2016 CHEVROLET EQUINOX

VISIBILITY/WIPER

Front wipers stop working in the middle of a rain storm while driving down the highway we were unable to see anything(road/cars)out of the window. We had to put on flashers and stick head out of a rolled down window to (which with rain slapping you in the face is not safe either) try and get to a shoulder on the highway safely. My hubby and I were terrified and thought we were going to die or cause harm to others on the highway. After rain slowed down we got home very slowly with hazard light running. Once home I searched the web for problems that could have caused the wipers to suddenly stop. Results were to check fuses and relays (all checked out fine). I read that it could be a bushing on linkage arm that came off. Husband and I took off wipers and the cowl and sure enough linkage arm bushing had popped off of the ball joint. We tried to replace old bushing with a new one and put everything back together as it was taken off. Turned on wipers and it popped right back off. My car is now sitting in the yard unusable because I can not safely (for my family or other families out there) go any where because it is raining/will rain. There were no warnings or messages nothing they just stopped moving. One of the most scariest things in our lives, so glad our kids and grandson was not with us when it happened and that by the grace of God my husband and I made it home safely. This is very dangerous. It is also not uncommon due to information/videos on the internet. Please help correct this dangerous issue. Car is available for inspection any time Thank you

ENGINE AND ENGINE COOLING

The contact owns a 2016 Chevrolet Equinox. The contact stated that the vehicle was consuming an excessive amount of engine oil. There were no warning lights illuminated. The contact stated that one and a half quarts of oil needed to be added every two days. The vehicle was taken to the local dealer to be diagnosed and it was determined that the failure was caused by the timing belt sagging, and the piston being burned. The dealer stated that the gasket kit, timing chain, tensioner, sensor, guards, actuator, and bolts needed to be replaced. The vehicle was repaired. The manufacturer was contacted and filed a claim. The failure mileage was approximately 148,000.

VISIBILITY/WIPER

While driving on the highway, it was barely raining so I turned my wipers on low and about 5 minutes into my drive the rain picked up, and I tried to turn my wipers up at which point the stopped working altogether. I had to pull off on the shoulder and wait for the rain to end, which was about 20 minutes later. Afterwards I proceeded to the nearest gas station and purchased a squeegee to use while I was driving since cars were kicking up rain from the wet ground. Having wipers abruptly stop while it is raining heavily and traveling at 55 mph is beyond dangerous. I see all of the complaints online and a recall should and needs to be issued, as this issue could have and still can caused a tragic accident.

ENGINE

The concern is the oil consumption. The car looses a quart of oil a month. I average only 620 miles per month. There is no leak. A mechanic has been keeping track of it every month since April 2025. No warning lights alerted me of the problem. This has been an ongoing problem with the Chevy Equinox. My last one had the same problem but it was fixed thru a recall. It is frustrating for me to have to bring my car in every month to have it checked, because I am a caregiver for my husband and its hard for me to get away. I also use the car for his doctor appointments. I need a dependable car and can't afford a different one.

POWER TRAIN

Coming home from a trip without any warning our 2016 equinox scared me when it made a terrible sound lost power and stopped working. We’re 100’s miles away from home on the side of a road in the dark. We called for towing to a dealer payed for a hotel waited till the next day for it to be looked at. Told the engine was blown that the timing belt and everything in there was bent and in pieces 10,000-12,000 dollars to replace. Mind you this car is a ltz and very well talking care of. Without fixing it it’s worth 1000.00. Shame on gmc we should have been notified about issues. This happens at 80,000miles No warranty. I actually thought it caught on fire. Gm step up and take care of your life long customer that have owned Chevy always.

ENGINE

Coming home from a trip without any warning our 2016 equinox scared me when it made a terrible sound lost power and stopped working. We’re 100’s miles away from home on the side of a road in the dark. We called for towing to a dealer payed for a hotel waited till the next day for it to be looked at. Told the engine was blown that the timing belt and everything in there was bent and in pieces 10,000-12,000 dollars to replace. Mind you this car is a ltz and very well talking care of. Without fixing it it’s worth 1000.00. Shame on gmc we should have been notified about issues. This happens at 80,000miles No warranty. I actually thought it caught on fire. Gm step up and take care of your life long customer that have owned Chevy always.

VISIBILITY/WIPER

component- windshield wipers available for inspection-yes How was your safety or the safety of others put at risk? I was driving in light rain at first, turned on the windshield wipers on low. Slowed for a service vehicle and the rain became heavy so I moved the selector to high on the second or third pass across the windshield they quit, I could not see anything. I had to roll down my window and stick my head out to see so I could get off the road. I had to wait for the rain to stop before I could move. I first checked the fuses, it was fine. I can hear the wiper motor working. Has the problem been reproduced or confirmed by a dealer or independent service center? Not yet Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No got the car home before the next rain Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No absolutely no warning

STEERING

My son was driving when the steering "locked" into one position which caused him to leave the interstate, cross the median, across oncoming traffic and roll the vehicle three times. He suffered a lower back injury and his passenger only encountered minor cuts. We were not aware of any issues at the time. We did not have the vehicle inspected after the crash. No warnings or prior warnings were displayed by the car.

ENGINE AND ENGINE COOLING

The contact owns a 2016 Chevrolet Equinox. The contact stated while driving approximately 40 MPH, the vehicle stalled. The contact stated that there were no warning lights illuminated. The contact had the vehicle towed to an independent mechanic, where it was diagnosed and determined that the engine oil pump had failed and caused the engine to seize. The contact was advised that the engine and oil pump needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 58,000.

STEERING

The contact owns a 2016 Chevrolet Equinox. The contact stated that the vehicle intermittently lost power steering functionality, making it difficult to steer the vehicle. The failure persisted and became a complete failure. The contact stated that the “Service Power Steering” warning light was illuminated. The vehicle was taken to a Firestone Certified mechanic, who informed the contact that the vehicle needed to be taken to a dealer for assistance. The certified mechanic had diagnosed the vehicle with power steering failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 94,688.

FUEL SYSTEM, GASOLINE

The contact owns a 2016 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed, the contact heard a loud sound coming from the vehicle with a gasoline odor coming from the engine compartment. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the exhaust manifold had failed and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 120,000.

ENGINE

The contact owns a 2016 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed, the contact heard a loud sound coming from the vehicle with a gasoline odor coming from the engine compartment. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the exhaust manifold had failed and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 120,000.

ENGINE

I was driving my vehicle on the highway when all of a sudden I started to lose speed and my car wouldn’t accelerate. When my vehicle wouldn’t accelerate it started to shake significantly and the check engine, abs, traction control, and service stabilitrak light came on all at once. I was able to pull over and get my car towed to the dealership. Once it was at the dealership it was diagnosed that my car had jumped time causing a misfire in cylinder 4. My dealership stated this was due to low oil and my piston had become warped due to making contact with my valve. My car had no check oil warnings or any indication that vehicle was low on oil prior to this happening. My vehicle drove perfectly fine until that point. My vehicle also had no oil leaks (confirmed by myself not seeing any leaks under my vehicle as well as the dealership when they did the diagnostics). Before I bought my vehicle I did research and knew this model vehicle had oil consumption issues, so I made sure to routinely check my oil levels. Even with getting oil changes approximately every 3,000 miles and checking my oil levels and topping off my oil whenever it got less then 5 quarts I still had to get a total engine replacement. This was a huge safely issue since there was no warning that my oil was low and my car lost speed on the highway and was trying to stall out before I had a chance to pull off to safe place.

WHEELS

TIRE PRESSURE SENSOR SYSTEM REPAIRED TWO YEARS AGO. CAR HAS JUST CROSSED OVER 16K MILES, SO IT IS USED VERY LITTLE. TIRE PRESSURE SENSORS KEEP GOING. INTERESTINGLY, MY NEIGHBOR HAS JUST BOUGHT THE SAME YEAR VEHICLE AND SHE HAS THE SAME EXACT PROBLEM. THIS NEEDS TO BE RECALLED IMMEDIATELY

FUEL/PROPULSION SYSTEM

In Feb 2025, I was driving, a day after a snow storm, on the highway when without warning my car stopped accelerating, and just shut down. The mechanic said my oil was all over the ground. He also stated that there's a defect in the 2.4l ecotec motors and the pistons broke on my vehicle. Now I have to pay $3500 to rebuild my motor. He stated that the vehicle has a higher oil consumption rate/ leaks and you will never know

ENGINE

In Feb 2025, I was driving, a day after a snow storm, on the highway when without warning my car stopped accelerating, and just shut down. The mechanic said my oil was all over the ground. He also stated that there's a defect in the 2.4l ecotec motors and the pistons broke on my vehicle. Now I have to pay $3500 to rebuild my motor. He stated that the vehicle has a higher oil consumption rate/ leaks and you will never know

ELECTRICAL SYSTEM

In Feb 2025, I was driving, a day after a snow storm, on the highway when without warning my car stopped accelerating, and just shut down. The mechanic said my oil was all over the ground. He also stated that there's a defect in the 2.4l ecotec motors and the pistons broke on my vehicle. Now I have to pay $3500 to rebuild my motor. He stated that the vehicle has a higher oil consumption rate/ leaks and you will never know

VISIBILITY/WIPER

The wipers quit working while I was driving in a thunderstorm. Safety was definitely a risk as I was on a major highway. I pulled over and waited for rain to stop and made it to an auto parts store to replace fuse. Unfortunately, this wasn’t the issue. The recall does not include 2016 equinox. I don’t understand why it’s not included.

ENGINE

The contact owns a 2016 Chevrolet Equinox. The contact stated while driving 10 MPH, the vehicle made an abnormal sound and then stalled. There was no warning light illuminated. The contact was able to coast the vehicle to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 117,583.

UNKNOWN OR OTHER

The 2016 Equinox is not keeping oil in the engine. Therefore, the engine is unsafe and extremely dangerous - there is no warning! It will just stop in traffic! Life threatening to driver, passengers and other vehicles on the road.

ENGINE

The 2016 Equinox is not keeping oil in the engine. Therefore, the engine is unsafe and extremely dangerous - there is no warning! It will just stop in traffic! Life threatening to driver, passengers and other vehicles on the road.

UNKNOWN OR OTHER

Rear main seal blew due to freezing condensation in the pcv valve. The vehicle is at the dealership but can be available for inspection. This happened in an isolated area, when temperatures were below -15 degrees with the windchill. The vehicle started leaking oil and was not drivable, so me and my elderly mother were broke down on the side of the road in freezing temperatures! The problem have been verified by a transmission shop as well as a GM certified dealership. The vehicle has been inspected by a transmission shop, as well as a GM dealership, and a 3rd party investigator from my extended warranty company. There were no warning lights or indications prior to the vehicle starting to pour oil out from underneath it!

ENGINE

The contact owns a 2016 Chevrolet Equinox. The contact stated while driving 55 MPH, the vehicle started making a ticking noise. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, and the mechanic informed the contact that the engine was low by two quarts of engine oil. On another occasion, the vehicle was taken to the independent mechanic for an oil change, and the engine was low by two quarts of engine oil. The following month the vehicle was taken to the independent mechanic, due to the vehicle hesitating to accelerate, the vehicle was diagnosed with excessive oil consumption. The vehicle was not repaired after the most recent failure. The dealer was not made aware of the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 94,690.

ENGINE

Engines rear main seal failed and was replaced Freezing weather-15 degrees car will not run GM dealer that car was towed too Just a shutter no dash or any lights ever came on Repair by GM dealer said pcv valve froze resulting in dramatically increased oil pressure

ENGINE

The contact owns a 2016 Chevrolet Equinox. The contact stated that while driving on a rural road at 55 MPH, the vehicle lost motive power. No warning lights were illuminated. The contact entered a nearby parking lot, where the vehicle was parked and inspected. The contact stated that there was an abnormal amount of oil leaking from underneath the vehicle. The vehicle was towed to a local independent mechanic, who diagnosed the vehicle and informed the contact that the vehicle had experienced engine failure and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 120,000.

FUEL/PROPULSION SYSTEM

When temperatures were around 0 degrees, I was driving to work and I started hearing a noise and the car was shaking. I oil all over the ground and checked the oil once parked, the dip stick had no oil and there was white foam under the oil cap. This issue could've cause me to lose control of my vehicle while driving, putting myself and anyone around me at risk. I had the vehicle towed to a dealership where they found out that the rear main seal failed. They replaced the rear main seal along with the front main seal and sent me on my way. I had no issues for the next month, but the weather went back below 0 degrees and the same issue happened again, this time there was ice found in the intake manifold. This repair is being completed now. The vehicle has not been inspected by anyone other than the dealership. No warning light, messages or any other symptoms were present prior to the failure. The engine light DID NOT turn on when the seal "blew" but did turn on after turning the car off and back on.

ENGINE

When temperatures were around 0 degrees, I was driving to work and I started hearing a noise and the car was shaking. I oil all over the ground and checked the oil once parked, the dip stick had no oil and there was white foam under the oil cap. This issue could've cause me to lose control of my vehicle while driving, putting myself and anyone around me at risk. I had the vehicle towed to a dealership where they found out that the rear main seal failed. They replaced the rear main seal along with the front main seal and sent me on my way. I had no issues for the next month, but the weather went back below 0 degrees and the same issue happened again, this time there was ice found in the intake manifold. This repair is being completed now. The vehicle has not been inspected by anyone other than the dealership. No warning light, messages or any other symptoms were present prior to the failure. The engine light DID NOT turn on when the seal "blew" but did turn on after turning the car off and back on.

ENGINE

On January 21st,2025 (a day where temps did not exceed zero degrees driving this vehicle 3/4 of mile home from work, as pulling down my street, engine began to run rough. No warning lights came on. i pulled in my drive and garage and turned off, there was an oil trail up my drive. After about an hour i looked under car and a HUGE puddle of oil was there. I then had it towed to Chevy dealer. They said it was the 3rd car with this same engine brought in that week, and same issue, a blown rear seal, and in my case damaged the engine quickly. we were told by other dealers that fire could have happened. After doing research, models 2004-2015 have the same exact engine and same exact Defect. the PVC intake valve can develop condinsation (the design does not allow this to escape) and on extreme cold days this can freeze, causing the pressure to build quickly and without warning blow the seal and damage the engine. In 2015 GM put out a service bulliten to dealers warning of this issue and fixed at no charge and also extended the warranty to 10 year 125000 miles (we are currently 8 years , 90K) GM did not change the Defect in this engine until the 2018 model years, GM did not contact any owners of 2016-2027 with the same exact engine and defect to fix or make aware it existed. There are hundred if not thousands of these engines with this defect on the road. It is all over GM related forums, the dealership service departments are aware of the issue as well. GM is refusing to fix my vehicle which now needs a new engine at cost close to $10K, For last month I have had to rent a vehicle for $300 per week at my cost while I fight with GM They have offered me a $1500 coupon to buy a new car, and now today offered $2000 towards the fix this is not acceptable to me. They are aware of the issue and have fully paid for and fixed the SAME EXACT issue all except 2016-2017 we think there should be an urgency to this matter

VISIBILITY/WIPER

The wipers stopped working during a rain snow mix. My brother looked up der the shroud and the motor and assembly are all working fine. But the bushing or housing that keeps the arm in place has corroded and there are barely no threads left to them. This was said to be a problem with the 2015 Equinox as well. He tried to put a new nut in to fix the problem. But that only worked for a little while. Now it is no longer holding and it's going to be an awfully snowy few days starting tonight.

ENGINE

1. Excessive oil consumption! Adding one quart of oil every two weeks! 2. Timing chain replaced (TWICE) within 2 years! 2022/2023 3. Rear main seal replaced! 2022 4. VVT solenoid replaced because of rapid oil consumption causing metal shavings from engine! 2025 No warning lights just loud ticking all of a sudden and then engine shaking! Camshaft locked up and would not start, had to be towed to repair shop! This is a very dangerous engine (EcoTec 2.4L 4 cylinder) to drive with, as it can lock up or just fail causing an accident!

ELECTRICAL SYSTEM

Snowy conditions. All of the traction control, stabilitrak, and abs systems are working normally. Sometimes when i accelerate and the wheels start to spin the whole infotainment console turns off. Its almost like the battery is dead for a few seconds then everything turns back on.

ENGINE

I'm aware of the history of oil consumption issues with Equinoxs, as this is my third one, but I am told by the mechanic who did the oil change that there are no leaks, yet there 8 day later, after the oil change has been preformed, there is absolutely no oil on the dip stick. I just bought this car from Showcase Auto Sales, in Chesaning, MI and they will not take it back, as they sell them as is. There was no oil then either.

FUEL/PROPULSION SYSTEM

I'm aware of the history of oil consumption issues with Equinoxs, as this is my third one, but I am told by the mechanic who did the oil change that there are no leaks, yet there 8 day later, after the oil change has been preformed, there is absolutely no oil on the dip stick. I just bought this car from Showcase Auto Sales, in Chesaning, MI and they will not take it back, as they sell them as is. There was no oil then either.

ENGINE

There is a oil consumption issue with this vehicle and there are no warning indicators whatsoever that there is no-low oil If I hadn't caught it I would've blown my engine

FUEL/PROPULSION SYSTEM

no lights came on my car just became sluggish and I continued to drive up the road trying to get to safe spot to stop and it completely shut off on me I had to push out of road thankfully no one was behind me. I had towed to mechanic and he said my timing belt skipped and it had no oil has bent valves and piston damage and that I need a new engine

POWER TRAIN

no lights came on my car just became sluggish and I continued to drive up the road trying to get to safe spot to stop and it completely shut off on me I had to push out of road thankfully no one was behind me. I had towed to mechanic and he said my timing belt skipped and it had no oil has bent valves and piston damage and that I need a new engine

ENGINE

no lights came on my car just became sluggish and I continued to drive up the road trying to get to safe spot to stop and it completely shut off on me I had to push out of road thankfully no one was behind me. I had towed to mechanic and he said my timing belt skipped and it had no oil has bent valves and piston damage and that I need a new engine

POWER TRAIN

Driving vehicle on two days 1/21-1/22/25 both days had a high of zero degrees, vehicle say for 4 hours at work outside and then was driven the 1 mile home. As pulling down my street car started running rough. Pulled into my garage looked and there was a oil steak up my driveway . My wife called me and when I got home I looked under car and looked like several quarts of oil on floor under car. She said no warning lights came on. I had it towed the next day to a local garage. He inspected the vehicle and said rear seal was blown and that there is knock in engine , so basically shot. We bought the car new in 2016 and it has less the. 90k miles. I contacted Chevy and they said nothing is out about that year. I contacted local Chevy dealer and was told this is a known pvc freeze issue with equinoxes and this engine but it has not been recalled. There is a Chevy bulliten about this issue that is the same engine but the bulliten covers 2010-1014. This is the same exact issue in the same exact engine. On my hat service bulliten they have increased the warranty to 10year 100k and are covering the repairs. But they will do nothing and ignore the issue on every other vehicle with this engine and this flaw. Lucky my wife made it home safe I am having the car towed to a Chevy dealership and am prepared to leave it there and demand it gets fixed.

ENGINE

Driving vehicle on two days 1/21-1/22/25 both days had a high of zero degrees, vehicle say for 4 hours at work outside and then was driven the 1 mile home. As pulling down my street car started running rough. Pulled into my garage looked and there was a oil steak up my driveway . My wife called me and when I got home I looked under car and looked like several quarts of oil on floor under car. She said no warning lights came on. I had it towed the next day to a local garage. He inspected the vehicle and said rear seal was blown and that there is knock in engine , so basically shot. We bought the car new in 2016 and it has less the. 90k miles. I contacted Chevy and they said nothing is out about that year. I contacted local Chevy dealer and was told this is a known pvc freeze issue with equinoxes and this engine but it has not been recalled. There is a Chevy bulliten about this issue that is the same engine but the bulliten covers 2010-1014. This is the same exact issue in the same exact engine. On my hat service bulliten they have increased the warranty to 10year 100k and are covering the repairs. But they will do nothing and ignore the issue on every other vehicle with this engine and this flaw. Lucky my wife made it home safe I am having the car towed to a Chevy dealership and am prepared to leave it there and demand it gets fixed.

POWER TRAIN

What started as my car guzzling just a little too much oil too quickly, turned into my engine sitting at 1200RPM while parked, and then yesterday all the oil had leaked out, oil pressure was very low and the car wouldn’t run, and I’m being told by my mechanic that I need a whole new engine.

FUEL/PROPULSION SYSTEM

What started as my car guzzling just a little too much oil too quickly, turned into my engine sitting at 1200RPM while parked, and then yesterday all the oil had leaked out, oil pressure was very low and the car wouldn’t run, and I’m being told by my mechanic that I need a whole new engine.

ENGINE

What started as my car guzzling just a little too much oil too quickly, turned into my engine sitting at 1200RPM while parked, and then yesterday all the oil had leaked out, oil pressure was very low and the car wouldn’t run, and I’m being told by my mechanic that I need a whole new engine.

ENGINE

This was the third time I have had my vehicle in the shop for the same exact issue - stalling while driving. This time we decided to take it to a Chevy Dealer who very quickly diagnosed the PCV System Freeze "causing the rear main seal to push out causing a major oil leak". Seeing as this issue is known in prior years, it is baffling why Chevy has not addressed this design flaw, which causes engine damage, nor have they chosen to included later models - such as my 2016 - in a recall. I am so very lucky that I started being aware of the warning signs and did not get on the highway to go home. It would have likely been a deadly incident in that case - I am not joking. This was a VERY expensive repair - especially considering this is the 3rd repair regarding the same issue.

UNKNOWN OR OTHER

Make: Chevy ---- Model: Equinox ----- Year: 2016 ----- Mileage: Just under 78,000 miles ----- Component or system: Rear main seal failed leaking nearly all the oil left in the vehicle over the course of a few minutes of driving, which also left a dinner sized plate of oil underneath the car after parking in my garage. ----- Available upon request: Incident occurred 1/14/2025, with diagnosis from dealer on 1/15/2025. As of this moment the vehicle is still available and is being held by the mechanic while I decide on next course of action (repair or scrap). ----- How was your safety or the safety of others put at risk? I luckily made it home before all of the oil had depleted but this could have caused engine damage and failure while driving. The repair shop noted they did not notice any signs of engine damage but they are worried that engine damage may have occurred. There is no warning on the dash or computer related to the seal breaking or oil being almost entirely depleted. ----- Has the problem been reproduced or confirmed by a dealer or independent service center? It was brought in to a local repair shop who I personally trust which also has a 4.8 stars with 700 ratings on google. They degreased the car due to the oil everywhere and noted the rear main seal on the car had a massive leak and the car is non-operable in this condition. ----- Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Vehicle has only been inspected by the dealer mentioned above. ----- Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There is no warning or check engine light on the dash or computer related to the seal breaking or oil being almost entirely depleted.