2016 CHEVROLET TRAX

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

General Motors LLC (GM) is recalling certain 2015-2018 Chevrolet Trax vehicles. A joint in one or both of the front lower control arms may have been improperly welded. An improperly welded joint may break, resulting in the partial separation of the lower control arm from the vehicle.

Risk: A partial separation of the lower-control arm from the vehicle could cause the attached front wheel to toe outward, impacting the vehicle's handling and steering and increasing the risk of crash.

AIR BAGS:FRONTAL

General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

AIR BAGS:FRONTAL

General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Sonic and Trax, and 2013-2015 Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver fails to fasten their seatbelt or if the driver leaves the key in the ignition. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208 "Occupant Crash Protection" and 114 "Theft Protection."

Risk: Without audible indicators, the driver may not fasten their seatbelt, increasing the risk of injury during a crash.

ELECTRICAL SYSTEM

We have had problems with this vehicle since we purchased it 2yrs ago. It started with loosing power once in awhile, then the AC quit working, both sets of keys have lost the buttons on the keypad, we have to manually lock and unlock the doors and the auto start is unusable, and now it stalls out at a speed above 30mph and starts smoking severely. It is not drivable. I have to pull over every 2 to 3 miles, because it overheats. We had it towed to a mechanic 2 weeks ago and he did what he could for what we could afford, but we didn't get 10 miles before it started again. The mechanic said this vehicle had a lot of problems. We are [XXX] and we always have our grandchildren [XXX] and [XXX] with us. You can imagine how frightening it is when this happens and we pull over and get everyone out. People pull off and try to help, but we worry about the wrong person stopping for the wrong reason. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

We have had problems with this vehicle since we purchased it 2yrs ago. It started with loosing power once in awhile, then the AC quit working, both sets of keys have lost the buttons on the keypad, we have to manually lock and unlock the doors and the auto start is unusable, and now it stalls out at a speed above 30mph and starts smoking severely. It is not drivable. I have to pull over every 2 to 3 miles, because it overheats. We had it towed to a mechanic 2 weeks ago and he did what he could for what we could afford, but we didn't get 10 miles before it started again. The mechanic said this vehicle had a lot of problems. We are [XXX] and we always have our grandchildren [XXX] and [XXX] with us. You can imagine how frightening it is when this happens and we pull over and get everyone out. People pull off and try to help, but we worry about the wrong person stopping for the wrong reason. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

I purchased my vehicle on January 6, 2025. Two days later, the check engine light came on. After struggling to reach anyone at the dealership, I finally got in touch on January 14, and dropped the car off on January 22 for a catalytic converter and A/C issue. On February 23, the check engine light returned with the same code. I brought the car back on March 7, and by May, the light came on again and the A/C failed for a second time. Over 1–2 weeks, I called repeatedly but was either hung up on or transferred with no resolution. On May 23, I had the car checked at an independent shop, who confirmed it was the catalytic converter again and recommended I return to the dealer. I made an appointment online and dropped the car off on May 29. I didn’t hear anything for nearly a week. When I called, the same communication issues happened. On June 3, my sister picked up the car — it was a mess, with the back seat torn apart. I was told it wasn’t the cat but a fuel pump, water pump, and quoted over $2,000. I got a second opinion on June 22. That mechanic said it did not need a fuel pump and that it was the cat — plus spark plugs, coil pack, serpentine belt — none of which had ever been mentioned before. I’ve since spent $600 on repairs that shouldn't be necessary months after purchase. Emails to the service team went unanswered until I followed up. The car also had an ongoing rotten egg smell.On June 30, I was told they’d replace the aftermarket cat with an OEM. I emailed asking about the A/C and a service history — no reply. I dropped the car off July 2 or 3, was told it’d be ready July 7, then July 8, then told the issue was actually a cracked turbocharger, not the catalytic converter. I asked if it was safe to drive — the manager said yes, but everything online said otherwise. I was told the part would arrive in 1 day and take 2 days to replace.As of July 15, the car is still not ready. Trenton told me in person the part still hasn’t even arrived and would take 5 more days

ENGINE AND ENGINE COOLING

The contact owns a 2016 Chevrolet Trax. The contact stated that while her niece was driving 40 MPH, she became aware there was coolant leaking from the engine. The check engine warning light was illuminated. The contact stated that the vehicle was drivable until arriving at the residence. The contact added coolant to the coolant reservoir and became aware there was coolant leaking on the driveway. A dealer was not contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed or repaired. The manufacturer was notified of the failure, and informed the contact there were no recalls associated with the VIN, and that the vehicle was out of warranty. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 87,000.

ENGINE

The contact owns a 2016 Chevrolet Trax. The contact stated that while her niece was driving 40 MPH, she became aware there was coolant leaking from the engine. The check engine warning light was illuminated. The contact stated that the vehicle was drivable until arriving at the residence. The contact added coolant to the coolant reservoir and became aware there was coolant leaking on the driveway. A dealer was not contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed or repaired. The manufacturer was notified of the failure, and informed the contact there were no recalls associated with the VIN, and that the vehicle was out of warranty. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 87,000.

ENGINE

My 2016 chevy Trax has had 4 replacement of the the thermostat housing assembly with sensor. It causes the engine light to come on and can make the car idle rough, die at a red light, can cause the car to suddenly just go to 5 miles an hour. I have 79,900 miles on this chevy trax and this is the 4th replacement in less then 2 or 3 month.

ENGINE

The air bag light randomly came on about two yeatago and never went off. The engine(turbo) has been having problems for two years now. I’ve been to the dealership several times over the year. I was almost hit by another vehicle because of slow take off

STEERING

The air bag light randomly came on about two yeatago and never went off. The engine(turbo) has been having problems for two years now. I’ve been to the dealership several times over the year. I was almost hit by another vehicle because of slow take off

AIR BAGS

The air bag light randomly came on about two yeatago and never went off. The engine(turbo) has been having problems for two years now. I’ve been to the dealership several times over the year. I was almost hit by another vehicle because of slow take off

POWER TRAIN

2016 Chevrolet Trax experienced turbocharger failure in June 2024. Initial minor acceleration inconsistencies progressed to dangerous turbulence and power loss during acceleration at both high and low speeds, with check engine light temporarily illuminating. Initial Firestone diagnostic (June 7) documented 'TURBULENCE AS ACCELERATES - CEL BLINKED.' After diagnosis, completed repair June 11. Searched for recalls at time of failure but found none listed. Given 50-minute highway commute and unsafe acceleration issues, immediate repair was necessary. Due to expected dealer costs and wait times, repair was completed at Firestone Complete Auto Care for $3,036.81. Double-checked for recalls after repair with no results. On February 3, 2025, while organizing digital records, discovered original GM Special Coverage Program notice from November 2021 covering turbocharger wastegate actuator linkage issues. Program promises coverage for 10 years/120,000 miles. At 68,283 miles, vehicle is well within coverage period. On February 3, 2025 at 4:19pm, called GM customer service (case #[XXX], 29 minute call). Rep Takesha spoke with supervisor Britney but refused transfer. Put on hold 4 times totaling over 6 minutes. When requesting Special Coverage Program information, rep repeatedly stated 'it was not done at a dealership' over 15 times as blanket response. Initially cited expired bumper-to-bumper warranty from 2019 (irrelevant to Special Coverage). When pressed, shifted to claiming 'no active recalls' for VIN. Stated 'the decision has already been made, and a supervisor will tell you the same decision,' refusing escalation or document review. All attempts to discuss Program terms met with same non-dealer repair response. Refused to provide submission process information or contacts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

2016 Chevrolet Trax experienced turbocharger failure in June 2024. Initial minor acceleration inconsistencies progressed to dangerous turbulence and power loss during acceleration at both high and low speeds, with check engine light temporarily illuminating. Initial Firestone diagnostic (June 7) documented 'TURBULENCE AS ACCELERATES - CEL BLINKED.' After diagnosis, completed repair June 11. Searched for recalls at time of failure but found none listed. Given 50-minute highway commute and unsafe acceleration issues, immediate repair was necessary. Due to expected dealer costs and wait times, repair was completed at Firestone Complete Auto Care for $3,036.81. Double-checked for recalls after repair with no results. On February 3, 2025, while organizing digital records, discovered original GM Special Coverage Program notice from November 2021 covering turbocharger wastegate actuator linkage issues. Program promises coverage for 10 years/120,000 miles. At 68,283 miles, vehicle is well within coverage period. On February 3, 2025 at 4:19pm, called GM customer service (case #[XXX], 29 minute call). Rep Takesha spoke with supervisor Britney but refused transfer. Put on hold 4 times totaling over 6 minutes. When requesting Special Coverage Program information, rep repeatedly stated 'it was not done at a dealership' over 15 times as blanket response. Initially cited expired bumper-to-bumper warranty from 2019 (irrelevant to Special Coverage). When pressed, shifted to claiming 'no active recalls' for VIN. Stated 'the decision has already been made, and a supervisor will tell you the same decision,' refusing escalation or document review. All attempts to discuss Program terms met with same non-dealer repair response. Refused to provide submission process information or contacts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)