2010 CHEVROLET MALIBU

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.

Risk: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.

STEERING

Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.

Risk: A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.

ELECTRICAL SYSTEM:WIRING

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Risk: Any of the above failure conditions increases the risk of a crash.

SUSPENSION

Lug studs repeatedly snap at wheel no matter how installed.

STEERING

Lug studs repeatedly snap at wheel no matter how installed.

WHEELS

Lug studs repeatedly snap at wheel no matter how installed.

UNKNOWN OR OTHER

The blinker level does not automatically shut off after the turn is preformed. It never has. Yes it can be inspected if asked. Because of this fault, people driving behind me have thought I am turning and have attempted to go around my vehicle, almost causing collision on several occasions. This puts myself, my passengers, and the other vehicle in immediate danger. As well as the vehicle behind the one attempting to go around my vehicle. Yes it has been reproduced by multiple car repair shops. There is never a time that the turn lever has worked properly. When talking to the previous owner, he indicated that he also had the same problem since he purchased the vehicle. Many online vehicle specific forums have owners who talk about having the same problem and the accidents they've gotten in due to it. There are no warning lights. The blinker stays active as well as the dash light indicating the blinker is still on. The date indicated was the most recent it happened and almost caused an accident.

WHEELS

The car will drive but is unable to turn. It's like the steering wheel is locked.

FUEL/PROPULSION SYSTEM

The car will drive but is unable to turn. It's like the steering wheel is locked.

ELECTRICAL SYSTEM

The car will drive but is unable to turn. It's like the steering wheel is locked.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The issue I'm having is the traction light is on and my rear break lights stay on constantly. I took the car to a shop and had the break light switch replaced. Two days later the lights was back on. I did some research and there was a recall for the exact issue I'm have (NHTSA14V252) when I gave the Chevrolet dealership my VIN they said there were no recalls but there was three recalls but they are no longer open. Is there any thing I can do? Please help

SERVICE BRAKES

The issue I'm having is the traction light is on and my rear break lights stay on constantly. I took the car to a shop and had the break light switch replaced. Two days later the lights was back on. I did some research and there was a recall for the exact issue I'm have (NHTSA14V252) when I gave the Chevrolet dealership my VIN they said there were no recalls but there was three recalls but they are no longer open. Is there any thing I can do? Please help

AIR BAGS

I was driving down the highway when the passenger side curtain airbags deployed for no reason. Air bag deployment stunned the driver, but fortunately did not cause accident.

STEERING

My power steering quit working

EXTERIOR LIGHTING

The contact owns a 2010 Chevrolet Malibu. The contact had been informed by other drivers that the brake lights failed to illuminate as intended while driving. Additionally, the contact stated that the brake lights randomly illuminated while driving. The traction control warning light was illuminated intermittently, causing the cruise control to become inoperable. The contact stated that as an independent mechanic, he had replaced the brake sensors twice; however, the failure persisted. Additionally, the contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V252000 (Electrical System, Exterior Lighting, Vehicle Speed Control, Electronic Stability Control (ESC); however, the failure persisted. The dealer was notified of the failure and informed the contact that the failure might be related to the brake sensors. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.

ELECTRONIC STABILITY CONTROL (ESC)

The contact owns a 2010 Chevrolet Malibu. The contact had been informed by other drivers that the brake lights failed to illuminate as intended while driving. Additionally, the contact stated that the brake lights randomly illuminated while driving. The traction control warning light was illuminated intermittently, causing the cruise control to become inoperable. The contact stated that as an independent mechanic, he had replaced the brake sensors twice; however, the failure persisted. Additionally, the contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V252000 (Electrical System, Exterior Lighting, Vehicle Speed Control, Electronic Stability Control (ESC); however, the failure persisted. The dealer was notified of the failure and informed the contact that the failure might be related to the brake sensors. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.

ELECTRICAL SYSTEM

The contact owns a 2010 Chevrolet Malibu. The contact had been informed by other drivers that the brake lights failed to illuminate as intended while driving. Additionally, the contact stated that the brake lights randomly illuminated while driving. The traction control warning light was illuminated intermittently, causing the cruise control to become inoperable. The contact stated that as an independent mechanic, he had replaced the brake sensors twice; however, the failure persisted. Additionally, the contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V252000 (Electrical System, Exterior Lighting, Vehicle Speed Control, Electronic Stability Control (ESC); however, the failure persisted. The dealer was notified of the failure and informed the contact that the failure might be related to the brake sensors. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.

UNKNOWN OR OTHER

The shift lever does not want to release from park. I cant get it to go into drive. Traction light comes on and overrides cruise control. Refer to recall dated 5/14/2014 #14V252000 or GM recall 13036. It is in for repair now. Almost $500 for repair.