2015 CHEVROLET SILVERADO 3500

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

Risk: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.

Risk: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.

Risk: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.

FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK

General Motors LLC (GM) is recalling certain 2011-2015 Chevrolet Silverado 3500 and GMC Sierra 3500 trucks equipped with dual fuel tanks. The low fuel level sensor for the front tank may stick causing the rear tank to overfill the front tank.

Risk: If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.

AIR BAGS:FRONTAL

General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

AIR BAGS:FRONTAL

General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

ENGINE

The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while driving 65 MPH, the message "Fuel Filter Needed to be Replaced" followed by the "Engine Power Reduced" were displayed on the instrument panel. The contact then stated that fuel started leaking from the vehicle and the vehicle stalled. The contact was left stranded in the middle of the road; a tow truck was called, and the vehicle was towed to an independent diesel mechanic. The mechanic performed a diagnostic test, and the contact was informed that the fuel pump had disintegrated which caused debris from the fuel pump to leak into the fuel system. The contact was provided an estimate to replace the fuel pump, fuel pump filter, fuel pump housing, and the fuel injectors. The manufacturer was notified of the failure and referred the contact to the NTHSA Hotline to file a complaint. The vehicle had yet to be repaired. The failure mileage was approximately 270,000.

FUEL SYSTEM, DIESEL

The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while driving 65 MPH, the message "Fuel Filter Needed to be Replaced" followed by the "Engine Power Reduced" were displayed on the instrument panel. The contact then stated that fuel started leaking from the vehicle and the vehicle stalled. The contact was left stranded in the middle of the road; a tow truck was called, and the vehicle was towed to an independent diesel mechanic. The mechanic performed a diagnostic test, and the contact was informed that the fuel pump had disintegrated which caused debris from the fuel pump to leak into the fuel system. The contact was provided an estimate to replace the fuel pump, fuel pump filter, fuel pump housing, and the fuel injectors. The manufacturer was notified of the failure and referred the contact to the NTHSA Hotline to file a complaint. The vehicle had yet to be repaired. The failure mileage was approximately 270,000.

VISIBILITY/WIPER

A rear defrost system malfunctioned and was smoking in the interior of the vehicle followed by the rear glass shattering. The electrical malfunction could have easily started a fire and glass flying around the cab a highway speeds could definitely be hazard. I called the dealership and they were unconcerned and gave me a quote to replace it. the dealer or the aftermarket glass replacement company have not heard of it happening. I did find a recall in Canada. Strangely enough mine was done in Canada and it happened again.

VISIBILITY/WIPER

The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while the vehicle was parked, the contact noticed that the instrument panel was inoperable. The contact stated that the instrument panel failed to function properly while attempting to activate the windshield wiper. The vehicle was taken to the dealer, where it was diagnosed that the fuse block had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 5,100.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while the vehicle was parked, the contact noticed that the instrument panel was inoperable. The contact stated that the instrument panel failed to function properly while attempting to activate the windshield wiper. The vehicle was taken to the dealer, where it was diagnosed that the fuse block had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 5,100.