2019 CHEVROLET EQUINOX

POWER TRAIN:AUTOMATIC TRANSMISSION

General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Cruze and Buick LaCrosse, 2018-2020 Chevrolet Equinox, Chevrolet Traverse and GMC Terrain, 2018 Chevrolet Malibu, 2019-2020 Buick Encore, Buick Enclave, Cadillac XT4, Chevrolet Blazer and GMC Acadia, and 2020 Cadillac XT6 vehicles. The start/stop accumulator endcap may have missing bolts.

Risk: Missing bolts on the start-stop accumulator endcap could result in a transmission oil leak and may progress to a loss of propulsion, increasing the risk of a crash. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.

SEATS

General Motors LLC (GM) is recalling certain Chevrolet Equinox and GMC Terrain vehicles. The rear-right seat may have insufficient welds on the head-restraint bracket.

Risk: In the event of a crash, the insufficient welds may result in an increased risk of injury for an occupant seated in the rear-right position.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Equinox all-wheel drive vehicles. The fuel tanks may have been manufactured with an improperly sealed seam, possibly allowing fuel to leak along the seam near the fuel inlet.

Risk: A fuel leak in the presence of the ignition source can increase the risk of a fire.

ELECTRICAL SYSTEM

Vehicle experienced derating. Check engine light on. Called mobile repair service. 20 year mechanic. Replaced Pedal Sensor. Fail. Second visit replaced Throttle Body. Fail. He advised better to take it to a reputable shop. Did. Shop worked on it for 2 months and ended up replacing ECM. I finally had the unit towed to an Electrical Specialist in Longmont Colorado. They replaced Wiring loom between pedal sensor and car worked again. Drove car to Kansas and after about 300 miles, loud boom and messages on display. ECM engaged electric emergency brake hard at 79 MPH. WAS on cruise. At 20 mph car stopped messaging, and resumed normal operation. Pulled over, checked car. 50 miles from nearest city. cautiously drove about 20mph, then 30, then more until up to speed limit again. Worked fine 140 miles (needed a population center to get car fixed)) and it happened again. Limped car a few miles to repair in Salina, Kansas. ECM erased all miles, messages, etc. They could find nothing. my research showed the 2025 Equinox EV recall (We had replaced ECM and reprogrammed). I went to get car and risked driving, but without cruise. Warnings would come up, but car ran. No more emergency stops, but plenty of warnings. $3K in repairs and still problem. I believe current problem is electrical that Equinox is known for. The ECM/Reprogramming problem that activated the Brake is the issue here and previously reported by many. Extremely dangerous! Car has 50K miles. Was flawless driver until now. Note: Unit was Rebuilt Salvage. I bought at 1460 miles. Hit right rear, Replaced right rear sheet metal, Rear driveline on right side (Genuine GM parts), Replaced Hatch door. Inspected by state of Michigan. Reputable Rebuilder. Zero bad reviews. Hundreds of excellent reviews. P.S. Cannot take to Chevrolet - they universally refuse to work on car - not to even change oil.

ENGINE

The contact owns a 2019 Chevrolet Equinox. The contact stated that on several occasions while driving at various speeds, the brake pedal was depressed; however, the engine revved continuously as if the vehicle was going to drive forward. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

SERVICE BRAKES

Break assist break vacuum pump

SERVICE BRAKES

Vehicle Information: 2019 Chevrolet Equinox VIN: [XXX] Mileage: [Insert your current mileage] Engine: 1.5L Turbo ⸻ Complaint Summary: Sudden and complete loss of brake assist while driving. Brake pedal became extremely hard to press, making it difficult to stop the vehicle safely. A warning message appeared on the dashboard stating “Brake Assist”. This happened without warning and made braking unpredictable and dangerous. If I had been driving downhill or in the mountains, I could have easily lost control or crashed. I was lucky to be on a relatively flat road when it happened. I inspected the vacuum hose and brake fluid level — both were normal. After researching, I discovered this is a known issue in 2019 Equinox models with the 1.5L turbo engine, related to vacuum pump failure or loss of vacuum supply to the brake booster. There are service bulletins and limited coverage programs (N192268490 and N182202780), but my VIN does not show an open recall. I believe this is a serious safety defect that could affect many vehicles not yet covered by the recall or service campaigns. GM needs to expand the recall and properly warn drivers before someone gets killed. Please investigate this problem and hold GM accountable for fixing this safety-critical issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN:AUTOMATIC TRANSMISSION

The contact owns a 2019 Chevrolet Equinox. The contact stated while driving approximately 20-30 MPH, the vehicle jerked and stalled, and the vehicle was nearly rear-ended. There was no warning light illuminated. The contact immediately made a turn into the nearby independent mechanic shop parking lot. The contact stated that the vehicle was able to restart; however, the failure recurred while the vehicle was being test-driven by the independent mechanic. The mechanic diagnosed the vehicle and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

AIR BAGS

On July 1, 2025 I was involved in an accident and none of my airbags deployed. Car was inspected by police, insurance company and General Motors who haven’t sent me the report yet. No warnings or symptoms appeared.

STEERING

My vacuum pump failed on this vehicle. Causing my brakes to lock and a crash to almost happen

ENGINE

My vacuum pump failed on this vehicle. Causing my brakes to lock and a crash to almost happen

SERVICE BRAKES

My vacuum pump failed on this vehicle. Causing my brakes to lock and a crash to almost happen

UNKNOWN OR OTHER

I was following my usual routine with my young child. I unlocked the vehicle, secured him in his car seat, then placed my bag (containing the key fob) inside the vehicle. I then closed the door and walked to the driver’s side to enter the car—as I do daily. However, when I reached for the door, every door was locked—including the trunk—and the vehicle would not respond to any button pressing, handle pulling, or proximity unlocking. My child was locked inside the car on a 92-degree day with no way for me to gain access. I immediately called emergency services. Both police and fire arrived quickly, but due to the design of the locking system and the placement of the lock buttons, they were unable to use their unlocking tools. Ultimately, they had no choice but to shatter a window to rescue my child, who had been trapped for 25 minutes in extreme heat. This malfunction could have led to serious injury or worse. I’m extremely shaken and concerned that this happened at all—especially considering I had the key fob in the vehicle and never manually locked the doors.

ENGINE

My car had been sitting for a week as we were off on vacation and when I came back the car would not start. Oil had been changed 1 week before that by Miller and Son. After towing it to Miller and Son Chevrolet (724-378-0542)we were told it was a timing chain issue and once they opened things up I was told the engine is ruined. The car only had 71,000 miles on it(I purchased it last year) We spoke to multiple mechanics who stated this was a common problem for this car and if the engine had failed while driving it could have caused a fire/accident. I have a [XXX] son and he very much could have been trapped in the car. If this is happening frequently as the mechanics have told me why has this not been recalled. I religiously had my oil changed as required. I tried calling GM (case #[XXX]) without much success. The dealer wants $9000 to put in a new engine which I need to get a loan to do but also my fear is will this happen again. I would appreciate you looking into this issue. Thank You. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

On Sunday, [XXX] (a very hot day in Michigan. My vehicle registered 100 degrees) I was driving on [XXX] about 70-73 mph when I got an alert that said (to the best of my recollection) TOO HOT - IDLE IMMEDIATELY! and there was a continuous high pitch beeping which I only heard after turning off the radio. I continued at highway speed for a good 2-3 miles to the next exit afraid at any minute my car would start smoking. I exited and had to stop at a red light before turning left into a Kroger plaza with a fuel station. When the light turned green I accelerated and a grinding sound came from my car. I pulled into the plaza and turned the car off but had to turn it back on in about a minute as it was too hot to sit in car without air conditioning. It started and idled just fine. I googled roadside service and got a nice fellow (on a SUNDAY!) and he arrived in about 40 minutes. He towed me 40 miles away to a recommended auto shop that on Monday told me it was my transmission cooler that was defective and that I needed a transmission shop for a new transmission. It was then towed another 20 minutes away where it stayed for 9 days. Cost: $6564.48 plus $150 for paying with a credit card so totaled $6714.48. My drive train warranty was only good to 60,000 miles/5 years and I have 76,000 miles on my car at the time. Was told the transmission cooler was defective so I asked to have the cooler part and I have it in my garage. I spent over $1000 at the dealership in the months of Feb/March/April 2025 as my car hit the 70,000 mile mark so I had them do all work required by the car manual. The transmission cooler is apparently not a part they check. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

I was driving one day and my radio shut off, screen black and no sound. Came back on like it rebooted. Worked fine. The next day it did the same thing but only the screen went out but for longer this time. I work at a collision center and used our scanner to see what the problem might have been. It was giving a bunch of codes for radio and onstar. The next day it was perfectly fine. So I scanned it again just to see if the codes were still there. They weren't, but instead had 2 codes for brake control module in my engine and my transmission. My fan in the front has also been making slowing down and speeding up randomly.

ELECTRICAL SYSTEM

I was driving one day and my radio shut off, screen black and no sound. Came back on like it rebooted. Worked fine. The next day it did the same thing but only the screen went out but for longer this time. I work at a collision center and used our scanner to see what the problem might have been. It was giving a bunch of codes for radio and onstar. The next day it was perfectly fine. So I scanned it again just to see if the codes were still there. They weren't, but instead had 2 codes for brake control module in my engine and my transmission. My fan in the front has also been making slowing down and speeding up randomly.

SERVICE BRAKES

I own a 2019 Chevy Equinox LT 1.5L and am experiencing the exact symptoms described in GM recall 18V576000. After 1–2 hours of driving, the rear brakes begin to drag, creating hesitation during takeoff. The issue resolves after the vehicle cools down. Both my mechanic and independent research confirm this is the same safety defect described in that recall, but my VIN is not included.

VISIBILITY/WIPER

Driver side mirror changes position at start of vehicle for no reason. This makes for a very dangerous situation while driving as nitro has moved and is showing other than where it was set at.

SERVICE BRAKES

I was driving brake pedal went causing me to use emergency brake to stop. Took and got it diagnosed. The brake vacuum went out. The repair bill was $680 that have to pay tomorrow 6-19. I had someone in my car that I was transporting. This could end very card if I was an experienced CDL driver. My car 2019 Chevy Equinox only has 107,310 miles. I am so frustrated this is not on the recall list for the same problem other GM owners were having

UNKNOWN OR OTHER

I have a leak somewhere inside the car. Every time it rains I have water under the cargo area, that I have to vacuum water out. ( where the spare tire is) I don't know where its coming in at. I don't feel like vehicles that cost as much as they do should have major problems like this and now because of this my moon roof no longer works. Thank you for your time

POWER TRAIN

Symptoms were poor gas mileage, highly rough idle (especially in DRIVE, while at a stop), lag in acceleration as well as delayed response to gas pedal depression, struggled take off from an incline while utilizing AC on high output. Diagnosed by a code reader with confirmation by a trusted mechanic that the transmission is malfunctioning. Mechanic indicates the need to seek a shop specializing in transmissions because this entails disassembly of drain pan and plug to find issue either with fluid seal or the start/stop assembly in relation to the transmission. Issues began approximately 6 months ago, as I have been trying to deduce the issue by process of elimination by way of services and mileage recommendation. All professional involved indicate that a Chevy at this mileage and age do not typically display concerns related to the transmission.

ENGINE

The contact owns a 2019 Chevrolet Equinox. The contact stated that while at a stop, the vehicle lost automotive power. In addition, the contact stated that the vehicle failed to respond while shifted into gear. Several unknown warning lights were intermittently illuminated. The vehicle was taken to a local independent mechanic, where it was diagnosed and a transmission error code was retrieved; however, no other failure was identified. The contact stated that the vehicle was repaired, and an unknown part was replaced; however, the failure persisted. The vehicle was taken to another independent mechanic for a second opinion; however, the cause of the failure was not yet determined. The vehicle was not repaired. The vehicle was taken to a third independent mechanic, where it was it was diagnosed; however, the cause of the failure was not yet determined. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 97,000.

ENGINE AND ENGINE COOLING

The contact called on behalf of the owner of a 2019 Chevrolet Equinox. The contact stated that there was coolant leaking from the engine compartment. The vehicle was driven to the contact and to a local mechanic who diagnosed that the coolant expansion tank recovery hose had failed causing engine coolant to leak from the hose onto the PCM. The contact stated that the hose needed to be replaced. The vehicle was not repaired. The contact was concerned that due to the location on the hose the failure would reoccur once the hose was replaced. The manufacturer and local dealer were not yet contacted regarding the failure. The failure mileage was 49,549.

SERVICE BRAKES

I was driving and all of a sudden my brake assist light and engine light come on and then when I tried to brake, the brake pedal was very hard to push and it was very hard to stop.

POWER TRAIN

To Whom It May Concern, I'm writing to formally report a critical failure of the Auto Start-Stop system in my 2019 Chevy Equinox that occurred today, resulting in a hazardous situation during rush hour traffic. While stopped in the northbound left turn lane of Route 202 at the intersection with Baltimore Pike, the vehicle’s Auto Start-Stop feature engaged as expected. However, upon releasing the brake to proceed, the engine failed to restart, and the vehicle remained completely inoperative — engine off, no power, and unresponsive to ignition attempts. This failure caused the vehicle to become stranded in a live intersection during heavy traffic, posing a serious safety risk not only to myself but also to other motorists. A Pennsylvania State Police officer arrived on the scene and assisted by pushing the vehicle across three active lanes of traffic while in neutral, performing a battery jump with a brand new battery of five months, and escorting me home to ensure I was safe. This situation was both dangerous and unacceptable, especially considering that the failure stemmed from a system designed for emissions/fuel efficiency, not safety. The Auto Start-Stop feature in this vehicle clearly introduces critical failure points without adequate redundancy or reliability, particularly in real-world driving conditions. Additionally, I contacted my local Chevrolet dealership and spoke directly with a technician in the service department. He confirmed that they have had multiple customers reporting similar failures with the Auto Start-Stop system. According to him, this is not an isolated incident, and in several cases, it has placed drivers in equal danger. I am formally requesting: An investigation into this incident, Information on any existing Technical Service Bulletins (TSBs) or recalls related to this failure, A full inspection of the vehicle at GM’s expense, And a report on what steps GM is taking to prevent similar failures from putting other drivers in harm’s way.

ELECTRICAL SYSTEM

To Whom It May Concern, I'm writing to formally report a critical failure of the Auto Start-Stop system in my 2019 Chevy Equinox that occurred today, resulting in a hazardous situation during rush hour traffic. While stopped in the northbound left turn lane of Route 202 at the intersection with Baltimore Pike, the vehicle’s Auto Start-Stop feature engaged as expected. However, upon releasing the brake to proceed, the engine failed to restart, and the vehicle remained completely inoperative — engine off, no power, and unresponsive to ignition attempts. This failure caused the vehicle to become stranded in a live intersection during heavy traffic, posing a serious safety risk not only to myself but also to other motorists. A Pennsylvania State Police officer arrived on the scene and assisted by pushing the vehicle across three active lanes of traffic while in neutral, performing a battery jump with a brand new battery of five months, and escorting me home to ensure I was safe. This situation was both dangerous and unacceptable, especially considering that the failure stemmed from a system designed for emissions/fuel efficiency, not safety. The Auto Start-Stop feature in this vehicle clearly introduces critical failure points without adequate redundancy or reliability, particularly in real-world driving conditions. Additionally, I contacted my local Chevrolet dealership and spoke directly with a technician in the service department. He confirmed that they have had multiple customers reporting similar failures with the Auto Start-Stop system. According to him, this is not an isolated incident, and in several cases, it has placed drivers in equal danger. I am formally requesting: An investigation into this incident, Information on any existing Technical Service Bulletins (TSBs) or recalls related to this failure, A full inspection of the vehicle at GM’s expense, And a report on what steps GM is taking to prevent similar failures from putting other drivers in harm’s way.

POWER TRAIN

The contact owns a 2019 Chevrolet Equinox. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an Advanced Auto Parts where a diagnostic test was performed and DTC U0101 and P12A6 were retrieved. The vehicle was then taken to a local independent mechanic where the vehicle was diagnosed, and the contact was informed that the transmission control module was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 108,533.

ENGINE

Poor quality Vacuum Pump failed, resulting in debris in crack shaft assembly and preventing brake functionality. Check engine displays and error message stated "Service Brake Assist" which does not indicate a vacuum pump failure, which is misleading in troubleshooting issue. Hard brake pedal is a symptom, which would lead a repair facility or consumer to replace Brake Power Booster, which does not resolve issue, but will temporarily resolve brake pedal symptom, leading to further damage to crank shaft.

SERVICE BRAKES

Poor quality Vacuum Pump failed, resulting in debris in crack shaft assembly and preventing brake functionality. Check engine displays and error message stated "Service Brake Assist" which does not indicate a vacuum pump failure, which is misleading in troubleshooting issue. Hard brake pedal is a symptom, which would lead a repair facility or consumer to replace Brake Power Booster, which does not resolve issue, but will temporarily resolve brake pedal symptom, leading to further damage to crank shaft.

UNKNOWN OR OTHER

Started off with my computer on my dashboard randomly turning off I called the dealership they told me it was because I was not using an iPhone Apple chord. Another instance I was driving down the road close to home and my car started stalling and flashing engine codes on my dashboard, I managed to make it home and park. The next day I tried to start my vehicle and it sounded like the battery was dead. I called a tow truck. The car had enough power for me to put it into neutral and get it onto the flatbed. My mechanic is less than 10 minutes away by the time they got it there they couldn’t do anything to move the vehicle. It had to be jacked up on the flatbed and rolled off because the car would not do anything My mechanic spent two weeks going through the computer system only to find out that I needed a software update and that my computer software had major glitches and electrical issues. Sometimes when I get into my vehicle to start it, it won’t start. I’ve learned that I need to put both feet on the brake. Push it all the way to the floor wait a second and then it will start otherwise my break seizes up and I’m locked out of my vehicle for at least an hour. This has happened to me on the side of highways in public parking lots in front of my home at the grocery stor. This past week I’ve had to get my car jumped 2 different times because when I turn my car off and lock it, my brake lights do not turn off and it killed my battery. I’ve had nothing but issues with the computer since day one from what I’ve googled this is a known issue with my make and model of vehicle. I contacted the dealership and they want to charge me thousands of dollars for something that was a factory defect.

EXTERIOR LIGHTING

Started off with my computer on my dashboard randomly turning off I called the dealership they told me it was because I was not using an iPhone Apple chord. Another instance I was driving down the road close to home and my car started stalling and flashing engine codes on my dashboard, I managed to make it home and park. The next day I tried to start my vehicle and it sounded like the battery was dead. I called a tow truck. The car had enough power for me to put it into neutral and get it onto the flatbed. My mechanic is less than 10 minutes away by the time they got it there they couldn’t do anything to move the vehicle. It had to be jacked up on the flatbed and rolled off because the car would not do anything My mechanic spent two weeks going through the computer system only to find out that I needed a software update and that my computer software had major glitches and electrical issues. Sometimes when I get into my vehicle to start it, it won’t start. I’ve learned that I need to put both feet on the brake. Push it all the way to the floor wait a second and then it will start otherwise my break seizes up and I’m locked out of my vehicle for at least an hour. This has happened to me on the side of highways in public parking lots in front of my home at the grocery stor. This past week I’ve had to get my car jumped 2 different times because when I turn my car off and lock it, my brake lights do not turn off and it killed my battery. I’ve had nothing but issues with the computer since day one from what I’ve googled this is a known issue with my make and model of vehicle. I contacted the dealership and they want to charge me thousands of dollars for something that was a factory defect.

ELECTRICAL SYSTEM

Started off with my computer on my dashboard randomly turning off I called the dealership they told me it was because I was not using an iPhone Apple chord. Another instance I was driving down the road close to home and my car started stalling and flashing engine codes on my dashboard, I managed to make it home and park. The next day I tried to start my vehicle and it sounded like the battery was dead. I called a tow truck. The car had enough power for me to put it into neutral and get it onto the flatbed. My mechanic is less than 10 minutes away by the time they got it there they couldn’t do anything to move the vehicle. It had to be jacked up on the flatbed and rolled off because the car would not do anything My mechanic spent two weeks going through the computer system only to find out that I needed a software update and that my computer software had major glitches and electrical issues. Sometimes when I get into my vehicle to start it, it won’t start. I’ve learned that I need to put both feet on the brake. Push it all the way to the floor wait a second and then it will start otherwise my break seizes up and I’m locked out of my vehicle for at least an hour. This has happened to me on the side of highways in public parking lots in front of my home at the grocery stor. This past week I’ve had to get my car jumped 2 different times because when I turn my car off and lock it, my brake lights do not turn off and it killed my battery. I’ve had nothing but issues with the computer since day one from what I’ve googled this is a known issue with my make and model of vehicle. I contacted the dealership and they want to charge me thousands of dollars for something that was a factory defect.

FUEL/PROPULSION SYSTEM

Fuel pump isn't pumping gas.

ELECTRICAL SYSTEM

I was driving down the road and my engine stopped. It stopped so suddenly that I did not have time to get out of the road and my safety was put at risk. When I took it to a certified Chevrolet dealership, they told me that the vacuum pump failure caused extensive damage to the motor and I needed to have my entire motor replaced. When I asked them what I could have done to prevent such catastrophic failure, they stated that there was nothing to prevent it. I did not have any warning on my dash at the time of the incident. This was at least the 2nd vacuum pump failure on this vehicle since I've owned it. I got it replaced at a certified Chevrolet dealership in 05/2022 when my brakes went out. In 05/22, the brakes went out but I was in a driveway and I did not feel my safety was a concern at that time. Now it's not even been 3 years and the vacuum pump failure risked my safety and caused catastrophic damage to engine to be replaced.

ENGINE

I was driving down the road and my engine stopped. It stopped so suddenly that I did not have time to get out of the road and my safety was put at risk. When I took it to a certified Chevrolet dealership, they told me that the vacuum pump failure caused extensive damage to the motor and I needed to have my entire motor replaced. When I asked them what I could have done to prevent such catastrophic failure, they stated that there was nothing to prevent it. I did not have any warning on my dash at the time of the incident. This was at least the 2nd vacuum pump failure on this vehicle since I've owned it. I got it replaced at a certified Chevrolet dealership in 05/2022 when my brakes went out. In 05/22, the brakes went out but I was in a driveway and I did not feel my safety was a concern at that time. Now it's not even been 3 years and the vacuum pump failure risked my safety and caused catastrophic damage to engine to be replaced.

SERVICE BRAKES

I was driving down the road and my engine stopped. It stopped so suddenly that I did not have time to get out of the road and my safety was put at risk. When I took it to a certified Chevrolet dealership, they told me that the vacuum pump failure caused extensive damage to the motor and I needed to have my entire motor replaced. When I asked them what I could have done to prevent such catastrophic failure, they stated that there was nothing to prevent it. I did not have any warning on my dash at the time of the incident. This was at least the 2nd vacuum pump failure on this vehicle since I've owned it. I got it replaced at a certified Chevrolet dealership in 05/2022 when my brakes went out. In 05/22, the brakes went out but I was in a driveway and I did not feel my safety was a concern at that time. Now it's not even been 3 years and the vacuum pump failure risked my safety and caused catastrophic damage to engine to be replaced.

FUEL SYSTEM, GASOLINE

The contact owns a 2019 Chevrolet Equinox. The contact stated that upon inspecting the vehicle, there was fuel leaking onto the driveway near the fuel tank. No warning lights were illuminated. The contact stated that the dealer was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 19V667000 (FUEL SYSTEM, GASOLINE). The manufacturer was not notified of the failure. The failure mileage was 229,000.

ENGINE

The vehicle is leaking oil from in between the engine and transmission I am some bit mechanical and im sure its the rear Maine seal leaking yes the vehicle is available for inspection im taking it to H&H chevrolet [XXX] for a inspection I talked to Christian brothers repair and I told them what it was doing and they told me alot about my vehicles problem and gave me some Estimates and also said they have 2 in there shop right now needing the same repair...How was my safety or the safety of others put at risk? well me and my family went out to get a few groceries and it was -25 outside and we almost didn't make it back home because the car was not wanting to drive.if it had died we would have been stuck in dangerously cold weather.no warning lights came on I only found it was leaking when I started to smell burning oil so I looked under it and there was a small puddle of oil. this happened Monday [XXX] and the car hasn't been drivable since it sounds fine but I don't know we haven't moved it since we got it home. this is really inconvenient this vehicle is my only means of transportation to work and I never thought on a car I purchased brand new it would ever blow a rear seal I have heard many other having these problems and I still can't understand why this isn't a recall this is a very expensive problem to just be put on people financially. i hoping GM can resolve this for me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

The vehicle is leaking oil from in between the engine and transmission I am some bit mechanical and im sure its the rear Maine seal leaking yes the vehicle is available for inspection im taking it to H&H chevrolet [XXX] for a inspection I talked to Christian brothers repair and I told them what it was doing and they told me alot about my vehicles problem and gave me some Estimates and also said they have 2 in there shop right now needing the same repair...How was my safety or the safety of others put at risk? well me and my family went out to get a few groceries and it was -25 outside and we almost didn't make it back home because the car was not wanting to drive.if it had died we would have been stuck in dangerously cold weather.no warning lights came on I only found it was leaking when I started to smell burning oil so I looked under it and there was a small puddle of oil. this happened Monday [XXX] and the car hasn't been drivable since it sounds fine but I don't know we haven't moved it since we got it home. this is really inconvenient this vehicle is my only means of transportation to work and I never thought on a car I purchased brand new it would ever blow a rear seal I have heard many other having these problems and I still can't understand why this isn't a recall this is a very expensive problem to just be put on people financially. i hoping GM can resolve this for me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

The vehicle is leaking oil from in between the engine and transmission I am some bit mechanical and im sure its the rear Maine seal leaking yes the vehicle is available for inspection im taking it to H&H chevrolet [XXX] for a inspection I talked to Christian brothers repair and I told them what it was doing and they told me alot about my vehicles problem and gave me some Estimates and also said they have 2 in there shop right now needing the same repair...How was my safety or the safety of others put at risk? well me and my family went out to get a few groceries and it was -25 outside and we almost didn't make it back home because the car was not wanting to drive.if it had died we would have been stuck in dangerously cold weather.no warning lights came on I only found it was leaking when I started to smell burning oil so I looked under it and there was a small puddle of oil. this happened Monday [XXX] and the car hasn't been drivable since it sounds fine but I don't know we haven't moved it since we got it home. this is really inconvenient this vehicle is my only means of transportation to work and I never thought on a car I purchased brand new it would ever blow a rear seal I have heard many other having these problems and I still can't understand why this isn't a recall this is a very expensive problem to just be put on people financially. i hoping GM can resolve this for me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

While driving, the vehicle went into Engine Power Reduced mode, check engine light went on, and the Brake Assist notification came on. I pulled over and turned off the vehicle; vehicle would not restart. Had the vehicle towed for diagnosis; told initial codes were timing issues. Vehicle has 83,000 miles and showed no evidence of any sort of failures - no warning lights, no brake issues, no hesitation, no unusual sounds, no rough idling or driving. Dealership stated the vacuum pump failed and broke apart into the camshaft and into the engine. Official diagnosis was new vacuum system and engine replacement for a cost of $14,000.

ENGINE

While driving, the vehicle went into Engine Power Reduced mode, check engine light went on, and the Brake Assist notification came on. I pulled over and turned off the vehicle; vehicle would not restart. Had the vehicle towed for diagnosis; told initial codes were timing issues. Vehicle has 83,000 miles and showed no evidence of any sort of failures - no warning lights, no brake issues, no hesitation, no unusual sounds, no rough idling or driving. Dealership stated the vacuum pump failed and broke apart into the camshaft and into the engine. Official diagnosis was new vacuum system and engine replacement for a cost of $14,000.

AIR BAGS

Component or System Failed: The airbag system failed to deploy during three separate accidents in 2024. The vehicle is still in my possession and available for inspection upon request. How Safety Was Put at Risk: The failure of the airbags to deploy during all three incidents increased the risk of injury to me and my passengers. While the seatbelts provided some protection, the lack of airbag deployment compromised the safety system and could have resulted in serious injuries in higher-severity impacts. Accident Details: 1.Accident #1 (July 2024): •Type: Side collision on the driver’s rear door. •Other Vehicle Speed: Estimated 30–40 mph. •Damage: Significant damage to the driver’s side rear door. •Airbag Deployment: None. •Warnings or Errors: No warning lights or messages before or after the incident. 2.Accident #2 (March 2024): •Type: Sideswipe collision on the passenger front end. •My Vehicle’s Impact: Passenger side front wheel and body. •Damage: The front wheel was severely damaged. •Airbag Deployment: None. •Warnings or Errors: No warning lights or messages before or after the incident. Inspection Status: The issue has not yet been reproduced or confirmed by a Chevrolet dealership or independent service center. Insurance adjusters inspected the vehicle after each accident, but no specific investigation into the airbag system was performed. The manufacturer has not yet inspected the vehicle. Warning Lamps or Symptoms Prior to Failure: There were no warning lamps, messages, or other symptoms.