BMW X3

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

BMW of North America, LLC (BMW) is recalling certain 2025 X3 30 xDrive and X3 M50 xDrive vehicles. The rear brake hoses may leak, causing a loss of rear brake function, and a loss of the Antilock Brake System (ABS) and the Dynamic Stability Control (DSC) system.

Risk: A loss of rear brake function increases the risk of a crash.

LATCHES/LOCKS/LINKAGES:DOORS:LOCK

BMW of North America, LLC (BMW) is recalling certain 2022-2024 X3 sDrive30i and X3 xDrive30i vehicles. The second-row seat side door locking modules may not function properly and allow the doors to be unlocked with a single motion. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."

Risk: Doors that can be inadvertently unlocked and unlatched may open unexpectedly, increasing the risk of injury to rear seat occupants.

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

BMW of North America, LLC (BMW) is recalling certain 2025 330i, 330i xDrive, 530i, 530i xDrive, 4 Series Coupe (430i, 430i xDrive), 4 Series Convertible (430i, 430i xDrive), 4 Series Gran Coupe (430i, 430i xDrive) and X3 30 xDrive vehicles. The electrical connection between the starter-generator and battery may come loose.

Risk: A loose starter-generator connection can result in an engine stall, increasing the risk of a crash. In addition, the wiring may overheat, increasing the risk of a fire.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

BMW of North America, LLC (BMW) is recalling certain 2025 X3 30 xDrive vehicles. The front brake discs may have been damaged during transport before they were installed on the vehicle.

Risk: Damaged front brakes may not function properly, increasing the risk of a crash.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

BMW of North America, LLC (BMW) is recalling certain 2025 X3 30 xDrive vehicles. The connection between the positive battery cable and the starter-generator may have been improperly tightened and overheat.

Risk: An overheated battery cable connection can cause an engine stall and increase the risk of a crash. In addition, an overheated battery cable increases the risk of a fire.

ENGINE AND ENGINE COOLING:COOLING SYSTEM:PUMP

BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 2015-2016 428xi vehicles. An improperly sealed electrical connector on the water pump may be exposed to water and short circuit.

Risk: An electrical short increases the risk of a fire.

STRUCTURE

BMW of North America, LLC (BMW) is recalling certain 2018-2023 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3 M vehicles. The attachment for the interior cargo rail may become damaged in a rear crash and result in the cargo rail detaching.

Risk: Interior cargo rail detachment during a rear crash can increase the risk of injury.

AIR BAGS:SIDE/WINDOW:CURTAIN

BMW of North America, LLC (BMW) is recalling certain 2025 X3 30 xDrive vehicles. The gas generator in the right-side head curtain air bag may have been assembled incorrectly.

Risk: An incorrectly assembled air bag can result in delayed activation or improper deployment of the head curtain air bag, increasing the risk of injury in a crash.

AIR BAGS:PASSENGER SIDE FRONTAL:CUSHION

BMW of North America, LLC (BMW) is recalling certain 2025 X3 xDrive30i and X3 M50i vehicles. The front passenger air bag fabric may have been damaged during transport between suppliers.

Risk: A damaged air bag may not inflate properly, increasing the risk of injury in a crash.

ENGINE

Coolant leak. Oil filter housing coolant leak. Water pump leak. Coolant leaked while driving, and vehicle was not driveable after arriving at the dealership when all the coolant purged out of the vehicle.

ELECTRICAL SYSTEM

Drivers left front daytime running lights failed after <4 years from warranty replacement. 3rd set of lights in under 7 years on this vehicle.

EXTERIOR LIGHTING

Drivers left front daytime running lights failed after <4 years from warranty replacement. 3rd set of lights in under 7 years on this vehicle.

ELECTRICAL SYSTEM

Front headlights were replaced under warranty after daytime running lights both stopped working in Oct. 2021. Similar problem now on 9/4/25 approximately 4 years later, and BMW is leaving me to foot the bill on a barely 7 year old vehicle, forcing me to have 3 sets of lights on a car that is 7 years old.

EXTERIOR LIGHTING

Front headlights were replaced under warranty after daytime running lights both stopped working in Oct. 2021. Similar problem now on 9/4/25 approximately 4 years later, and BMW is leaving me to foot the bill on a barely 7 year old vehicle, forcing me to have 3 sets of lights on a car that is 7 years old.

ELECTRICAL SYSTEM

Regarding SIB 65 12 22, NHTSA ID Number 10227571, Manufacturer Communication Number B651222. Summary: The seal of the roof-mounted antenna housing is separating from the vehicle. Affected Products: (20) Vehicle BMW X3 2018-2022 - BMW X4 2019-2022 - BMW X5 2019-2022 - BMW X6 2020-2022 - BMW X7 2019-2022 I would like to mention that, this issue was known by BMW and acknowledge as Painting Process Deffect, BMW havent release a recall. BMW released on oct 2022 a BMW Service Information Bulletin detailing a defect in the paint and sealant of the roof-mounted antenna housing, which can allow water to leak into the vehicle and damage electrical components, including the emergency call system and GPS. Vehicles produced before January 10, 2022, are affected. The bulletin provides instructions for dealers to inspect for water ingress, remove the affected antenna housing, inspect the paint for separation on the sealing surface, and replace the housing if the paint is separating. Even when this production deffect main consequence is the damage of the Telematics Control Unit (tcu) due to physical closeness and consequently failure of the vehicle’s emergency call system and other communication systems and gps. The bulletin only focus on replace of antenna and painting of area (approx cost $700) and doesnt mention any alternatives for solution to damaged TCU (approx cost $3000) and on top the solution mentioned is even more restricted to Coverage under the terms of the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks. Please, respectfully request you to consider reviewing this situation due to affects 20 models and a considerable big amount of people.

STRUCTURE:BODY

Regarding SIB 65 12 22, NHTSA ID Number 10227571, Manufacturer Communication Number B651222. Summary: The seal of the roof-mounted antenna housing is separating from the vehicle. Affected Products: (20) Vehicle BMW X3 2018-2022 - BMW X4 2019-2022 - BMW X5 2019-2022 - BMW X6 2020-2022 - BMW X7 2019-2022 I would like to mention that, this issue was known by BMW and acknowledge as Painting Process Deffect, BMW havent release a recall. BMW released on oct 2022 a BMW Service Information Bulletin detailing a defect in the paint and sealant of the roof-mounted antenna housing, which can allow water to leak into the vehicle and damage electrical components, including the emergency call system and GPS. Vehicles produced before January 10, 2022, are affected. The bulletin provides instructions for dealers to inspect for water ingress, remove the affected antenna housing, inspect the paint for separation on the sealing surface, and replace the housing if the paint is separating. Even when this production deffect main consequence is the damage of the Telematics Control Unit (tcu) due to physical closeness and consequently failure of the vehicle’s emergency call system and other communication systems and gps. The bulletin only focus on replace of antenna and painting of area (approx cost $700) and doesnt mention any alternatives for solution to damaged TCU (approx cost $3000) and on top the solution mentioned is even more restricted to Coverage under the terms of the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks. Please, respectfully request you to consider reviewing this situation due to affects 20 models and a considerable big amount of people.

SUSPENSION

Brand new 2025 BMW X3 loud suspension noise coming front the font below 20 miles per hour. The car has ~5,000 miles. It happens every time and is pretty consistent. You can hear every imperfection on the road. I think is can be a safety concert - I see multiple reports that having similar concern.

VEHICLE SPEED CONTROL

Odometer failed - unable to get this fixed!