2011 BMW 535I

POWER TRAIN:DRIVELINE:CONSTANT VELOCITY JOINT

BMW of North America, LLC (BMW) is recalling certain 2011-2012 135i Coupe, 1 Series M Coupe and 135i Convertible vehicles, 2011 Z4 sDrive 35i, 335i, 335d, 335i Coupe, 335is Coupe, 335i Convertible, 335is Convertible, 535i, 535i xDrive, 535i Gran Turismo and 550i xDrive Gran Turismo vehicles and 2012 740i and 740Li vehicles. The rear driveshaft constant velocity (CV) joint on the affected vehicles may fatigue and break.

Risk: If the CV joint breaks, the vehicle may have a loss of propulsion, increasing the risk of a crash.

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

BMW of North America, LLC (BMW) is recalling certain model year 2011 BMW 528i, 528xi, 535i, 535xi, 550i and 550xi vehicles manufactured March 1, 2010, through August 31, 2011. The affected vehicles may have received a replacement Sensor Cluster Unit (SCU) during a service visit. These SCUs have an acceleration sensor that may have been incorrectly programmed and, as a result, the SCU may not accurately determine if activation and deployment of the air bags, safety belt pre-tensioners and head restraints is necessary in the event of a crash.

Risk: Depending on the severity of the crash, inadequate activation of the driver and/or passenger air bags, safety belt pre-tensioners and active head restraints may increase the risk of injury.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.

Risk: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.

AIR BAGS

The contact owns a 2011 BMW 535i. The contact stated that when pressing the accelerator pedal to drive from being idle at a red light, the driver's side air bag deployed out of the steering wheel without impact. The contact sustained burns to the left arm, right cheek, and chest area. The contact had suffered stomach issues due to inhaling the dust and fumes from the air bag. Medical attention was required. The vehicle was towed by AAA to an independent mechanic, where it was diagnosed that the horn module needed to be replaced; however, the part was not available. The vehicle was towed to another independent mechanic, where the vehicle remained for a month, and Liberty Mutual was to retrieve the vehicle and investigate the failure. The contact stated that the vehicle was not investigated to her knowledge, and the vehicle was returned without being repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 132,000.

UNKNOWN OR OTHER

I purchased the BMW 535 and it continues to have drivetrain malfunction issues. This feels like a safety concern for several reasons. The first is that were not able to identify the issue, but I believe it has to do with the systems diagnostics being triggered or misfiring this is an unfortunateissue because wherever we are, we can get stuck randomly. Lastly, the car has an issue with Oberheu. Issue because wherever we are, we can get stuck randomly. Lastly, the car has a issue with overheating believe it has to do with the radial hose

FUEL/PROPULSION SYSTEM

My car suddenly shut off when I came to a stop at a red light while on a busy state route. The information cluster then began to read “Fuel supply” and “Battery Discharge” My car would not turn back on and still has not turned back on since and it's been over a month now. According to the OBD results, the fuel pump and injectors were somehow seized and therefore have caused the car to become inoperable. I was forced to spend over $1000 just to get my car out of the police tow yard and towed to my home because I could not afford the cost of the repairs needed. The NHSTA website states that there is a recall on both the fuel system and the electrical system for my exact vehicle, but according to my Vin search results, there are 0 recalls. That doesn't make sense. I had just got my new inspection done maybe a month prior to my car breaking down.

ENGINE

My car suddenly shut off when I came to a stop at a red light while on a busy state route. The information cluster then began to read “Fuel supply” and “Battery Discharge” My car would not turn back on and still has not turned back on since and it's been over a month now. According to the OBD results, the fuel pump and injectors were somehow seized and therefore have caused the car to become inoperable. I was forced to spend over $1000 just to get my car out of the police tow yard and towed to my home because I could not afford the cost of the repairs needed. The NHSTA website states that there is a recall on both the fuel system and the electrical system for my exact vehicle, but according to my Vin search results, there are 0 recalls. That doesn't make sense. I had just got my new inspection done maybe a month prior to my car breaking down.

ELECTRICAL SYSTEM

My car suddenly shut off when I came to a stop at a red light while on a busy state route. The information cluster then began to read “Fuel supply” and “Battery Discharge” My car would not turn back on and still has not turned back on since and it's been over a month now. According to the OBD results, the fuel pump and injectors were somehow seized and therefore have caused the car to become inoperable. I was forced to spend over $1000 just to get my car out of the police tow yard and towed to my home because I could not afford the cost of the repairs needed. The NHSTA website states that there is a recall on both the fuel system and the electrical system for my exact vehicle, but according to my Vin search results, there are 0 recalls. That doesn't make sense. I had just got my new inspection done maybe a month prior to my car breaking down.

ELECTRICAL SYSTEM

The contact owned a 2011 BMW 535i. The contact stated that while the vehicle was unoccupied and parked in a parking lot, it was brought to the attention of the contact that the vehicle caught on fire. The local fire department arrived on the scene to extinguish the fire. The contact stated that it was unknown if a fire report was filed. A police report was filed. No injuries were sustained. The origin of the fire was unknown. The contact stated that the fire damaged one other parked and unoccupied vehicle that was nearby. The vehicle was towed by the insurance and was deemed a total loss. The vehicle remained in the possession of the insurance provider for further investigation. The local dealer was contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

WHEELS

Product Safety Alert: Jan 30, 2025 Stop using the following item because of a potential safety issue. Visit the public recall notice for more guidance. 245/45R18 100Y XL RFT PIR CINTURA P7 (M0E)(BMW/RR) 245/45R18 100Y XL RFT PIR CINTURA P7 (M0E)(BMW/RR)