CHEVROLET IMPALA

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.

Risk: A reduction of braking performance can increase the risk of a crash.

ELECTRICAL SYSTEM:WIRING

General Motors LLC (GM) is recalling certain model year 2009-2010 Chevrolet Impala vehicles manufactured April 25, 2008 through February 16, 2010. The front passenger seat frame may contact and damage the wires of the passenger presence sensor module.

Risk: If the wires are damaged, the passenger presence sensory system may fail to recognize that the passenger seat is occupied, disabling the air bag. Damage may also cause the air bag fuse to short resulting in a loss of all air bags and seat belt pretensions. Both conditions increase the risk of injury during a crash.

PARKING BRAKE

General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured November 15, 2012, to May 30, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Systems (FMVSS) No. 135 "Light Vehicle Brake Systems."

Risk: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.

PARKING BRAKE

General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured March 22, 2013, to May 22, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Systems (FMVSS) No. 135 "Light Vehicle Brake Systems."

Risk: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.

ENGINE AND ENGINE COOLING:ENGINE

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Risk: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

ENGINE AND ENGINE COOLING:ENGINE

General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

Risk: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

AIR BAGS

General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Impala vehicles manufactured April 15, 2013, to June 19, 2015, equipped with front vented-heated passenger seats. Accordingly, the Automatic Occupant Sensing (AOS) system may fail to suppress the front passenger air bag if a child seat is in the front passenger seat. These vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection."

Risk: If the front passenger air bag deploys with a child seat in the front passenger seat, it increases the risk of injury to the child.

STEERING

General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, Cadillac XTS, Chevrolet Camaro and Chevrolet Impala vehicles. Improperly torqued fasteners may cause the steering intermediate shaft and the steering gear and/or the lower control arm and the lower ball joint to separate.

Risk: If any of the components separate, the vehicle may have a loss of steering, increasing the risk of a crash.

POWER TRAIN:AUTOMATIC TRANSMISSION

General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."

Risk: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

SEAT BELTS

The contact owns a 2007 Chevrolet Impala. The contact stated while the vehicle was parked, the seat belt buckle failed to latch securely. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was unknown.

LANE DEPARTURE: BLIND SPOT DETECTION

Seatbelt warning and blinkers have no sound warnings and driver side blind spot warning are not working

ELECTRICAL SYSTEM

Seatbelt warning and blinkers have no sound warnings and driver side blind spot warning are not working

SEAT BELTS

Seatbelt warning and blinkers have no sound warnings and driver side blind spot warning are not working

ENGINE

The contact owns a 2004 Chevrolet Impala. The contact stated that while driving approximately 40 MPH, the vehicle suddenly decelerated to approximately 20 MPH, and the instrument panel went black. The contact stated that the vehicle lost power steering functionality, and then lost motive power and stalled. The contact was assisted by persons nearby to push the vehicle to the side of the road. The vehicle was towed to a mechanic, who was unable to determine the cause of the failure. The vehicle was towed to the dealer, but was not diagnosed. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 71,000.

ELECTRICAL SYSTEM

The contact owns a 2004 Chevrolet Impala. The contact stated that while driving approximately 40 MPH, the vehicle suddenly decelerated to approximately 20 MPH, and the instrument panel went black. The contact stated that the vehicle lost power steering functionality, and then lost motive power and stalled. The contact was assisted by persons nearby to push the vehicle to the side of the road. The vehicle was towed to a mechanic, who was unable to determine the cause of the failure. The vehicle was towed to the dealer, but was not diagnosed. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 71,000.

SERVICE BRAKES

See attached document for complaint.

STEERING

The contact owns a 2015 Chevrolet Impala. The contact stated that while driving at 65 MPH, the steering wheel started to feel loose. There was no warning light illuminated. The contact continued driving and the steering wheel tightened with the "Service Power Steering - Drive with Care," message displayed. Due to the failure, excessive force was needed to steer the vehicle. The contact called her husband to meet her for assistance. The contact's husband arrived and was able to drive the vehicle to a dealer. While at the dealer, the vehicle was diagnosed with a defective power steering gear module. The contact was provided an estimate for the repair. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN related to the failure. The contact was then referred to the NHTSA Hotline to report the failure. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 109,000.

STEERING

2020 Chevrolet Impala Premier purchased July, 2015, mileage: + or - 12 miles I started having hard steering and made several trips to the dealer while under warranty and the dealer could not gen an OBD reading and no on dash reading. Right after the warranty was up and at 5,322 miles they were able to get an OBD reading. Information from the dealer invoice: A multi-point inspection DI1 Multi-Point inspection 716106 CPC B C/S veh is hard to steer at times- acts like it has no electric steering ADV cause: DTC O800 power steering control module low voltage, found while battery sitting over TP test dead cell and low cca 185/535cca EGO1 drivability test 716106 CPC $69.95 1 88866309 $190.00 New Battery Final charge: $317.44 No hard steering for a while, and now at 7,500 + or - miles hard steering is back and becoming harder to steer at times, especially if breaking. I have been to the dealer more often and had wait for the a while to get checked in and by the time he gets to me and someone to drive my car the steering is back to normal again. They told me that without a dash or ODB reading there is nothing they can do. 5 years same problem and never know when it will happen.