs. I purchased the coil for a four cylinder engine because that's the only way they come. My mechanic took off the part which was broke and upon taking it out.he saw water in the coil holder and told me this was bad. He suggested I look up recalls on my vehicle upon which I found e recall on the puge valve along with a recall on the coil system which described the same problem of water leaking into the engine. After call recall department I was told they would cover the purge valve repair but there was no recall attached to my vin on other problem which should be. I bought the car with 28000 miles on it and have less than 44000 on it now. It should be covered under thus recall I have done all maintenance required and don't put many miles on it. I am a retired individual living on a budgeted income and thus problem should be covered under recall as it is the same problem as others have had. My