BMW 430I

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

BMW of North America, LLC (BMW) is recalling certain 2025 330i, 330i xDrive, 530i, 530i xDrive, 4 Series Coupe (430i, 430i xDrive), 4 Series Convertible (430i, 430i xDrive), 4 Series Gran Coupe (430i, 430i xDrive) and X3 30 xDrive vehicles. The electrical connection between the starter-generator and battery may come loose.

Risk: A loose starter-generator connection can result in an engine stall, increasing the risk of a crash. In addition, the wiring may overheat, increasing the risk of a fire.

ENGINE

BMW of North America, LLC (BMW) is recalling certain 2024 BMW 430i convertible vehicles. The cylinder head cover may develop cracks, resulting in oil leaking into engine compartment.

Risk: An oil leak in the presence of an ignition source, such as a hot engine or exhaust components, can increase the risk of a fire.

SEAT BELTS

BMW of North America, LLC (BMW) is recalling certain 2019-2022 330i, 330i xDrive, M340i, 2022 430i Coupe, 2021-2022 430i, M440i Convertible, and 2020-2022 228i xDrive Gran Coupe vehicles. The receiver audio module control unit software may fail to properly generate audible seat belt warnings to the driver to fasten their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: An audible chime that does not properly alert the driver to fasten their seat belt increases the risk of injury in a crash.

ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE

BMW of North America, LLC (BMW) is recalling certain 2023 330i, 330i xDrive, M340i, M340i xDrive, M3, 330e, 330e xDrive, 430i Convertible, 430i xDrive, M440i, 2022-2023 430i, 430i xDrive, M440i xDrive, i4 eDrive40, and i4 M50 vehicles. During a service visit, a replacement electronic control unit (ECU) may have been installed with incorrect programming, which can cause the automatic door locking (ADL) function to not lock the doors as intended.

Risk: Doors that do not lock as intended while the vehicle is in motion may open during a crash, increasing the risk of injury.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

BMW of North America, LLC (BMW) is recalling certain 2022 4 Series Gran Coupe (430i, 430i xDrive, M440i xDrive); 2019-2022 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M; 2021-2022 X5 xdrive45e; 2020-2022 X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6M and 2019-2023 X7 xDrive40i, X7 xDrive50i, X7 M50i, X7 xDrive60i, X7 M60i, X7M, Alpina XB7 vehicles. The roof function control unit may be programmed incorrectly, allowing the sunroof to close without the key fob present inside the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

Risk: A sunroof that closes without the key fob present inside the vehicle can increase the risk of injury.

AIR BAGS:SIDE/WINDOW:THORAX

BMW of North America, LLC (BMW) is recalling certain 2021 430i and M440i 4 Series Convertible vehicles. In certain side-impact crashes, the head-thorax air bag may not deploy as intended.

Risk: An air bag that deploys incorrectly can increase the risk of injury in a crash.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.

SEAT BELTS

BMW of North America, LLC (BMW) is recalling certain 2021 2 Series (230i, 230i xDrive, M240i, M240i xDrive), 330e, 330e Xdrive, 4 Series Coupe (430i, 430i xDrive, M440i xDrive) M4 Coupe, M4 Competition Coupe, BMW 4 Series Convertible (430i, M440i), BMW X1 sDrive28i, xDrive28i, 2 Series Gran Coupe (228i, 228i xDrive, M235i xDrive), M2 Competition Coupe, 330i, 330i xDrive, M340i, M340i xDrive, M3, M3 Competition, 530i, 530i xDrive, 540i, 540i xDrive, MINI Hardtop 2 Door (Cooper, CooperS, JCW), X2 sDrive28i, X2 xDrive28i, X2 M35i, Z4 sDrive30i, Z4 M40i, MINI Hardtop 2 Door (Cooper SE), MINI Convertible (Cooper, Cooper S, JCW), MINI Clubman (Cooper S, Cooper S All4, JCW), MINI Countryman (Cooper, Cooper All4, Cooper S, Cooper S All4, JCW All4), Rolls Royce Ghost, MINI Countryman (Cooper S E All4), Rolls Royce Phantom, Rolls Royce Cullinan, and Toyota Supra vehicles. The passenger seat belt Automatic Locking Retractor (ALR) may deactivate early, before the webbing fully retracts. As such, these assemblies fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: During a crash, a seat belt retractor that does not function as intended increases the risk of injury.

AIR BAGS:KNEE BOLSTER

BMW of North America, LLC (BMW) is recalling certain 2019-2020 230i, 230i xDrive, M240i, M240i xDrive, M2 Competition Coupe, 430i, 430i xDrive, 440i, 440i xDrive, M4, and 2019 330i xDrive Sportswagon vehicles. The driver and passenger knee air bag assemblies may have been improperly folded and assembled.

Risk: An improperly folded and assembled air bag may not deploy as intended, increasing risk of injury.

ENGINE AND ENGINE COOLING

The contact owns a 2017 BMW 430I. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating, prompting the contact to discontinue driving the vehicle. After a visual inspection of the engine compartment, the contact observed that the coolant reservoir was empty, even though it had been refilled two weeks prior. The low coolant warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 123,000.

ELECTRICAL SYSTEM

The contact owns a 2018 BMW 430I. The contact stated that the vehicle was taken to a local dealer for routine service, and the vehicle was diagnosed and the contact was informed that the water pump was leaking and needed to be replaced. The low coolant level warning light was illuminated. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM) as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 66,690.

ENGINE AND ENGINE COOLING

The contact owns a 2018 BMW 430I. The contact stated that the vehicle was taken to a local dealer for routine service, and the vehicle was diagnosed and the contact was informed that the water pump was leaking and needed to be replaced. The low coolant level warning light was illuminated. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM) as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 66,690.

ELECTRICAL SYSTEM

On 8/7/2025, I pulled into my driveway very slowly, I didn’t have my foot on gas as I just went to our dumpster, and pressed the brake, I through the car was off, and went to exit, instead the car suddenly accelerated i tried to break, but the car didn’t stop and smashed into my garage. It is at the dealership, Wesley chapel BMW, they sent me a message that it won’t be ready today because there is recall and an issue but they have not told me what it is. I was researching and i saw what’s called “sudden unintended acceleration.”

UNKNOWN OR OTHER

On 8/7/2025, I pulled into my driveway very slowly, I didn’t have my foot on gas as I just went to our dumpster, and pressed the brake, I through the car was off, and went to exit, instead the car suddenly accelerated i tried to break, but the car didn’t stop and smashed into my garage. It is at the dealership, Wesley chapel BMW, they sent me a message that it won’t be ready today because there is recall and an issue but they have not told me what it is. I was researching and i saw what’s called “sudden unintended acceleration.”

SERVICE BRAKES

On 8/7/2025, I pulled into my driveway very slowly, I didn’t have my foot on gas as I just went to our dumpster, and pressed the brake, I through the car was off, and went to exit, instead the car suddenly accelerated i tried to break, but the car didn’t stop and smashed into my garage. It is at the dealership, Wesley chapel BMW, they sent me a message that it won’t be ready today because there is recall and an issue but they have not told me what it is. I was researching and i saw what’s called “sudden unintended acceleration.”

ENGINE

Disconnect coupling on cylinder head broke caused loss of coolant from engine. Overheated my Car damaged the engine and the car did accelerate when I was crossing a highway almost causing a collision

ENGINE

On my way home driving, my car dashboard and LCD screen give me a warning of overheating and engine oil pressure too low. Car stalled on stalled soon after, and started smoking. So I had the car towed and was told from bmw dealership, I had to get a new engine. I have kept up on my oil change and maintenance and never got these warning signs until now. I did mr research and found out from Kelly blue book and other websites such Dealer Rater that bmw same year make and model have a few recalls including engine cooling and crankshaft sensor malfunction. The bmw mechanic advise the coolant and oil holder made of plastic melted down into the engine and engine needs to be replaced. However, there have been reports states that other have experience the same thing with bmw cars. This should not have happened when much warnings was not given and how ironic same year make and model had the same issue and recall was issued. I have screen shots to prove it.

AIR BAGS

I owned a 2020 BMW 430i (VIN: [XXX] ) manufactured in March 2019 at the Regensburg plant. This vehicle matches the exact criteria of NHTSA Recall 19V-352 for defective knee airbags that may fail to deploy in an accident. I was involved in a serious crash on [XXX], and the airbags did not deploy. Despite this, my VIN is not showing as included in the recall. I am submitting this as a potential VIN exclusion error that may have resulted in harm and needs urgent investigation. I have documentation of the vehicle's production date, model match, and accident details. I also suffered significant psychological trauma as a result of this failure, which escalated due to the lack of explanation at the time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)