2020 CHEVROLET TRAVERSE

TIRES

General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.

Risk: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.

POWER TRAIN:AUTOMATIC TRANSMISSION

Braun Corporation (Braun) is recalling certain 2020-2021 Chevrolet Traverse wheelchair accessible vehicles with Power In-floor Ramp conversion. The screw and clip that hold the inner wheel-well plastic shroud in place may chafe against the transmission case, possibly resulting in a transmission fluid leak.

Risk: A transmission fluid leak can cause a loss of drive power, increasing the risk of a crash. In addition, a leak in the presence of an ignition source increases the risk of a fire.

TIRES

General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5, GMC Acadia and Chevrolet Traverse vehicles and 2020-2021 Chevrolet Silverado 1500, GMC Sierra 1500 vehicles. The vehicles may have been manufactured with Continental tires that were overcured.

Risk: Overcured tires may experience a carcass break in the sidewall resulting in a sudden air loss or could develop a belt edge separation which could lead to partial or full tread/belt loss. Either condition increases the risk of a crash.

POWER TRAIN:AUTOMATIC TRANSMISSION

General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Cruze and Buick LaCrosse, 2018-2020 Chevrolet Equinox, Chevrolet Traverse and GMC Terrain, 2018 Chevrolet Malibu, 2019-2020 Buick Encore, Buick Enclave, Cadillac XT4, Chevrolet Blazer and GMC Acadia, and 2020 Cadillac XT6 vehicles. The start/stop accumulator endcap may have missing bolts.

Risk: Missing bolts on the start-stop accumulator endcap could result in a transmission oil leak and may progress to a loss of propulsion, increasing the risk of a crash. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5, Cadillac XT6, Chevrolet Traverse, and GMC Acadia vehicles. The fuel pump's jet nozzle may have a plastic burr remaining from the manufacturing process, possibly causing a blocked nozzle and an insufficient fuel supply to the engine.

Risk: Insufficient fuel supply can result in an engine stall without warning, increasing the risk of a crash.

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles. The diffuser component of the Roof-Rail Air Bag (RRAB) inflator may not have been properly crimped to the inflator and could separate from the inflator during air bag deployment.

Risk: If the diffuser separates from the inflator during deployment, RRAB performance may be degraded, increasing the risk of injury in a crash.

UNKNOWN OR OTHER

Exhaust and catalytic converters keep breaking off causing loud noise and check engine light to stay on

SUSPENSION

Exhaust and catalytic converters keep breaking off causing loud noise and check engine light to stay on

POWER TRAIN

Check engine light came on day after I purchased this vehicle. Cracks in both front exhaust pipes. Seem to be an issue with 2020 chevy traverse models.

POWER TRAIN

I recently had to replace my transmission (2020 Chevrolet Traverse) due to shuddering from manufacturer's fault in assembly process. Now I'm having to replace the transmission in my mother's 2018 Chevrolet Colorado that has less than 65k miles. These issues cause power loss while driving. I was in the middle of passing another vehicle when my vehicle experienced power loss. This is a HUGE safety issue, not only for my family but many others that I know that are experiencing or have experienced the same issues. I have 3 family members that have had to have the same repairs as well as over 40 acquaintances. I had assumed with the thousands others that I've chatted with on facebook and reddit that this would have been a recall, sadly, GM/Chevrolet doesn't seem to care that it is their fault that their consumers are having to spend THOUSANDS of dollars to correct an issue that leaves the manufacturer at fault. With the thounsands experiencing the same issue, i feel that those that have already had to spend money should be reimbursed.

UNKNOWN OR OTHER

Catalyst converter bracket on the front of my exhaust is broken causing loud noise and the check engine light to remain on. This should be in connection with specialized coverage program N212356540

FUEL/PROPULSION SYSTEM

Ive got this vehicle on 5/12/2025 and all of this need to be done CATALYTIC CONVERTER REPLACEMENT. DURING INSPECTION FOUND LOUD EXHAUST ON STARTUP. UPON FURTHER INSPECTION FOUND BANK 1 CATALYTIC CONVERTER CRACKED CAUSING EXHAUST LEAK. BOTH EXHAUST FRONT PIPES DAMAGED AS WELL(BROKEN MOUNTING BRACKETS BETWEEN BOTH PIPES) . RECOMMEND REPLACEMENT OF CATALYTIC CONVERTER AND BOTH EXHAUST FRONT PIPESBRAKE SYSTEM FLUID EXCHANGE-PERFORMED PRESSURIZED FLUID EXCHANGE OF OLD BRAKE FLUID, REMOVED MOISTURE AND AIR CONTAMINATION FROM BRAKE SYSTEM. INSTALLED NEW DOT SPECIFIC FLUID TO MEET MANUFACTURE SPECIFICATIONSAUTOMATIC TRANSMISSION SERVICE FLUID EXCHANGECF - COOLING SYSTEM SERVICE 6830/5881-01 INCLUDES FLUSH COOLING SYSTEM, PRESSURE TEST, CHECK HOSES, CAP AND CHECK CONNECTION. INSTALL COOLING SYSTEM CORROSION CONTROL KIT Drain old Transfer case fluid and replace with new fluid REAR DIFFERENTIAL SERVICE This should have been done when the dealership got the vehicle, and it should be GM or BERGER responsibility. I am sure this was an issue to begin with.

ENGINE

Ive got this vehicle on 5/12/2025 and all of this need to be done CATALYTIC CONVERTER REPLACEMENT. DURING INSPECTION FOUND LOUD EXHAUST ON STARTUP. UPON FURTHER INSPECTION FOUND BANK 1 CATALYTIC CONVERTER CRACKED CAUSING EXHAUST LEAK. BOTH EXHAUST FRONT PIPES DAMAGED AS WELL(BROKEN MOUNTING BRACKETS BETWEEN BOTH PIPES) . RECOMMEND REPLACEMENT OF CATALYTIC CONVERTER AND BOTH EXHAUST FRONT PIPESBRAKE SYSTEM FLUID EXCHANGE-PERFORMED PRESSURIZED FLUID EXCHANGE OF OLD BRAKE FLUID, REMOVED MOISTURE AND AIR CONTAMINATION FROM BRAKE SYSTEM. INSTALLED NEW DOT SPECIFIC FLUID TO MEET MANUFACTURE SPECIFICATIONSAUTOMATIC TRANSMISSION SERVICE FLUID EXCHANGECF - COOLING SYSTEM SERVICE 6830/5881-01 INCLUDES FLUSH COOLING SYSTEM, PRESSURE TEST, CHECK HOSES, CAP AND CHECK CONNECTION. INSTALL COOLING SYSTEM CORROSION CONTROL KIT Drain old Transfer case fluid and replace with new fluid REAR DIFFERENTIAL SERVICE This should have been done when the dealership got the vehicle, and it should be GM or BERGER responsibility. I am sure this was an issue to begin with.

POWER TRAIN

Ive got this vehicle on 5/12/2025 and all of this need to be done CATALYTIC CONVERTER REPLACEMENT. DURING INSPECTION FOUND LOUD EXHAUST ON STARTUP. UPON FURTHER INSPECTION FOUND BANK 1 CATALYTIC CONVERTER CRACKED CAUSING EXHAUST LEAK. BOTH EXHAUST FRONT PIPES DAMAGED AS WELL(BROKEN MOUNTING BRACKETS BETWEEN BOTH PIPES) . RECOMMEND REPLACEMENT OF CATALYTIC CONVERTER AND BOTH EXHAUST FRONT PIPESBRAKE SYSTEM FLUID EXCHANGE-PERFORMED PRESSURIZED FLUID EXCHANGE OF OLD BRAKE FLUID, REMOVED MOISTURE AND AIR CONTAMINATION FROM BRAKE SYSTEM. INSTALLED NEW DOT SPECIFIC FLUID TO MEET MANUFACTURE SPECIFICATIONSAUTOMATIC TRANSMISSION SERVICE FLUID EXCHANGECF - COOLING SYSTEM SERVICE 6830/5881-01 INCLUDES FLUSH COOLING SYSTEM, PRESSURE TEST, CHECK HOSES, CAP AND CHECK CONNECTION. INSTALL COOLING SYSTEM CORROSION CONTROL KIT Drain old Transfer case fluid and replace with new fluid REAR DIFFERENTIAL SERVICE This should have been done when the dealership got the vehicle, and it should be GM or BERGER responsibility. I am sure this was an issue to begin with.

POWER TRAIN

Severe transmission shudder, issues accelerating. Torque converter failure is very common with this vehicle, even with following routine scheduled maintenance. There is no engine or MIL light on and symptoms appeared out of nowhere. Failing to be able to safely accelerate can cause accidents, putting lives and property at risk. Looking information up online will show that this is a very common issue with this model year and transmission.

ELECTRICAL SYSTEM

The alternator failed randomly while driving down the road. The vehicle only has 26500 miles. There was no lights on prior to the car stalling. When it failed my whole car started to flash every warning at the screen to me. My car then stopped working and I barely was able to coast into a parking lot. Luckily I was not on the highway and no one was behind me when the car stopped working. The problem was confirmed by the dealer it was the alternator. What sucks though is that the alternator killed the battery. The battery is not covered by warranty so it is $507 to replace a battery.

FUEL SYSTEM, GASOLINE

The contact owns a 2020 Chevrolet Traverse. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who retrieved diagnostic trouble code: P0091 (Fuel Pressure Regulator 1 Control Circuit Low). The contact was informed that the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 68,000.

UNKNOWN OR OTHER

Leaking exhaust noise at start up began around 7/14/25. Noise became louder over the following week. Check engine light came on morning of 7/25. Immediately took it to local GM dealership for inspection. Dealership first said it was a cracked front exhaust pipe but then they also determined that the check engine light was from the catalytic converter. Dealership said both the exhaust pipe and catalytic converter require replacement. Through research, we discovered there are already recalls and special coverage for the same issue on the 2019, 2021 and 2022 year models of this vehicle.

POWER TRAIN

July 2025 the transmission started stuttering. Took to an outside transmission shop, report showed torch converter failure.

ENGINE

July 2025 the transmission started stuttering. Took to an outside transmission shop, report showed torch converter failure.

VEHICLE SPEED CONTROL

Cracked exhaust & bracket back in 2023 causing a loud rattling noise. Now catalytic converter is cracked & gasket leak. Dealer does have notes that it was cracked & they noticed it in 2023 at 46k miles & that converter has now cracked causing engine light to turn on. Car does not speed up properly & GM only wants to cover 30 percent of cost.

FUEL/PROPULSION SYSTEM

Cracked exhaust & bracket back in 2023 causing a loud rattling noise. Now catalytic converter is cracked & gasket leak. Dealer does have notes that it was cracked & they noticed it in 2023 at 46k miles & that converter has now cracked causing engine light to turn on. Car does not speed up properly & GM only wants to cover 30 percent of cost.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving at various speeds, the vehicle made an abnormally loud rattling sound. The contact stated that the failure also occurred upon starting the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the mounting bracket on the front exhaust pipe had separated from the pipe and might develop a hole in the exhaust pipe. The dealer determined that the front exhaust pipe mounting bracket needed to be replaced. The vehicle was not repaired due to the cost. The dealer notified the manufacturer of the failure, but no assistance was provided. The failure mileage was approximately 85,000.

UNKNOWN OR OTHER

Exhaust system developed a hole due to poor weld, Bulletin # PIP5681A. Updated 10-5-20 to include 2020 Traverse. Fumes are getting into the cabin.

POWER TRAIN

The contact owns a 2020 Chevrolet Traverse. The contact stated that while parking the vehicle, the message “Shift to Park” was displayed and the contact was unable to turn off the vehicle. The contact stated that there was no warning light illuminated. Additionally, while driving at various speeds, the vehicle jolted abnormally while accelerating. The local dealer was contacted; however, the vehicle was not diagnosed since the VIN was not under an open recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 107,000.

POWER TRAIN

Vehicle started to show error for shift to park. Not able to shut vehicle off. Vehicle drives fine but when I go to park and vehicle is in park. I go to turn vehicle off and error appears. I called dealership according to them just to look at vehicle its going to cost me $275.. For everything else $1,100. After reading all the complaints on this issue why has manufacture done anything. Obviously this is a well known problem I've always loved my chevy

ELECTRICAL SYSTEM

Vehicle started to show error for shift to park. Not able to shut vehicle off. Vehicle drives fine but when I go to park and vehicle is in park. I go to turn vehicle off and error appears. I called dealership according to them just to look at vehicle its going to cost me $275.. For everything else $1,100. After reading all the complaints on this issue why has manufacture done anything. Obviously this is a well known problem I've always loved my chevy

ENGINE

For the last year or so my car keeps making this really loud noise and it gets worse within hours/days. We have had it in 3 maybe even 4 different shops to have an exhaust fixed. One shop said that a part of it was never secured like it should have been and they fixed it. Every time we have had it fixed it does it again within a couple weeks/month. I did some research and saw a bunch of people are having the same issue with theirs.

ENGINE AND ENGINE COOLING

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving 55 MPH, there was an abnormally loud sound coming from the engine. The check engine warning light was illuminated. The vehicle was taken to an unknown dealer, where it was diagnosed and determined that the catalytic converter was leaking and there was a blockage in the catalytic converter. The contact was also informed that coolant was leaking into the engine. The vehicle was not repaired. The contact stated that upon lifting the hood, there was a rodent nest near the engine cover. The contact related the failure to GM Technical Service Bulletin Number: PIP5681C (Exhaust leak, Lean Codes, Rattle Noise, or Catalytic Converter Failure Codes); however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was notified of the failure and later informed the contact that the case was closed. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 85,600.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving 45 MPH, the vehicle jerked, with an abnormal sound coming from underneath the vehicle. In addition, the contact stated the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was taken to Firestone, where the contact was provided DTC: P0420 (Catalytic converter was fractured and punctured, and a bracket was missing). The vehicle was not repaired. The contact then took the vehicle to the dealer where it was diagnosed and determined that the muffler was punctured and not the catalytic converter. The vehicle was not repaired. The contact then took the vehicle to a Valvoline Center to be diagnosed and DTC: P0420; was retrieved. The vehicle was not repaired. The contact stated that the failure persisted. The contact stated that the vehicle was vibrating abnormally while driven with an abnormal rattling sound coming from underneath the vehicle. Upon further investigation, the contact related the failure to Manufacturer's Recall Numbers: N212356540 and N222385510; however, the vehicle was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 102,000.

ENGINE

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving 45 MPH, the vehicle jerked, with an abnormal sound coming from underneath the vehicle. In addition, the contact stated the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was taken to Firestone, where the contact was provided DTC: P0420 (Catalytic converter was fractured and punctured, and a bracket was missing). The vehicle was not repaired. The contact then took the vehicle to the dealer where it was diagnosed and determined that the muffler was punctured and not the catalytic converter. The vehicle was not repaired. The contact then took the vehicle to a Valvoline Center to be diagnosed and DTC: P0420; was retrieved. The vehicle was not repaired. The contact stated that the failure persisted. The contact stated that the vehicle was vibrating abnormally while driven with an abnormal rattling sound coming from underneath the vehicle. Upon further investigation, the contact related the failure to Manufacturer's Recall Numbers: N212356540 and N222385510; however, the vehicle was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 102,000.

POWER TRAIN

Purchased the vehicle in 2024, the vehicle recently has been notifying “shift to park” when vehicle is on park and ignition is turned off, the notification stays on and alerting, so I am unable to leave the vehicle. I must turn the vehicle on and off again, while moving the shifting lever back and forth from drive to park, this must be done a minimum of four times before it reads the lever in park position. It’s a safety hazard because, the vehicle cannot be left on shift to park and possibly roll away or drive/excel on its own. Vehicle has not been inspected at this time, when purchasing the vehicle in 2024, car fax report did not indicate any issue with power train. Would also like vehicle to be inspected for missing airbags, when driving 65mph or more, you can hear and feel air coming in and out of side front left passenger side of the vehicle.

AIR BAGS

Purchased the vehicle in 2024, the vehicle recently has been notifying “shift to park” when vehicle is on park and ignition is turned off, the notification stays on and alerting, so I am unable to leave the vehicle. I must turn the vehicle on and off again, while moving the shifting lever back and forth from drive to park, this must be done a minimum of four times before it reads the lever in park position. It’s a safety hazard because, the vehicle cannot be left on shift to park and possibly roll away or drive/excel on its own. Vehicle has not been inspected at this time, when purchasing the vehicle in 2024, car fax report did not indicate any issue with power train. Would also like vehicle to be inspected for missing airbags, when driving 65mph or more, you can hear and feel air coming in and out of side front left passenger side of the vehicle.

ENGINE

Engine light came on couple weeks ago. Code is p0420 so I did some research and inspected the exhaust system and found the weld on the support bracket of the exhaust pipes was cracked and wore a hole between the pipe and the bracket. There are others that have the same problem with different year models Chevrolet traverses. Mine is a 2020 Chevrolet traverse LT

UNKNOWN OR OTHER

The car started making a weird sound, thought it was transmission because it only happened when i accelerated. Took it to the dealership abd they wanted to charge me $1000 plus labor. I said no,this is a deffect and it should be covefed by the warranty, the said it wasnt. So i took it to a exhaust shop and they welded it but it cracked again and after a while, it actually tore a little hole into the muffler. So i let it be, maybe make the repair when i had the money to spare. But money being the issue, i went to a muffler shop and had it re soldered, it worked for a while, but now its back. It sucks thay gm put out the recall for specific vehicles knowing that it is a very general thing. Plase help me.

UNKNOWN OR OTHER

It just started showing a error message to SHIFT TO PARK when the car is already in Park. I took it to Register Chevrolet in Brooksville, Fl on May 14, 2025 and they said it needed a whole new shifter that it is defective. This is a major safety issue. I can currently still turn the car off but alarms start going off and was told I may not be able to turn the vehicle off or not lock the doors and could drain the battery. This is absolutely ridiculous there has not been a recall on the safety issue. I have seen that hundreds of others have had the same issue and there has been class action lawsuits. The dealership said it would be around $800 to fix the defective part. Also, I purchased the vehicle in Ohio but moved to Florida in Sep.2021.

ENGINE

The check engine light is illuminated. The Chevy app indicates there is an emission related concern regarding the catalyst system. After inspected, the catalytic converter bracket has a hole or is separating from the exhaust pipes. This causes the vehicle sound very loud during driving. Additionally the vehicle has less power during acceleration. The vehicles performance is poor and the maintenance is accelerated.

FUEL/PROPULSION SYSTEM

Prematurely damaged exhaust system. Identical to Special Coverage Adjustment N212356540 Front Exhaust Pipe but my dealer and GM says that my VIN it’s not coveted

UNKNOWN OR OTHER

The car violently shudders when it attempts to shift from 1st to 2nd gear. This happens every time I drive the car and I'm unsure what's wrong with it. I am unable to accelerate quickly when attempting to drive on the highway or when making a turn and am afraid of being hit because it won't accelerate shift gears as it should. I've taken it to the Chevy dealership twice, and the issue was not addressed as requested so, I researched online and learned that this is a common issue in Chevy Traverses, and it doesn't seem to be fixed, even after dealership intervention. I'm wondering if this is why the dealership is hesitant to address the issue. I am concerned for my family's safety.

POWER TRAIN

[XXX] [XXX] [XXX] [XXX] 4/16/2025 General Motors Customer Assistance Center P.O. Box 33170 Detroit, MI 48232-5170 Subject: Power Steering Issue – 2020 Chevy Traverse (VIN: [XXX] ) To Whom It May Concern, I am writing to express my concern and frustration regarding a serious issue with my 2020 Chevrolet Traverse, VIN [XXX] . On [XXX], while driving, the steering wheel suddenly became very stiff, making it extremely difficult to turn right or left. A warning message appeared on the dashboard that read: "Reduced Steering Assist." I immediately took the vehicle to a certified dealership, where it has now been sitting for over two months. Despite multiple follow-ups, I have not been provided with a clear repair date. When I contacted the manufacturer, I was informed that the required part is currently on backorder, but again, no estimated time of resolution has been given. During this extended wait, I have been forced to rent a car to manage my daily responsibilities, and so far I’ve accumulated close to $1,000 in rental expenses. My case number is: [XXX]. I am requesting the following: 1. A clear update regarding the repair status of my vehicle. 2. Urgent assistance in obtaining the necessary replacement part. 3. Reimbursement or compensation for the rental car expenses caused by the extended delay, which has not been my fault. I trust that General Motors values its customers and the reliability of its vehicles, and I hope for a prompt and fair resolution to this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING

[XXX] [XXX] [XXX] [XXX] 4/16/2025 General Motors Customer Assistance Center P.O. Box 33170 Detroit, MI 48232-5170 Subject: Power Steering Issue – 2020 Chevy Traverse (VIN: [XXX] ) To Whom It May Concern, I am writing to express my concern and frustration regarding a serious issue with my 2020 Chevrolet Traverse, VIN [XXX] . On [XXX], while driving, the steering wheel suddenly became very stiff, making it extremely difficult to turn right or left. A warning message appeared on the dashboard that read: "Reduced Steering Assist." I immediately took the vehicle to a certified dealership, where it has now been sitting for over two months. Despite multiple follow-ups, I have not been provided with a clear repair date. When I contacted the manufacturer, I was informed that the required part is currently on backorder, but again, no estimated time of resolution has been given. During this extended wait, I have been forced to rent a car to manage my daily responsibilities, and so far I’ve accumulated close to $1,000 in rental expenses. My case number is: [XXX]. I am requesting the following: 1. A clear update regarding the repair status of my vehicle. 2. Urgent assistance in obtaining the necessary replacement part. 3. Reimbursement or compensation for the rental car expenses caused by the extended delay, which has not been my fault. I trust that General Motors values its customers and the reliability of its vehicles, and I hope for a prompt and fair resolution to this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

Mounting bracket on front exhaust pipe separated from the exhaust pipe while driving.

UNKNOWN OR OTHER

Broken exhaust pipe brackets

BACK OVER PREVENTION: WARNINGS

Unknown to some, but yesterday Saturday around 12:30 I was inspecting the speaker ports in the rear 3rd row passenger area and I noticed these square tabs that says airbags, also in the very middle of second row the same thing but in the rear I was removing one of the mouldings to see why the speakers were not playing, upon inspection there are no speakers and neither are there any form of side and or rear collision safety devices ( airbags) other than seatbelts. If that truck were in an accident say like a T-Bone, or rear end collision, or side rear impact no one is guaranteed safely making out without adverse affects on their bodies and health. I'm starting to wonder if this traverse was salvaged and or restored. Why are there no safety features in this truck?!!

ENGINE

Unknown to some, but yesterday Saturday around 12:30 I was inspecting the speaker ports in the rear 3rd row passenger area and I noticed these square tabs that says airbags, also in the very middle of second row the same thing but in the rear I was removing one of the mouldings to see why the speakers were not playing, upon inspection there are no speakers and neither are there any form of side and or rear collision safety devices ( airbags) other than seatbelts. If that truck were in an accident say like a T-Bone, or rear end collision, or side rear impact no one is guaranteed safely making out without adverse affects on their bodies and health. I'm starting to wonder if this traverse was salvaged and or restored. Why are there no safety features in this truck?!!

AIR BAGS

Unknown to some, but yesterday Saturday around 12:30 I was inspecting the speaker ports in the rear 3rd row passenger area and I noticed these square tabs that says airbags, also in the very middle of second row the same thing but in the rear I was removing one of the mouldings to see why the speakers were not playing, upon inspection there are no speakers and neither are there any form of side and or rear collision safety devices ( airbags) other than seatbelts. If that truck were in an accident say like a T-Bone, or rear end collision, or side rear impact no one is guaranteed safely making out without adverse affects on their bodies and health. I'm starting to wonder if this traverse was salvaged and or restored. Why are there no safety features in this truck?!!

UNKNOWN OR OTHER

Front exhaust pipe broken causing check engine light and vehicle to sound rough. It is an emissions issue. This has been confirmed with a dealership. The issue started around middle of March 2025 when check engine light came on.

ENGINE

Front exhaust pipe broken causing check engine light and vehicle to sound rough. It is an emissions issue. This has been confirmed with a dealership. The issue started around middle of March 2025 when check engine light came on.

POWER TRAIN

TRANSMISSION CHATTER AND SLIPPING. I WAS NOT ABLE TO SECURE AN APPOINTMENT BEFORE MY WARRANTY EXPIRED. ATTEMPTED TO CALL GM FOR ASSISTANCE AND THEY WANTED TO CHARGE ME FOR DIAGNOSIS AND COULD NOT ASURE ME OF ANY ASSISTANCE AND SINCE I HAD A DIFFERENT ISSUE WITH MY CHECK ENGINE LIGHT DUE TO FAULTY CATALYTIC CONVERTER THAT WAS UNDER WARRANTY AND I WAS CHARGED AND DID NOT GET MY MONEY BACK, I WENT A DIFFERENT ROUTE. THE DEALER ACTUALLY WANTED TO CHARGE ME TO REPLACE THE CONVERTER. i HAD MY TRANSMISSION REPAIRED AT AAMCO $6000.00. KNOWN ISSUE WITH THESE TRANSMISSIONS BY MANUFACTURER.

FUEL SYSTEM, GASOLINE

The contact owns a 2020 Chevrolet Traverse. The contact stated that while driving at various speeds, the vehicle jerked abnormally and stalled. The check engine warning light was illuminated. Additionally, the message "Shift into Neutral, and Start Vehicle" was displayed on the instrument panel. The vehicle was towed to a local dealer; where the fuel injectors were cleaned; however, the failure persisted. The contact stated that while attempting to use the Push-To-Start feature, the vehicle hesitated to start. The vehicle was taken back to the same local dealer where it was diagnosed and determined that the fuel injectors needed to be replaced. The vehicle was taken to a local Pep Boys for a second opinion, where it was diagnosed, and several unknown error codes were retrieved. The vehicle was not repaired. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 20V639000 (Fuel System, Gasoline); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

ENGINE

Had noticed a rattle every time when I start the vehicle.I got under and had located a broken front exhaust hanger. A few week later I noticed a different sound coming from under the vehicle. I go back to the under side and locked the exhaust flex pipe has now ripped at the front exhaust bracket. Mine being a 2020 isn't coved by the 2019 or the 2021 special coverage. Chevrolet needs to fix this issue.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving 25 MPH, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the catalytic convertor had failed needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, and the contact was informed that there were no recalls associated with the VIN. The approximate failure mileage was 58,000.

ENGINE

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving 25 MPH, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the catalytic convertor had failed needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, and the contact was informed that there were no recalls associated with the VIN. The approximate failure mileage was 58,000.

ENGINE

Car started making a “pinging” noise and gradually got worse over time. Finally today, it’s really bad so I crawl under and look to notice not one but TWO holes in the exhaust pipe. I noticed several recalls on other models with the same issue but not this year.

POWER TRAIN

The Transmission went out at 128k miles, a BRAND NEW GM transmission was replaced at a cost of $6,800 to me as it was not under warranty. Less than 2 months and 2k miles later, the new transmission went out. I just got my car back yesterday with yet another GM transmission and once again it is jerking, so I’m sure another faulty transmission from General Motors

ENGINE

The exahust leaks and has noise just like all the other Traverse that have the recall, this also needs the same recall

ENGINE

Vehicle developed a large hole in the exhaust pipe going to front converter. Identical failure which is noted in an April 30,2023 bulletin which specifically narrowed defects down to the 2019 Chevy Traverse. ( Special Coverage# N212356540). Dealership did repair defective exhaust section although my warranty coverage refused to cover defect. Significant safety hazard to state the least anytime a section of any exhaust component begins to deteriorate and come apart on welded sections of pipe. My vehicle has approximately 59000 miles of use and I simply cannot understand why GM refuses to reimburse my out of pocket costs related to this defect.

ENGINE

A few weeks ago, I started noticing a purring, kind of sound coming from my vehicle when I would turn it on. I took it in to Chevy and they said there was a leak or a hole in the exhaust that they needed to be replaced for over $1600 and that wasn’t covered through warranty that it was normal wear and tear. My vehicle has 53,000 miles. They said that it’s common for a vehicle of over five years to have these kinds of issues. And that it wasn’t covered through my warranty. Which expires in April

ELECTRICAL SYSTEM:STARTER ASSEMBLY

The contact owns a 2020 Chevrolet Traverse. The contact stated that while his wife was driving at an undisclosed speed, the vehicle inadvertently lost motive power in the middle of the roadway. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the starter. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 105,000. The VIN was not available.

POWER TRAIN

The car displayed a message on the board advising the following: "Steering assist is reduced, drive with care" right after the message popped out my steering wheel locked and I couldn't turn, and move the car to a safe place was very hard, almost had a crash. I was able to park, and turned the engine off. When turned back on the message disappeared and turned on again. Next day, no message, the car was running fine and after 8 miles of drive did the same and it required towing.

STEERING

The car displayed a message on the board advising the following: "Steering assist is reduced, drive with care" right after the message popped out my steering wheel locked and I couldn't turn, and move the car to a safe place was very hard, almost had a crash. I was able to park, and turned the engine off. When turned back on the message disappeared and turned on again. Next day, no message, the car was running fine and after 8 miles of drive did the same and it required towing.

POWER TRAIN

See GMBulletin #19-NA-206 I am getting the "shift to park" warning which makes it difficult to turn off/safely park my vehicle. I know the NHTSA is aware of this as well as numerous lawsuits in progress against GM for significant safety issues. Will this go to recall status soon?

ENGINE

Noise from under hood, took vehicle to dealer. Dealers inspection identified cracked exhaust PIPES before catalytic converter. Exhaust fumes get into car cabin causing health concerns not to mention a life threatening situation for the occupants. Vehicle was under 70k miles. Seems to be an emission issue/faulty workmanship with failure in QC in weld inspection causing harm to owners

POWER TRAIN

1 year after buying my car two of my seat belts stop working one was the back driver side the clip doesn't stay in sometimes and then the middle seat and middle belt got stick in the seat and I wasn't able to pull it out to use it. I bought my car in Dec of 2020 and in October of 2024 my whole transmission went out which I never had any problems before not even a warning sign, I took it to a mechanic since it was only driving in first gear and they said it might be from the inside of the transmission when it was made they solenoids are bad.

SEAT BELTS

1 year after buying my car two of my seat belts stop working one was the back driver side the clip doesn't stay in sometimes and then the middle seat and middle belt got stick in the seat and I wasn't able to pull it out to use it. I bought my car in Dec of 2020 and in October of 2024 my whole transmission went out which I never had any problems before not even a warning sign, I took it to a mechanic since it was only driving in first gear and they said it might be from the inside of the transmission when it was made they solenoids are bad.

UNKNOWN OR OTHER

The vehicle start stop feature is malfunctioning (I have a video) .When stopping or coming to a stop after driving through the city, at random times sometimes back to back when being stopped it goes down to 1 rpm then the auto stop feature kicks on and when it's time to depress the break to move again it malfunctions then sounds like a circular saw slicing through metal. At times you have put car in park hit engine ignition button to make it stop then wait a few seconds then start it back up. There's also a smell of strong fuel vapors coming in through the vents including defrost. Navigation stopped working ( turn by turn ) feature, also sounds as if the front end is knocking around going over speed bumps, the front right wheel has an odd rub sound that increases when accelerating. The gas also with a full tank depletes nearly within a day, and ait being a V6 should not guzzle $50 in fuel of 87 grade petrol. This thing is a rolling safety hazard. I have a wife and 6 children I transport daily. If something happens and we are injured I will sue your entire company General Motors.

FUEL/PROPULSION SYSTEM

The vehicle start stop feature is malfunctioning (I have a video) .When stopping or coming to a stop after driving through the city, at random times sometimes back to back when being stopped it goes down to 1 rpm then the auto stop feature kicks on and when it's time to depress the break to move again it malfunctions then sounds like a circular saw slicing through metal. At times you have put car in park hit engine ignition button to make it stop then wait a few seconds then start it back up. There's also a smell of strong fuel vapors coming in through the vents including defrost. Navigation stopped working ( turn by turn ) feature, also sounds as if the front end is knocking around going over speed bumps, the front right wheel has an odd rub sound that increases when accelerating. The gas also with a full tank depletes nearly within a day, and ait being a V6 should not guzzle $50 in fuel of 87 grade petrol. This thing is a rolling safety hazard. I have a wife and 6 children I transport daily. If something happens and we are injured I will sue your entire company General Motors.

ENGINE

The vehicle start stop feature is malfunctioning (I have a video) .When stopping or coming to a stop after driving through the city, at random times sometimes back to back when being stopped it goes down to 1 rpm then the auto stop feature kicks on and when it's time to depress the break to move again it malfunctions then sounds like a circular saw slicing through metal. At times you have put car in park hit engine ignition button to make it stop then wait a few seconds then start it back up. There's also a smell of strong fuel vapors coming in through the vents including defrost. Navigation stopped working ( turn by turn ) feature, also sounds as if the front end is knocking around going over speed bumps, the front right wheel has an odd rub sound that increases when accelerating. The gas also with a full tank depletes nearly within a day, and ait being a V6 should not guzzle $50 in fuel of 87 grade petrol. This thing is a rolling safety hazard. I have a wife and 6 children I transport daily. If something happens and we are injured I will sue your entire company General Motors.

ENGINE

Front Flex pipe broken after failed weld. Issue is known by GM/Chevorlet and has been corrected on all years Except for the 2020 model year. Not sure why 2020 models were left out because they have the same condition.

UNKNOWN OR OTHER

My backup camera only works about 3% of the time. If the temp are too cold or too hot then the screen goes black with a red triangle. Frequently, this occurs when I'm in the process of backing up and I lose all visibility. I almost struck a pedestrian this morning. I've already had the cable repaired at the dealership once but it immediately began not working about 2 weeks later. I had taken it back to the dealership but they were unable to repair because the representative could not reproduce the error when he attempted to back up. I have videos of what is occurring.

SUSPENSION

Purchased the 2020 traverse on [XXX] from Basswood in Ft. Payne Alabama. Under the guise of the salesman I was assured that the vehicle was in great shape, with no issues at all, and a very clean Carfax. Well I'm new to purchasing a car via financing with a co-signer in which he was assured the vehicle was in great shape. Well unbeknownst to us my household the car was nothing of the sort. Within a few days the Start/Stop malfunctioned to the point it would not restart 98% of the time without sounding like a Demo Saw, it's a dangerous problem and there's times we smelled fuel once we were able to restart the vehicle. The front right wheel assembly looks as if it were on fire and if that's brake dust and it has a grinding whomp whomp sound when in motion,that's really not good no wonder it's hard to stop at times. The front end sounds like drums when going over bumps, speed bumps, road imperfections etc.. on morning start-up there's an absurd amount of exhaust coming into the cabin area, the codes [P3055 and P3056] are registered from the computer of vehicle. Now the smell of fuel is blowing through all vents whenever the defrost is running or all vents are used front and rear, with the truck in motion. It was so bad today that my entire family had to pull over to a gas station and get fresh air our eyes were burning and my [XXX] son nose started to bleed., so that's two parents and 6 children scrambling for safety. This is our only reliable vehicle other than an old 99 suburban that is hardly even road worthy anymore. I spoke with several people that have purchased vehicles and all agreed that the salesman and mostly the sales managers knew that the vehicle came from an auction and was never serviced nor inspected at the basswood dealership, which equates to them actively concealing major effects and problems with the vehicle in question. Just to make a one time commission on a fraudulent deal! They didn't provide any inspection papers to me! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA

FUEL/PROPULSION SYSTEM

Purchased the 2020 traverse on [XXX] from Basswood in Ft. Payne Alabama. Under the guise of the salesman I was assured that the vehicle was in great shape, with no issues at all, and a very clean Carfax. Well I'm new to purchasing a car via financing with a co-signer in which he was assured the vehicle was in great shape. Well unbeknownst to us my household the car was nothing of the sort. Within a few days the Start/Stop malfunctioned to the point it would not restart 98% of the time without sounding like a Demo Saw, it's a dangerous problem and there's times we smelled fuel once we were able to restart the vehicle. The front right wheel assembly looks as if it were on fire and if that's brake dust and it has a grinding whomp whomp sound when in motion,that's really not good no wonder it's hard to stop at times. The front end sounds like drums when going over bumps, speed bumps, road imperfections etc.. on morning start-up there's an absurd amount of exhaust coming into the cabin area, the codes [P3055 and P3056] are registered from the computer of vehicle. Now the smell of fuel is blowing through all vents whenever the defrost is running or all vents are used front and rear, with the truck in motion. It was so bad today that my entire family had to pull over to a gas station and get fresh air our eyes were burning and my [XXX] son nose started to bleed., so that's two parents and 6 children scrambling for safety. This is our only reliable vehicle other than an old 99 suburban that is hardly even road worthy anymore. I spoke with several people that have purchased vehicles and all agreed that the salesman and mostly the sales managers knew that the vehicle came from an auction and was never serviced nor inspected at the basswood dealership, which equates to them actively concealing major effects and problems with the vehicle in question. Just to make a one time commission on a fraudulent deal! They didn't provide any inspection papers to me! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA