2016 CHEVROLET TAHOE

SEAT BELTS:FRONT

General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.

Risk: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.

ELECTRONIC STABILITY CONTROL (ESC)

General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.

Risk: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.

Risk: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.

SEAT BELTS:FRONT

General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 1500 and Tahoe Police Pursuit and Special-Service vehicles. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.

Risk: If the pretensioner cable becomes fatigued or breaks, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.

AIR BAGS:FRONTAL

General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

AIR BAGS:FRONTAL

General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

POWER TRAIN

Gear slip and shutter when accelerating loss power from taking off

UNKNOWN OR OTHER

Component Failure: AC condenser assembly failed due to thermal cycling cracks in combination transmission fluid/oil cooler design - exact failure documented in GM TSB 17336-05. TSB states "thermal cycling creates a crack that may allow refrigerant to escape." Safety Risk: AC system failure after sun exposure creates dangerous interior temperatures lasting 30-45 minutes with family including two teenagers in 95°F+ NC summer heat. Risk of heat exhaustion/stroke during highway travel where immediate stopping impossible. Dealer Confirmation: Hendrick Chevrolet diagnosed refrigerant leak from upper left condenser on 7/22/25 (Invoice CTCS913252, $1,904.60). Official work order documents identical symptoms and repair operation covered by GM TSB 17336-05 Special Coverage. Manufacturer Knowledge: GM issued TSB 17336-05 acknowledging their combi-cooler design cannot withstand normal thermal cycling, affecting 908,000+ vehicles. GM provides Customer Service Satisfaction Campaign 17336-01 free repairs for this exact defect but denied my reimbursement (Case #72260590) solely due to mileage, claiming manufacturing design defect becomes customer responsibility after 60k miles. Symptoms: Problem began summer 2024 - AC functions normally when parked in shade but requires 30-45 minutes to cool after direct sun exposure, exactly matching TSB heat-soak failure pattern. No warning lights as system retained sufficient refrigerant until complete thermal stress failure.

UNKNOWN OR OTHER

The sunroof shattered when nothing hit it driving down the road.

UNKNOWN OR OTHER

The stabilitrak notification comes on constantly. While we are driving/reversing and turn our steering wheel the whole car will shut down and the steering wheel jerks. It's happened multiple times. It takes forever for the car to turn back on.This is super dangerous and cause myself and my children to end up getting hit by another vehicle while on the road.

STEERING

The stabilitrak notification comes on constantly. While we are driving/reversing and turn our steering wheel the whole car will shut down and the steering wheel jerks. It's happened multiple times. It takes forever for the car to turn back on.This is super dangerous and cause myself and my children to end up getting hit by another vehicle while on the road.

ELECTRICAL SYSTEM

The stabilitrak notification comes on constantly. While we are driving/reversing and turn our steering wheel the whole car will shut down and the steering wheel jerks. It's happened multiple times. It takes forever for the car to turn back on.This is super dangerous and cause myself and my children to end up getting hit by another vehicle while on the road.

POWER TRAIN

The vehicle shudders and shakes going down the road causing a safety hazard when failing. The transmission fluid has been changed multiple times and yet the transmission remains unstable with no errors or check lights appearing. When taken to the repair shop it seems there is a large number of failures for this transmission type.

SERVICE BRAKES

There are times that the brake assist will stop working. The bake assist light has started coming on once in a while. I looked up the vin and it said all recalls were repaired. I have a concern that the vaccume brake issue was not properly taken care of at whatever dealership that claimed to fix the issue.

UNKNOWN OR OTHER

Air conditioning could cause a safety problem during hot days, forcing the driver to drive with all windows down and still remain very hot and sweaty while driving. The A/C system in this vehicle is so poorly designed that I've spent $6,000 in 8 years of ownership just to keep the A/C running. The primary problem is that is has a separate rear HVAC zone, which requires both high & low side freon lines to run under the length of the vehicle to a rear condenser. These lines are not shielded in any way from being hit by road debris. I'm replacing a leaking rear A/C for the third time at a cost of $1800. These lines should be shielded so they are not getting pelted by rocks and other debris. It's a very bad design that exposes a potential safety issue. When these lines break, it also dumps all of the freon into the atmosphere.

ENGINE

I was driving on the freeway when I lost power and the engine started to vibrate. Had to have it towed back to the dealer. They stated it was a bad lifter in cylinder six. It will cost 8K+ to repair. I have had the car less than a year and less than 90k in mileage.

POWER TRAIN

Shuttering started with transmission which ultimately lead to the transmission failing at 140,900 miles. Costly repair for a vehicle that was serviced regularly.

POWER TRAIN

Engine failure - lifters and cam shaft . Also, transmission had previously failed and had to be replaced as well as air conditioner condenser (pin hole leak).

ENGINE

Engine failure - lifters and cam shaft . Also, transmission had previously failed and had to be replaced as well as air conditioner condenser (pin hole leak).

ENGINE

The contact owns a 2016 Chevrolet Tahoe. The contact stated while driving uphill, the vehicle stalled and started rolling backwards. The contact allowed the vehicle to roll back to a stop sign. The contact depressed the brake pedal and shifted to park(P). The contact stated that the vehicle was restarted after several attempts. The vehicle was taken to the dealer, where it was diagnosed that the oil pump, fuel injectors, and the spark plugs had failed. The contact's husband stated that while driving 65 MPH, the vehicle jerked, and the instrument gauges decreased to zero(0) and then increased. The check engine warning light was illuminated. The vehicle was taken to the dealer, where the transmission was replaced; however, the failure recurred. The vehicle was taken to dealer, where it was diagnosed that the camshaft and the engine lifters had failed. The dealer determined that the engine needed to be replaced. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 85,000.

ENGINE

My engine is blown at only 80,000 miles. Dealer said bad lifter. I was on the freeway and with no warning I lost power and black smoke. No warning. And now $16,000 to repair. Only 80,000 miles. At 100,000 you change spark plugs. I cannot afford to fix it. I spent 6 years saving up for just the down and now it’s gone. And I could have been very hurt on the freeway and hurt other people. I hope someone can help me.

Chest Clip, Buckle, Harness

Summary: The straps on this car seat came loose with a firm pull with my baby already buckled in. Description: On Saturday April 5th, we place our baby in the Britax One4Life ClickTight All-In-One Car Seat. My husband had our baby fully buckled in with the straps tightened when for some reason (thank goodness he did), he gave the straps a pretty firm pull (not holding the strap release lever down) and they loosened up. We were very shocked that this could happen. I also tested it as well and had the same result. This concerning because with a forceful pull on the car seat straps, they came loose. If we had been in some sort of collision and were unaware of this issue, the force of an accident certainly would have loosened the straps which could have had a lethal outcome ever for a minor collision. Because we weren't sure why this was happening with this car seat. We ordered a new car seat from a different manufacturer due to this safety concern. On Monday April 7th I called Britax twice to see if I could get an answer as to why this may be happening. I could not get a live person so I left a voicemail. I also scheduled an appointment for a video call on Wednesday the 9th in an attempt to contact someone. I was able to speak with someone on Wednesday the 9th. The person I spoke with asked me to check if there was any debris under the button to release the strap. with her on the call, I shook the car seat upside down, and vacuumed under the release button. Once that was done, the straps did function again as expected, not loosening with a firm pull. The representative did mention that she had seen this issue before with something even as minor as sand getting stuck under the button. If you have kids, you know how impossible it is to keep car seats completely clean. The seats get dirty from kids being at parks, daycare, in their own back yard, eating snacks, etc.. I believe this is a design flaw of this car seat and it needs to be investigated for safety.

UNKNOWN OR OTHER

-MALFUNCTION---WHILE DRIVING, WHEN I PRESS THE BRAKES TO COME TO A STOP, IT SEEMS AS IF THE BRAKES CATCH BUT THEN RELEASES AND THEN CATCHES AGAIN. AS IT RELEASES, IT CONTINUES TO ROLL. VEHICLE IS AVAILABE UPON REQUEST. -SAFETY RISK--- BECAUSE THE BRAKE RELEASES AND/OR EVENTUALLY NOT CATCH AT ALL, THIS IS UNSAFE BECAUSE I CAN ROLL INTO TRAFFIC -REPRODUCED AND/OR CONFIRMED--- I HAVE BROUGHT MY VEHICLE TO A SERVICE CENTER TO REPAIR A RECALL AND WAS TOLD TO THAT THE ISSUE SHOULD BE RESOLVED ONCE THE RECALL WAS COMPLETE. THE ISSUE WAS TEMPORARILY RESOLVED FOR APPROXIMATELY ONE MONTH OR SO, AND NOW IT IS BACK TO BREAKING AND RELEASING. -ONE CAN ONLY ASSUME THAT THE VEHICLE AND/OR ITS COMPONENTS HAVE BEEN INSPECTED GIVEN THAT I BROUGHT THE VEHICLE TO THE SERVICE CENTER, STATED THE ISSUE, AND WAS TOLD THAT THE ISSUE SHOULD BE RESOLVED AFTER IT HAS BEEN SERVICED.  -THERE WERE NO WARNING LAMPS, MESSAGES, OR OTHER SYMPTOMS OF THE PROBLEM PRIOR TO THIS ISSUE.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

-MALFUNCTION---WHILE DRIVING, WHEN I PRESS THE BRAKES TO COME TO A STOP, IT SEEMS AS IF THE BRAKES CATCH BUT THEN RELEASES AND THEN CATCHES AGAIN. AS IT RELEASES, IT CONTINUES TO ROLL. VEHICLE IS AVAILABE UPON REQUEST. -SAFETY RISK--- BECAUSE THE BRAKE RELEASES AND/OR EVENTUALLY NOT CATCH AT ALL, THIS IS UNSAFE BECAUSE I CAN ROLL INTO TRAFFIC -REPRODUCED AND/OR CONFIRMED--- I HAVE BROUGHT MY VEHICLE TO A SERVICE CENTER TO REPAIR A RECALL AND WAS TOLD TO THAT THE ISSUE SHOULD BE RESOLVED ONCE THE RECALL WAS COMPLETE. THE ISSUE WAS TEMPORARILY RESOLVED FOR APPROXIMATELY ONE MONTH OR SO, AND NOW IT IS BACK TO BREAKING AND RELEASING. -ONE CAN ONLY ASSUME THAT THE VEHICLE AND/OR ITS COMPONENTS HAVE BEEN INSPECTED GIVEN THAT I BROUGHT THE VEHICLE TO THE SERVICE CENTER, STATED THE ISSUE, AND WAS TOLD THAT THE ISSUE SHOULD BE RESOLVED AFTER IT HAS BEEN SERVICED.  -THERE WERE NO WARNING LAMPS, MESSAGES, OR OTHER SYMPTOMS OF THE PROBLEM PRIOR TO THIS ISSUE.

SERVICE BRAKES

-MALFUNCTION---WHILE DRIVING, WHEN I PRESS THE BRAKES TO COME TO A STOP, IT SEEMS AS IF THE BRAKES CATCH BUT THEN RELEASES AND THEN CATCHES AGAIN. AS IT RELEASES, IT CONTINUES TO ROLL. VEHICLE IS AVAILABE UPON REQUEST. -SAFETY RISK--- BECAUSE THE BRAKE RELEASES AND/OR EVENTUALLY NOT CATCH AT ALL, THIS IS UNSAFE BECAUSE I CAN ROLL INTO TRAFFIC -REPRODUCED AND/OR CONFIRMED--- I HAVE BROUGHT MY VEHICLE TO A SERVICE CENTER TO REPAIR A RECALL AND WAS TOLD TO THAT THE ISSUE SHOULD BE RESOLVED ONCE THE RECALL WAS COMPLETE. THE ISSUE WAS TEMPORARILY RESOLVED FOR APPROXIMATELY ONE MONTH OR SO, AND NOW IT IS BACK TO BREAKING AND RELEASING. -ONE CAN ONLY ASSUME THAT THE VEHICLE AND/OR ITS COMPONENTS HAVE BEEN INSPECTED GIVEN THAT I BROUGHT THE VEHICLE TO THE SERVICE CENTER, STATED THE ISSUE, AND WAS TOLD THAT THE ISSUE SHOULD BE RESOLVED AFTER IT HAS BEEN SERVICED.  -THERE WERE NO WARNING LAMPS, MESSAGES, OR OTHER SYMPTOMS OF THE PROBLEM PRIOR TO THIS ISSUE.

SERVICE BRAKES

Brake vacuum pump

FUEL/PROPULSION SYSTEM

Fuel pump went bad and needed to be replaced.

ENGINE

Lifters were stuck and ruined the cam shaft. All lifters and cam shaft replaced

POWER TRAIN

Transmission fell to metal shavings being found in the pan and oil filter when checked

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

The contact owns a 2016 Chevrolet Tahoe. The contact stated that while driving approximately 50-55 MPH, the vehicle started to shudder. The contact stated that the odometer was moving erratically. The contact stated that the engine overheated quickly. There were no warning lights illuminated. The contact was stranded on the side of the road. The vehicle was towed to the local dealer, where it was diagnosed that the torque converter was faulty and there were metal shavings inside the engine. The vehicle was repaired, but the failure recurred. While driving at 35-45 MPH, the vehicle was shuddering and overheated. The vehicle was towed back to the local dealer, where it was diagnosed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 112,000.

POWER TRAIN

The contact owns a 2016 Chevrolet Tahoe. The contact stated that while driving approximately 50-55 MPH, the vehicle started to shudder. The contact stated that the odometer was moving erratically. The contact stated that the engine overheated quickly. There were no warning lights illuminated. The contact was stranded on the side of the road. The vehicle was towed to the local dealer, where it was diagnosed that the torque converter was faulty and there were metal shavings inside the engine. The vehicle was repaired, but the failure recurred. While driving at 35-45 MPH, the vehicle was shuddering and overheated. The vehicle was towed back to the local dealer, where it was diagnosed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 112,000.

ENGINE

The contact owns a 2016 Chevrolet Tahoe. The contact stated that while driving approximately 50-55 MPH, the vehicle started to shudder. The contact stated that the odometer was moving erratically. The contact stated that the engine overheated quickly. There were no warning lights illuminated. The contact was stranded on the side of the road. The vehicle was towed to the local dealer, where it was diagnosed that the torque converter was faulty and there were metal shavings inside the engine. The vehicle was repaired, but the failure recurred. While driving at 35-45 MPH, the vehicle was shuddering and overheated. The vehicle was towed back to the local dealer, where it was diagnosed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 112,000.