2020 ALTEC AERIAL DEVICE
View all complaints and recalls for this specific model year.
2020 ALTEC AERIAL DEVICE Summary
2020
Model Year
0
Total Complaints
22
Total Recalls
16303
Vehicles Affected
Recalls
2020 ALTEC AERIAL DEVICE
1128 vehicles affected
EQUIPMENT:MECHANICAL:BOOM/CRANE/LADDER
Altec Industries, Inc. (Altec) is recalling certain 2020-2024 Altec LR7 and LR8 aerial devices. The hydraulic cylinder feeder tube routed near the cylinder rest bracket may become damaged and leak oil, which can result in uncontrolled boom movement.
Risk: Uncontrolled movement of the boom can increase the risk of injury.
2020 ALTEC AERIAL DEVICE
437 vehicles affected
ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Altec Industries, Inc. (Altec) is recalling certain 2004-2023 AT Series aerial devices. The cables in the engine compartment may contact the vehicle's hood, damaging the cables and causing a short circuit.
Risk: A short circuit increases the risk of a fire.
2020 ALTEC AERIAL DEVICE
59 vehicles affected
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Altec Industries, Inc. (Altec) is recalling certain 2020-2023 D4000B, D2000B, and AC18 trucks. The collision mitigation system software may not be calibrated correctly, prohibiting the active braking system from activating.
Risk: An active braking system that fails to activate as intended increases the risk of a crash.
2020 ALTEC AERIAL DEVICE
1967 vehicles affected
STRUCTURE:BODY
Altec Industries, Inc. (Altec) is recalling certain 2016-2022 DM, DH, DC, DL, D2000, D3000, and D4000 series digger derricks, and AM55 aerial devices. The base of the rear pole rack may be missing a weld.
Risk: A missing weld on the rear pole rack can lead to a crack that could cause the pole and rack to drop in height, increasing the risk of an injury.
2020 ALTEC AERIAL DEVICE
18 vehicles affected
ELECTRICAL SYSTEM
Altec Industries, Inc. (Altec) is recalling certain 2019-2022 AT335 vehicles. An inverter-powered outlet may have been installed at the aerial boom tip without ground-fault interrupter (GFCI) protection.
Risk: An outlet without GFCI protection may fail to shut off electrical power when a ground-fault occurs, increasing the risk of injury or fire.
2020 ALTEC AERIAL DEVICE
167 vehicles affected
EQUIPMENT:MECHANICAL:BOOM/CRANE/LADDER
Altec Industries, Inc. (Altec) is recalling certain 2018-2021 DC and DM Series Digger Derricks and AM series Aerial Devices. The unit subbase may develop cracks in the bulkhead plate, which can cause the shear plates to fail.
Risk: Shear plate failure can result in the separation of the subbase and truck frame, increasing the risk of injury.
2020 ALTEC AERIAL DEVICE
46 vehicles affected
EQUIPMENT
Altec Industries, Inc. (Altec) is recalling certain 2017-2021 SK185-MP, and SKC landscaping spray vans. The vehicles are not equipped with carbon monoxide detectors.
Risk: Elevated levels of carbon monoxide gas may not be detected, increasing the risk of injury.
2020 ALTEC AERIAL DEVICE
454 vehicles affected
EQUIPMENT:MECHANICAL:BOOM/CRANE/LADDER:TURNTABLE
Altec Industries, Inc. (Altec) is recalling certain 2019-2021 ATTXX-M/P/S aerial devices. Bolts in the rotation bearing outer-race may have been over-tightened, allowing the bolts to break.
Risk: Broken bolts can cause separation of the pedestal and turntable, increasing the risk of injury.
2020 ALTEC AERIAL DEVICE
71 vehicles affected
EQUIPMENT:MECHANICAL:BOOM/CRANE/LADDER
Altec Industries, Inc. (Altec) is recalling certain 2019-2022 AT41ME aerial devices. The material handling interlocking valve may lose power when the outriggers are not set, allowing the jib winch to be operated while the outriggers are up.
Risk: Outriggers that are not set when loads are being lifted by the jib winch may cause the unit to tip, increasing the risk of injury.
2020 ALTEC AERIAL DEVICE
594 vehicles affected
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Altec Industries, Inc. (Altec) is recalling certain 2017-2021 Altec AT200A, AT235, AT235P, AT237, AT37G, AT40G, AT41M, and CB5-132D-S aerial devices. A wire to the boom stow sensor may be routed over a sharp edge, which can expose the wire to metal and result in a blown ignition circuit fuse.
Risk: A blown fuse can cause an engine stall, increasing the risk of a crash.
2020 ALTEC AERIAL DEVICE
157 vehicles affected
EQUIPMENT:MECHANICAL:BOOM/CRANE/LADDER:TURNTABLE
Altec Industries, Inc. (Altec) is recalling certain 2017-2021 LS60 aerial devices. The outer-race rotation bearing bolt washers may interfere with an adjacent pedestal weld, which could cause the rotation bearing bolts to break.
Risk: Broken bolts can cause the pedestal to separate from the turntable, increasing the risk of injury.
2020 ALTEC AERIAL DEVICE
213 vehicles affected
EQUIPMENT:MECHANICAL:BOOM/CRANE/LADDER
Altec Industries, Inc. (Altec) is recalling certain 2016-2020 DH-B Series, DH-E Series, and D3000-E digger derricks set up for combined use and equipped with radio remote upper controls. These units only have the derrick use capacity chart and do not have the combined use capacity chart.
Risk: The operator may not have access to the rated capacity information while they are operating the equipment in combined use, increasing the risk of an injury.
2020 ALTEC AERIAL DEVICE
150 vehicles affected
EQUIPMENT:MECHANICAL:BOOM/CRANE/LADDER:MOTOR/HYDRAULIC PUMP
Altec Industries, Inc. (Altec) is recalling certain 2017-2021 AN67-E100, AA67-E100, AN67, AA67, and AN55-E88 aerial devices. The hydraulic plumbing to the lift cylinders of the lower and upper booms could be connected incorrectly, allowing the boom to overextend.
Risk: The operator could overextend the boom while using the material handling jib, causing the aerial device to tip over and increasing the risk of injury.
2020 ALTEC AERIAL DEVICE
218 vehicles affected
EQUIPMENT
Altec Industries, Inc. (Altec) is recalling certain 2020-2021 AT200A, AT235, AT235P Aerial Devices. Bolts of insufficient strength may have been used to connect the pedestal and sub-base, which could cause the bolts to become overloaded.
Risk: Overloaded bolts can fail, causing the pedestal to separate and increasing the risk of injury or death.
2020 ALTEC AERIAL DEVICE
94 vehicles affected
EQUIPMENT:MECHANICAL:BOOM/CRANE/LADDER:TURNTABLE
Altec Industries, Inc. (Altec) is recalling certain 2016-2021 LS87 aerial devices. The outer-race rotation bearing bolt washers may interfere with an adjacent pedestal weld, which could cause the rotation bearing bolts to break.
Risk: Broken bolts can cause the pedestal to separate from the turntable, increasing the risk of injury.
2020 ALTEC AERIAL DEVICE
1977 vehicles affected
EQUIPMENT
Altec Industries, Inc. (Altec) is recalling certain 2005-2021 A65, A70, A75, A72-T, A77-T, and A82-T vehicles. The lower and upper boom raise spools can shift after releasing the joystick or control interlock.
Risk: Unintended movement of the lower and upper booms increases the risk of injury.
2020 ALTEC AERIAL DEVICE
396 vehicles affected
TRAILER HITCHES
Altec Industries Inc. (Altec) is recalling certain 2014-2020 Aerial Devices and body only units equipped with Class 3 towing hitches. The tow hitch may have incorrect load rating markings, and may have been damaged by unintentional overloading.
Risk: If the tow hitch is overloaded, the hitch may fail, increasing the risk of a crash.
2020 ALTEC AERIAL DEVICE
157 vehicles affected
EQUIPMENT
Altec Industries Inc. (Altec) is recalling certain 2018-2020 AA55, AM50 and A77 Aerial Devices and D2, D3, D4, DH-B and DH-H Digger Derricks. The bolts that secure the pedestal to the turntable (with head marking 5185) may fail.
Risk: If the fasteners break, the pedestal may separate from turntable, increasing the risk of injury or death.
2020 ALTEC AERIAL DEVICE
280 vehicles affected
EQUIPMENT
Altec Industries Inc. (Altec) is recalling certain 2019-2020 AA55, AM50, A77-T Aerial Devices and D2/3/4B, D3E, DHB, DHH and DHE Digger Derricks. The bolts that secure the pedestal to the turntable (with head marking 5252) may fail.
Risk: If the fasteners break, the pedestal may separate from the turntable, increasing the risk of injury or death.
2020 ALTEC AERIAL DEVICE
2550 vehicles affected
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Altec Industries, Inc. (Altec) is recalling certain 2017-2020 AT200A, AT235, AT37-G, AT40-G, AT41/48M Aerial Devices mounted on a Ford F-350, F-450 or F-550 chassis equipped with a gas engine and Chelsea 249 Power Take-Off (PTO). The PTO may leak oil onto the exhaust heat shield thermal blanket.
Risk: Oil absorbed by the exhaust heat shield thermal blanket has an increased risk of a fire from being exposed to hot engine components.
2020 ALTEC AERIAL DEVICE
183 vehicles affected
EQUIPMENT
Altec Industries, Inc. (Altec) is recalling certain 2020 AN67-E100 articulating non-overcenter aerial device vehicles. The boom valve has a shuttle cartridge installed instead of a plug.
Risk: The valve not having a plug could result in unintended boom movement, increasing the risk of an injury.
2020 ALTEC AERIAL DEVICE
4987 vehicles affected
EQUIPMENT
Altec Industries, Inc. (Altec) is recalling certain 2018-2020 AA, AM, AN, A-Class, TA, DM, DL, DXXXX, DC, and DT digger derricks and aerial device vehicles equipped with a DC pump. A hydraulic check valve can have a snap ring failure resulting in the snap ring becoming lodged in a counterbalance or control valve allowing continued movement.
Risk: Unintended boom movement may result in potential injury and or property damage.
Complaints
No complaints found.