CADILLAC DTS

ELECTRICAL SYSTEM:IGNITION

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.

ELECTRICAL SYSTEM

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Risk: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

STEERING

I was traveling on Stevenson expressway at 55 mph when the fuel pump relay overheated and melted, which burned up the REC (Rear Electrical Electrical Center /fusebox). When the fuse pump relay overheated it shut fuel down going to the fuel pump, which caused the engine to stall. When the engine stalled the car cut off, causing me to loose power steering. Because I was traveling in the middle lane of a three lane expressway at a high rate of speed, the vehicle started deaccelerating and I couldn’t control the vehicle with no power steering, I couldn’t get over to the shoulder. This nearly caused a wreck putting me in harm, because vehicles around me were accelerating at 55 to 70mph. All I could do is put my flashers on. Coast to a stop, and hope no one rear ended me, which nearly occurred. General Motors Cadillac division was aware of this possibility see: GLOBAL SAFETY FIELD INVESTIGATIONS DCS5755 URGENT - DISTRIBUTE IMMEDIATELY Date: April 14, 2021 Subject: REVISION: 18226-01 - Special Coverage Overheating of Fuel Relay or Motor Terminal Revised Service Procedure Models: 2008-2011 Buick Lucerne 2009-2011 Cadillac DTS To: All General Motors Dealers This bulletin is being revised to update the service procedure. all previous copies of 18226. END OF MESSAGE GLOBAL SAFETY FIELD INVESTIGATIONS Please discard Special Coverage Adjustment 18226 Overheating of Fuel Relay or Motor Terminal Condition On some 2008 – 2011 model year Buick Lucerne and 2009 – 2011 model year Cadillac DTS vehicles, the vehicle’s rear-seat bracket could contact the vehicle’s Rear Electrical Center (REC), which can, over time, damage electrical components within the REC enclosure. If damage occurs, the If damage occurs, the components canmelt or overheat, which the customer may detect by a melting odor in the vehicle. Damage could also cause the vehicle’s battery to drain, a no-start condition, or a stall. Because no accident occurred ther were no police reports filed. The date is est

FUEL/PROPULSION SYSTEM

I was traveling on Stevenson expressway at 55 mph when the fuel pump relay overheated and melted, which burned up the REC (Rear Electrical Electrical Center /fusebox). When the fuse pump relay overheated it shut fuel down going to the fuel pump, which caused the engine to stall. When the engine stalled the car cut off, causing me to loose power steering. Because I was traveling in the middle lane of a three lane expressway at a high rate of speed, the vehicle started deaccelerating and I couldn’t control the vehicle with no power steering, I couldn’t get over to the shoulder. This nearly caused a wreck putting me in harm, because vehicles around me were accelerating at 55 to 70mph. All I could do is put my flashers on. Coast to a stop, and hope no one rear ended me, which nearly occurred. General Motors Cadillac division was aware of this possibility see: GLOBAL SAFETY FIELD INVESTIGATIONS DCS5755 URGENT - DISTRIBUTE IMMEDIATELY Date: April 14, 2021 Subject: REVISION: 18226-01 - Special Coverage Overheating of Fuel Relay or Motor Terminal Revised Service Procedure Models: 2008-2011 Buick Lucerne 2009-2011 Cadillac DTS To: All General Motors Dealers This bulletin is being revised to update the service procedure. all previous copies of 18226. END OF MESSAGE GLOBAL SAFETY FIELD INVESTIGATIONS Please discard Special Coverage Adjustment 18226 Overheating of Fuel Relay or Motor Terminal Condition On some 2008 – 2011 model year Buick Lucerne and 2009 – 2011 model year Cadillac DTS vehicles, the vehicle’s rear-seat bracket could contact the vehicle’s Rear Electrical Center (REC), which can, over time, damage electrical components within the REC enclosure. If damage occurs, the If damage occurs, the components canmelt or overheat, which the customer may detect by a melting odor in the vehicle. Damage could also cause the vehicle’s battery to drain, a no-start condition, or a stall. Because no accident occurred ther were no police reports filed. The date is est