AUDI S4

SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY

Volkswagen Group of America, Inc. (Audi) is recalling certain 2019-2021 Audi A5 Sportback, RS5 Coupe, RS5 Sportback, S5 Sportback, 2020-2021 A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A6 Allroad, A6 Sedan, A7, A8, Q5, S4 Sedan, S5 Coupe, S5 Cabriolet, S6 Sedan, S7, S8, SQ5, 2021 Q5 Sportback, Q7, Q8, RS6 Avant, RS7, RSQ8, SQ5 Sportback, SQ7, and SQ8 vehicles. The rear axle alignment may not have been inspected after the repairs for Recall 21V-295 (42L1) were performed.

Risk: Rear axle misalignment may cause premature or uneven tire wear, increasing the risk of a crash.

BACK OVER PREVENTION:DISPLAY FUNCTION

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Audi A8, RS7, RS6 Avant, RS5 Sportback, RS5 Coupe, Q8, Q7, Q5 Sportback, S4 Sedan, Q5, A7, A6, A6 Allroad, A5 Sportback, A5 Coupe, A5 Cabrioleet, A4 Sedan, A4 Allroad, E-Tron Sportback Quattro, SQ7, S5 Cabriolet, E-Tron Quattro, SQ8, SQ5 Sportback, SQ5, S8, S7, S6 Sedan, S5 Sportback, S5 Coupe, 2022 E-Tron GT, and 2021-2022 RSQ8 vehicles. Due to a software issue, a blank or black screen may be displayed instead of the rearview camera image when the vehicle is placed in reverse gear. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A blank rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2000-2001 Audi TT Coupe, TT Roadster, 2000-2002 A4, and S4 vehicles equipped with Non-Azide Driver Air Bag Inflators (NADI) that do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, possibly causing the air bag to deploy improperly in the event of a crash.

Risk: In the event of a crash necessitating air bag deployment, the air bag may not properly protect the occupant, increasing the risk of serious injury or death.

SEATS

Volkswagen Group of America, Inc. (Audi) is recalling certain 2017-2020 A4 Allroad, A4 Sedan, 2018-2019 RS5 Coupe, 2019 RS5 Sportback, 2018-2020 A5 Cabriolet, A5 Coupe, A5 Sportback, S4 Sedan, S5 Cabriolet, S5 Coupe, and Audi S5 Sportback vehicles. The cable connecting the seat heater to the Passenger Occupant Detection System (PODS) may have a contact fault, causing the software to misdiagnose a malfunction and disable the passenger air bag.

Risk: A disabled passenger air bag increases the risk of injury in the event of a crash.

SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY

Volkswagen Group of America, Inc. (Audi) is recalling certain 2021 Q7, Q8, Q5 Sportback, SQ5 Sportback, RS6 Avant, RS7, RS Q8, 2020-2021 Audi S6 sedan, Q5, A8, S8, A7, A6 Allroad, A5 Cabriolet, A4 sedan, A4 Allroad, SQ5, S7, A6 sedan, S5 coupe, S4 sedan, S5 Cabriolet, A5 coupe, 2019-2021 RS5 coupe, A5 Sportback, S5 Sportback, RS5 Sportback vehicles. The lock nut on the trailing arm of the rear axle may break due to stress corrosion.

Risk: A broken lock nut may misalign the rear axle, causing a loss of control and increasing the risk of a crash.

SEAT BELTS

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: An unsecured child restraint system can increase the risk of injury during a crash.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Volkswagen Group of America, Inc. (Audi) is recalling certain 2018-2019 Audi RS5 Sportback, 2018 S5 Cabriolet, S5 Sportback, S5 Coupe, S4 Sedan, A5 Cabriolet, A5 Sportback, A5 Coupe, and 2017-2018 A4 Sedan and A4 Allroad vehicles. Oxidation on the Passenger Occupant Detection System (PODS) connecting cable may cause the software to misdiagnose a malfunction and disable the passenger air bag.

Risk: A disabled passenger air bag increases the risk of injury in the event of a crash.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2005-2008 Audi A4 Sedan, A4 Avant, S4 Avant and S4 Sedan, 2007-2008 RS4 Sedan, 2004 RS4 Cabriolet, 2007-2009 A4 Cabriolet and S4 Cabriolet, 2005-2011 A6 Sedan, 2006-2011 A6 Avant, and 2007-2011 S6 Sedan vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009 Audi A4 Cabriolet, S4 Cabriolet, A6 Avant, A6 Sedan and S6 Sedan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone B" above, Volkswagen is recalling certain 2005-2008 Audi A4 Avant, A4 Sedan, A6 Sedan, S4 Avant and S4 Sedan vehicles, 2007-2008 A4 Cabriolet, RS4 Sedan, S4 Cabriolet and S6 Sedan vehicles, and 2006-2008 A6 Avant and 2008 RS4 Cabriolet vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

ELECTRICAL SYSTEM

My instrument cluster and its replacements have malfunctioned multiple times. The original instrument cluster/virtual cockpit failed to boot and had a black/blank screen on 4/19/2024 at 29,687 miles and was replaced on 5/15/2024 at 29,923 mi. That replacement one worked fine for a while and then did the same thing on 7/15/2024 at 33,655 miles and on 1/10/2025 at 42,532 miles. The instrument cluster was then replaced again on 2/10/2025 at 43,841 miles. That replacement unit took only a couple of days to act up again with the blank screen on startup on 2/13/2025 at 43,965 miles and once more on 8/1/2025 at 52,673 miles. I'm currently waiting to hear back from the dealer to get the instrument cluster replaced once again.

ELECTRICAL SYSTEM

The Audi MMI malfunctions and reboots randomly while driving. Possibly being a software issue. There is a TSB code that the dealer used to reference for me ( TSB 2078437/1), but I cannot find it on the NHTSA website. The reboot issue shuts off all functions associated with it, including, but not limited to: navigation, rearview camera, and parking sensor use. This poses a risk since it can be distracting to pull back your navigation while driving or having your rearview camera cutoff mid mid-use. The issue does not appear as a warning lamp or any type of notification, and there are multiple reports of similar issues on online forums that have not been addressed.

UNKNOWN OR OTHER

The MMI reboots continuously throughout my drive - whether it is 1 minute or an hour. It does this without a Bluetooth connection or wired connection. There is no ability to use hands free calling, listen to the radio, use Apple car play, Bluetooth, navigation, back up camera, parking assistance… It is startling to have your camera black out on your as your backing up (may back up camera works for about 45 seconds before stopping) I have done a hard reset. This is a problem that I am reading over and over and over again on forums I live nearly 2 hours from a dealer who takes weeks to get into and looking at a huge bill Hoping there is a fix soon

BACK OVER PREVENTION: WARNINGS

I am submitting a formal complaint regarding a persistent and dangerous issue with the MMI (Multi Media Interface) system in my 2020 Audi S4. Since February 2025, the system has been spontaneously rebooting both while the vehicle is idling and in motion. When this occurs, the screen goes black and critical safety systems such as the rearview camera, parking sensors, and navigation become unavailable. The system requires driver interaction to restore functionality once it restarts, creating a major distraction. These reboots now occur every few minutes, severely affecting both usability and safe operation of the vehicle. Initially, this issue happened infrequently (about once every two weeks), but over time it has become constant. Based on extensive online reports from other owners—including threads such as this one on AudiWorld: [XXX] appears to be a widespread defect affecting other Audi A4/S4 vehicles of the same year. This malfunction compromises several driver assistance and safety features, and I believe it presents a serious hazard, especially if it occurs during parking, reversing, or navigating unfamiliar areas. I urge NHTSA to investigate this matter and determine whether a recall or safety bulletin is appropriate. Thank you for your attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

I am submitting a formal complaint regarding a persistent and dangerous issue with the MMI (Multi Media Interface) system in my 2020 Audi S4. Since February 2025, the system has been spontaneously rebooting both while the vehicle is idling and in motion. When this occurs, the screen goes black and critical safety systems such as the rearview camera, parking sensors, and navigation become unavailable. The system requires driver interaction to restore functionality once it restarts, creating a major distraction. These reboots now occur every few minutes, severely affecting both usability and safe operation of the vehicle. Initially, this issue happened infrequently (about once every two weeks), but over time it has become constant. Based on extensive online reports from other owners—including threads such as this one on AudiWorld: [XXX] appears to be a widespread defect affecting other Audi A4/S4 vehicles of the same year. This malfunction compromises several driver assistance and safety features, and I believe it presents a serious hazard, especially if it occurs during parking, reversing, or navigating unfamiliar areas. I urge NHTSA to investigate this matter and determine whether a recall or safety bulletin is appropriate. Thank you for your attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

I am submitting a formal complaint regarding a persistent and dangerous issue with the MMI (Multi Media Interface) system in my 2020 Audi S4. Since February 2025, the system has been spontaneously rebooting both while the vehicle is idling and in motion. When this occurs, the screen goes black and critical safety systems such as the rearview camera, parking sensors, and navigation become unavailable. The system requires driver interaction to restore functionality once it restarts, creating a major distraction. These reboots now occur every few minutes, severely affecting both usability and safe operation of the vehicle. Initially, this issue happened infrequently (about once every two weeks), but over time it has become constant. Based on extensive online reports from other owners—including threads such as this one on AudiWorld: [XXX] appears to be a widespread defect affecting other Audi A4/S4 vehicles of the same year. This malfunction compromises several driver assistance and safety features, and I believe it presents a serious hazard, especially if it occurs during parking, reversing, or navigating unfamiliar areas. I urge NHTSA to investigate this matter and determine whether a recall or safety bulletin is appropriate. Thank you for your attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

BACK OVER PREVENTION: WARNINGS

The vehicle software (known as Audi MMI) has been continuously rebooting every 30 seconds after the vehicle is started. This causes the entire dashboard (and entertainment screen) to repeatedly reboot which is very distracting while driving. While backing out of a parking spot, the MMI system rebooted which then disconnected my backup camera, blind spot warning, and rear collision warning systems which resulted in me almost hitting a car crossing behind me. There are zero messages anywhere in the car that an issue is present.

BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING

The vehicle software (known as Audi MMI) has been continuously rebooting every 30 seconds after the vehicle is started. This causes the entire dashboard (and entertainment screen) to repeatedly reboot which is very distracting while driving. While backing out of a parking spot, the MMI system rebooted which then disconnected my backup camera, blind spot warning, and rear collision warning systems which resulted in me almost hitting a car crossing behind me. There are zero messages anywhere in the car that an issue is present.

LANE DEPARTURE: BLIND SPOT DETECTION

The vehicle software (known as Audi MMI) has been continuously rebooting every 30 seconds after the vehicle is started. This causes the entire dashboard (and entertainment screen) to repeatedly reboot which is very distracting while driving. While backing out of a parking spot, the MMI system rebooted which then disconnected my backup camera, blind spot warning, and rear collision warning systems which resulted in me almost hitting a car crossing behind me. There are zero messages anywhere in the car that an issue is present.