2022 CHEVROLET SILVERADO 2500

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE

General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.

Risk: Rear wheel lock-up can increase the risk of a crash.

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

ENGINE AND ENGINE COOLING

See attached document for complaint.

SERVICE BRAKES

While driving on the freeway in a construction zone, I smelled a burning oil smell. I considered the possibility it was in relation to road repairs being done (roads being repaved, ie tar resurfacing). I was cut off by another vehicle and depressed my brakes and I saw a poof of smoke over the front passenger area near tire. I noticed all of my gauges were in the normal ranges (temperature, battery voltage, etc.) In less than a minute my truck went into limp mode and advised it had a DEF system issue and it would be limited to a set MPH and a set number of miles. Check engine light came on and another driver alerted me that the underneath of my vehicle was on fire. I pulled over to the side of the highway and my truck became engulfed in flames in. Truck is under factory warranty, unmodified, never been in an accident and has had all recommended services performed at local dealership. There was a significant amount of traffic and luckily I did not collide with anyone or set neighboring dry grass field on fire. Fire department responded and extinguished the fire, but it is a total loss. Insurance company has been notified, and vehicle will be available for inspection by appropriate agencies. While local law enforcement did respond, they did not take a report because I didn't hit anything, and the only property damage was my own. (There is documentation of the event, but just dispatch notes.) Prior to the situation above the truck had been at operating temperature for at least 20 minutes and I had traveled for about 20 miles on the highway. The total distance traveled from when I smelled the burning smell was maybe 1.5 miles.

ENGINE

While driving on the freeway in a construction zone, I smelled a burning oil smell. I considered the possibility it was in relation to road repairs being done (roads being repaved, ie tar resurfacing). I was cut off by another vehicle and depressed my brakes and I saw a poof of smoke over the front passenger area near tire. I noticed all of my gauges were in the normal ranges (temperature, battery voltage, etc.) In less than a minute my truck went into limp mode and advised it had a DEF system issue and it would be limited to a set MPH and a set number of miles. Check engine light came on and another driver alerted me that the underneath of my vehicle was on fire. I pulled over to the side of the highway and my truck became engulfed in flames in. Truck is under factory warranty, unmodified, never been in an accident and has had all recommended services performed at local dealership. There was a significant amount of traffic and luckily I did not collide with anyone or set neighboring dry grass field on fire. Fire department responded and extinguished the fire, but it is a total loss. Insurance company has been notified, and vehicle will be available for inspection by appropriate agencies. While local law enforcement did respond, they did not take a report because I didn't hit anything, and the only property damage was my own. (There is documentation of the event, but just dispatch notes.) Prior to the situation above the truck had been at operating temperature for at least 20 minutes and I had traveled for about 20 miles on the highway. The total distance traveled from when I smelled the burning smell was maybe 1.5 miles.

FUEL/PROPULSION SYSTEM

While driving on the freeway in a construction zone, I smelled a burning oil smell. I considered the possibility it was in relation to road repairs being done (roads being repaved, ie tar resurfacing). I was cut off by another vehicle and depressed my brakes and I saw a poof of smoke over the front passenger area near tire. I noticed all of my gauges were in the normal ranges (temperature, battery voltage, etc.) In less than a minute my truck went into limp mode and advised it had a DEF system issue and it would be limited to a set MPH and a set number of miles. Check engine light came on and another driver alerted me that the underneath of my vehicle was on fire. I pulled over to the side of the highway and my truck became engulfed in flames in. Truck is under factory warranty, unmodified, never been in an accident and has had all recommended services performed at local dealership. There was a significant amount of traffic and luckily I did not collide with anyone or set neighboring dry grass field on fire. Fire department responded and extinguished the fire, but it is a total loss. Insurance company has been notified, and vehicle will be available for inspection by appropriate agencies. While local law enforcement did respond, they did not take a report because I didn't hit anything, and the only property damage was my own. (There is documentation of the event, but just dispatch notes.) Prior to the situation above the truck had been at operating temperature for at least 20 minutes and I had traveled for about 20 miles on the highway. The total distance traveled from when I smelled the burning smell was maybe 1.5 miles.

UNKNOWN OR OTHER

Tailgate going up and down on its own when in park. Now it will not open at all. There is a recall #N232426400 but dealership says it is not listed for my truck.

ELECTRICAL SYSTEM

Tailgate going up and down on its own when in park. Now it will not open at all. There is a recall #N232426400 but dealership says it is not listed for my truck.

ELECTRICAL SYSTEM

See recall N232426400 or customer satisfaction recall N232426401. My tailgate opens on its own and the button has quit working manually. My truck is apparently not a part of the recall?

ELECTRICAL SYSTEM

After driving truck. Attempt to turn KEYED ignition off, they key will not move the the off position for removal. Must wait several minutes for the key lock mechanism to release then remove the key.

UNKNOWN OR OTHER

Vehicle was brought to Lone Star Chevrolet in Houston on 6/16/2025 because Tailgate would not open with the button and only would open with the fob. They stated no parts to fix and did not advise of the severity of risk from the recall when picked truck up. Saturday afternoon [XXX] while leaving a parking lot and driving on the feeder road the tailgate opened resulting in the large ice chest that was full of water bottles ice and and storage containers with food to fall on road along with battery power fan and several extra batteries. These items unexpectedly sliding down the feeder resulted in several cars making defensive maneuvers nearly resulting in several crashes and the ice chest bumping 1 vehicle. All lanes of traffic stopped and several people helped to pick up the debris off the road. No information from people who stopped was collected, and no report from driver of truck that hit cooler. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

Service trailer brake system fault resulting in battery drain causing failure to strart

SERVICE BRAKES

While towing our camper, the trailer brakes constantly turn off and on. The camper dealer already checked over the camper wiring, and hooked it to Ford and Ram tow vehicles and could not replicate the problem. The problem is obviously with my Silverado. For the additional details below; - The approximate date is Anytime and Everytime we tow the camper. - There could be a crash anytime the trailer brakes turn off. - A crash due to no trailer brakes Could cause a fire. - An injury or fatality would be highly likely if the trailer brakes "disconnect" at the wrong time causing a crash, with or without fire. - There would most certainly be a police report if any of the above happened.

ELECTRICAL SYSTEM

While towing our camper, the trailer brakes constantly turn off and on. The camper dealer already checked over the camper wiring, and hooked it to Ford and Ram tow vehicles and could not replicate the problem. The problem is obviously with my Silverado. For the additional details below; - The approximate date is Anytime and Everytime we tow the camper. - There could be a crash anytime the trailer brakes turn off. - A crash due to no trailer brakes Could cause a fire. - An injury or fatality would be highly likely if the trailer brakes "disconnect" at the wrong time causing a crash, with or without fire. - There would most certainly be a police report if any of the above happened.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

So the electrical would be when I shut my truck off in park I cannot turn my key completely back to release the key so therefore I’m killing my battery leaving the power on as far as the tires they’re rated for 50 or 55,000 miles I have 37,000 miles and I have no tread left and as far as my drivetrain when accelerating onto a highway pulling my fifth wheel camper that is 16,000 pounds loaded the truck box really bad as far as the crash warning breaking system it does not break

ELECTRICAL SYSTEM

So the electrical would be when I shut my truck off in park I cannot turn my key completely back to release the key so therefore I’m killing my battery leaving the power on as far as the tires they’re rated for 50 or 55,000 miles I have 37,000 miles and I have no tread left and as far as my drivetrain when accelerating onto a highway pulling my fifth wheel camper that is 16,000 pounds loaded the truck box really bad as far as the crash warning breaking system it does not break

POWER TRAIN

So the electrical would be when I shut my truck off in park I cannot turn my key completely back to release the key so therefore I’m killing my battery leaving the power on as far as the tires they’re rated for 50 or 55,000 miles I have 37,000 miles and I have no tread left and as far as my drivetrain when accelerating onto a highway pulling my fifth wheel camper that is 16,000 pounds loaded the truck box really bad as far as the crash warning breaking system it does not break

UNKNOWN OR OTHER

Tail gate opens and shut by its self while I’m going down the road have dropped a couple things out and lost them could have been worse if some one hit by jack that fell out

ELECTRICAL SYSTEM

Tail gate opens and shut by its self while I’m going down the road have dropped a couple things out and lost them could have been worse if some one hit by jack that fell out

STEERING

When vehicle is placed in park the safety lock will not allow the key to turn to the "off" position and be removed. The vehicle will not turn "off" any further than the accessory position. Sometimes after turning the steering wheel back and forth while working the ignition the key will release. If this does not work after a minute or so, sometimes you can start the truck and immediately turn it all the way off and get the key to release. If all of that fails the last option is to disconnect the battery. It is an intermittent issue that will happen 5 times a day for a week, and then will not replicate again for a week or two.

ELECTRICAL SYSTEM

When vehicle is placed in park the safety lock will not allow the key to turn to the "off" position and be removed. The vehicle will not turn "off" any further than the accessory position. Sometimes after turning the steering wheel back and forth while working the ignition the key will release. If this does not work after a minute or so, sometimes you can start the truck and immediately turn it all the way off and get the key to release. If all of that fails the last option is to disconnect the battery. It is an intermittent issue that will happen 5 times a day for a week, and then will not replicate again for a week or two.

POWER TRAIN

When vehicle is placed in park the safety lock will not allow the key to turn to the "off" position and be removed. The vehicle will not turn "off" any further than the accessory position. Sometimes after turning the steering wheel back and forth while working the ignition the key will release. If this does not work after a minute or so, sometimes you can start the truck and immediately turn it all the way off and get the key to release. If all of that fails the last option is to disconnect the battery. It is an intermittent issue that will happen 5 times a day for a week, and then will not replicate again for a week or two.

TIRES

I was driving to an event and I noticed my truck was pulling slightly. As I pulled onto the freeway and accelerated, I felt and heard a thumping sound but could not distinguish it between the pattern in the freeway or an issue with a tire. I continued to accelerate and the tire blew at about 55 mph. I was pulling a 5th wheel in a construction zone and was not immediately able to safely pull off the roadway. Extensive damage was done to the body of the truck with a current estimate at $4,832.18. The rim and tire were also destroyed with the rim being valued at $841.08 and tire at $408.

WHEELS

I was driving to an event and I noticed my truck was pulling slightly. As I pulled onto the freeway and accelerated, I felt and heard a thumping sound but could not distinguish it between the pattern in the freeway or an issue with a tire. I continued to accelerate and the tire blew at about 55 mph. I was pulling a 5th wheel in a construction zone and was not immediately able to safely pull off the roadway. Extensive damage was done to the body of the truck with a current estimate at $4,832.18. The rim and tire were also destroyed with the rim being valued at $841.08 and tire at $408.

STRUCTURE:BODY

I was driving to an event and I noticed my truck was pulling slightly. As I pulled onto the freeway and accelerated, I felt and heard a thumping sound but could not distinguish it between the pattern in the freeway or an issue with a tire. I continued to accelerate and the tire blew at about 55 mph. I was pulling a 5th wheel in a construction zone and was not immediately able to safely pull off the roadway. Extensive damage was done to the body of the truck with a current estimate at $4,832.18. The rim and tire were also destroyed with the rim being valued at $841.08 and tire at $408.

SERVICE BRAKES

the emergency brake warning light keeps coming on, service, reduced engine function. I have taken in to the dealership and they cant find the problem, this is on many forums and with little to no answers, just a lot of speculation.

ENGINE

I started to her a light tapping in engine and also noticed smoke color coming from exhaust when I used the remote start and at other time. Truck has been going through a quart of oil or more at roughly 3400 miles before the 5000 miles before the service is actually due. Spoke to dealership several times and they say that is normal. Called GM directly and filed a complaint.Never had a vehicle that needed oil before service was due. That’s not normal. I feel like I’m getting the run around

LATCHES/LOCKS/LINKAGES

The contact owns a 2022 Chevrolet Silverado 2500. The contact stated that the tailgate intermittently unintendedly unlocked. The vehicle was taken to the dealer, and the contact was informed that the vehicle was previously included in NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages) and was repaired under the recall. The dealer could not confirm where and when the vehicle was repaired. The vehicle was not repaired a second time. The manufacturer was made aware of the issue. The failure mileage was 109,000.

STRUCTURE:BODY

Tailgate is opening unexpectedly as I drive down the road and parked.

TIRES

Tire = LT275/65R20. After 20 minutes on surface streets in 98° weather, entered freeway and heard a "thumping" sound every second at about 45 mph. Appeared to be the freeway but after accelerating to about 55 mph a loud bang was heard and the tire blew. This was a catastrophic failure where the tread fully separated from the wheel and did substantial damage to the side and wheel well of the truck. The rim was also damaged beyond repair.

UNKNOWN OR OTHER

The key constantly gets stuck in the ignition after shutting off the vehicle. Some times have have to start the car multiple times and move the steering wheel to get the key to come out. Sometimes that doesn't work and I have to play with it for up to 3 minutes just trying to get the key out.

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

The contact owns a 2022 Chevrolet Silverado 2500. The contact stated while driving at an undisclosed speed, the tailgate was independently unlatched. The contact stopped and parked the vehicle. The contact stated that the tailgate opened and closed independently. The vehicle was taken to the dealer where it was diagnosed with a tailgate module failure. The contact was informed that the tailgate module needed to be replaced. The vehicle was repaired. The failure reoccurred two months after the repair. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 67,500.

ELECTRICAL SYSTEM

When I park and attempt to turn off my truck, the key will not turn completely all the way so I can take it out!!! Takes MULTIPLE TIMES which is EXTREMELY INCOVENIENT

LATCHES/LOCKS/LINKAGES

The contact owns a 2022 Chevrolet Silverado 2500. The contact stated that the tailgate opened independently while driving and while the vehicle was parked. The contact stated that failure also occurred while using the tow hitch and the tailgate was scratched. The dealer was notified of the failure and the contact was informed that there were no recalls on the VIN. Upon investigation, the contact discovered NHTSA Campaign Number: 24V060000 (LATCHES/LOCKS/LINKAGES); and the contact linked the failure to the recall. The manufacturer was notified of the failure and the contact was informed that the vehicle was not covered under warranty and was provided an estimate for the repair. The vehicle was not yet repaired. The failure mileage was approximately 25,000.

VISIBILITY/WIPER

Rear back-up camera is intermittent and is a safety concern due to the size of the vehicle. I makes it un-safe when backing up. This has been happening more and more. Screen is either black or icon displays that the camera is not working.

UNKNOWN OR OTHER

Rear back-up camera is intermittent and is a safety concern due to the size of the vehicle. I makes it un-safe when backing up. This has been happening more and more. Screen is either black or icon displays that the camera is not working.

ELECTRICAL SYSTEM

Rear back-up camera is intermittent and is a safety concern due to the size of the vehicle. I makes it un-safe when backing up. This has been happening more and more. Screen is either black or icon displays that the camera is not working.

POWER TRAIN

I have a 2022 Chevrolet Silverado 2500 HD diesel truck. Twice while driving uphill the transmission seemed to lock up with a very “jerky” move. GM has acknowledged this problem and has issued a recall. I have taken my truck and have had the recall “remedy” performed. However, THIS REMEDY IS A BAND AID NOT A SOLUTION. The remedy/recall is only reprogramming the computer that controls the transmission to warn the driver that the problem is about to occur and will limit the speed of the vehicle to not exceed the fifth gear until the problem is repaired. I feel the transmission issue should be addressed in the recall not delayed until the issue re-occurs. As per a letter I received from GM the repair that’s needed is Special Coverage N232395330 is the replacement of Transmission Valve Body.

UNKNOWN OR OTHER

Repeated shift to park message even when in park. Resulting in many hours of shutting off and on, shifting between gears to get it to recognize it is in park. Dealership where purchased is trying to convince me it's a $700 fix with no recall. It is a known GM problem. This blatant disregard for proper repairs is costing GM customers thousands in additional repair for their gross negligence as well as endangering the safety of its customers. It additionally results in draining the battery, starter and transmission problems. GM needs to be held accountable since they know it is an issue.

UNKNOWN OR OTHER

Key gets stuck in the ignition and won't come out. I see lots of people online with the same issue.